check engine light FORD BRONCO 1996 5.G User Guide

292 [SV13745( ALL)02/95]Synthetic engine oils which are CERTIFIED and
of the preferred viscosity may be used in your
engine. The engine oil and oil filter must still be
changed according to the maintenance schedule.
*
[SV13775( ALL)01/95]
Checking and Adding Engine Oil
*
[SV13800( ALL)03/95]
Since the proper amount of engine oil is
important for safe engine operation, check the oil
using the dipstick each time you put fuel in
your vehicle. Remember the engine must be off,
the oil must be warm and the vehicle must be
parked on level ground.
*
[SV13900( ALL)03/95]
Checking the engine oil level:
*
[SV14000( ALL)02/95]
1. Turn the engine off after it has warmed up
and allow a few minutes for the engine oil
to drain back into the oil pan.
*
[SV14050(B F )03/95]
2. Set the parking brake, making sure that the
gearshift is securely latched in P (Park)
(automatic transmission) or 1 (First) (manual
transmission).
*
[SV14100( ALL)02/95]
3. Open the hood. Protect yourself from engine
heat.
*
[SV14200( ALL)03/95]
4. Locate the engine oil dipstick (highlighted in
yellow) and carefully pull it out of the
engine.
*
[SV14300( ALL)01/95]
5. Wipe the dipstick clean and put it back into
position, making sure it is fully seated.
*
[SV14400( ALL)05/94]
quarter page art:0010364-D
Engine oil dipstick
File:ltsvb.ex
Update:Tue Jun 20 16:56:22 1995

293
*
[SV14500( ALL)02/95]
6. Carefully, pull the dipstick out again. If the
oil level is below the ªADD 1 QT.º line, add
engine oil as necessary. If the oil level is
beyond the letter ªFº in FULL, engine
damage or high oil consumption may occur
and some oil must be removed from the
engine.
*
[SV14600( ALL)01/95]
7. Put the dipstick back in and make sure it is
fully seated.
*
[SV14800( ALL)01/95]
It may be necessary to add some oil between oil
changes. Make sure you use a CERTIFIED
engine oil of the preferred viscosity. Your
vehicle's warranty coverage may not apply if
engine damage is caused by the use of improper
engine oil.
*
[SV15000( ALL)03/95]
Add engine oil through the oil filler cap
highlighted in yellow. To add oil, remove the
filler cap and use a funnel to pour oil into the
opening. Be careful not to overfill the engine.
Recheck the oil level after you finish adding oil.
*
[SV16500( ALL)04/95]
Change the engine oil and oil filterper the
following, whichever occurs first.
*
[SV16600(BEF )04/95]
one third page art:0060618-C
Oil change intervals
File:ltsvb.ex
Update:Tue Jun 20 16:56:22 1995

305 [SV26435( ALL)05/95]
Whenever a wheel is removed and then
re-installed, always remove any corrosion that
may be present on the mounting surface of the
wheel and/or the surface of the hub, drum or
rotor that contacts the wheel.
*
[SV26440( ALL)05/95]
RWARNING
Installing wheels without good
metal-to-metal contact at the wheel
mounting surface can cause the wheel lug
nuts to loosen and could allow the wheel
to come off while the vehicle is in motion.
*
[SV26450(BEF )03/95]
Traction-Lok Rear Axle (If equipped)
*
[SV26460(BEF )03/95]
This axle provides added drive away traction on
slippery surfaces, particularly when one or more
wheels are on a surface with poor traction.
*
[SV26470(BEF )05/95]
RWARNING
To avoid injury, never run the engine
with one wheel off the ground, such as
when changing a tire.
%*
[SV26500( ALL)02/95]
Tire Rotation
*
[SV26600( ALL)03/95]
Because your vehicle's front and rear tires
perform different jobs, they often wear
differently. To make sure your tires wear evenly
and last longer, rotate them at the mileage
shown in theMaintenance Schedule and Record
booklet which came with your vehicle.
*
[SV26700(BEF )07/92]
Rotate the tires according to the following
diagram. If you notice that the tires wear
unevenly, have them checked. If your light truck
has a temporary spare tire, do not include it in
the tire rotation pattern.
File:ltsvb.ex
Update:Tue Jun 20 16:56:22 1995

