seats FORD EXPEDITION 2008 3.G Service Manual

Fuse/Relay
LocationFuse
Amp
RatingPower Distribution Box Description
36 10A* Powertrain Control Module (PCM) – Keep
alive power, Canister vent
37 15A* Transmission B+
38 30A** Third row seats (passenger side)
39 60A** Air suspension pump
40 30A** Starter motor
41 20A** IP/Console power point
42 — Not used
43 20A** 4x4 module motor
44 — Not used
45 30A** Driver seat
46 40A** Run/Start bus bar
47 30A** Air suspension – solenoids
48 — Not used
49 30A** Front wipers/washer
50 30A** PCM – bus bar
51 20A** Cargo power point
52 20A** Cigarette lighter
53 — Air suspension relay
54 — Starter relay
55 — Trailer tow connector relay (park lamp)
56 — Trailer tow connector relay (battery charge)
57 — Run/Start relay
58 — Not used
59 — PCM relay
60 — One-touch Start diode
61 — Not used
62 — Fuel pump diode
63 15A* Trailer tow connector (back-up lamp)
64 — Not used
2008 Expedition(exd)
Owners Guide (post-2002-fmt)
USA(fus)
Roadside Emergencies
309

1. Wipe up spilled liquid using a clean, white, cotton cloth.
2. Apply Motorcraft Deluxe Leather and Vinyl Cleaner (ZC-11-A) [In
Canada use Motorcraft Multi-Purpose Cleaner (CXC-101)] to the wiped
area and spread around evenly.
3. Apply more Motorcraft cleaner to a clean, white, cotton cloth and
press the cloth onto the soiled area–allow this to set at room
temperature for 30 minutes.
4. Remove the soaked cloth, and if it is not soiled badly, use this cloth to
clean the area by using a rubbing motion for 60 seconds.
5. Following this, wipe area dry with a clean, white, cotton cloth.
INTERIOR
For fabric, carpets, cloth seats, safety belts and seats equipped with side
airbags:
•Remove dust and loose dirt with a vacuum cleaner.
•Remove light stains and soil with Motorcraft Professional Strength
Carpet & Upholstery Cleaner (ZC-54).
•If grease or tar is present on the material, spot-clean the area first
with Motorcraft Spot and Stain Remover (ZC-14).
•If a ring forms on the fabric after spot cleaning, clean the entire area
immediately (but do not oversaturate) or the ring will set.
•Do not use household cleaning products or glass cleaners, which can
stain and discolor the fabric and affect the flame retardant abilities of
the seat materials.
Do not use cleaning solvents, bleach or dye on the vehicle’s
safety belts, as these actions may weaken the belt webbing.
Do not use chemical solvents or strong detergents when cleaning
the seat-mounted side airbag (vehicles equipped with
seat-mounted side airbags only). Such products could contaminate the
side airbag system and affect performance of the side airbag in a
collision.
CLEANING THE CLIMATE CONTROLLED SEATS (IF EQUIPPED)
Remove dust and loose dirt with a whisk broom or a vacuum cleaner.
Remove fresh spots immediately. Clean the seat with a damp cloth, using
a mild soap and water solution, if necessary.
2008 Expedition(exd)
Owners Guide (post-2002-fmt)
USA(fus)
Cleaning
340

LEATHER SEATS
(IF EQUIPPED, EXCEPT FOR THE KING RANCH EXPEDITION)
Your leather seating surfaces have a clear, protective coating over the
leather.
For King Ranch Expedition leather seats, refer to separate
section in this chapter.
•To clean, use a soft cloth with Motorcraft Deluxe Leather and Vinyl
Cleaner (ZC-11–A). Dry the area with a soft cloth.
•To help maintain its resiliency and color, use the Motorcraft Deluxe
Leather Care Kit (ZC-11–D), available from your authorized dealer.
•Do not use household cleaning products, alcohol solutions, solvents or
cleaners intended for rubber, vinyl and plastics, or oil/petroleum-based
leather conditioners. These products may cause premature wearing of
the clear, protective coating.
Note:In some instances, color or dye transfer can occur when wet
clothing comes in contact with leather upholstery. If this occurs, the
leather should be cleaned immediately to avoid permanent staining.
LEATHER SEATS FOR THE KING RANCH EXPEDITION ONLY
(IF EQUIPPED)
Your vehicle is equipped with seating covered in premium, top-grain
leather which is extremely durable, but still requires special care and
maintenance in order to ensure longevity and comfort.
Regular cleaning and conditioning will maintain the appearance of the
leather. Failure to care for the leather can result in drying out and fading
of the material.
Note:In some instances, color or dye transfer can occur when wet
clothing comes in contact with leather upholstery. If this occurs, the
leather should be cleaned immediately to avoid permanent staining.
Cleaning
For dirt, use a vacuum cleaner then use a clean, damp cloth or soft
brush.
For routine cleaning, wipe the surface with a soft, damp cloth. For more
thorough cleaning, wipe the surface with a mild soap. If the leather
cannot be completely cleaned using a mild soap and water solution, the
leather may be cleaned using a commercially available cleaning product
“Tanners Preserve Leather Cleaner” and a 3M “Type T” scrubbing pad.
•Clean spills as quickly as possible.
2008 Expedition(exd)
Owners Guide (post-2002-fmt)
USA(fus)
Cleaning
341

