warning light FORD EXPEDITION 2009 3.G Workshop Manual

WARNING:The fuel system may be under pressure. If you hear
a hissing sound near the fuel filler door (Easy Fuel™ “no cap”
fuel system), do not refuel until the sound stops. Otherwise, fuel may
spray out, which could cause serious personal injury.
Flex Fuel Vehicle (FFV) fuel fill inlet
Flex fuel vehicles have a yellow bezel placed over the fuel fill inlet.
Choosing the right fuel
Use only UNLEADED FUEL and FUEL ETHANOL (Ed75–Ed85).
The use of leaded fuel is prohibited by law and could damage your
vehicle.
Your vehicle was not designed to use fuel or fuel additives with metallic
compounds, including manganese-based additives.
Note:Use of any fuel other than those recommended may cause
powertrain damage, a loss of vehicle performance, and repairs may not
be covered under warranty.
Octane recommendations
Your vehicle is designed to use
“Regular” unleaded gasoline with a
pump (R+M)/2 octane rating of 87.
We do not recommend the use of
gasolines labeled as “Regular” in
high altitude areas that are sold with octane ratings less than 87.
Do not be concerned if your engine sometimes knocks lightly. However, if
it knocks heavily under most driving conditions while you are using fuel
with the recommended octane rating, see your authorized dealer to
prevent any engine damage.
87(R+M)/2 METHOD
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Maintenance and Specifications
387

Cleaner air
Ford endorses the use of reformulated “cleaner-burning” gasolines to
improve air quality, per the recommendations in theChoosing the right
fuelsection.
Running out of fuel
Avoid running out of fuel because this situation may have an adverse
effect on powertrain components.
If you have run out of fuel:
•You may need to cycle the ignition from off to on several times after
refueling to allow the fuel system to pump the fuel from the tank to
the engine. On restarting, cranking time will take a few seconds longer
than normal.
•Normally, adding 1 gallon (3.8L) of fuel is enough to restart the
engine. If the vehicle is out of fuel and on a steep grade, more than
1 gallon (3.8L) may be required.
•TheService engine soon
indicator may come on. For more
information on the “service engine soon” indicator, refer toWarning
lights and chimesin theInstrument Clusterchapter.
Refilling with a portable fuel container
With the Easy Fuel™ “no cap” fuel system, use the following directions
when filling from a portable fuel container:
WARNING:Do not insert the nozzle of portable fuel containers
or aftermarket funnels into the Easy Fuel™ system. This could
damage the fuel system and its seal, and may cause fuel to run onto
the ground instead of filling the tank, which could result in serious
personal injury.
WARNING:Do not try to pry open or push open the Easy
Fuel™ system with foreign objects. This could damage the fuel
system and its seal and cause injury to you or others.
When filling the vehicle’s fuel tank from a portable fuel container, use the
included funnel.
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Maintenance and Specifications
389

If other than Ford, Motorcraft or Ford-authorized parts are used for
maintenance replacements or for service of components affecting
emission control, such non-Ford parts should be equivalent to genuine
Ford Motor Company parts in performance and durability.
WARNING:Do not park, idle, or drive your vehicle in dry grass
or other dry ground cover. The emission system heats up the
engine compartment and exhaust system, which can start a fire.
Illumination of theService engine soon
indicator, charging system
warning light or the temperature warning light, fluid leaks, strange odors,
smoke or loss of engine power could indicate that the emission control
system is not working properly.
An improperly operating or damaged exhaust system may allow exhaust
to enter the vehicle. Have a damaged or improperly operating exhaust
system inspected and repaired immediately.
WARNING:Exhaust leaks may result in entry of harmful and
potentially lethal fumes into the passenger compartment.
Do not make any unauthorized changes to your vehicle or engine. By
law, vehicle owners and anyone who manufactures, repairs, services,
sells, leases, trades vehicles, or supervises a fleet of vehicles are not
permitted to intentionally remove an emission control device or prevent
it from working. Information about your vehicle’s emission system is on
the Vehicle Emission Control Information Decal located on or near the
engine. This decal also lists engine displacement.
Please consult yourWarranty Guide/Customer Information Guidefor
complete emission warranty information.
On board diagnostics (OBD-II)
Your vehicle is equipped with a computer that monitors the engine’s
emission control system. This system is commonly known as the On
Board Diagnostics System (OBD-II). The OBD-II system protects the
environment by ensuring that your vehicle continues to meet
government emission standards. The OBD-II system also assists your
authorized dealer in properly servicing your vehicle. When theService
engine soon
indicator illuminates, the OBD-II system has detected
a malfunction. Temporary malfunctions may cause theService engine
soon
indicator to illuminate. Examples are:
1. The vehicle has run out of fuel—the engine may misfire or run poorly.
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Maintenance and Specifications
394