320
*
[SV37600( ALL)03/95]
Power Steering Fluid
*
[SV37700( ALL)01/95]
Check the level of the power steering fluid at
least twice a year (i.e., every Spring and Fall).
*
[SV37800( ALL)03/95]
To check the level of your power steering fluid:
*
[SV37900( ALL)02/95]
1. Start the engine and let it run until the
power steering fluid reaches normal
operating temperature. The power steering
fluid will be at the right temperature when
the engine coolant temperature gauge in the
instrument cluster is near the center of the
NORMAL operating temperature range.
*
[SV38000( ALL)01/95]
2. While the engine idles, turn the steering
wheel back and forth several times. Make
sure that the cap assembly is installed at this
time.
*
[SV38100(BEF )05/95]
3. Turn the engine off.
%*
[SV38200( ALL)03/94]
4. Check the fluid level on the dipstick (which
is highlighted in yellow in your vehicle). The
fluid level should be between the arrows in
the FULL HOT range, which is marked on
the side of the dipstick, opposite the side
marked FULL COLD. Do not add fluid if the
level is within the FULL HOT range.
*
[SV38250( ALL)03/94]
one third page art:0021016-B
Power steering dipstick
File:ltsvb.ex
Update:Tue Jun 20 16:56:22 1995

340
*
[SV49250( ALL)03/95]
In general, maintenance, replacement, or service
of the emissions control devices or systems in
your new Ford Motor Company vehicle or
engine may be performed at your expense by
any automotive repair establishment or
individual using automotive parts equivalent to
those which your vehicle or engine was
originally equipped.
*
[SV49300( ALL)05/95]
RWARNING
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine
compartment and exhaust system, which
can start a fire.
*
[SV49400(BEF )05/95]
RWARNING
On vehicles without original equipment
floor covering or insulation, do not let
passengers ride in your truck in a manner
that allows contact between skin and the
metal floor.
*
[SV49450( ALL)05/95]
If other than Ford or Motorcraft or Ford
authorized remanufactured parts are used for
maintenance, replacement, or for the service of
components affecting emissions control, the
owner should be assured that such parts are
warranted by their manufacturer to be
equivalent to genuine Ford Motor Company
parts in performance and durability. Please
consult your warranty information booklet for
complete warranty information.
*
[SV49500(BEF )05/95]
Watch for fluid leaks, strange odors, smoke, loss
of oil pressure, the charge warning light, the
check engine light, or the temperature warning
light. These sometimes indicate that the emission
system is not working properly.
File:ltsvb.ex
Update:Tue Jun 20 16:56:22 1995

352 %
*
[SV57350( ALL)01/95]
Engine
*
[SV57400( ALL)01/95]
q
Start engine every 15 days. Run at fast idle
until it reaches normal operating temperature.
*
[SV57500( ALL)01/95]
q
With your foot on the brake, shift through all
the gears while the engine is running.
%*
[SV57600( ALL)01/95]
Fuel system
*
[SV57700( ALL)07/94]
q
Fill fuel tank with high-quality unleaded fuel
until the first automatic shutoff of the fuel
pump nozzle.
*
[SV57900( ALL)03/95]
NOTE: During extended periods of vehicle
storage (60 days or more), fuel may
deteriorate due to oxidation. This can
damage rubber and other polymers in
the fuel system and may also clog
small orifices.
*
[SV58000( ALL)01/95]
Ford Gas Stabilizer should be added whenever
actual or expected storage periods exceed 60
days. Follow the instructions on the label. The
vehicle should then be operated at idle speed to
circulate the additive throughout the fuel system.
*
[SV58100( ALL)01/95]
A volatile corrosion inhibitor added to the fuel
system will protect the fuel system's inner
surfaces from corrosion. Follow the instructions
packaged with the product.
%*
[SV58200( ALL)01/95]
Cooling system
*
[SV58300( ALL)01/95]
q
Protect against freezing temperatures.
%*
[SV58400( ALL)01/95]
Battery
*
[SV58500( ALL)01/95]
q
Check and recharge as necessary.
*
[SV58600( ALL)01/95]
q
Keep connections clean and covered with a
light coat of grease.
%*
[SV58700( ALL)01/95]
Brakes
*
[SV58800( ALL)01/95]
q
Make sure brakes and parking brake are fully
released.
File:ltsvb.ex
Update:Tue Jun 20 16:56:22 1995

