manual transmission FORD ESCORT 1998 7.G Owners Manual

6. Remove the dipstick and inspect
the fluid level. The fluid level
should be between the notches on
the dipstick.
7. If necessary, add fluid in .25L
(1/2 pint) increments through the
filler tube until the level is correct.
8. If an overfill occurs, excess fluid
should be removed by a qualified
technician.
Checking and adding manual
transmission fluid
The lubricant level and quality
should not deteriorate under
normal conditions. However, you
should have the fluid checked
occasionally. If lubricant is
required, refer toLubricant
specificationsin this section.
BATTERY
Your vehicle may be equipped with
a Motorcraft maintenance-free
battery. If the original equipment
battery needs replacing, it may be
replaced with a low-maintenance
battery. The low-maintenance
battery normally does not require
additional water during its life of
service. However, for severe usage
or in high temperature climates,
check your battery electrolyte
level, at least every 24 months or
40,000 km (24,000 miles). Keep
the electrolyte in each cell up to
the ªlevelº indicator. Do not overfill
the battery cells.
If the electrolyte level in the
battery is low, you can add plain
Maintenance and care
145

FluidFord Part
NameApplication Capacity
Engine oil
(includes filter
change)Motorcraft 5W30
Super Premium
Motor OilZX2 4.25L
(4.5 quarts)
Sedan/wagon 3.8L
(4.0 quarts)
Fuel tank
capacityN/A All 48.5L
(12.8 gallons)
Power steering
fluidMotorcraft
MERCONtAT FAll Fill to line in
reservoir
Transmission
fluid
Motorcraft
MERCONtAT FAutomatic
transaxles3.9L
(4.1 quarts)
Manual
transaxles3.35L
(3.55 quarts)
Windshield
washer fluidUltra-Clear
Windshield
Washer
ConcentrateAll 2.2L
(2.32 quarts)
LUBRICANT SPECIFICATIONS
FluidFord Part
Name or
EquivalentFord Part
NumberFord
Specification
Brake master
cylinderHigh
Performance
DOT 3 Motor
Vehicle Brake
FluidC6AZ-19542-AB ESA-M6C25-A
Door latch, hood
latch, auxiliary
hood latch,
trunk latchMulti-Purpose
GreaseDOAZ-19584-AA ESR-M1C159-A
and
ESA-M1C93-A
Capacities and specifications
181

FluidFord Part
Name or
EquivalentFord Part
NumberFord
Specification
Lock cylinder Penetrating
lubricantE8AZ-19A501-B N/A
Automatic
transmissionMotorcraft
MERCONtAT FXT-2-QDX MERCONt
Manual
transmissionMotorcraft
MERCONtAT FXT-2-QDX MERCONt
Engine oil Motorcraft 5W30
Super Premium
Motor OilXO-5W30-QSP WSS-M2C153-G
and API
Certification
Mark
Constant
velocity jointsCV Joint Grease
(High Temp.)E43Z-19590-A ESP-M1C207-A
Engine coolant Ford Premium
Cooling System
FluidE2FZ-19549-AA ESE-M97B44-A
Power steering
reservoirMotorcraft
MERCONtAT FXT-2-QDX MERCONt
ENGINE DATA
Engine 2.0L-2V engine 2.0L-4V Zetec engine
Cubic inches 121 121
Horsepower 110 @ 5000 rpm 130 @ 5750 rpm
Torque 125 lb. ft. @
3750 rpm127 lb-ft. @ 4250 rpm
Required fuel grade 87 octane 87 octane
Firing order 1-3-4-2 1-3-4-2
Spark plug gap 1.3-1.4 mm
(0.052-.056 inch)1.22-1.32 mm
(0.048-.052 inch)
Ignition system DIS DIS
Capacities and specifications
182

Sliding moon roof (see
Moonroof) ....................................35
Speed control ..............................28
canceling a set speed ...............32
resuming a set speed ...............33
tap up/tap down ..................30,31
turning off .................................29
Speedometer ...............................15
Starting your vehicle ........80,81,84
Tachometer
mechanical cluster ...................16
Tilt steering wheel ......................33
Tires ....................................149,152
checking the pressure ............152
replacing ..................................153
rotating ....................................152
snow tires and chains ............154
treadwear ................................150
Trailer towing ............................100
tips ....................................102,122
Transaxle .....................................90
automatic operation ..94,95,96,97
manual operation .......90,91,92,93
Transmission .............................143
fluid, checking and adding
(automatic) ......................143,145Trip odometer .............................15
Trunk
using the remote entry
system to open .........................41
Turn signal
lever ...........................................27
Vehicle dimensions ...................183
Vehicle headlamp aiming
device (VHAD) .........................172
Vehicle Identification Number
(VIN) ..........................................186
Vehicle loading ............................97
Ventilating your vehicle .............86
Warning chimes .............................6
Windows
power windows, operating .......37
Windshield washer fluid and
wipers
checking and adding fluid .....137
checking and replacing wiper
blades ......................................148
operation ...................................34
Wrecker towing .........................121
Index
190

Recommended fuel Unleaded fuel only - 87 octane
Fuel tank capacity 48.5L (12.8 gallons)
Engine oil Use Motorcraft 5W30 Super
Premium Motor Oil, Ford
Specification WSS-M2C153-G
Tire size and pressure Refer to Tire Pressure Decal on
passenger's door panel
Hood release Pull handle under the left side of
the instrument panel
Oil capacity (with filter change) Sedan/wagon-3.8L (4.0 quarts)
ZX2-4.25L (4.5 quarts)
Coolant capacity Automatic transaxle-6.0L
(6.3 quarts)
Manual transaxle-5.0L (5.3 quarts)
Power steering fluid capacity Fill to line on reservoir
Automatic transmission capacity 3.9L (4.1 quarts)
Manual transmission capacity 3.35L (3.55 quarts)
Filling station information
192