service indicator FORD C MAX 2016 User Guide

Locating the headlamp bulbs:
Direction indicator lamp.
A
Low beam headlamp.
B
High beam headlamp.
C
Replacing the High Beam Headlamp
Bulb: 1. Remove the headlamp assembly.
2. Remove service cap.
3. Disconnect the electrical connector.
4. Remove bulb from the headlamp
assembly by turning it
counterclockwise, then pull it straight
out.
Replacing the Low Beam Headlamp
Bulb: 1. Remove the headlamp assembly.
2. Remove service cap.
3. Disconnect the electrical connector.
4. Remove bulb from the headlamp
assembly by turning it
counterclockwise, then pull it straight
out.
Install the new bulbs in reverse order.
Replacing Side Marker Bulbs: 1. Remove the headlamp assembly.
2. Remove service cap.
3. Remove the bulb holder.
4. Remove bulb from the headlamp
assembly.
Install the new bulb in reverse order.
233
C-MAX (CCG) Canada/United States of America, enUSA, First Printing MaintenanceE162549 E162550 E162551 E162552

Please note that the TPMS is not a
substitute for proper tire maintenance, and
it is the driver
’s responsibility to maintain
correct tire pressure, even if under-inflation
has not reached the level to trigger
illumination of the TPMS low tire pressure
telltale.
Your vehicle has also been equipped with
a TPMS malfunction indicator to indicate
when the system is not operating properly.
The TPMS malfunction indicator is
combined with the low tire pressure
telltale. When the system detects a
malfunction, the telltale will flash for
approximately one minute and then remain
continuously illuminated. This sequence
will continue upon subsequent vehicle
start-ups as long as the malfunction exists.
When the malfunction indicator is
illuminated, the system may not be able
to detect or signal low tire pressure as
intended. TPMS malfunctions may occur
for a variety of reasons, including the
installation of replacement or alternate
tires or wheels on the vehicle that prevent
the TPMS from functioning properly.
Always check the TPMS malfunction
telltale after replacing one or more tires or
wheels on your vehicle to ensure that the
replacement or alternate tires and wheels
allow the TPMS to continue to function
properly.
The tire pressure monitoring system
complies with part 15 of the FCC rules and
with RSS-210 of Industry Canada.
Operation is subject to the following two
conditions: (1) This device may not cause
harmful interference, and (2) This device
must accept any interference received,
including interference that may cause
undesired operation. Changing Tires With a Tire
Pressure Monitoring System
Note:
Each road tire is equipped with a tire
pressure sensor located inside the wheel
and tire assembly cavity. The pressure
sensor is attached to the valve stem. The
pressure sensor is covered by the tire and is
not visible unless the tire is removed. Take
care when changing the tire to avoid
damaging the sensor
You should always have your tires serviced
by an authorized dealer.
Check the tire pressure periodically (at
least monthly) using an accurate tire
gauge. See Inflating Your Tires in this
chapter.
Understanding Your Tire Pressure
Monitoring System
The tire pressure monitoring system
measures pressure in your four road tires
and sends the tire pressure readings to
your vehicle. The low tire pressure warning
light will turn on if the tire pressure is
significantly low. Once the light is
illuminated, your tires are under-inflated
and need to be inflated to the
manufacturer ’s recommended tire
pressure. Even if the light turns on and a
short time later turns off, your tire pressure
still needs to be checked.
271
C-MAX (CCG) Canada/United States of America, enUSA, First Printing Wheels and TiresE142549