A
ABS (see Brakes) .....................271
Accessory delay ........................107
AdvanceTrac ..............................273
Air cleaner filter .......372–373, 375
Air suspension ...........................278
description ..............................278
Airbag supplemental restraint
system ........................202, 206, 208
and child safety seats ............204
description ..............202, 206, 208
disposal ....................................211
driver airbag ............204, 207, 209
indicator light .................206, 211
operation .................204, 207, 209
passenger airbag .....204, 207, 209
side airbag ...............................206
Antifreeze
(see Engine coolant) ................354
Anti-lock brake system
(see Brakes) ..............................271
Anti-theft system
arming the system ..................168
Armrests ....................................173
Audio system
(see Radio) ......................20, 24, 31
Automatic transmission
driving an automatic
overdrive .................................282
fluid, adding ............................372
fluid, checking ........................372
fluid, refill capacities ..............376
fluid, specification ..................376
Auxiliary input jack (Line in) ....39
Auxiliary power point ...............103Axle
lubricant specifications ..........376
refill capacities ........................376
B
Battery .......................................352
acid, treating emergencies .....352
jumping a disabled battery ....319
maintenance-free ....................352
replacement, specifications ...375
servicing ..................................352
Belt-Minder
.............................198
Booster seats .............................213
Brakes ........................................270
anti-lock ...................................271
anti-lock brake system (ABS)
warning light ...........................271
fluid, checking and adding ....372
fluid, refill capacities ..............376
fluid, specifications .................376
lubricant specifications ..........376
parking ....................................272
shift interlock ..................280–281
Bulbs ............................................92
C
Capacities for refilling fluids ....376
Cargo cover ...............................150
Cargo management system ......150
Cassette tape player ...................24
Cell phone use ..............................8
Changing a tire .........................310
Child safety restraints ..............212
child safety belts ....................212
Child safety seats ......................216
in front seat ............................217
2008 Expedition(exd)
Owners Guide (post-2002-fmt)
USA(fus)
Index
384

in rear seat ......................217, 220
Child safety seats - booster
seats ...........................................213
Cleaning your vehicle
engine compartment ..............337
instrument panel ....................339
interior .....................................340
plastic parts ............................338
washing ....................................335
waxing .....................................336
wheels ......................................337
wiper blades ............................338
Clock adjust
6-CD in dash .............................33
AM/FM/CD .................................26
Compass, electronic ..................124
calibration ...............................125
set zone adjustment .......124, 134
Console ......................................102
overhead ..........................101–102
Controls
power seat ...............................174
steering column ......................115
Coolant
checking and adding ..............354
refill capacities ................358, 376
specifications ..........................376
Cruise control
(see Speed control) ..................112
Customer Assistance ................300
Ford Extended Service
Plan ..........................................332
Getting assistance outside the
U.S. and Canada .....................333
Getting roadside assistance ...300
Getting the service you
need .........................................328
Ordering additional owner’s
literature .................................334Utilizing the
Mediation/Arbitration
Program ...................................332
D
Daytime running lamps
(see Lamps) ................................88
Defrost
rear window ..............................86
Dipstick
automatic transmission
fluid ..........................................372
engine oil .................................349
Driving under special
conditions ..................285, 294, 297
sand .........................................296
snow and ice ...........................298
through water .................296, 299
DVD system .................................48
E
Electronic message
center .................................122, 132
Emergencies, roadside
jump-starting ..........................319
Emission control system ..........368
Engine ........................................379
cleaning ...................................337
coolant .....................................354
fail-safe cooling .......................358
idle speed control ...................352
lubrication specifications .......376
refill capacities ........................376
service points ..........................346
starting after a collision .........302
Engine block heater .................268
Engine oil ..................................349
2008 Expedition(exd)
Owners Guide (post-2002-fmt)
USA(fus)
Index
385

