warning light FORD E SERIES 2014 4.G Service Manual

Low tire pressure
warning lightPossible cause Customer action required
Flashing warning
lightSpare tire in use Repair the damaged road wheel
and tire assembly and reinstall it
on the vehicle to restore system
function. For a description on
how the system functions, see
When your temporary spare
tire is installedin this section.
TPMS
malfunctionIf the tires are properly inflated
and the spare tire is not in use
but the light remains on, contact
your authorized dealer as soon
as possible.
When inflating your tires
When putting air into your tires (such as at a gas station or in your
garage), the tire pressure monitoring system may not respond
immediately to the air added to your tires.
It may take up to two minutes of driving over 20 mph (32 km/h) for the
light to turn off after you have filled your tires to the recommended
inflation pressure.
How temperature affects your tire pressure
The tire pressure monitoring system monitors tire pressure in each
pneumatic tire. While driving in a normal manner, a typical passenger
tire inflation pressure may increase approximately 2 to 4 psi (14 to
28 kPa) from a cold start situation. If the vehicle is stationary overnight
with the outside temperature significantly lower than the daytime
temperature, the tire pressure may decrease approximately 3 psi
(21 kPa) for a drop of 30°F (17°C) in ambient temperature. This lower
pressure value may be detected by the system as being significantly
lower than the recommended inflation pressure and activate the system
warning light for low tire pressure. If the low tire pressure warning light
is on, visually check each tire to verify that no tire is flat. If one or more
tires are flat, repair as necessary. Check air pressure in the road tires. If
any tire is under-inflated, carefully drive the vehicle to the nearest
location where air can be added to the tires. Inflate all the tires to the
recommended inflation pressure.
Wheels and Tires257
2014 Econoline(eco)
Owners Guide gf, 1st Printing, November 2012
USA(fus)

Tire Pressure Monitoring System Reset Procedure
WARNING:To determine the required pressure(s) for your
vehicle, see the Safety Compliance Certification Label (affixed to
either the door hinge pillar, door-latch post, or the door edge that
meets the door-latch post, next to the driver’s seating position), or Tire
Label located on the B-Pillar or the edge of the driver’s door. See the
Load Carryingchapter for more information.
Note:The system reset procedure needs to be performed after each tire
rotation on vehicles that require different recommended tire pressures in
the front tires as compared to the rear tires.
Overview
To provide the vehicle’s load carrying capability, some vehicles require
different recommended tire pressures in the front tires as compared to
the rear tires. The tire pressure monitoring system equipped on these
vehicles is designed to illuminate the low tire pressure warning light at
two different pressures; one for the front tires and one for the rear tires.
Since tires need to be rotated to provide consistent performance and
maximum tire life, the tire pressure monitoring system needs to know
when the tires are rotated to determine which set of tires are on the
front and which are on the rear. With this information, the system can
detect and properly warn of low tire pressures.
System reset tips:
•To reduce the chances of interference from another vehicle, the
system reset procedure should be performed at least three feet (one
meter) away from another Ford Motor Company vehicle undergoing
the system reset procedure at the same time.
•Do not wait more than two minutes between resetting each tire sensor
or the system will time-out and the entire procedure will have to be
repeated on all four wheels.
•A double horn chirp indicates the need to repeat the procedure.
Performing the System Reset Procedure
It is recommended that you read the entire procedure before attempting.
1. Drive the vehicle above 20 mph (32 km/h) for at least two minutes
and then park in a safe location where you can easily get to all four tires
and have access to an air pump.
2. Place the ignition in the off position and keep the key in the ignition.
258Wheels and Tires
2014 Econoline(eco)
Owners Guide gf, 1st Printing, November 2012
USA(fus)

10. Turn the ignition off. If two short horn beeps are heard, the reset
procedure was unsuccessful and must be repeated.
If after repeating the procedure and two short beeps are heard when the
ignition is turned to off, seek assistance from your authorized dealer.
11. Set all four tires to the recommended air pressure as indicated on
the Safety Compliance Certification Label or Tire Label.
Full-size matching spare tire and wheel information
This spare tire and wheel will match the road tire and wheel. When
driving with the full size matching spare tire and wheel, do not exceed
70 mph (113 km/h). It is intended for temporary use only. This means if
you need to use it, you should replace it as soon as possible.
CHANGING A ROAD WHEEL
WARNING:The use of tire sealants may damage your tire
pressure monitoring system and should not be used. However, if
you must use a sealant, have an authorized dealer install a new tire
pressure monitoring system sensor and valve stem.
WARNING:SeeTire Pressure Monitoring Systemin this
chapter for important information. If the tire pressure monitoring
sensor becomes damaged, it will no longer function.
Note:The tire pressure monitoring system indicator light will illuminate
when the spare tire is in use. To restore the full function of the
monitoring system, all road wheels equipped with tire pressure
monitoring sensors must be mounted on this vehicle.
If you get a flat tire while driving, do not apply the brake heavily.
Instead, gradually decrease your speed. Hold the steering wheel firmly
and slowly move to a safe place on the side of the road.
Have a flat serviced by an authorized dealer in order to prevent damage
to the system sensors. SeeTire Pressure Monitoring Systemearlier in
this chapter. Replace the spare tire with a road tire as soon as possible.
During repairing or replacing of the flat tire, have the authorized dealer
inspect the tire pressure monitoring system sensor for damage.
260Wheels and Tires
2014 Econoline(eco)
Owners Guide gf, 1st Printing, November 2012
USA(fus)

