steering FORD EXPEDITION 1998 1.G User Guide

Fuse/Relay
LocationFuse Amp
RatingDescription
5 15A Digital Transmission Range (DTR)
Sensor, Daytime Running Lamps
(DRL) Module, Speed Control
Servo/Amplifier Assembly,
Heater-A/C Control Assembly,
Blend Door Actuator, Electronic
Variable Orifice (EVO) Module
6 5A Shift Lock Actuator, Generic
Electronic Module (GEM), 4
Wheel Air Suspension (4WAS)
Module, Compass Sensor, Steering
Wheel Rotation Sensor, Heated
Grid Relay, Overhead Trip
Computer (OTC) Module
7 5A Auxiliary A/C Relay, Console
Blower Motor
8 5A Radio, Main Light Switch, Remote
Anti-Theft Personality (RAP)
Module
9 Ð Not Used
10 Ð Not Used
11 30A Washer Pump Relay, Wiper
Run/Park Relay, Wiper Hi/Lo
Relay, Windshield Wiper Motor,
Rear Wiper Pump Relay
12 5A Data Link Connector (DLC)
13 15A Brake On/Off (BOO) Switch,
Brake Pressure Switch
14 15A Battery Saver Relay, Interior
Lamp Relay
15 5A Generic Electronic Module
(GEM), Passive Anti-Theft System
(PATS) Module
Roadside emergencies
131

The engine mini fuses are located
on the drivers side of the engine
compartment.
Slot
NumberFuse
Amperage
RatingCircuits Protected
1 5 amp Powertrain Control Module (PCM)
2 20 amp Trailer Tow Stop/Turn Lamps
3 10 amp Audio Rear Integrated Control Panel
(RICP), Compact Disc Changer, Radio
4 10 amp Running Board Lamps
5 20 amp Amplifier, Subwoofer Amplifier
6 Ð Not Used
CHANGING THE TIRES
If you get a flat tire while driving,
do not apply the brake heavily.
Instead, gradually decrease your
speed. Hold the steering wheel
firmly and slowly move to a safe
place on the side of the road.
6
5
4
3
2
1
Roadside emergencies
138

2. Automatic transmission fluid
dipstick
3. Engine oil filler
4. Engine oil dipstick
5. Power steering fluid reservoir
6. Brake fluid reservoir
7. Power distribution box
8. Air filter assembly
9. Engine coolant recovery
reservoir
10. Windshield washer fluid
reservoir
ENGINE OIL
Checking the engine oil
Check the engine oil each time you
fuel your vehicle.
1. Make sure the vehicle is on level
ground.
2. Turn the engine off and wait a
few minutes for the oil to drain
into the oil pan.
3. Set the parking brake and
ensure the gearshift is securely
latched in P (Park).
4. Open the hood. Protect yourself
from engine heat.
Maintenance and care
153

no air conditioning capability.
Continued operation will increase
engine temperature and cause the
engine to completely shut down.
The vehicle will coast to a stop.
As the engine temperature cools,
the engine may be re-started. Take
your vehicle to a service facility as
soon as possible to minimize
engine damage.
When fail-safe mode is
activated
²Pull off the road as soon as
possible.
²Immediately turn the engine off
to prevent severe engine
damage.
²Wait for the engine to cool.
²Check the coolant level.
CHECKING AND ADDING
POWER STEERING FLUID
Check the power steering fluid at
least twice a year. If adding fluid is
necessary, use only MERCONt
ATF power steering fluid.
1. Start the engine and let it run
until it reaches normal operating
temperature (the engine coolant
temperature gauge will be near the
center of the NORMAL band).
Maintenance and care
163

2. While the engine idles, turn the
steering wheel left and right
several times.
3. Turn the engine off.
4. Check the fluid level in the
reservoir. It should be between the
MIN and MAX lines. Do not add
fluid if the level is in this range.
5. If the fluid is low, add fluid in
small amounts, continuously
checking the level until it reaches
the range between the MIN and
MAX lines. Be sure to put the cap
back on the reservoir.
TRANSMISSION FLUID
Checking and adding automatic
transmission fluid
Follow the scheduled service
intervals outlined in the ªService
Guide.º
Before adding any fluid, make sure
the correct type is used. The type
of fluid used is normally indicated
on the dipstick and/or dipstick
handle and also in theLubricant
specificationssection in the
MAX
MIN
MAX
MIN
Maintenance and care
164

