automatic transmission fluid FORD EDGE 2008 1.G Owners Manual
[x] Cancel search | Manufacturer: FORD, Model Year: 2008, Model line: EDGE, Model: FORD EDGE 2008 1.GPages: 336, PDF Size: 2.8 MB
Page 320 of 336
TRANSAXLE FLUID
Checking automatic transaxle fluid
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes.Your transaxle does not consume
fluid. However, the fluid level should be checked if the transaxle is not
working properly, i.e., if the transaxle slips or shifts slowly or if you
notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 20 miles [30 km]). If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry lint free rag. If
necessary, refer toIdentifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect the fluid level. The fluid should be in
the designated areas for normal operating temperature.
Low fluid level
Do not drive the vehicle if the fluid
level is in the add range or does not
show at all on the dipstick.
Correct fluid level
The transmission fluid should be checked at normal operating
temperature 149°F (65°C) on a level surface. The normal operating
temperature can be reached after approximately 20 miles (30 km) of
driving.
2008 Edge(edg)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
320
Page 321 of 336
The transmission fluid should be
within the cross-hatch area if at
normal operating temperature 149°F
(65°C).
High fluid level
Fluid levels above the safe range
may result in transaxle failure. An
overfill condition of transmission
fluid may cause shift and/or
engagement concerns and/or possible damage.
High fluid levels can be caused by an overheating condition.
Adjusting automatic transmission fluid levels
Before adding any fluid, make sure the correct type is used. The type of
fluid used is normally indicated on the dipstick and also in the
Maintenance product specifications and capacitiessection in this
chapter.
Use of a non-approved automatic transmission fluid may cause
internal transaxle component damage.
If necessary, add fluid in 1/2 pint
(250 mL) increments through the
filler tube until the level is correct.
If an overfill occurs, excess fluid
should be removed by an authorized
dealer.
An overfill condition of
transmission fluid may cause shift and/or engagement concerns
and/or possible damage.
Do not use supplemental transmission fluid additives, treatments or
cleaning agents. The use of these materials may affect transmission
operation and result in damage to internal transaxle components.
AIR FILTER
Refer toscheduled maintenance informationfor the appropriate
intervals for changing the air filter element.
When changing the air filter element, use only the Motorcraft air filter
element listed. Refer toMotorcraft part numbersin this chapter.
2008 Edge(edg)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
321
Page 325 of 336
Item Capacity Ford part nameFord part number /
Ford specification
Automatic
transmission fluid10.0 quarts (9.5L)
3
Motorcraft MERCONV
AT F
4
XT-5-QM /
MERCONV
Rear differential
(AWD) fluid2.4 pints (1.15L)Motorcraft SAE 80W-90
Premium Rear Axle
LubricantXY-80W90-QL /
WSP-M2C197-A
Power Transfer Unit
(PTU) fluid (AWD)
5
12 ounces (0.35L)Motorcraft SAE 75W-140
Synthetic Rear Axle
LubricantXY-75W140-QL /
WSL-M2C192-A
Windshield washer
fluid4.75 quarts (4.5L)Motorcraft Premium
Windshield Washer
ConcentrateZC-32-A /
WSB-M8B16-A2
Fuel tank
(front-wheel drive)19.2 gallons
(72.7L)——
Fuel tank (all-wheel
drive)20.8 gallons
(78.7L)——
1Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the
requirements of Ford specification WSS-M2C930-A and the API Certification mark.2Add the coolant type originally equipped in your vehicle.3Indicates only approximate dry-fill capacity. Some applications may vary based on cooler size and
if equipped with an in-tank cooler. The amount of transmission fluid and fluid level should be set
by the indication on the dipstick’s normal operating range.4Automatic transmissions that require MERCONV should only use MERCONV fluid or fluid that
is specified dual usage MERCON/MERCONV. Refer toscheduled maintenance informationto
determine the correct service interval. Use of any fluid other than the recommended fluid may
cause transmission damage.5See your authorized dealer for fluid level checking or filling.
