trailer FORD ESCORT 1997 6.G Owners Manual

²GAWR (Gross axle weight
rating)Ð carrying capacity for
each axle system (front and
rear). This amount is specific to
each vehicle and is listed on the
Safety Compliance Certification
Label on the driver's door pillar.
Payload = Gross vehicle weight
rating - Base curb weight
To obtain correct weights, try
taking your vehicle to a shipping
company or an inspection station
for trucks.
Do not use replacement tires with
lower weight capacities than the
originals because they may lower
the vehicle's GVWR and GAWR
limitations. (Replacement tires
with a higher weight limit than the
originals do not increase the
GVWR and GAWR limitations.)
If the GVWR or the GAWR
specified on the Safety
Compliance Certification Label is
exceeded, your vehicle may be
damaged or you may lose control
and cause injury.
Trailer towing
Your vehicle is capable of towing a
trailer up to 454 kg (1000 lb) gross
trailer weight with a maximum
tongue load of 45 kg (100 lb). The
trailer should have 18.6 m
2(20 ft2)
or less frontal area.
Do not exceed the maximum loads
stated on the Safety Compliance
Certification Label. For load
Driving
102

specification terms found on the
label, refer toLoading your
vehiclein this chapter. Remember
to figure in the tongue load of your
loaded trailer when figuring the
total weight.
Towing trailers beyond the
maximum recommended
gross trailer weight exceeds the
limits of the vehicle and could
result in engine damage,
transaxle/axle damage, structural
damage, loss of control, and
personal injury.
Preparing to tow
Use the proper equipment for
towing a trailer and make sure it is
properly attached to your vehicle.
See your dealer or a reliable trailer
dealer if you require assistance.
Auxiliary coolers are recommended
for the power steering system and
automatic transaxle system (if
equipped ) if you are planning on:
²traveling farther than 80 km (50
miles).
²towing in hilly terrain.
²towing frequently.
Using a hitch
Do not use hitches that clamp onto
the vehicle bumper. Use a load
carrying hitch.
Distribute the load so that only 10
to 15% of the total weight of the
trailer is on the tongue. Tie down
the load so that it does not shift
Driving
103

and change the weight on the
hitch.
Using trailer brakes
Use electric brakes or manual,
automatic, or surge-type hydraulic
brakes that meet federal and local
regulations. Install and adjust the
brakes according to the
manufacturer's instructions.
Do not connect a trailer's
hydraulic brake system
directly to your vehicle's brake
system. Your vehicle may not
have enough braking power and
your chances of having a
collision greatly increase.
Using safety chains
Always connect the trailer's safety
chains to the vehicle. To connect
the chains, cross the chains under
the trailer tongue and attach to the
vehicle frame or hook retainers
(not the bumper). Make sure there
is enough slack to allow the vehicle
to turn corners.
Using trailer lamps
See your local trailer dealer or
rental agency for the proper
instructions and equipment for
hooking up trailer lamps.
Do not hook the trailer lights
directly into the vehicle's lighting
system wiring. If the trailer lamps
are not installed properly, the
warning lights in the instrument
cluster may not work properly.
Driving
104

Driving while towing a trailer
Do not drive faster than 88 km/h
(55 mph) while towing a 454 kg
(1000 lb) trailer. Do not drive
faster than 72 km/h (45 mph) with
any weight trailer while towing in
hilly country or on hot days.
Speed control (if equipped) may
not work properly while towing on
very long, steep grades.
If driving with an automatic
transaxle:
²use D or L rather than
Dwhile towing up or down
steep hills.
²anticipate stops and brake
gradually.
If driving with a manual transaxle:
²select a gear that avoids jerking
or excessive engine speed.
²avoid driving excessively in first
or second gear. In first or
second gear the trailer may be
too big or too heavily loaded for
the vehicle drivetrain.
²shift to a lower gear while
towing up or down steep hills.
²anticipate stops and brake
gradually.
Servicing while towing
If you tow a trailer for long
distances, your vehicle requires
more frequent service than a
vehicle not used for towing. Refer
to theService Guidefor more
information.
Driving
105

CHECKING AND ADDING
ENGINE OIL
Use SAE 5W-30 motor oil
CERTIFIED FOR GASOLINE
ENGINES by the American
Petroleum Institute. Look for the
certification Ð Ford specification
WSS-M2C153-F.
Additional engine oil additives, oil
treatments, or engine treatments
are never needed and could, under
certain conditions, lead to engine
damage which is not covered by
your Warranty.
Changing the engine oil and oil
filter
Change the engine oil and oil filter
per the following, whichever
occurs first.
5,000 MILES (8,000 KM) OR 6 MONTHS
NORMAL SCHEDULE
3,000 MILES (5,000 KM) OR 3 MONTHS
SEVERE DUTY SCHEDULE
EXTENSIVE IDLING
TRAILER TOWING
DRIVING IN SEVERE DUST
POLICE, TAXI, OR DELIVERY
Oil change intervals
Refer to theService Guide
booklet for additional information.
Checking the engine oil
Check the engine oil every time
you fuel your vehicle.
Maintenance and care
130