MOTORCRAFT PART NUMBERS
Component 4.6L engine 5.4L engine
Air filter FA-1632 FA-1632
Fuel filter FG-872 FG-872
Battery (standard) BXT-59 BXT-59
Battery (optional) BXT-65-750 BXT-65-750
Oil filter FL-820-S FL-820-S
PCV Valve EV-98 EV-233
Spark plugs*-platinum AWSF-32PP AWSF-22E
* Replacement double platinum spark plug ªEEº will replace ªEº and
ªEGº and ªPº will replace ªPº and ªPGº suffixed spark plugs.
REFILL CAPACITIES
Fluid Ford Part
NameApplication
Capacity
Engine oil
(includes filter
change)Motorcraft 5W30
Super Premium
Motor OilAll
5.7L
(6.0 quarts)
Brake fluid Ford High
Performance
DOT 3 Brake
FluidAll
Fill to line in
reservoir
Power steering
fluidMotorcraft
MERCONtAT FAll Fill to line in
reservoir
Transmission
fluidMotorcraft
MERCONtV
AT F4R70W
13.1L
(13.9 quarts)
Motorcraft
MERCONtAT FE4OD (4 x 2)15.0L
(15.9 quarts)
E4OD (4 x 4) 15.5L
(16.4 quarts)
Transfer case
fluidMotorcraft
MERCONtAT F4 x 4 vehicles 1.9L
(2.0 quarts)
Capacities and specifications
200

ItemFord part
nameFord part
numberFord
specification
Engine oil Motorcraft 5W30
Super Premium
Motor OilXO-5W30-QSP WSS-M2C153-G
with API
Certification
Mark
4x4 front wheel
bearings, 4x4
spindle needle
bearings, spindle
thrust bearings
& front drive
axle u-joint/slip
splineHigh
Temperature
4x4 Front Axle
& Wheel Bearing
GreaseE8TZ-19590-A ESA-M1C198-A
Automatic
transmission
(E4OD)Motorcraft
MERCONtAT FXT-2-QDX MERCONt
Automatic
transmission
(4R70W)Motorcraft
MERCONtV
AT FXT-5-QM
WSS-M2C202-B
Power steering
reservoirPremium Power
Steering FluidE6AZ-19582-AA ESW-M2C33-F
Rear axle
1Motorcraft SAE
75W140 High
Performance
Synthetic Rear
Axle LubeF1TZ-19580-B WSL-M2C192-A
Front axle 75W90 Gear
LubeF1TZ-19C547-MA WSL-M2C192-A
Transfer case -
Four wheel
driveMotorcraft
MERCONtAT FXT-2-QDX MERCONt
1Add 118 ml (4 oz.) of
EST-M2C118±A (friction modifier
Part No. C8AZ-19B546±A) for
Capacities and specifications
203

Fuel
calculating fuel economy .......182
improving fuel economy ........126
octane rating ...........................180
quality ......................................180
safety information relating to
automotive fuels .....................177
Fuel gauge ...................................13
Fuel pump shut-off switch .......127
Fuse panels
instrument panel ....................129
power distribution box ....133,137
Fuses ............................128,129,136
Gauges, Mechanical ....................13
engine coolant temperature
gauge .........................................14
Hazard flashers .........................127
Head restraints ...........................63
Headlamps
autolamp system .......................21
flashing ......................................39
high beam .................................39
turning on and off ....................20
Heating ........................................23
High beams
indicator light .............................9
Hood
release lever ............................152
Ignition
positions of the ignition ...........32
Instrument panel
lighting up panel and interior .21
Jump-starting your vehicle 145,147
attaching cables ......................146
disconnecting cables ..............147
Keys
key in ignition chime ...............13
Lamps
interior lamps .........................193
map lamps ...............................193
parking lamps .........................189
Liftgate ........................................53Lights, warning and indicator
air bag ..........................................8
anti-lock brakes (ABS) ..............9
anti-theft ...................................10
brake ............................................9
charging system ........................10
check engine ............................6,7
door ajar ....................................12
engine oil pressure ...................10
four-wheel drive ........................11
fuel reset ................................6,12
safety belt ...................................8
turn signal indicator ...................9
Load limits
trailer towing ..........................117
Lubricant specifications ...........202
Luggage rack .............................126
Message center ......................16,42
english/metric button ...............17
menu button .............................17
Mirrors
automatic dimming rearview
mirror ........................................46
heated ........................................51
side view mirrors (power) .......50
Moon roof ....................................42
Odometer .....................................15
Off road driving, 4-wheel drive 110
Overdrive ................................39,40
Overhead console
compass/temperature display ..40
storage compartment ...............41
Panic alarm feature, remote
entry system ................................56
Parking brake ............................100
Parts (see Motorcraft parts) ....200
Power door locks ........................48
Power steering
fluid, checking and adding ....163
Rear window
wiper ..........................................38
Refill capacities for fluids ........200
Index
209

