brake fluid FORD ESCORT 1996 7.G Owners Manual

120 [LG02549(E )06/94]Safety Belt Warning Light/Chime
(Canadian vehicles equipped with
combination lap and shoulder belts)
[LG02550(E )09/95]
This warning light and chime remind you in two
ways to fasten your safety belt. If you do not
fasten the safety belt before you turn the ignition
key to ON, the chime sounds for four (4) to
eight (8) seconds. Also, each time you turn the
ignition key to ON, the warning light comes on
for one to two minutes to remind you to fasten
your combination lap and shoulder belt.
[LG02700(ALL)03/91]
one inch art:0070005-A
The safety belt light
[LG02750(ALL)08/95]
Brake Warning Light
*
[LG02900(ALL)03/95]
The warning light for the brakes can show two
things Ð that the parking brake is not fully
released, or that the brake fluid level is low in
the master cylinder reservoir. If the fluid level is
low, the brake system should be checked by
your dealer or a qualified service technician.
[LG03500(ALL)12/89]
This light comes on when you turn the ignition
key to START, but it normally goes off shortly
after the engine starts and you release the
parking brake. If the light stays on or comes on
after you have released the parking brake fully,
have the hydraulic brake system serviced.
File:05ctlge.ex
Update:Tue Sep 19 14:44:43 1995

315
%*
[SV29300(ALL)05/95]
Automatic Transaxle Fluid
*
[SV29310(ALL)03/95]
Under normal circumstances, you do not need to
check the fluid level of the transaxle, since your
vehicle does not use up transaxle fluid. Refer to
theMaintenance Schedule and Recordbooklet for
replacement intervals. However, if the transaxle
is not working properly Ð for instance, the
transaxle may slip or shift slowly, or you may
notice some sign of fluid leakage Ð the fluid
level should be checked.
*
[SV29335(ALL)01/95]
NOTE: If the vehicle has been operated for an
extended period at high speeds, driven
in city traffic during hot weather, or
has been pulling a trailer, the vehicle
should be turned off for about 30
minutes to allow the fluid to cool
before checking.
%*
[SV29340(ALL)02/93]
Checking the Automatic Transaxle Fluid
[SV29345(ALL)03/95]
It is preferable to check the transaxle fluid level
at normal operating temperature after
approximately 20 miles (32 km) of driving.
*
[SV29350(ALL)02/95]
With the vehicle on a level surface and the brake
pedal fully applied, start the engine and move
the gearshift selector through all of the gears.
Allow sufficient time for each position to engage.
Securely latch the gearshift selector in the P
(Park) position. Fully set the parking brake and
leave the engine running.
*
[SV29370(ALL)01/95]
Wipe off the dipstick cap and pull the dipstick
out. Wipe the indicator end clean. Put the
dipstick back into the filler tube and make sure
it is fully seated. Pull the dipstick out and read
the fluid level.
[SV29392(ALL)12/89]
When checking fluid at the normal operating
temperature, the fluid level should be within the
normal operating temperature marks on the
File:15ctsve.ex
Update:Tue Sep 19 14:37:50 1995

317 %
*
[SV29425(ALL)04/95]
NOTE: Always dispose of used automotive
fluids in a responsible manner. Follow
your community's standards for
disposing of these types of fluids. Call
your local recycling center to find out
about recycling automotive fluids.
*
[SV29800(ALL)01/89]
Manual Transaxle Fluid
[SV29900(ALL)01/92]
The lubricant level and quality should not
deteriorate under normal driving conditions.
However, you should have the fluid level
checked occasionally. If lubricant is required, see
Lubricant specificationsin the Index.
%*
[SV30200(ALL)02/95]
Brake Fluid
[SV30250(ALL)02/94]
If you have a manual transaxle, the brake fluid
reservoir in your vehicle includes the clutch
fluid reservoir.
*
[SV30300(ALL)03/95]
Under normal circumstances, your vehicle
should not use up brake fluid rapidly. However,
expect the level of the brake fluid to slowly fall
as you put more mileage on your vehicle and
the brake pads wear.
%*
[SV30400(ALL)06/93]
You should check the brake fluid at every
scheduled engine oil change, but be sure to
check it at least once a year. You can do this by
looking at the fluid level in the plastic reservoir
on the master cylinder. (SeeThe Engine Typesin
this chapter to locate the master cylinder.) The
fluid level should be at or near the MAX mark.
[SV30425(ALL)03/95]
If the brake fluid level is low, the brake warning
light in the instrument cluster will illuminate.
*
[SV30450(ALL)05/95]
RWARNING
Brake fluid is toxic.
File:15ctsve.ex
Update:Tue Sep 19 14:37:50 1995

