steering FORD CONTOUR 1998 2.G User Guide
[x] Cancel search | Manufacturer: FORD, Model Year: 1998, Model line: CONTOUR, Model: FORD CONTOUR 1998 2.GPages: 200, PDF Size: 2.7 MB
Page 134 of 200
Maintenance and care
134
Power
steering
reservoirEngine
coolant
reservoir 2.5 litre EFI-engine compartment
For ease of identification, all filler caps and the engine oil dipstick are
marked yellow/black.Air
cleanerBrake fluid
reservoirAutomatic
transaxle
dipstick
(if equipped)
BatteryWindshield
washer fluid
reservoirEngine oil
dipstickPower
distribution
boxEngine oil
filler cap
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 134
Page 143 of 200
Maintenance and care
143
Checking and adding power
steering fluid
Switch off the engine. With the
steering system at normal
operating temperature, the fluid
level should come up to the MAX
mark.
If the fluid level drops below the
MIN mark, add the specified fluid.
Refer to the Capacities and
specificationschapter.
Severe winter climate
If you drive in extremely cold
climates (less than -36°C [-34°F]),
it may be necessary to increase the
coolant concentration above 50%.
Refer to the chart on the coolant
container to ensure the coolant
concentration in your vehicle is
such that the coolant will not
freeze at the temperature level in
which you drive during the winter
months. Never increase the engine
coolant concentration above 60%.
Leave a 50/50 mixture of engine
coolant and water in your vehicle
year-round in non-extreme
climates.
MAX
MIN
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 143
Page 158 of 200
Maintenance and care
158The tires on your vehicle have all-
weather treads to provide traction
in rain and snow. However, in some
climates, using snow tires and
chains may be necessary. Ford
offers snow chains as a Ford
approved accessory and
recommends use of these or their
equivalents on approved tires. See
your dealer or a qualified service
technician for more information on
tire chains for your vehicle. Follow
these guidelines when using snow
tires and chains:
•Install chains securely, verifying
that the chains do not touch any
wiring, brake lines or fuel lines.
•Install the chains on the front
tires only.
•Do not use tire chains on 205/60
tires and 205/55R16 Z rated tires.
Steering, suspension and body
components may be damaged by
use of chains.
Snow tires must be the same
size and grade as the tires
you currently have on your
vehicle.
Using snow tires and chains
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 158
Page 187 of 200
Capacities and specifications
187
* Total capacity
** with automatic transaxle
Engine oil
- with filter
- without
Manual transaxle2.6 l (2.7 qts)
Automatic transaxle
with oil cooler
Power steering
Cooling system with heating
Windshield washer fluid
Fuel tank
Braking system4.25 l (4.5 qts)
3.75 l (4.0 qts)
8.5 l (9.0 qts.)
6.6 l (7.0 qts)*
7.1 l (7.5 qts)**
Fill to MAX mark
Fill to top of reservoir
61.5 l (16.2 gallons)
Fill to MAX mark5.5 l (5.8 qts)
5.0 l (5.3 qts)
9.6 l (10.2 qts)
9.5 l (10.0 qts)*
9.7 l (10.2 qts)**
Capacities2.0 litre
engine2.5 litre
engine
CDW_VB1-5_Caps_en_C 5/15/97 8:58 PM Page 187
Page 188 of 200
Capacities and specifications
188
ItemFord part name
or equivalent
High performance
DOT 3 brake fluid
Premium engine
coolant
Motorcraft motor
oil 5W-30 super
premium
MERCON
®
power steering
fluid
Motorcraft
MERCON
®ATF
Ultra-clear
windshield washer
concentrate
Ford
part number
C6AZ-19542-AB
E2FZ-19549-AA
CXC-8-B*
XO-5W30-QSP
E6AZ-19582-AA
XT-2-QDX
C9AZ-19550-AA
or
C9AZ-19550-BA
Ford
specification
ESA-M6C25-A
WSE-97B44-A
American Petroleum
Institute Certification
Mark and
WSS-M2C153-G
MERCON®
MERCON®
ESR-M17P5-A Brake fluid
Engine coolant
Engine oil
Power steering
fluid
Transaxle fluid
automatic/
5-speed manual
Windshield
washer
fluid
Lubricant Specifications
CDW_VB1-5_Caps_en_C 5/15/97 8:58 PM Page 188
