FORD BRONCO SPORT 2022 Warranty Guide

• Heavy duty vehicles (applies to trucks over 8,500 poundsGVWR up through 19,500 pounds GVWR)
— The emissions warranty coverage period for heavy duty vehicles (HDVs) is 5 years or 50,000 miles (whichever
comes first) for all parts covered by your emissions warranty.
The 5 year or 50,000 mile warranty includes coverage of
components whose failure would increase the vehicle’s
emissions of air conditioning refrigerants.
•Only for HDVs designated as "vocational vehicles" on
the underhood "VEHICLE EMISSION CONTROL
INFORMATION" label: Tire defects that affect compliance
with greenhouse gas requirements are covered for 2 years or
24,000 miles, whichever comes first.
EMISSIONS PERFORMANCE WARRANTY COVERAGE
Under Emissions Performance Warranty Coverage, Ford Motor
Company will repair, replace, or adjust - with no charge for labor,
diagnosis, or parts - any emissions control device or system, if
you meet all of the following conditions:
• You have maintained and operated your vehicle according to the instructions on proper care in the Owner’s Manualand this
booklet.
•
Your vehicle fails to conform, during the warranty coverage
period, to the applicable national EPA standards, as determined
by an EPA approved inspection and maintenance program.
• You are subject to a penalty or sanction under local, state, or federal law because your vehicle has failed to conform to the
emissions standards. (A penalty or sanction can include being
denied the right to use your vehicle.)
• Your vehicle has not been tampered with, misused, or abused.
24

The warranty coverage period for:
• Passenger cars and light duty trucks (applies to vehicles upthrough 8,500 pounds GVWR) is as follows:
— 8 years or 80,000 miles (whichever occurs first) for catalytic converter, electronic emissions control unit, and onboard
emissions diagnostic devices.
— 2 years or 24,000 miles (whichever occurs first) for all other covered parts .
• Heavy duty vehicles (applies to trucks over 8,500 pounds GVWR up through 19,500 pounds GVWR)
— 5 years or 50,000 miles (whichever occurs first) for all covered parts.
See WHAT IS COVERED? below for list of covered parts.
Note that the warranty period begins on the Warranty Start Date
as specified on page 2 of this booklet.
25

WHAT IS COVERED?
For your vehicle if these parts contain an emissions-related
defect, they are covered by both the Emissions Defect Warranty
and the Emissions Performance Warranty.
• Active Air Dam (3.0L dieselF-150 only)
• Active Grill Shutters (3.0L diesel F-150 only)
• Air Flow Sensor
• Air/Fuel Feedback Control System and Sensors
• Air Induction System
• Battery Energy Control Module (BECM)
• Brake Hydraulic/Electric Control Assembly (Plug-in
Hybrid vehicles only)
• Brake Vacuum Pump (Plug-in Hybrid vehicles
only)
• Catalytic Converters (including Selective Catalytic
Reduction and Diesel
Oxidation Catalysts)
•
Charger and Bracket
Assembly High Voltage
Battery (Hybrid and Plug-in
Hybrid vehicles only)
• Cold Start Enrichment System (diesel only)
• Controls for Deceleration (diesel only)
• Converter and Bracket Assembly High Voltage to Low Voltage (Hybrid and
Plug-in Hybrid vehicles only)
• Diesel Exhaust Fluid System
• Diesel Particulate Filter
• Electronic Ignition System (diesel only)
• Electronic Engine Control Sensors and Switches
• Powertrain Control Module (PCM)/ Engine Control
Module (ECM)*
• Evaporative Emission Control System
• Exhaust Gas Recirculation (EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to Catalyst)
• Fuel Filler Door Sensor (Hybrid and Plug-in Hybrid
vehicles only)
• Fuel Filler Tube and Seal (non-diesel only)
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank (non-diesel only)
• Fuel Tank Pressure Control Valve
26

• Heating Element of BackWindow (3.0L diesel F-150
only)
• High Voltage Battery (Hybrid and Plug-in Hybrid vehicles
only)
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/or Control Module
• Intake Manifold
• Intercooler Assembly - Engine Charger
• Inverter System Controller (Plug-in Hybrid vehicles
only)
• Jumper Assembly Charge Inlet to Charger (Hybrid and
Plug-in Hybrid vehicles only)
• Jumper Assembly DC/DC Converter to High Voltage
Panel (Hybrid and Plug-in
Hybrid vehicles only)
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic
(OBD) System
• Module and Bracket Assembly Transmission
Inverter Control (Hybrid and
Plug-in Hybrid vehicles only) • Motor Electronics Coolant
Pump (Plug-in Hybrid
vehicles only)
• PCV system and Oil Filler Cap
• Onboard Charger (Plug-in Hybrid vehicles only)
• Secondary Air Injection System
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Assembly (Plug-in Hybrid vehicles
only)
• Transmission Auxiliary Oil Pump (Plug-in Hybrid
vehicles only)
• Transmission Fluid Temperature Sensor (Plug-in
Hybrid vehicles only)
• Transmission Control Module (TCM) and
Solenoids
• Turbocharger Assembly
• Vacuum Distribution System
* Includes hardware and emissions related software changes only
27

