brake fluid FORD EXPLORER 1996 2.G User Guide

Servicing Your Explorer
377
[SV35500(ALL)10/94]
10-1/2 pica art:0020376-E
Clutch fluid reservoir
%*
[SV35800(ALL)07/95]
Driveline Universal Joint and Slip Yoke
*
[SV36000(ALL)06/93]
The universal joints that come standard with your vehicle do
not require lubrication. If your original equipment universal
joints are replaced with universal joints equipped with grease
fittings, lubrication will be necessary at the intervals shown in
theMaintenance Schedule and Recordbooklet.
%*
[SV36300(ALL)03/95]
Brake Fluid
*
[SV36350(ALL)05/90]
Your vehicle is equipped with a brake fluid level indicator in
the master cylinder which lights the BRAKE warning light on
the instrument panel when the brake fluid level is low.
*
[SV36400(ALL)03/95]
Under normal circumstances, your vehicle should not use up
brake fluid rapidly. However, expect the level of the brake fluid
to slowly fall as you put more mileage on your vehicle and the
brake pads wear.
*
[SV36500(ALL)08/95]
Check the brake fluid at least once a year. You can do this by
looking at the fluid level in the plastic brake fluid reservoir on
the master cylinder. The fluid level should be at or near the
MAX mark.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

378
*
[SV36550(ALL)05/95]
RWARNING
Brake fluid is toxic.
*
[SV36560(ALL)07/95]
If brake fluid contacts eyes, flush eyes with running water for
15 minutes. Get medical attention if irritation persists. If taken
internally, drink water and induce vomiting. Get medical
attention immediately.
*
[SV36600(ALL)03/95]
If the fluid is low, carefully clean and remove the cap from the
reservoir. Fill the reservoir to the MAX line with Ford High
Performance DOT 3 Brake Fluid C6AZ-19542-AA,
C6AZ-19542-BA, or equivalent DOT 3 fluid meeting Ford
specification ESA-M6C25-A.
*
[SV36850(ALL)12/91]
NOTE: If brake fluid is spilled on painted surfaces, it must
be flushed and wiped away immediately. Brake fluid
may dissolve the paint finish on your vehicle.
*
[SV36900(ALL)01/95]
RWARNING
If you use a brake fluid that is not DOT 3, you will
cause permanent damage to your brakes.
*
[SV37000(ALL)01/95]
Do not fill the reservoir above the MAX line.
*
[SV37100(ALL)01/95]
If you find that the fluid level is excessively low Ð below the
seam or ridge on the outside of the plastic reservoir Ð have the
brake system inspected.
*
[SV37200(ALL)01/95]
RWARNING
Do not let the reservoir for the master cylinder run dry.
This may cause the brakes to fail.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

Servicing Your Explorer
379
[SV37500(ALL)04/94]
7-1/2 pica art:0020382-C
Brake master cylinder
%*
[SV37600(ALL)03/95]
Power Steering Fluid
*
[SV37700(ALL)01/95]
Check the level of the power steering fluid at least twice a
year (i.e., every Spring and Fall).
%*
[SV37800(ALL)03/95]
Checking and Adding Power Steering Fluid
*
[SV37900(ALL)02/95]1.
Start the engine and let it run until the power steering fluid
reaches normal operating temperature. The power steering
fluid will be at the right temperature when the engine
coolant temperature gauge in the instrument cluster is near
the center of the NORMAL operating temperature range.
*
[SV38000(ALL)01/95]2.
While the engine idles, turn the steering wheel back and
forth several times. Make sure that the cap assembly is
installed at this time.
*
[SV38100(ALL)05/95]3.
Turn the engine off.
%*
[SV38200(ALL)03/94]4.
Check the fluid level on the dipstick (which is highlighted in
yellow in your vehicle). The fluid level should be between
the arrows in the FULL HOT range, which is marked on the
side of the dipstick, opposite the side marked FULL COLD.
Do not add fluid if the level is within the FULL HOT range.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

423
Index
Brake fluid
brake warning light.................. 81
checking and adding................ 377
description..................... 377
specifications.................... 406
Brakelamp, high-mount brakelamp........... 134
Brakes
adjustment..................... 261
anti-lock...................... 261
applying the brakes................. 265
brake warning light.................. 81
fluid, checking and adding.............. 377
fluid, refill capacities................ 377
fluid, specifications................. 406
front disc...................... 261
if brakes do not grip well.............. 264
master cylinder................... 377
new brake linings................... 5
noise........................ 261
parking...................... 266
power braking................... 261
servicing....................264, 377
stopping distances................265, 267
trailer....................... 290
when storing your vehicle.............. 410
Brake-shift interlock.................. 247
Break-in period..................... 5
Brights (high beams).................91,136
Built-in child seat
cleaning....................... 52
operation....................... 34
Bulbs, replacing.................... 392
halogen...................... 393
headlamps..................... 393
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996

