towing FORD EXPLORER 1997 2.G User Guide

working properly, the warning
lights in the instrument cluster
may not work properly.
Using a hitch
Do not use hitches that:
²clamp onto the vehicle bumper
²attach to the axle.
Distribute the load so that only 10
to 15% of the total weight of the
trailer is on the tongue. tie down
the load so that it does not shift
and change the weight on the
hitch. Follow the towing
instructions of a reputable rental
agency.
Driving while towing a trailer
Do not drive faster than 70 km/h
(45 mph) while towing a 454 kg
(1000 lb) trailer. Do not drive
faster than 72 km/h (45 mph) with
any weight trailer while towing in
hilly terrain or on hot days.
Speed control (if equipped) may
not work properly while towing on
long, steep grades.
If driving with an automatic
transmission:
²use D or L rather than while
towing up or down steep hills
²anticipate stops and brake
gradually.
Towing behind another vehicle
Do not tow your vehicle behind
another vehicle, such as an RV,
unless front wheel dollies are used.
uno_hitch
uno_driving_towing
uno_towing_behind
Driving
144

Your vehicle can not be flat towed
with all wheels on the ground.
Servicing while towing
If you tow a trailer for long
distances, your vehicle requires
more frequent service than a
vehicle not used for towing. Refer
to the ªService Guideº for more
information on maintenance
intervals.
Using a step bumper
The rear bumper is equipped with
an integral hitch and requires only
a ball with a ô inch shank
diameter. The bumper has a Class
II capability (1590 kg / 3500 lb
trailer weight and 159 kg / 350 lb
tongue weight).
Use a frame mounted weight
distributing hitch for trailers over
1590 kg (3500 lb).
Launching or retrieving a boat
When backing down a ramp during
boat launching or retrieval,
²Do not allow the static water
level to rise above the bottom
edge of the rear bumper and
²Do not allow waves to break
higher than 15 cm (six inches)
above the bottom edge of the
rear bumper.
Exceeding these limits may allow
water to enter critical vehicle
components, adversely affecting
driveability, emissions and
reliability.uno_servicing_while_towing
uno_step_bumper_towing
com_launch-retrieving_boat.01
uno_roof-rack_title
Driving
145

16. Install the lug nuts and tighten
until snug.
17. Lower the vehicle and tighten
the lug nuts as shown.
18. Unblock the wheels and place
the flat tire, jack hhandle and lug
wrench away.
Stowing flat tires
Stow aluminum wheel and tire
with the valve stem down.
To stow largest flat tire, place it
inside the vehicle and secure with
a webbing retainer.
The conventional spare tire
(if equipped)
Your vehicle may be equipped with
a conventional spare tire which
can be used as a spare or a regular
tire. This spare tire is identical to
the other tires on your vehicle,
although the wheel style may not
match.
The temporary spare tire
(if equipped)
Your vehicle may be equipped with
a temporary spare tire. This spare
is smaller than a regular tire and is
intended for emergency use only.
Us this spare when you get a flat
1
4
2
5 3
uno_stowing_flat_tires
uno_conventional_spare
uno_temporary_spare
Roadside emergencies
159

Do not connect the end of
the second cable to the
negative ([-]) terminal of the
battery to be jumped. A spark
may cause an explosion of the
gases that surround the battery.
Jump starting
1. Start the booster vehicle and
run the engine at moderately
increased speed.
2. Start the engine of the vehicle
with the discharged battery.
3. Once the engine has been
started, run both vehicles for a
further three minutes before
disconnecting the cable leads.
Removing the jumper cables
1. Remove the jumper cables in
reverse order. Take the cable off
the metallic surface (1) first,
followed by the cable on the
negative (-) booster battery
terminal (2).
2. Remove the cable from the
positive (+) terminal of the booster
battery (3) and then the
discharged battery (4).
3. After the disabled vehicle has
been started, allow it to idle for a
while so the engine can ªrelearnº
its idle conditions.
+–
+–
2
3
4
1
uno_jump_starting
com_removing_cables.01
uno_wrecker_towing
Roadside emergencies
162

WRECKER TOWING
Ford recommends that your
vehicle be towed with wheel lift
and dollies or flatbed equipment.
Do not tow with slingbelt
equipment. Ford Motor Company
has not developed or approved a
T-hook or slingbelt towing
procedure.
For vehicles equipped with control
trac, the ignition must be in the
OFF position when towing.
When calling for a tow truck, tell
the operator what kind of vehicle
you have. A towing manual is
available for Ford Motor Company
Roadside emergencies
163

for all authorized tow truck
operators. Have your tow truck
driver refer to this manual for
proper hook-up and towing
procedures.
Neutral tow kit accessory
Neutral tow feature is an option
which can be activated at any
dealership that has a Service Bay
Diagnostic System (SBDS). When
activated the feature may be
enabled by following the
instruction located on the visor or
the headliner.
The feature is available on vehicles
with Control Trac and automatic
transmission only. It is not
available on vehicles with
All-Wheel Drive.
There are no wrecker or
recreational vehicle towing
restrictions on method or distance
if the above feature is activated
and enabled.
See your dealer for more
information.
uno_tow-kit
Roadside emergencies
164

kilometers (mileage) and time
requirements, whichever occurs
first:
²Normal Schedule ± 8,000 km
(5,000 miles) or six months.
²Severe Duty Schedule ± 5,000
km (3,000 miles) or three
months. Severe duty operation
would include extensive idling,
trailer towing, driving in severe
dust and police, taxi or delivery
service.
Ford production and aftermarket
(Motorcraft) oil filters are designed
for added engine protection and
long life. If a replacement oil filter
is used that does not meet Ford
material and design specifications,
startup engine noises or knock
may be experienced.
It is recommended you use the
appropriate Motorcraft oil filter (or
another brand meeting Ford
specifications) for your engine
application.
DRIVELINE UNIVERSAL JOINT
AND SLIP YOKE
The universal joints standard with
your vehicle do not require
lubrication. If the original
equipment universal joints are
replaced with universal joints
equipped with grease fittings,
lubrication will be necessary at the
intervals shown in the ªService
Guideº supplement.
com_universal_joint.01
com_checking-adding_fluid.01
Maintenance and care
176