A
ABS (see Brakes) .....................291
Accessory delay ........................115
AdvanceTrac ..............................293
Air cleaner filter .......397–398, 400
Air suspension ...........................298
description ..............................298
Airbag supplemental restraint
system ........................218, 222, 224
and child safety seats ............220
description ..............218, 222, 224
disposal ....................................228
driver airbag ............220, 223, 225
indicator light .................222, 227
operation .................220, 223, 225
passenger airbag .....220, 223, 225
side airbag ...............................222
Antifreeze
(see Engine coolant) ................377
Anti-lock brake system
(see Brakes) ..............................291
Anti-theft system ..............178, 182
arming the system ..................182
disarming a triggered
system .....................................183
Armrests ....................................188
Audio system
(see Radio) ......................20, 24, 31
Automatic transmission
driving an automatic
overdrive .................................303
fluid, adding ............................397
fluid, checking ........................397
fluid, refill capacities ..............401
fluid, specification ..................401
Auxiliary input jack (Line in) ....39
Auxiliary power point ...............111Axle
lubricant specifications ..........401
refill capacities ........................401
B
Battery .......................................375
acid, treating emergencies .....375
jumping a disabled battery ....341
maintenance-free ....................375
replacement, specifications ...400
servicing ..................................375
Belt-Minder
.............................214
Booster seats .............................242
Brakes ........................................290
anti-lock ...................................291
anti-lock brake system (ABS)
warning light ...........................291
fluid, checking and adding ....397
fluid, refill capacities ..............401
fluid, specifications .................401
lubricant specifications ..........401
parking ....................................292
shift interlock ..................300, 302
Bulbs ..........................................101
C
Capacities for refilling fluids ....401
Cargo cover ...............................160
Cargo management system ......160
Cassette tape player ...................24
Cell phone use ..............................8
Changing a tire .........................331
Child safety seats ......................232
in front seat ............................232
in rear seat ..............................232
LATCH .....................................235
recommendations ...................230
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Index
410

Illuminated visor mirror ...........109
Infant seats
(see Safety seats) .....................232
Inspection/maintenance (I/M)
testing ........................................395
Instrument panel
cleaning ...................................361
cluster ........................................12
lighting up panel and
interior .......................................97
J
Jack ............................................331
positioning ...............................331
storage .....................................331
Jump-starting your vehicle ......341
K
Keyless entry system ...............176
autolock ...................................165
keypad .....................................176
locking and unlocking doors ..177
programming entry code .......176
Keys ...................................163, 179
positions of the ignition .........284
L
Lamps
autolamp system .......................95
bulb replacement
specifications chart ................101
daytime running light ...............96
fog lamps ...................................96
headlamps .................................95
headlamps, flash to pass ..........96
instrument panel, dimming .....97
interior lamps ...................99, 102
replacing bulbs ...............102, 105LATCH anchors .........................235
Liftgate ......................155, 159, 171
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........291
Limited-slip axle .......................299
Load limits .................................269
Loading instructions .................275
Locks
autolock ...................................165
childproof ................................169
doors ........................................165
Lubricant specifications ...........401
Lug nuts ....................................340
Lumbar support, seats .....188–189
M
Message center .................131, 141
english/metric button .....136, 146
system check button ......135, 144
warning messages ...........138, 151
Mirrors ...............................115, 117
automatic dimming rearview
mirror ......................................116
fold away .................................117
heated ..............................118–119
programmable memory ..........172
signal .......................................119
Moon roof ..................................126
Motorcraft parts ........365, 383, 400
N
Navigation system .......................83
O
Octane rating ....................387–388
Oil (see Engine oil) ..................372
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Index
413