Page 194 of 200
CPage
Child safety restraints
built-in child seat . . . . . . . . . . .68
child safety seats . . . . . . . . . . . .74
children and safety belts . . .64, 66
Child safety seats
and air bags . . . . . . . . . . . . . . . .59
attaching with tether straps . . .77
automatic locking mode . . . . . .52
Childproof safety locks . . . . . . . .38
Chimes . . . . . . . . . . . . . . . . . . . . .13
Circuit breakers . . . . . . . . . . . . .112
Cleaning your vehicle
engine compartment . . . . . . . .182
exterior lamps . . . . . . . . . . . . .183
fabric . . . . . . . . . . . . . . . . . . . .184
instrument panel . . . . . . . . . . .184
plastic exterior parts . . . . . . . .183
safety belts . . . . . . . . . . . . . . .185
wheels . . . . . . . . . . . . . . . . . . .181
wiper blades . . . . . . . . . . . . . .183
Climate control system
air conditioning . . . . . . . . . . . . .24
controlling airflow . . . . . . . . . . .23
defrosting . . . . . . . . . . . . . . . . . .26
temperature . . . . . . . . . . . . . . . .23
vents . . . . . . . . . . . . . . . . . . . . . .22
Clock . . . . . . . . . . . . . . . . . . . . . .21
Clutch
operation . . . . . . . . . . . . . . . . . .96
recommended shift speeds . . . .97
Cold engine starting . . . . . . . . . .85
Controls
instrument panel . . . . . . . . . . . .17
mirrors . . . . . . . . . . . . . . . . . . . .20
power seats . . . . . . . . . . . . . . . .48
steering column . . . . . . . . . . . . .27DPage
Daytime running lights . . . . . . . .18
Defects, reporting . . . . . . . . . . .192
Defrost
rear window . . . . . . . . . . . . . . . .19
windshield . . . . . . . . . . . . . . . . .26
Dipstick, engine oil . . . . . . . . . .133
Door mounted controls . . . . . . . .37
Driving under special conditions
heavy load . . . . . . . . . . . . . . . .102
towing a trailer . . . . . . . . . . . .103
E
Electrical system
fuses . . . . . . . . . . . . . . . . . . . . .112
Emergencies, roadside
fuel pump shut-off switch . . . .110
jump starting . . . . . . . . . . . . . .124
towing . . . . . . . . . . . . . . . . . . .127
Emergency brake (see Parking
brake)
Emission control system . . . . . .166
Engine
check engine warning light . . . . .9
fuel pump shut-off switch . . . .110
lubricant specifications . . . . . .188
preparing to start . . . . . . . . . . .82
refill capacities . . . . . . . . . . . .187
starting . . . . . . . . . . . . . . . . . . . .85
Engine block heater . . . . . . . . . .86
Engine coolant
checking and adding . . . . . . . .139
disposal . . . . . . . . . . . . . . . . . .141
low coolant warning light . . . . . .8
refilll capacities . . . . . . . . . . . .187
specifications . . . . . . . . . . . . . .188
Engine fan . . . . . . . . . . . . . . . . .129
Index
194
CDW_Index_en_C 5/15/97 8:59 PM Page 194
Page 197 of 200
Index
197 MPage
Maintenance (see Servicing)
Manual transaxle
backing up (reverse) . . . . . . . . .98
clutch . . . . . . . . . . . . . . . . . . . . .96
fluid, capacity . . . . . . . . . . . . .187
fluid, checking and adding . . .138
shift speeds . . . . . . . . . . . . . . . .97
Mileage, calculating fuel
economy . . . . . . . . . . . . . . . . . . .165
Mirrors
side view mirrors (power) . . . .20
Motorcraft parts . . . . . . . . . . . .186
N
National Highway Traffic Safety
Administration . . . . . . . . . . . . . .192
O
Octane rating . . . . . . . . . . . . . . .163
Odometer . . . . . . . . . . . . . . . . . . .15
Oil (see Engine oil)
Oil filter . . . . . . . . . . . . . . .136, 187
On-board diagnostic (OBDII)
system . . . . . . . . . . . . . . . . . . . .169
Overdrive . . . . . . . . . . . . . . . . .9, 93
Overhead controls . . . . . . . . . . . .36
P
Panel dimmer control . . . . . . . . .19
Panic alarm, remote entry sytem42
Parking brake . . . . . . . . . . . . . . .89
Parts (see Motorcraft parts) . . .186
Passenger compartment