Capacities and Specifications...............280
Specifications..................................................... 280
Car Wash See: Cleaning the Exterior............................... 241
Center Console..............................................128
Changing a Bulb...........................................232 Replacing Fog, Park and Direction Indicator
Bulbs.................................................................. 234
Replacing Headlamp Bulbs........................... 232
Replacing License Plate Lamp Bulb...........236
Replacing Reverse Lamp and Tail Lamp Bulbs.................................................................. 235
Replacing Tail, Brake and Direction Indicator Bulbs............................................... 234
Replacing the Center High Mounted Brake Lamp Bulbs..................................................... 236
Changing a Fuse............................................217 Fuses........................................................................\
217
Changing the 12V Battery.........................228
Changing the Engine Air Filter................238 Air Cleaner Assembly Components...........238
Installing the Engine Air Filter
Element
............................................................ 240
Removing the Engine Air Filter Element............................................................ 239
Changing the Wiper Blades.....................229 Changing the Rear Window Wiper
Blade
................................................................. 230
Changing the Windshield Wiper Blades............................................................... 230
Service Position.................................................. 229
Charging the High Voltage Battery........155 Charge Port........................................................... 158
Charging................................................................. 158
Charging Equipment......................................... 155
Disconnecting the Charging Coupler..........160
Locking the Charging Coupler....................... 159
Waiting to Charge............................................... 159
Checking MyKey System Status...............54 MyKey Distance.................................................... 54
Number of Admin Keys...................................... 54
Number of MyKeys.............................................. 54
Checking the Wiper Blades......................229
Child Restraint and Seatbelt Maintenance.................................................33
Child Restraint Positioning.........................24
Child Safety
.......................................................15
General Information............................................. 15Child Safety Locks
..........................................25
Left-Hand Side...................................................... 26
Right-Hand Side................................................... 26
Cleaning Leather Seats.............................245
Cleaning Products
........................................241
Cleaning the Alloy Wheels.......................245
Cleaning the Engine....................................243
Cleaning the Exterior
...................................241
Exterior Chrome Parts...................................... 242
Exterior Plastic Parts........................................ 242
Stripes or Graphics............................................ 242
Underbody............................................................ 242
Cleaning the Instrument Panel and Instrument Cluster Lens
........................244
Cleaning the Interior...................................244
Cleaning the Windows and Wiper Blades...........................................................243
Clearing All MyKeys.......................................52
Climate Control............................................108
Collision, Damage or Fire Event..............199 Guidance for Ford Motor Company Electric
and Hybrid-Electric Vehicles Equipped
With High Voltage Batteries...................... 199
Coolant Check See: Engine Coolant Check............................ 223
Crash Sensors and Airbag Indicator........42
Creating a MyKey............................................52 Programming/Changing Configurable
Settings............................................................... 52
Cruise Control.................................................68 Principle of Operation....................................... 179
Cruise control See: Using Cruise Control................................ 179
Customer Assistance
.................................202
D
Data Recording
..................................................9
Event Data Recording........................................... 9
Service Data Recording........................................ 9
Daytime Running Lamps..............................77 Type 1 - Conventional
(Non-Configurable)........................................ 77
Type 2 - Configurable.......................................... 77
Digital Radio...................................................291 HD Radio Reception and Station
Troubleshooting............................................ 292
Direction Indicators
........................................78
384
C-MAX (CCG) Canada/United States of America, enUSA, First Printing Index

Driver and Passenger Airbags...................36
Children and Airbags.......................................... 36
Proper Driver and Front Passenger Seating Adjustment........................................................ 36
Driver Knee Airbag.........................................40
Driving Aids......................................................181
Driving Hints...................................................192
Driving Through Water................................193
DRL See: Daytime Running Lamps.......................... 77
E
Economical Driving......................................192
EcoSelect.........................................................142
Emission Control System
..........................150
On-Board Diagnostics (OBD-II)..................... 151
Readiness for Inspection and Maintenance (I/M) Testing.................................................... 152
End User License Agreement.................366 VEHICLE SOFTWARE END USER LICENSE
AGREEMENT (EULA) ................................ 366
Engine Block Heater.....................................132 Using the Engine Block Heater...................... 133
Engine Coolant Check
................................223
Adding Coolant................................................... 224
Adding Engine Coolant.................................... 225
Adding Inverter System Controller Coolant............................................................. 225
Checking the Engine Coolant........................ 223
Checking the Inverter System Controller Coolant............................................................. 224
Engine Coolant and Inverter System Controller Coolant........................................ 223
Recycled Engine Coolant................................ 225
Severe Climates.................................................. 225
What You Should Know About Fail-Safe Cooling.............................................................. 226
Engine Immobilizer See: Passive Anti-Theft System..................... 65
Engine Oil Check
..........................................222
Adding Engine Oil............................................... 222
Low Engine Use.................................................. 223
Engine Oil Dipstick
.......................................222
Engine Specifications.................................276
Environment......................................................14
Event Data Recording See: Data Recording.............................................. 9Export Unique Options..................................13
Extended Service Plan (ESP).................346
EXTENDED SERVICE PLAN (CANADA
ONLY)................................................................ 347
EXTENDED SERVICE PLAN (U.S. Only).................................................................. 346
Exterior Mirrors
.................................................81
Fold-Away Exterior Mirrors............................... 82
Heated Exterior Mirrors...................................... 82
Integrated Blind Spot Mirrors.......................... 82
Power Exterior Mirrors......................................... 81
Signal Indicator Mirrors...................................... 82
F
Fastening the Seatbelts..............................28 Safety Belt Extension Assembly.................... 30
Safety Belt Locking Modes............................... 29
Using Safety Belts During Pregnancy...........28
Flat Tire Inflation See: Tire Sealant and Inflator Kit.................249
Floor Mats.......................................................194
Fog Lamps - Front See: Front Fog Lamps......................................... 77
Ford Credit
..........................................................11
(U.S. Only)................................................................. 11
Front Fog Lamps.............................................77
Front Parking Aid............................................171
Front Passenger Sensing System.............37
Fuel and Refueling.......................................143
Fuel Consumption
.......................................150
Calculating Fuel Economy.............................. 150
Filling the Tank.................................................... 150
Fuel Filler Funnel Location........................145
Fuel Filter.........................................................227
Fuel Quality....................................................144 Choosing the Right Fuel................................... 144
Fuel Freshness Mode........................................ 144
Fuel Shutoff
...................................................196
Fuses................................................................209
Fuse Specification Chart
..........................209
Luggage Compartment Fuse Panel............214
Passenger Compartment Fuse Panel.........212
Power Distribution Box................................... 209
Pre-Fuse Box....................................................... 209
385
C-MAX (CCG) Canada/United States of America, enUSA, First Printing Index