Owner Checks and Services
Certain basic maintenance checks and inspections should be performed
every month or at six month intervals.
Check every month
Engine oil level.
Function of all interior and exterior lights.
Tires (including spare) for wear and proper pressure.
Windshield washer fluid level.
Check every six months
Battery connections. Clean if necessary.
Body and door drain holes for obstructions. Clean if necessary.
Cooling system fluid level and coolant strength.
Door weatherstrips for wear. Lubricate if necessary.
Hinges, latches and outside locks for proper operation. Lubricate if
necessary.
Parking brake for proper operation.
Safety belts and seat latches for wear and function.
Safety warning lamps (brake, ABS, airbag, safety belt) for operation.
Washer spray and wiper operation. Clean or replace blades as
necessary.
416Scheduled Maintenance
2014 Econoline(eco)
Owners Guide gf, 1st Printing, November 2012
USA(fus)

911 Assist™ ..............................318
A
ABS (see Brakes) .....................128
Accessing call history/phone
book during active call .............307
Accessing the help screen .......380
Accessing the music in your
jukebox ......................................374
Accessing your media menu
features ......................................330
Accessing your phone menu
features ......................................309
Accessory delay ..........................71
Active call menu options .........307
Advanced menu options ...316, 337
Advanced menu options
(prompts, languages, defaults,
master reset, installing
applications) ..............................316
Airbag supplemental restraint
system ..........................................46
and child safety seats ..............47
description ................................46
disposal ......................................53
driver airbag ..............................46
passenger airbag .......................46
passenger deactivation
switch ........................................48
side airbag .................................46
Air cleaner filter ...............213, 279
Air conditioning ....................90–91
manual heating and air
conditioning system ...........90–91
Ambulance packages ..................15
AM/FM .......................................356Antifreeze
(see Engine coolant) ................197
Anti-lock brake system
(see Brakes) ..............................128
Anti-theft system ........................62
arming the system ....................62
AppLink™ .................................325
Audio system
Single CD ........................290–291
Audio system
(see Radio) ........................290–291
Automatic transmission
driving an automatic
overdrive .........................120, 122
fluid, adding ............................201
fluid, checking ........................201
fluid, refill capacities ..............272
fluid, specification ..................272
Auxiliary input jack (Line in) ..296
Auxiliary powerpoint ................102
Axle
lubricant specifications ..........272
refill capacities ........................272
traction lok ..............................127
B
Battery .......................................209
acid, treating emergencies .....209
jumping a disabled battery ....174
maintenance-free ....................209
replacement, specifications ...279
servicing ..................................209
Booster seats ...............................22
Brakes ........................................128
anti-lock ...................................128
anti-lock brake system (ABS)
warning light ...........................128
Index431
2014 Econoline(eco)
Owners Guide gf, 1st Printing, November 2012
USA(fus)

brake warning light ................128
fluid, checking and adding ....207
fluid, refill capacities ..............272
fluid, specifications .................272
lubricant specifications ..........272
parking ....................................129
shift interlock ..........................125
trailer ...............................156–157
C
Capacities for refilling
fluids ..........................................272
CD ......................................290–291
CD player ..................................288
CD voice
commands .................370, 372–373
Cell phone use ............................16
Changing a tire .........................260
Child safety seats
automatic locking mode
(retractor) .................................38
LATCH .......................................28
tether anchorage hardware .....33
Child safety seats -
booster seats ...............................22
Cleaning the touchscreen ........351
Cleaning your vehicle ...............224
engine compartment ..............226
instrument panel ....................228
interior .....................................228
plastic parts ............................225
washing ....................................224
waxing .....................................226
wheels ......................................230
wiper blades ............................227
Climate control
(see Air conditioning or
Heating) .................................90–91Clock ..................................290–291
Coolant ......................................197
checking and adding ..............197
refill capacities ........................272
specifications ..........................272
Creating a playlist .....................375
Cruise control ...........................140
Customer Assistance ................171
Ford Extended Service
Plan ..........................................285
Getting roadside
assistance ................................171
Getting the service you
need .........................................177
Ordering additional owner’s
literature .................................183
Utilizing the
Mediation/Arbitration
Program ...................................181
Customizing your home
screen ........................................349
D
Daytime running lamps
(see Lamps) ................................68
Defrost ...................................90–91
Dipstick
automatic transmission
fluid ..........................................201
engine oil .................................196
Drivebelt ....................................271
Driveline universal joint and
slip yoke ....................................207
Driving under special
conditions ..................................126
through water .........................168
432Index
2014 Econoline(eco)
Owners Guide gf, 1st Printing, November 2012
USA(fus)