318
*
[SV30460(ALL)07/95]
If brake fluid contacts eyes, flush eyes with
running water for 15 minutes. Get medical
attention if irritation persists. If taken internally,
drink water and induce vomiting. Get medical
attention immediately.
[SV30475(ALL)07/93]
one third page art:0070173-A
Brake fluid master cylinder reservoir
%*
[SV30500(ALL)02/95]
If the fluid is low, carefully clean and remove
the filler cap from the reservoir. Fill the
reservoir to the MAX line with Ford High
Performance DOT 3 Brake Fluid C6AZ-19542-AA
or DOT 3 equivalent fluid meeting Ford
specification ESA-M6C25-A.
*
[SV30800(ALL)01/95]
RWARNING
If you use a brake fluid that is not DOT
3, you will cause permanent damage to
your brakes.
*
[SV30900(ALL)01/95]
Do not fill the reservoir above the MAX line.
[SV30950(ALL)06/93]
NOTE: Avoid spilling brake fluid on painted
surfaces.
*
[SV31000(ALL)01/95]
If you find that the fluid level is excessively low
Ð below the seam or ridge on the outside of the
plastic reservoir Ð have the brake system
inspected.
File:15ctsve.ex
Update:Tue Sep 19 14:37:50 1995

319
*
[SV31100(ALL)01/95]
RWARNING
Do not let the reservoir for the master
cylinder run dry. This may cause the
brakes to fail.
%*
[SV31200(ALL)02/95]
Power Steering Fluid
*
[SV31300(ALL)01/95]
Check the level of the power steering fluid at
least twice a year (i.e., every Spring and Fall).
%*
[SV31400(ALL)03/95]
Checking and Adding Power Steering
Fluid
*
[SV31500(ALL)02/95]
1. Start the engine and let it run until the
power steering fluid reaches normal
operating temperature. The power steering
fluid will be at the right temperature when
the engine coolant temperature gauge in the
instrument cluster is near the center of the
NORMAL operating temperature range.
*
[SV31600(ALL)01/95]
2. While the engine idles, turn the steering
wheel back and forth several times. Make
sure that the cap assembly is installed at this
time.
*
[SV31700(ALL)05/95]
3. Turn the engine off.
[SV31850(ALL)02/94]
4. Check the fluid level in the reservoir. The
fluid level should be in between the F (Full)
and L (Low) markings on the reservoir.
[SV32100(ALL)02/94]
5. If the power steering fluid is low, add fluid
in small amounts, continuously checking the
level until you reach the F (Full) range. Do
not overfill. To find out how much fluid
your vehicle's reservoir for the power
steering fluid will hold, seeRefill capacitiesin
the Index.
[SV32150(ALL)03/95]
6. When you are finished, put the reservoir cap
back on and make sure that it fits snugly.
File:15ctsve.ex
Update:Tue Sep 19 14:37:50 1995

372 Index
Automatic transaxle
driving with............. 223
fluid, adding............. 315
fluid, checking............ 315
fluid, refill capacities......... 345
fluid, specification........... 348
B
Backing up............... 229
Basic vehicle warranty........... 4
Battery................. 313
acid, treating emergencies....... 243
charging system warning light..... 121
disconnecting............. 248
how to service............ 313
jumping a disabled battery....... 243
maintenance-free........... 313
proper disposal, recycling....... 314
replacement, specifications....... 347
servicing............... 313
when storing your vehicle....... 352
Brake fluid
checking and adding......... 317
description.............. 317
specifications...........318, 348
Brakes
anti-lock............... 233
anti-lock brake system (ABS)
warning light............ 127
applying the brakes.......... 232
fluid, checking and adding....... 317
fluid, specifications.......... 348
new brake linings............ 5
noise................. 233
parking............... 235
servicing............... 317
stopping distances........... 238
when storing your vehicle....... 352
Break-in period.............. 5
Brights (high beams)........... 160
File:ctixe.ex
Update:Tue Sep 19 15:00:54 1995

382 Index
Overdrive................ 226
Overseas offices............. 269
P
Parking brake
operation............... 235
Parts (see Motorcraft Parts)........ 347
PCV valve, specifications......... 347
Power door locks............ 170
Power features
door locks.............. 170
mirrors................ 184
moon roof.............. 174
windows............... 172
Power steering
dipstick............... 319
driving with power steering...... 232
fluid, checking and adding....... 319
fluid, refill capacity.......... 345
fluid, specifications.......... 348
Prop rod, hood............. 282
R
Radio (see Electronic sound systems) . . . 197
Rear axle
lubricant specification......... 349
Rear window.............. 172
washer reservoir........... 301
Refill capacities for fluids........ 345
Restraints, safety (see Safety restraints)
adult.................. 9
child.................. 58
head................. 177
infant................. 58
Roadside assistance........... 259
Roadside emergencies.......... 243
Rotating the tires............ 307
File:ctixe.ex
Update:Tue Sep 19 15:00:54 1995