Important Information About List of Parts
Also covered by the two emissions warranties are all
emissions-related bulbs, hoses, clamps, brackets, tubes, gaskets,
seals, belts, connectors, non-diesel fuel lines, sensors, and wiring
harnesses that are used with components on the list of parts,
above.
Concerning parts that should be replaced on a certain
maintenance schedule: these parts remain under warranty until :
(a) the first replacement time that is specified in yourOwner’s
Manual; or (b) the time or mileage limits of the Federal Defect
and Performance Warranties (whichever occurs first). Your Ford
Motor Company dealer maintains a complete list of parts
covered by the emissions performance warranty. For questions
about emission-related parts, contact your dealer.
WHAT IS NOT COVERED?
Ford Motor Company may deny you emissions warranty coverage
if your vehicle or a part does not contain an emissions-related
defect or has failed because of abuse, neglect, improper
maintenance, unapproved modifications, or any items included in
What Is Not Covered?, pages 14-19.
If you need more information about getting service under the
Federal Emissions Performance Warranty, or if you want to
report what you believe to be violations of the terms of this
warranty, you may contact:
U.S. Environmental Protection Agency
Office of Transportation and Air Quality
Compliance Division, Light-Duty Vehicle Group
Attn: Warranty Complaints
2000 Traverwood Drive
Ann Arbor, MI 48105
Email: [email protected]
28

6. California requirements for emissions warranties
QUICK REFERENCE: EMISSIONS WARRANTY COVERAGE
This chart shows the emission warranty that Ford Motor Company
provides for your vehicle under the emissions control warranty in
accordance with the regulations of the California Air Resources Board.
This coverage is in addition to Federal Emission warranties (Page 22).
* Gross Vehicle Weight Rating
** These specific parts were selected on the basis of their estimated replacement cost at the time the California Air Resources Board certified your vehicle for sale in California
(up through 14,000 pounds GVWR).
***
Refer to your Vehicle Emission Control Information label for emissions certification information.
**** Except for the high voltage battery, which is covered for 10 years or 150,000 miles (whichever occurs first).
NOTE: Fully-electric vehicles are not eligible for any emissions
warranties described in this booklet.
TRANSITIONAL ZERO EMISSION VEHICLES (TZEV)***
DEFECTS AND PERFORMANCE WARRANTY**** 15/150,000
EMISSIONS DEFECTS WARRANTY FOR
VEHICLE WITH GVWR OVER 14,000 LBS.***
(Gasoline engines)
(2021 and earlier engine
model year diesel engines)
(2022 and later engine
model year diesel engines)
EMISSIONS PERFORMANCE WARRANTY (Vehicles of 14,000 LBS.* & under)
EMISSIONS DEFECTS WARRANTY FOR
VEHICLES WITH GVWR*
OF 14,000 LBS. & UNDER
Short-Term Warranty
Long-Term Warranty**
3/50,000
3/50,000
7/70,000
5/50,000 5/100,000
5/110,000
Emissions Warranties for California Certified Vehicles
TYPE OF
COVERAGE YEARS IN
SERVICE/MILES DRIVEN
29

Vehicles Eligible for California Emission Warranty Coverage
California emission warranty coverage applies if your vehicle
meets the following two requirements:
• Your vehicle is registered in a state
1that has adopted and is
enforcing California emission warranty regulations applicable
for your vehicle at the time of repair, and
• Your vehicle is certified for sale in California as indicated on the vehicle emission control information label.
1Subject to change, the following states have adopted and are
enforcing California emission warranty regulations:
-Passenger Car & Light-duty Trucks (up through 8,500
pounds GVWR) - California, Colorado, Connecticut,
Delaware, Maine, Maryland, Massachusetts, New Jersey,
New York, Oregon, Pennsylvania, Rhode Island, Vermont
and Washington
- Medium-Duty Passenger Vehicles (up through 10,000
pounds GVWR designed primarily for the transportation
of persons. Excludes incomplete trucks, trucks with a
seating capacity either over twelve persons total or over
nine persons rearward of the driver’s seat, or trucks with
an open cargo area of at least six feet of interior length):
California, Colorado, Connecticut, Delaware, Maine,
Maryland, Massachusetts, New York, Oregon, Rhode
Island, Vermont and Washington
- Medium-Duty Vehicles (over 8,500 pounds GVWR up
through 14,000 pounds GVWR) - California, Colorado,
Connecticut, Delaware, Maine, Maryland, Massachusetts,
New York, Oregon, Rhode Island, and Vermont.
- Light Heavy-Duty Diesel Engine Vehicles (over 14,000
pounds GVWR up through 19,500 pounds GVWR) -
California, Maine and Pennsylvania.
30