Air bag supplemental restraint
system
and child safety seats ..............90
description ................................89
disposal ......................................94
indicator light ...........................93
passenger air bag .....................91
Air cleaner filter .......................192
replacing ..................................193
Air conditioning
manual heating and air
conditioning
system ...................28,29,30,31,32
Air suspension ...........................119
All wheel drive (AWD) .............134
Anti-theft system ........................65
arming the system ....................66
disarming a triggered system ..68
disarming an untriggered
system .......................................68
warning light .............................67
Autolamp system (see
Headlamps) .................................49
Automatic dimming mirror ...47,48
Battery .......................................188
battery saver ...........................192
servicing ....................188,189,190
Brakes
adjustment ..............................117
anti-lock ...................................117
fluid, checking and adding ....177
parking ....................................118
Break-in period .............................2
Built-in child seat .......102,107,108
Bulbs,
replacing ........208,210,211,212,213
specifications ..........................213
Capacities for refilling fluids ....225
Cargo area shade ........................64
Childproof locks ..........................55
Cleaning your vehicle ...............215
built-in child seat ...................220engine compartment ..............216
fabric ........................................219
instrument panel ....................219
plastic parts ............................218
safety belts ..............................220
tail lamps .................................218
washing ....................................215
waxing .....................................215
wheels ......................................216
Climate control system ..............28
automatic temperature
control ...................32,33,34,35,36
defrosting .............................59,60
Clutch
fluid ..........................................177
Compass, electronic ....................50
calibration .................................51
set zone adjustment .................51
Console, description ..............58,61
Control trac 4WD system .........128
Controls ..................................58,59
Coolant (see Engine coolant)
proper solution .......................181
Daytime running light system ...26
Differential fluid ........................187
Driveline universal joint and
slip yoke .............................176,187
Driving under special
conditions ..................................130
high water ...............................131
slippery roads ..................132,133
towing a trailer .......................144
Emission control system ..........206
Engine .................................228,231
service points ............170,171,172
Engine block heater .................116
Engine coolant
checking and adding .......180,183
checking hoses .......................184
disposal ....................................182
refill capacities ........................182
Index
233

Power door locks ........................54
Power steering
fluid, checking and adding ....184
Rear window
wiper .....................................37,38
Refill capacities for fluids ........223
Relays ..........................149,150,153
Remote entry system .................69
locking/unlocking doors ......69,70
panic alarm ...............................70
replacement/additional
transmitters ...............................73
replacing the batteries .............72
Reporting safety defects ..........232
Restraints, safety (see Safety
restraints)
head ...........................................78
Safety restraints
adjusting the safety belts ....86,87
energy absorbing sew
pattern ..................................88,89
for children ...............................95
proper use ..................83,84,85,86
Safety seats for children
attaching with tether straps ..101
automatic locking mode
(retractor) ............................97,98
Seats ............................................79
adjusting the seat, power ........80
bench (60-40 split) ..................79
Servicing your vehicle ..............165
precautions when servicing ...165
servicing when you tow .........145
Snowplowing .................................4
Special notice ................................3
ambulance conversions ..............3
utility-type vehicles ....................3
Specification chart, lubricants .225
Speed control ..............................40
indicator light ........................8,43
Speedometer ...............................14
Starting your vehicle ................110preparing to start your
vehicle .....................................112
starting a warm engine ..........115
Steering wheel
tilting .........................................44
Storage compartments
overhead storage
compartment .............................52
Tachometer
mechanical cluster ...................15
Tires
changing ..................................156
checking the pressure ............197
inspection and maintenance ..195
replacing ..................................199
rotating ....................................198
snow tires and chains ............201
spare tire .................................156
tire grades ...............................195
treadwear ................................196
Traction-lok rear axle ...............119
Trailer towing ............................138
safety chains ...........................143
tips ....................................139,144
trailer brakes ...........................143
trailer lamps ............................143
Transfer case (see Differential
fluid) ..........................................188
Transmission
fluid, checking and adding
(automatic) .............................186
Trip odometer .............................14
Turn signal
indicator lights ............................9
Two step lock ..............................54
Vehicle dimensions ...................228
Vehicle headlamp aiming
device (VHAD) .........................214
Vehicle Identification Number
(VIN) ..........................................230
Ventilating your vehicle ...........111
Index
235

Voltmeter (see Battery voltage
gauge) ..........................................15
Warning chimes
headlamps on ............................11
key in ignition ...........................12
safety belt .................................12
Washer fluid
reservoir ..................................179
Windows
power windows, operating .......56Windshield washer fluid and
wipers ........................................193
checking and adding fluid .....178
checking and replacing wiper
blades ...............................193,194
liftgate reservoir .....................179
operation ...................................46
specifications ..........................178
Wrecker towing .........................163
236