Aiming headlamps ....................173
Air bag supplemental restraint
system ..........................................62
description ...........................62,63
disposal ......................................63
driver air bag ............................64
indicator light ........................7,64
operation ...................................63
tone generator ..........................64
wearing safety belts .................64
Air cleaner filter .......................145
replacing ..................................146
Air conditioning
manual heating and air
conditioning system .................19
Anti-lock brake system (ABS) ...93
noise ..........................................93
see also Brake ...........................93
warning light .............................94
Anti-theft system ........................45
arming the system ....................50
description ................................50
disarming a triggered system ..52
disarming an untriggered
system .......................................51
warning light ...............................9
Automatic transaxle ...................96
driving with ...............................96
fluid, adding ............................141
fluid, checking ........................140
Battery .......................................142
servicing ..................................143
Brakes ..........................................93
anti-lock .....................................93
anti-lock brake system (ABS)
warning light ...............................9
fluid, checking and adding ....133
power braking ...........................93
Break-in period .............................2
Bulbs, replacing ........................160
halogen ....................................161
headlamps ...............................162high-mount brakelamp ...........164
rear lamps ..........164,165,167,168
specifications ..........................172
Cargo area shade ........................41
Changing a tire .........................114
Charging system warning light ....9
Child safety seats
and air bags ............................185
Childproof locks ..........................33
Cleaning your vehicle ...............175
built-in child seat ...................178
engine compartment ..............177
exterior ....................................177
instrument panel ....................177
plastic parts ............................176
safety belts ..............................178
washing ....................................175
waxing .....................................175
wheels ......................................176
wiper blades ............................178
Climate control system ..............17
air conditioning .........................19
air distribution dial ...................19
temperature dial .......................18
Clutch
fluid ..........................................134
Controls ...................15,31,36,39,40
steering column ........................25
Daytime running light system ...26
Defects, reporting .....................186
Disabled vehicle (see Towing) 123
Driving under special
conditions
towing a trailer .......................105
Emergencies, roadside .............107
Emission control system ...157,158
Engine .................................129,182
check engine warning light .......7
Engine block heater ...................91
Engine coolant
checking and adding ..............136
low coolant warning light ........10
Index
187

Lights, warning and indicator ......6
air bag .....................................7,64
anti-lock brakes (ABS) ..............9
anti-theft .....................................9
brake ............................................8
charging system ..........................9
checkcoolant .............................10
high beam ...................................9
liftgate ajar ................................10
low fuel ........................................7
oil pressure .................................9
safety belt ...................................8
service engine soon ....................7
turn signal indicator ...................9
upshift indicator .........................8
Load limits .................................101
GVWR ......................................101
trailer towing ..........................102
Lubricant specifications ...........180
Luggage rack .............................106
Manual transaxle .........................99
driving .......................................99
fluid, checking and adding ....134
shifting gears ..........................100
Mirrors
side view mirrors (power) .......16
Motorcraft parts ........................179
National Highway Traffic
Safety Administration ...............186
Parking brake ..............................94
automatic release .....................38
operation ...................................94
warning light ...............................8
Parts (see Motorcraft Parts) ...179
Power door locks ........................31
Power features
door locks ..................................31
windows ....................................34
Power steering
fluid, checking and adding ....139
Rear window
defroster ....................................24washer .......................................30
wiper ..........................................30
Refill capacities for fluids ........179
Relays ........................................109
Remote control ...........................45
Remote entry system .................45
illuminated entry ......................49
locking/unlocking doors ......46,47
opening the trunk .....................47
panic alarm ...............................49
Repairing paint chips ...............176
Reporting safety defects ..........186
Restraints, safety(see Safety
restraints) ....................................55
head ...........................................54
infant .........................................67
Roadside emergencies ..............107
Safety chains, when towing a
trailer .........................................104
Safety defects, reporting ..........186
Safety restraints ..........................55
adjusting the safety belts .........59
automatic locking mode
(retractor) .................................57
for children ...............................65
lap and shoulder belts ........56,59
maintenance ..............................60
proper use ............................55,56
vehicle sensitive locking
mode ..........................................57
warning light and chime ..8,10,62
Safety seats for children ............67
automatic locking mode
(retractor) .................................81
built-in child seat .....................74
in front seat ..............................68
in rear seat ................................70
tether anchorage hardware .....71
Seats ............................................53
adjusting the seat, manual .......53
child safety seats ......................67
folding rear seats ......................54
Index
189

head restraints ..........................54
split-folding rear seat ...............54
Servicing your vehicle
precautions when servicing ...124
servicing when you tow .........105
Special driving conditions ..........89
Specification chart, lubricants .180
Speed control ..............................27
Starting your vehicle ..................88
preparing to start your
vehicle .......................................86
starting a cold engine ..............89
starting a warm engine ............89
Steering wheel
tilting .........................................29
Tail lamps
bulb replacement .............167,168
Tilt steering wheel ......................29
Tire types ..................................152
Tires ...........................................148
changing ..................................114
checking the pressure ............150
replacing ..................................151
rotating ....................................151
snow tires and chains ............152
tire grades ...............................148
treadwear ................................148
Trailer towing ............................102
safety chains ...........................104
tips ...........................................105
trailer brakes ...........................104
trailer lamps ............................104
Transaxle .....................................96
fluid, checking and adding
(automatic) .............................139
Turn signal
indicator lights ............................9
Upshift indicator light ...........8,100
Upshift speeds ..........................100
Vehicle dimensions ...................182
Vehicle headlamp aiming
device (VHAD) .........................173Vehicle Identification Number
(VIN) ..........................................185
Ventilating your vehicle (see
Climate control) ................18,19,23
Warning chimes ...........................10
headlamps on ............................11
key in ignition ...........................11
safety belt .................................10
Washer fluid ..............................134
reservoir ..................................135
windshield .................................30
Windows
one-touch down ........................35
power windows, operating .......34
Windshield
washing ......................................30
Windshield washer fluid and
wipers
checking and adding fluid .....134
checking and replacing wiper
blades ......................................146
liftgate reservoir .....................135
operation ...................................30
Wrecker towing .........................123
Index
190