Relays .................................128,136
Remote entry system .................55
illuminated entry ......................58
locking/unlocking doors ......55,56
replacement/additional
transmitters ...............................58
replacing the batteries .............57
Reporting safety defects ..........207
Safety restraints
automatic locking mode
(retractor) .......................72,73,74
extension assembly ..................76
for children ...............................83
lap and shoulder belts ........71,72
maintenance ..............................77
proper use .................................70
warning light and chime 12,76,77
Safety seats for children
attaching with tether straps ....90
automatic locking mode
(retractor) .................................87
tether anchorage hardware .....90
Seats ............................................60
adjusting the seat, manual .......60
adjusting the seat, power ........61
lumbar support .........................60
rear flip fold seat .................63,64
rear seat access ........................63
reclining the seat ......................65
third row seat ............65,66,67,68
Servicing your vehicle ..............150
precautions when servicing ...150
Side mirrors .................................51
Snowplowing .................................3
Special notice
utility-type vehicles ....................3
Specification chart, lubricants .202
Speed control ..............................33
canceling a set speed ...............36
resuming a set speed ...............37
tap up/tap down .......................35
turning off .................................33Speed sensitive steering ..........101
Speedometer ...............................14
Starting your vehicle ........92,93,95
Steering, power .........................101
Storage compartments
overhead storage
compartment .............................40
Tachometer
mechanical cluster ...................15
Tilt steering wheel ......................37
Tires ....................................172,174
checking the pressure ............174
replacing ..................................176
rotating ....................................175
snow tires and chains ............176
treadwear ................................173
Traction-lok rear axle ........103,167
Trailer towing
calculating maximum trailer
weight ......................................119
tips ...........................................124
Transmission .............................164
automatic
operation ............104,105,106,107
fluid, checking and adding
(automatic) .............................164
Trip odometer .............................15
Turn signal
lever ...........................................32
Vehicle dimensions ...................204
Vehicle Identification Number
(VIN) ..........................................206
Vehicle loading ..........................115
Ventilating your vehicle .............97
Warning chimes .............................6
Washer fluid
rear window reservoir ............158
warning light .............................12
Windows
accessory delay .........................48
power windows, operating ..45,47
Index
210

Recommended fuel Unleaded fuel only - 87 octane
Fuel tank capacity-4x2 without air
suspension98.0L (26 gallons)
Fuel tank capacity-4x2 vehicles
with air suspension and 4x4
vehicles114.0L (30 gallons)
Engine oil (with filter change) Use Motorcraft 5W30 Super
Premium Motor Oil, Ford
Specification WSS-M2C153-G
Tire size and pressure Refer to Tire Pressure Decal on
passenger's door panel
Hood release Pull handle under the left side of
the instrument panel
Oil capacity (with filter change) 5.7L (6.0 quarts)
Coolant capacity 19.7L (20.8 quarts)
Power steering fluid capacity Fill to line in reservoir
Automatic transmission fluid
capacity-4R70W13.1L (13.9 quarts)
Automatic transmission fluid
capacity-E4OD (4x2)15.0L (15.9 quarts)
Automatic transmission fluid
capacity-E4OD (4x4)15.5L (16.4 quarts)
Filling station information
216