Repairing Minor Paint Damage..............245
Replacement Parts
Recommendation.........................................11
Collision Repairs..................................................... 11
Scheduled Maintenance and Mechanical Repairs................................................................... 11
Warranty on Replacement Parts..................... 12
Replacing a Lost Key or Remote Control............................................................50
Reporting Safety Defects (Canada Only)..............................................................207
Reporting Safety Defects (U.S. Only)..............................................................207
Roadside Assistance...................................195 Vehicles Sold in Canada: Getting Roadside
Assistance........................................................ 195
Vehicles Sold in Canada: Roadside Assistance Program Coverage.................196
Vehicles Sold in Canada: Using Roadside Assistance........................................................ 196
Vehicles Sold in the United States: Getting Roadside Assistance.................................... 195
Vehicles Sold in the United States: Using Roadside Assistance.................................... 195
Roadside Emergencies...............................195
Running-In See: Breaking-In.................................................. 192
Running Out of Fuel.....................................145 Adding Fuel From a Portable Fuel
Container.......................................................... 145
Filling a Portable Fuel Container.................. 145
S
Safety Canopy ™
............................................40
Safety Precautions.......................................143
Satellite Radio..............................................294
Satellite Radio Electronic Serial Number
(ESN)................................................................ 295
Satellite Radio Reception Factors..............294
SIRIUS® Satellite Radio Service.................294
Troubleshooting................................................. 295
Scheduled Maintenance Record...........356
Scheduled Maintenance..........................348
Seatbelt Height Adjustment.....................30
Seatbelt Reminder
..........................................31
Belt-Minder™......................................................... 31Seatbelts............................................................27
Principle of Operation......................................... 27
Seatbelt Warning Lamp and Indicator Chime................................................................31
Conditions of operation...................................... 31
Seats...................................................................113
Security..............................................................65
Side Airbags.....................................................39
Sitting in the Correct Position...................113
Snow Chains See: Using Snow Chains................................. 270
Special Notices................................................12 New Vehicle Limited Warranty......................... 12
On-board Diagnostics (OBD-II)....................... 12
Special Instructions.............................................. 12
Special Operating Conditions Scheduled Maintenance..............................................354
Exceptions............................................................ 355
Speed Control See: Cruise Control............................................. 179
Stability Control
............................................168
Principle of Operation...................................... 168
Starter Switch See: Ignition Switch........................................... 129
Starting a Gasoline Engine.......................130 Guarding Against Exhaust Fumes................132
Important Ventilating Information...............132
Switching Off the Vehicle When It Is
Moving................................................................ 132
Switching Off the Vehicle When It Is Stationary.......................................................... 131
Vehicles with an Ignition Key......................... 130
Vehicles with Keyless Start............................ 130
Starting and Stopping the Engine..........129 General Information.......................................... 129
Steering
.............................................................181
Electric Power Steering..................................... 181
Steering Wheel
................................................67
Storage Compartments.............................128
Sun Shades
......................................................84
Bounce-Back......................................................... 84
Opening and Closing the Sun Shade...........84
Sun Shade Relearning....................................... 84
Sun Visors
.........................................................83
Illuminated Vanity Mirror................................... 83
Supplementary Restraints System.........35 Principle of Operation......................................... 35
Symbols Glossary
.............................................7
389
C-MAX (CCG) Canada/United States of America, enUSA, First Printing Index

W
Warning Lamps and Indicators................89
Anti-Lock Braking System................................ 89
Battery..................................................................... 89
Brake System........................................................ 89
Cruise Control....................................................... 89
Direction Indicator............................................... 89
Door Ajar................................................................. 89
EcoSelect................................................................ 89
Engine and Motor Coolant Temperature..................................................... 89
Engine Oil................................................................ 90
EV Later................................................................... 90
EV Now.................................................................... 90
Fasten Safety Belt............................................... 90
Front Airbag........................................................... 90
Front Fog Lamps.................................................. 90
High Beam.............................................................. 90
Liftgate Ajar........................................................... 90
Low Battery............................................................ 90
Low Fuel Level...................................................... 90
Low Tire Pressure Warning.............................. 90
Overdrive Cancel and Grade Assist..............90
Parking Lamps....................................................... 91
Powertrain Fault.................................................... 91
Ready to Drive........................................................ 91
Service Engine Soon............................................ 91
Stability Control..................................................... 91
Stability Control Off............................................ 92
Stop Safely............................................................. 92
Vehicle Plugged in................................................ 92
Washer Fluid Check.....................................227
Washers See: Cleaning the Exterior............................... 241
See: Wipers and Washers................................. 70
Waxing.............................................................242
Wheels and Tires
.........................................249
Technical Specifications................................. 274
Windows and Mirrors...................................80
Windshield Washers
......................................72
Windshield Wipers.........................................70
Intermittent Wipe................................................. 70
Speed Dependent Wipers................................ 70
Wiper Blades See: Checking the Wiper Blades.................. 229
Wipers and Washers.....................................70 Wrecker Towing
See: Transporting the Vehicle....................... 190
392
C-MAX (CCG) Canada/United States of America, enUSA, First Printing Index