2008 Edge(edg)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
325
Page 331 of 336
A
Accessory delay ..........................97
AdvanceTrac ..............................238
Air cleaner filter ...............321–323
Air conditioning ..........................77
Airbag supplemental restraint
system ........................171, 180, 183
and child safety seats ............173
description ..............171, 180, 183
disposal ....................................186
driver airbag ............173, 181, 184
indicator light .........179, 182, 185
operation .................173, 181, 184
passenger airbag .....173, 181, 184
side airbag ...............................180
All Wheel Drive (AWD),
driving off road .........................247
Antifreeze
(see Engine coolant) ................302
Anti-lock brake system
(see Brakes) ..............................236
Anti-theft system ......................141
Audio system
(see Radio) ......................18, 22, 30
Automatic transaxle
fluid, adding ............................320
fluid, checking ........................320
Automatic transmission
driving an automatic
overdrive .................................243
fluid, refill capacities ..............324
fluid, specification ..................324
Auxiliary input jack (Line in) ....38
Auxiliary power point .................94
Axle
lubricant specifications ..........324B
Battery .......................................300
acid, treating emergencies .....300
jumping a disabled battery ....270
maintenance-free ....................300
replacement, specifications ...323
servicing ..................................300
Belt-Minder.............................166
Booster seats .............................187
Brakes ........................................236
anti-lock ...................................236
anti-lock brake system (ABS)
warning light ...........................237
fluid, checking and adding ....319
fluid, refill capacities ..............324
fluid, specifications .................324
lubricant specifications ..........324
parking ....................................237
shift interlock ..........................242
Bulbs ............................................86
C
Capacities for refilling fluids ....324
Cargo management system ......124
Cell phone use ..............................7
Changing a tire .................264, 267
Child safety restraints ..............186
child safety belts ....................186
Child safety seats ......................190
attaching with tether straps ..194
in front seat ............................191
in rear seat ..............................191
Child safety seats - booster
seats ...........................................187
Cleaning your vehicle
engine compartment ..............287
2008 Edge(edg)
Owners Guide (post-2002-fmt)
USA(fus)
Index
331
Page 332 of 336
instrument panel ....................289
interior .....................................290
plastic parts ............................287
safety belts ..............................290
washing ....................................285
waxing .....................................286
wheels ......................................286
wiper blades ............................288
Climate control (see Air
conditioning or Heating) ............77
Clock adjust
6-CD in dash .............................32
AM/FM/CD .................................24
Compass, electronic
set zone adjustment ...............113
Console ........................................94
overhead ....................................93
Controls
power seat ...............................148
steering column ......................102
Convertible
cleaning ...................................288
Coolant
checking and adding ..............302
refill capacities ................305, 324
specifications ..........................324
Cruise control
(see Speed control) ....................99
Cupholder(s) .............................155
Customer Assistance ................254
Ford Extended Service
Plan ..........................................281
Getting assistance outside the
U.S. and Canada .....................282
Getting roadside assistance ...254
Getting the service you
need .........................................277
Ordering additional owner’s
literature .................................283Utilizing the
Mediation/Arbitration
Program ...................................281
D
Daytime running lamps
(see Lamps) ................................82
Dipstick
automatic transmission
fluid ..........................................320
engine oil .................................296
Driving under special
conditions ..................245, 248, 251
sand .........................................249
snow and ice ...........................252
through water .................250, 253
DVD system .................................45
E
Electronic message
center .................................109–110
Emergencies, roadside
jump-starting ..........................270
Emission control system ..........316
Engine ........................................326
cleaning ...................................287
coolant .....................................302
fail-safe cooling .......................306
idle speed control ...................300
lubrication specifications .......324
refill capacities ........................324
service points ..........................294
starting after a collision .........256
Engine block heater .................234
Engine oil ..................................296
change oil soon warning,
message center .......................296
checking and adding ..............296
2008 Edge(edg)
Owners Guide (post-2002-fmt)
USA(fus)
Index
332
Page 336 of 336
T
Tilt steering wheel ......................92
Tire Pressure Monitoring
System (TPMS)
Tires, Wheels and Loading ....215
Tires ...........................200–201, 264
alignment ................................208
care ..........................................204
changing ..................264, 266–267
checking the pressure ............204
inflating ...................................202
label .........................................214
replacing ..................................206
rotating ....................................208
safety practices .......................207
sidewall information ...............209
snow tires and chains ............219
spare tire .........................264, 266
terminology .............................201
tire grades ...............................201
treadwear ........................200, 205
Towing .......................................225
recreational towing .................229
trailer towing ..........................225
wrecker ....................................275
Transaxle
fluid, checking and adding
(automatic) .............................320
Transmission .............................242brake-shift interlock (BSI) ....242
fluid, refill capacities ..............324
lubricant specifications ..........324
Turn signal ..................................85
U
USB port ......................................39
V
Vehicle Identification Number
(VIN) ..........................................327
Vehicle loading ..........................219
Ventilating your vehicle ...........234
W
Warning lights (see Lights) .......10
Washer fluid ..............................295
Water, Driving through .............253
Windows
power .........................................96
rear wiper/washer .....................92
Windshield washer fluid and
wipers ..........................................91
checking and adding fluid .....295
replacing wiper blades ...295–296
Wrecker towing .........................275
2008 Edge(edg)
Owners Guide (post-2002-fmt)
USA(fus)
Index
336