air filter (see Cabin air filter) . .150
Passive Anti-Theft
System (PATS) . . . . . . . . . . . . . .44PPage
Power distribution box
(see Fuses)
Power door locks . . . . . . . . . . . . .37
Power features
mirrors . . . . . . . . . . . . . . . . . . . .20
seats . . . . . . . . . . . . . . . . . . . . . .48
sunroof . . . . . . . . . . . . . . . . . . . .36
windows . . . . . . . . . . . . . . . . . . .37
Power steering
fluid, checking and adding . . .143
fluid, refill capacity . . . . . . . . .187
fluid, specification . . . . . . . . . .188
R
Radio (see Audio system) . . . . . .21
Rear window defroster . . . . . . . .19
Refill capacities for fluids . . . . .187
Relays . . . . . . . . . . . . . . . . . . . . .112
Remote control
luggage compartment . . . . . . . .39
Remote entry system
locking/unlocking doors . . . . . .41
opening the trunk . . . . . . . . . . .42
panic alarm . . . . . . . . . . . . . . . .42
replacing the batteries . . . . . . .42
replacement/additional
transmitters . . . . . . . . . . . . . . . .43
Repairing paint chips . . . . . . . .181
Reporting safety defects . . . . . .192
Restraints, safety . . . . . . . . . . . . .50
Rotating the tires . . . . . . . . . . . .155
CDW_Index_en_C 5/15/97 8:59 PM Page 197
Page 198 of 200
SPage
Safety belts
(see Safety restraints)
Safety chains, when towing
a trailer . . . . . . . . . . . . . . . . . . . .107
Safety Compliance Certification
Label . . . . . . . . . . . . . . . . . . . . . .105
Safety defects, reporting . . . . . .192
Safety restraints
adjusting the safety belts . .50, 54
automatic locking mode
(retractors) . . . . . . . . . . . . . . . .52
cleaning the safety belts . . . . .185
extention assembly . . . . . . . . . .56
for children . . . . . . . . . . . . . . . .64
head restraints . . . . . . . . . . . . .47
lap and shoulder belts . . . . . . . .51
maintenance . . . . . . . . . . .57, 185
vehicle sensitive locking mode .52
warning light and chime . . . .7, 12
Safety seats for children
and air bags . . . . . . . . . . . . .59, 75
attaching with tether straps . . .77
automatic locking mode
(retractors) . . . . . . . . . . . . .53, 74
built-in child seat . . . . . . . . . . .68
in front seat . . . . . . . . . . . . .59, 75
tether anchorage hardware . . .78
Seats
adjusting the seats, manual . . .47
adjusting the seats, power . . . .48
folding rear seats . . . . . . . . . . . .49
head restraints . . . . . . . . . . . . .47
Servicing your vehicle . . . . . . . .128
Shift-lock system . . . . . . . . . . . . .91
Shift positions (see Gearshift)
Snow tires and chains . . . . . . . .158SPage
Spare tire
changing the tire . . . . . . . . . . .119
removing the spare tire . . . . . .121
temporary spare tire . . . . . . . .120
Spark plugs, certifications . . . .186
Specification charts, lubricants188
Speed control
disengaging speed control . . . .35
return to a set speed . . . . . . . . .35
set a speed . . . . . . . . . . . . . . . . .33
set a higher speed . . . . . . . . . . .34
set a lower speed . . . . . . . . . . . .34
turn speed control off . . . . . . . .32
turn speed control on . . . . . . . .32
Speedometer . . . . . . . . . . . . . . . .15
Starting your vehicle
preparing to start the vehicle . .82
starting the engine . . . . . . . . . .85
Steering column controls . . . . . .27
Steering wheel
horn . . . . . . . . . . . . . . . . . . . . . .29
speed control . . . . . . . . . . . . . . .32
tilting . . . . . . . . . . . . . . . . . . . . .28
Sunroof . . . . . . . . . . . . . . . . . . . .36
Supplemental restraint
system . . . . . . . . . . . . . . . . . .13, 58
T
Tachometer . . . . . . . . . . . . . . . . .14
Tail lamps (see Rear lamps)
Temperature control
(see Climate control)
Testing the warning lights . . . . . .12
Tether anchor installation
(see Child safety restraints)
Tilt steering wheel . . . . . . . . . . . .28
Index
198
CDW_Index_en_C 5/15/97 8:59 PM Page 198