Index 365
Brakes (continued)
trailer................ 231
when storing your vehicle....... 352
Brake-shift interlock.......... 66,178
Break-in period.............. 7
Bulbs, replacing
headlamps.............. 334
high-mount brakelamp........ 336
C
Canada, customer assistance....... 264
Canadian Motor Vehicle Arbitration Plan
(CAMVAP).............. 265
Capacities for refilling fluids....... 344
Carbon monoxide in exhaust........ 71
Car seats for children
(see Child safety seats)......... 37
Cassette tape player (see Electronic
sound system)..........163, 168
Catalytic converter........... 339
CD player (see Electronic sound system) . 156
Chains, tires.............. 310
Changing a tire............. 241
Charging system gauge.......... 82
Charging system warning light....... 81
Child safety restraints........... 34
child safety belts............ 36
child safety seats............ 37
Child safety seats, attaching with
tether straps.............. 57
Chime
headlamps on............. 84
key in ignition............. 61
safety belt............... 78
Circuit breakers, checking and replacing. . 332
Cleaning your vehicle
CD player and discs......... 160
chrome and aluminum parts....... 9
engine compartment......... 281
exterior................ 8
File:ltixb.ex
Update:Fri Jun 9 15:21:14 1995

Index 367
Controls
instrument panel............ 89
mirrors............... 139
steering column........... 105
Coolant (see Engine coolant)
checking and adding......... 295
drain and flush............ 299
preparing for storage......... 352
proper solution............ 297
refill capacities............ 344
specifications............. 298
temperature gauge........... 85
Cruise control (see Speed control).... 111
Customer Assistance Center, Ford (U.S.). . 257
Customer Assistance Centre,
Ford of Canada............ 257
D
Dashboard (see Instrument panel)..... 89
Daytime running light system....... 99
Defrost, rear window........... 97
Dipstick
automatic transmission fluid....313, 315
power steering fluid......... 320
Dispute Settlement Board........ 258
Doors................. 119
Driveline universal joint and slip yoke . . 317
Driving under special conditions
bad weather............. 211
heavy load.............. 214
high speed.............. 211
high water.............. 213
slippery roads............ 211
E
Electrical system
circuit breakers............ 332
fuses................ 322
operating when the engine is off..... 60
File:ltixb.ex
Update:Fri Jun 9 15:21:14 1995

368 Index
Electrical system (continued)
power point outlet.......... 148
Electronic sound system
radio reception............ 171
tuning the radio.........151, 165
warranty and service information.... 174
Electronic stereo cassette radio
(see Electronic sound system)..... 163
Electronic stereo radio (see Electronic
sound system)............ 163
Emergencies, roadside
assistance............... 255
battery acid spills.........237, 313
jump-starting............. 237
towing................ 251
Emergency brake (parking brake)..... 208
Emission control system, catalytic
converter............... 339
Engine
check engine warning light....... 78
fuel injected engine, starting....... 63
fuel pump shut-off switch........ 69
preparing to start............ 64
service points............. 279
starting............... 59,65
starting after a collision......... 69
storing your vehicle.......... 352
Engine block heater............ 68
Engine coolant
checking and adding......... 295
checking hoses............ 299
disposal...........294, 298, 315
preparing for storage......... 352
proper solution............ 297
recovery reservoir........... 296
refill capacities............ 344
specifications............. 298
Engine coolant temperature gauge,
description............... 85
File:ltixb.ex
Update:Fri Jun 9 15:21:14 1995

Index 369
Engine knocking............ 284
Engine oil
checking and adding......... 292
dipstick............... 292
disposal...........294, 298, 315
engine oil pressure gauge........ 83
filter, specifications.......... 346
refill capacities............ 344
specifications............. 290
synthetic oil............. 291
ªbreak-inº oils............. 7
viscosity............... 291
Entry system
illuminated.............. 125
remote................ 121
Exhaust fumes.............. 71
Extended Service Plan, Ford........ 4
F
Federal Communications Commission . . . 173
Federal Highway Administration
Regulation............... 6
Flashers, hazard............. 109
Flashing the lights............ 107
Flat tire................ 241
Fluid refill capacities.......... 344
Ford Customer Assistance Center..... 257
Ford Dispute Settlement Board...... 258
Ford Extended Service Plan........ 4
Ford Motor Company of Canada..... 264
Ford of Canada Customer
Assistance Centre........... 264
Foreign registration........... 263
4WD light.............191, 197
4x4 systems - lever operated....... 189
4x4 systems - touch drive........ 196
Four-Wheel Drive vehicles
description.............. 188
driving off road........... 200
indicator light............ 191
File:ltixb.ex
Update:Fri Jun 9 15:21:14 1995