434
Lamps (continued)
interior lamps.................127, 132
replacing bulbs................... 392
trailer....................... 290
Lane change indicator (see Turn signal)......... 135
Lights, warning and indicator
airbag........................ 83
anti-theft....................... 88
brake........................ 81
charging system................... 87
check engine..................... 84
engine oil pressure.................. 90
hazard warning light................ 139
high beam...................... 91
low washer fluid.................. 104
oil pressure...................... 90
overdrive off..................... 86
safety belt...................... 82
service engine soon.................. 84
theft system..................... 88
turn signal indicator................. 135
Load limits
GAWR....................... 271
GVWR....................... 271
trailer towing.................... 272
Lubricant specifications................ 406
Lug nuts
standard...................... 307
tightening sequence................. 304
M
Maintenance schedule and record (see separate Maintenance
Schedule and Record booklet)........... 3
Maintenance (see Servicing).............. 333
Manual transmission
clutch.....................251, 376
fluid, checking and adding.............. 376
lubricant specifications................ 406
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996

435
Index
Manual transmission (continued)
shifting gears.................... 251
shift speeds..................... 253
Master cylinder, brakes................. 377
Message center
low washer fluid.................. 104
system check button................. 100
Methanol in fuel.................... 344
Mileage, calculating fuel economy...........99,346
Mirrors
automatic dimming rearview mirror......... 188
dual electric remote control............. 191
rearview...................... 188
side view mirrors.................. 188
side view mirrors (power).............. 191
vanity mirror.................... 190
vanity mirror, illuminated.............. 190
Moon roof...................... 192
Motorcraft parts.................... 405
N
National Highway Traffic Safety Administration..... 323
New vehicle break-in.................. 5
O
Octane rating..................... 342
Odometer
description...................... 94
trip odometer..................... 94
Off road driving, 4-wheel drive............. 259
Oil filter.....................351, 405
Oil (see Engine oil).................. 348
Oil viscosity...................... 348
On-board diagnostic (OBD II) system.......... 401
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996

436
Overdrive...................... 248
Overhead console
compass/temperature display............ 197
map lamps..................... 200
storage compartment................ 201
Overseas offices.................... 325
P
Panic alarm feature, remote entry system........ 162
Parking brake
operation...................... 266
warning light..................... 81
Parts (see Motorcraft Parts)............... 405
PCV valve, specifications................ 405
Power distribution box (see Fuses)........... 386
Power door locks................... 155
Power features
door locks..................... 155
mirrors.....................188, 191
moon roof..................... 192
seats........................ 183
windows....................171±172
Power point electrical outlet.............. 204
Power steering
dipstick...................... 379
driving with power steering............. 255
fluid, checking and adding.............. 379
fluid, specifications................. 406
servicing...................... 255
Prop rod, hood.................... 335
R
Radio (see Electronic sound systems).......... 207
Rear axle
lubricant specification................ 406
traction lok...................269, 363
Rearview mirror.................... 188
Rear window..................... 171
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996

441
Index
Trailer towing
calculating maximum trailer weight.......... 277
safety chains.................... 290
trailer brakes.................... 290
trailer lamps.................... 290
Transaxle
automatic operation................. 246
lubricant specifications................ 406
Transaxle control switch................ 248
Transfer case, fluid checking.............. 376
Transmission
automatic operation................. 246
fluid, checking and adding (automatic)........ 374
fluid, checking and adding (manual)......... 376
lubricant specifications................ 406
Transmission control switch.............. 248
Transmitter (see Remote entry)............. 161
Trip odometer...................... 94
Tune-up specifications (VECI).............. 401
Turn signal...................... 135
indicator lights................... 135
lever........................ 135
U
Used engine oil, disposal............334, 351, 375
V
Vanity mirror..................... 190
Variable interval wipers................ 136
VECI (Vehicle Emission Control Information) decal.... 401
Vehicle Identification Number (VIN)........... 318
Vehicle loading.................... 272
calculating the load................. 277
understanding loading information.......... 271
Vehicle storage.................... 408
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996