change oil soon warning,
message center .......................349
checking and adding ..............349
dipstick ....................................349
filter, specifications ........351, 375
recommendations ...................351
refill capacities ........................376
specifications ..........................376
Event data recording ....................7
Exhaust fumes ..........................268
F
Fail safe cooling ........................358
Family entertainment system ....48
Floor mats .................................145
Fluid capacities .........................376
Foglamps .....................................87
Four-Wheel Drive vehicles .......290
control trac .............................290
description ..............................291
driving off road .......................293
indicator light .........................290
preparing to drive your
vehicle .....................................279
Fuel ............................................360
calculating fuel
economy ..................123, 135, 365
cap ...........................................362
capacity ...................................376
choosing the right fuel ...........363
comparisons with EPA fuel
economy estimates .................368
detergent in fuel .....................365
filling your vehicle with
fuel ...........................360, 362, 365
filter, specifications ........360, 375
fuel pump shut-off switch .....302
improving fuel economy ........365
octane rating ...................364, 379quality ......................................364
running out of fuel .................365
safety information relating to
automotive fuels .....................360
Fuses ..................................303–304
G
Gas cap (see Fuel cap) ............362
Gas mileage
(see Fuel economy) .................365
Gauges .........................................17
H
Hazard flashers .........................301
Headlamps ...................................87
aiming ........................................89
autolamp system .......................87
bulb specifications ....................92
daytime running lights .............88
flash to pass ..............................88
high beam .................................88
replacing bulbs .........................93
turning on and off ....................87
Heating
heating and air
conditioning system ...........76–77
Homelink wireless control
system ........................................118
Hood ..........................................345
How to get going ........................20
I
Ignition ...............................265, 379
Illuminated visor mirror ...........100
Infant seats
(see Safety seats) .....................216
2008 Expedition(exd)
Owners Guide (post-2002-fmt)
USA(fus)
Index
386

Inspection/maintenance (I/M)
testing ........................................370
Instrument panel
cleaning ...................................339
cluster ........................................12
lighting up panel and
interior .......................................89
J
Jack ............................................310
positioning ...............................310
storage .....................................310
Jump-starting your vehicle ......319
K
Keyless entry system ...............165
autolock ...................................152
keypad .....................................166
locking and unlocking doors ..167
programming entry code .......166
Keys ...................................167–169
positions of the ignition .........265
L
Lamps
autolamp system .......................87
bulb replacement
specifications chart ..................92
daytime running light ...............88
fog lamps ...................................87
headlamps .................................87
headlamps, flash to pass ..........88
instrument panel, dimming .....89
interior lamps .....................91, 93
replacing bulbs ...................93, 96
Lane change indicator
(see Turn signal) ........................90
Liftgate ..............146, 149, 158–159Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........271
Limited-slip axle .......................279
Load limits .................................250
Loading instructions .................256
Locks
autolock ...................................152
childproof ................................156
doors ........................................152
Lubricant specifications ...........376
Lug nuts ....................................318
Lumbar support, seats .....173–174
M
Message center .................122, 132
english/metric button .....128, 140
system check button ......127, 140
warning messages ...........129, 141
Mirrors ...............................107–108
automatic dimming rearview
mirror ......................................107
fold away .................................109
heated ..............................109–110
programmable memory ..........161
signal .......................................110
Moon roof ..................................117
Motorcraft parts ........343, 360, 375
N
Navigation system .......................75
O
Octane rating ............................364
Oil (see Engine oil) ..................349
2008 Expedition(exd)
Owners Guide (post-2002-fmt)
USA(fus)
Index
387

P
Panic alarm feature, remote
entry system ..............................160
Parking brake ............................272
Parts (see Motorcraft parts) ....375
Pedals (see Power adjustable
foot pedals) ...............................110
Power adjustable foot pedals ...110
Power deployable running
boards ........................................110
Power distribution box
(see Fuses) .......................304, 307
Power door locks ......................152
Power liftgate ............................146
Power mirrors ...........................108
Power point ...............................103
Power steering ..................277–278
fluid, checking and adding ....371
fluid, refill capacity ................376
fluid, specifications .................376
Power Windows .........................105
Preparing to drive your
vehicle ........................................279
R
Radio ................................20, 24, 31
Rear seat entertainment
system ..........................................48
Rear video camera ....................288
Rear window defroster ...............86
Relays ........................................303
Remote entry system ...............156
illuminated entry ....................164
locking/unlocking doors .........157opening the trunk ...........158–159
panic alarm .............................160
replacement/additional
transmitters .............................163
replacing the batteries ...........162
Reverse sensing system ...........285
Roadside assistance ..................300
Roll stability control .................273
S
Safety Belt Maintenance ..........197
Safety belts (see Safety
restraints) ..188, 190–191, 193–195
Safety Canopy ...................206, 208
Safety defects, reporting ..........335
Safety
restraints ...188, 190–191, 193–195
Belt-Minder
...........................198
extension assembly ................197
for adults .................191, 193–194
for children .............................212
safety belt maintenance .........197
warning light and
chime ...............................197–198
Safety seats for children ..........216
Safety Compliance
Certification Label ....................380
Satellite Radio Information ........46
Seats ..........................................171
child safety seats ....................216
cleaning ...................................341
climate control ........................177
memory seat ...................161, 176
SecuriLock passive anti-theft
system ................................167–169
Servicing your vehicle ..............344
2008 Expedition(exd)
Owners Guide (post-2002-fmt)
USA(fus)
Index
388