I
Ignition .......................106, 270–271
Illuminated visor mirror .............75
Information displays ...................82
Inspection/maintenance (I/M)
testing ........................................119
Instrument panel
cleaning ...................................228
cluster ........................................77
J
Jack ............................................260
positioning ...............................260
storage .....................................260
Joining two calls
(multiparty/conference call) ....307
Jukebox features .......................374
Jump-starting your vehicle ......174
K
Keyless entry system
autolock .....................................58
Keys .............................................63
positions of the ignition .........106
L
Lamps ..........................................67
bulb replacement
specifications chart ................223
daytime running light ...............68
headlamps .................................67
headlamps, flash to pass ..........67
interior lamps ...........................69
replacing bulbs .......................217
LATCH anchors ...........................28Lights, warning and indicator ....77
Loading instructions .................149
Loading pictures .......................349
Load limits .................................143
Locks
autolock .....................................58
doors ..........................................57
Lubricant specifications ...........272
Lug nuts ....................................268
M
Map icons ..................................395
Map mode ..................................395
Map updates ..............................399
Media Bluetooth menu options
(adding, connecting, deleting,
turning on/off) ..........................336
Message center ...........................82
system check button ................83
warning messages .....................87
Mirrors ...................................72, 75
fold away ...................................72
side view mirrors
(power) .....................................72
Motorcraft® parts .............224, 279
N
Navigation end user license
agreement ..................................409
Navigation features ...................381
O
Octane rating ............................113
434Index
2014 Econoline(eco)
Owners Guide gf, 1st Printing, November 2012
USA(fus)

P
Pairing other phones ................304
Pairing your phone for the
first time ....................................303
Parking brake ............................129
Parts
(see Motorcraft® parts) ..........279
Phone Bluetooth menu options
(adding, connecting, deleting,
turning on/off) ..........................315
Phone redial ..............................309
Playing music (by artist,
album, genre, playlist, tracks,
similar) ......................................333
POI categories ...........................390
Point of Interest (POI) .............390
Power distribution box
(see Fuses) ...............................186
Power door locks ........................57
Power mirrors .............................72
Powerpoint ................................102
Power steering ..........................142
fluid, checking and adding ....208
fluid, refill capacity ................272
fluid, specifications .................272
Power Windows ...........................71
Preparing to drive your
vehicle ........................................165
Privacy information ..................300
Putting a call on/off hold .........307
Q
Quick touch buttons .................398R
Radio ..................................290–291
Single CD ........................290–291
Radio reception .........................288
Radio voice commands .....357, 363
Rear view camera display ........136
Rear window defroster .........90–91
Receiving a text message .........311
Recommendations for
attaching safety restraints
for children ..................................24
Relays ................................185–186
Remote entry system
illuminated entry ......................59
locking/unlocking doors ...........57
replacing the batteries .............55
Reverse sensing system ...........135
Roadside assistance ..................171
Roll stability control .................133
S
Safety Belt Maintenance ............43
Safety belts
(see Safety restraints) ...............40
Safety defects, reporting ..........184
Safety information ....................299
Safety restraints ..............37–38, 40
Belt-Minder® ............................40
extension assembly ..................39
for adults .............................37–38
for children ...............................24
safety belt maintenance ...........43
seat belt maintenance ..............43
warning light and chime ..........40
Index435
2014 Econoline(eco)
Owners Guide gf, 1st Printing, November 2012
USA(fus)

trailer towing ..........................150
wrecker ....................................163
Traction control ........................130
Traction-lok rear axle ...............127
Traffic, Directions and
Information ................................323
Trailer Brake
Controller-Integrated ................157
Transmission .............................120
brake-shift interlock (BSI) ....125
fluid, checking and adding
(automatic) .............................201
fluid, refill capacities ..............272
lubricant specifications ..........272
Troubleshooting ........................400
Turn signal ..................................69
U
Upfitter controls .......................284
USB port ....................................297
Using privacy mode ..................307
V
Vehicle health report ................321Vehicle Identification Number
(VIN) ..........................................280
Vehicle loading ..........................143
Ventilating your vehicle ...........108
Voice commands in media
mode ..........................................328
Voice commands in phone
mode ..........................................305
Voice recognition ......................351
W
Warning lights (see Lights) .......77
Washer fluid ..............................208
Water, Driving through .............168
Where am I? ..............................377
Windows
power .........................................71
Windshield washer fluid and
wipers ..........................................66
checking and adding fluid .....208
replacing wiper blades ...........212
Wrecker towing .........................163
Index437
2014 Econoline(eco)
Owners Guide gf, 1st Printing, November 2012
USA(fus)