P
Parking brake ............................292
Parts (see Motorcraft parts) ....400
Pedals (see Power adjustable
foot pedals) ...............................119
Power adjustable foot pedals ...119
Power deployable running
boards ........................................120
Power distribution box
(see Fuses) .......................325, 328
Power door locks ......................165
Power liftgate ............................155
Power mirrors ...........................117
Power point ...............................111
Power steering ..................297–298
fluid, checking and adding ....396
fluid, refill capacity ................401
fluid, specifications .................401
Power Windows .........................113
Preparing to drive your
vehicle ........................................299
R
Radio ................................20, 24, 31
Rear seat entertainment
system ..........................................51
Recommendations for
attaching safety restraints for
children ......................................230
Relays ........................................324
Remote entry system .......169–170
illuminated entry ............174–175
locking/unlocking
doors ................................170–171
opening the trunk ...................171panic alarm .............................172
replacement/additional
transmitters .............................174
replacing the batteries ...........173
Reverse camera .........................309
Reverse sensing system ...........306
Roadside assistance ..................321
Roll stability control .................293
S
Safety Belt Maintenance ..........245
Safety belts (see Safety
restraints) ..........205, 207–210, 212
Safety Canopy ...................222, 224
Safety defects, reporting ..356–357
Safety restraints ........205, 207–212
Belt-Minder
...........................214
extension assembly ................213
for adults .........................208–210
for children .............................228
safety belt maintenance .........245
warning light and chime 213–214
Safety restraints - LATCH
anchors ......................................235
Safety seats for children ..........232
Safety Compliance
Certification Label ....................406
Satellite Radio Information ........48
Seats ..........................................184
child safety seats ....................232
cleaning ...................................364
climate control ........................193
heated ......................................201
memory seat ...................172, 191
SecuriLock passive anti-theft
system ................................178–179
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Index
414

Servicing your vehicle ..............367
Setting the clock
AM/FM single CD .....................26
AM/FM/In-dash 6 CD ................33
Snowplowing .................................8
Spark plugs,
specifications .....................400, 405
Special notice
utility-type vehicles ....................8
Specification chart,
lubricants ...................................401
Speed control ............................121
Stability system .........................293
Starting a flex fuel vehicle .......287
Starting your vehicle ........284–287
jump starting ..........................341
Steering wheel
controls ....................................124
tilting .......................................108
SYNC ............................................83
T
Tilt steering wheel ....................108
Tire Pressure Monitoring
System (TPMS)
Driving .....................................317
Tires, Wheels and Loading ....263
Warning Displays ......12, 138, 151
Tires ...........................248–249, 331
alignment ................................257
care ..........................................253
changing ..........................331, 335
checking the pressure ............253
inflating ...................................251
label .........................................262
replacing ..................................254
rotating ....................................257safety practices .......................256
sidewall information ...............258
snow tires and chains ............268
spare tire .................................332
terminology .............................250
tire grades ...............................249
treadwear ........................249, 253
Towing .......................................275
recreational towing .................283
trailer towing ..........................275
wrecker ....................................348
Transmission .............................300
brake-shift interlock
(BSI) ................................300, 302
fluid, checking and adding
(automatic) .............................397
fluid, refill capacities ..............401
lubricant specifications ..........401
Turn signal ..................................99
U
USB port ......................................41
V
Vehicle Identification Number
(VIN) ..........................................406
Vehicle loading ..........................269
Ventilating your vehicle ...........288
W
Warning lights (see Lights) .......12
Washer fluid ..............................370
Water, Driving through .............320
Windows
power .......................................113
rear wiper/washer ...................108
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Index
415