Vehicles Eligible for California Transitional Zero Emission
Vehicle (TZEV) Emission Warranty Coverage
California Transitional Zero Emissions Vehicle (TZEV) extended
emission warranty coverage applies if your vehicle meets the
following two requirements:
• Your vehicle is registered in a state** that has adopted and isenforcing California TZEV emissions warranty regulations
applicable to your vehicle at the time of repair, and
• Your vehicle is certified as a TZEV in California as indicated on the vehicle emission control information label.
**Subject to change, the following states have adopted and are
enforcing California TZEV emission warranty regulations:
California, Colorado, Connecticut, Maine, Maryland,
Massachusetts, New Jersey, New York, Rhode Island, Oregon and
Vermont (NOTE: Delaware, Pennsylvania and Washington did
not adopt the California TZEV emission warranty; standard
California emission warranty coverage applies to all emission
components.)
For full details about coverage under California requirements for
emissions control, see:
→ Defects Warranties (pages 32-39)
→ Performance Warranty (pages 32-35)
→ What Is Covered? (pages 36-38)
→ What Is Not Covered? (page 38)
31

EXPLANATION OF CALIFORNIA EMISSIONS WARRANTIES
Your Warranty Rights and Obligations
The California Air Resources Board and Ford Motor Company are
pleased to explain the emission control system warranty on your
2022-model vehicle. In California, new motor vehicles must be
designed, built, and equipped to meet the State's stringent
anti-smog standards. Ford must warrant the emission control
system on your vehicle for the periods of time listed on pages 32-35,
provided there has been no abuse, neglect, or improper maintenance
of your vehicle.
Your emission control system may include parts such as the fuel
injection system, the ignition system, catalytic converter, and the
engine computer. Also included may be hoses, belts, connectors,
and other emissions-related assemblies.
Where a warrantable condition exists, Ford Motor Company will
repair your vehicle at no cost to you including diagnosis, parts,
and labor.
Manufacturer's Warranty Coverage
For Vehicles Eligible for California Emission Warranty Coverage
If Gross Vehicle Weight Rating is 14,000 lbs. or less:
For 3 years or 50,000 miles (whichever occurs first):
1. If your vehicle fails a Smog Check inspection, all necessary
repairs and adjustments will be made by Ford to ensure that your
vehicle passes the inspection. This is your emission control
system PERFORMANCE WARRANTY.
2. If any emissions-related part on your vehicle is defective, the
part will be repaired or replaced by Ford. This is your short-term
emission control system DEFECTS WARRANTY.
For 7 years or 70,000 miles (whichever occurs first):
If a high-priced emissions-related part is defective or if its failure
causes your vehicle to fail a Smog Check inspection, the part will
be repaired or replaced by Ford. This is your long-term emission
control system DEFECTS WARRANTY.
32

For a list of the high-priced emission-related parts that are
covered for 7 years or 70,000 miles, go to www.owner.ford.com /
Owner Manuals.
Select the list that corresponds to the model and the model year
of your vehicle. NOTE: This list is vehicle specific and may not be
the same for all vehicles. It is based on the replacement cost of
each specific part, which can vary between vehicle lines.
If Gross Vehicle Weight Rating is 8,501 lbs. through 14,000 lbs.:
• For 5 years or 50,000 miles (whichever occurs first) forcomponents whose failure would increase the vehicle’s
emissions of air conditioning refrigerants.
• Only for HDVs designated as "vocational vehicles" on the
underhood "VEHICLE EMISSION CONTROL INFORMATION"
label: Tire defects that affect compliance with greenhouse gas
requirements are covered for 2 years or 24,000 miles,
whichever comes first.
If Gross Vehicle Weight Rating is over 14,000 lbs.:
For 5 years or 50,000 miles (gasoline engines), 5 years or
100,000 miles (2021 and earlier engine model year diesel
engines), and 5 years or 110,000 miles (2022 and later engine
model year diesel engines) (whichever occurs first). Warranty
coverage of 5 years or 50,000 miles (whichever occurs first)
applies for components whose failure would increase the
vehicle’s emissions of air conditioning refrigerants. Only for HDVs
designated as "vocational vehicles" on the underhood
"VEHICLE EMISSION CONTROL INFORMATION" label: Tire
defects that affect compliance with greenhouse gas
requirements are covered for 2 years or 24,000 miles, whichever
comes first.
33