warning light FORD EXPLORER SPORT TRAC 2010 Workshop Manual

BATTERY
Your vehicle is equipped with a
Motorcraft maintenance-free battery
which normally does not require
additional water during its life of
service.
If your battery has a cover/shield, make sure it is reinstalled
after the battery has been cleaned or replaced.
For longer, trouble-free operation, keep the top of the battery clean and
dry. Also, make certain the battery cables are always tightly fastened to
the battery terminals.
If you see any corrosion on the battery or terminals, remove the cables
from the terminals and clean with a wire brush. You can neutralize the
acid with a solution of baking soda and water.
It is recommended that the negative battery cable terminal be
disconnected from the battery if you plan to store your vehicle for an
extended period of time. This will minimize the discharge of your battery
during storage.
Note: Electrical or electronic accessories or components added to
the vehicle by the dealer or the owner may adversely affect
battery performance and durability.
WARNING:Batteries normally produce explosive gases which
can cause personal injury. Therefore, do not allow flames, sparks
or lighted substances to come near the battery. When working near the
battery, always shield your face and protect your eyes. Always provide
proper ventilation.
WARNING:When lifting a plastic-cased battery, excessive
pressure on the end walls could cause acid to flow through the
vent caps, resulting in personal injury and/or damage to the vehicle or
battery. Lift the battery with a battery carrier or with your hands on
opposite corners.
Maintenance and Specifications
302
2010 07+ Explorer Sport Trac(esp)
Owners Guide(own2002), 1st Printing
USA(fus)

WARNING:To reduce the risk of personal injury, make sure the
engine is cool before unscrewing the coolant pressure relief cap.
The cooling system is under pressure; steam and hot liquid can come
out forcefully when the cap is loosened slightly.
Add the proper mixture of coolant and water to the cooling system by
following these steps:
1. Before you begin, turn the engine off and let it cool.
2. When the engine is cool, wrap a thick cloth around the coolant
pressure relief cap on the coolant reservoir (a translucent plastic bottle).
Slowly turn cap counterclockwise (left) until pressure begins to release.
3. Step back while the pressure releases.
4. When you are sure that all the pressure has been released, use the
cloth to turn it counterclockwise and remove the cap.
5. Fill the coolant reservoir slowly with the proper coolant mixture, to
within the COLD FILL RANGE or the FULL COLD level on the reservoir.
If you removed the radiator cap in an overflow system, fill the radiator
until the coolant is visible and radiator is almost full.
6. Replace the cap. Turn until tightly installed. Cap must be tightly
installed to prevent coolant loss.
After any coolant has been added, check the coolant concentration (refer
toChecking engine coolant). If the concentration is not 50/50
(protection to –34°F/–36°C), drain some coolant and adjust the
concentration. It may take several drains and additions to obtain a 50/50
coolant concentration.
Whenever coolant has been added, the coolant level in the coolant
reservoir should be checked the next few times you drive the vehicle. If
necessary, add enough 50/50 concentration of engine coolant and
distilled water to bring the liquid level to the proper level.
If you have to add more than 1.0 quart (1.0 liter) of engine coolant per
month, have your authorized dealer check the engine cooling system.
Your cooling system may have a leak. Operating an engine with a low
level of coolant can result in engine overheating and possible engine
damage.
Recycled engine coolant
Ford Motor Company does NOT recommend the use of recycled engine
coolant since a Ford-approved recycling process is not yet available.
Maintenance and Specifications
307
2010 07+ Explorer Sport Trac(esp)
Owners Guide(own2002), 1st Printing
USA(fus)

Fuel filler cap
When fueling your vehicle:
1. Turn the engine off.
2. Carefully turn the filler cap counterclockwise until it spins off.
3. Pull to remove the cap from the fuel filler pipe.
4. Reinstall the cap on the filler pipe and turn it clockwise until at least
one click is heard.
If the check fuel cap light
or a “check fuel cap” message comes on,
the fuel filler cap may not be properly installed. The light or message can
come on after several driving events after you’ve refueled your vehicle.
At the next opportunity, safely pull off of the road, remove the fuel filler
cap, align the cap properly and reinstall it. The check fuel cap
light
or “check fuel cap” message may not reset immediately; it may
take several driving cycles for the check fuel cap light
or “check fuel
cap” message to turn off. A driving cycle consists of an engine start-up
(after four or more hours with the engine off) followed by city and
highway driving.
Continuing to drive with the check fuel cap light
or “check fuel cap”
message on may cause the service engine soon
light to turn on as
well.
If you must replace the fuel filler cap, replace it with a fuel filler
cap that is designed for your vehicle. The customer warranty may
be void for any damage to the fuel tank or fuel system if the
correct genuine Ford, Motorcraft or other certified fuel filler cap
is not used.
WARNING:The fuel system may be under pressure. Remove
fuel filler cap slowly. Otherwise, fuel may spray out and injure
you or others.
Maintenance and Specifications
313
2010 07+ Explorer Sport Trac(esp)
Owners Guide(own2002), 1st Printing
USA(fus)

WARNING:If you do not use the proper fuel filler cap,
excessive vacuum in the fuel tank may damage the fuel system
or cause the fuel cap to disengage in a collision, which may result in
personal injury.
Choosing the right fuel
Use only UNLEADED fuel or UNLEADED fuel blended with a maximum
of 10% ethanol. Do not use fuel ethanol (E85), diesel, methanol, leaded
fuel or any other fuel. The use of leaded fuel is prohibited by law and
could damage your vehicle.
Your vehicle was not designed to use fuel or fuel additives with metallic
compounds, including manganese-based additives.
Note:Use of any fuel other than those recommended may cause
powertrain damage, a loss of vehicle performance, and repairs may not
be covered under warranty.
Octane recommendations
Your vehicle is designed to use
“Regular” unleaded gasoline with a
pump (R+M)/2 octane rating of 87.
Some stations offer fuels posted as
“Regular” with an octane rating
below 87, particularly in high altitude areas. Fuels with octane levels
below 87 are not recommended.
Do not be concerned if your engine sometimes knocks lightly. However, if
it knocks heavily under most driving conditions while you are using fuel
with the recommended octane rating, see your authorized dealer to
prevent any engine damage.
87(R+M)/2 METHOD
Maintenance and Specifications
314
2010 07+ Explorer Sport Trac(esp)
Owners Guide(own2002), 1st Printing
USA(fus)

Fuel quality
If you are experiencing starting, rough idle or hesitation driveability
problems, try a different brand of unleaded gasoline. If the problems
persist, see your authorized dealer.
Do not add aftermarket fuel additive products to your fuel tank. It
should not be necessary to add any aftermarket products to your fuel
tank if you continue to use high quality fuel of the recommended octane
rating. These products have not been approved for your engine and
could cause damage to the fuel system. Repairs to correct the effects of
using an aftermarket product in your fuel may not be covered by your
warranty.
Many of the world’s automakers approved the World-Wide Fuel Charter
that recommends gasoline specifications to provide improved
performance and emission control system protection for your vehicle.
Gasolines that meet the World-Wide Fuel Charter should be used when
available. Ask your fuel supplier about gasolines that meet the
World-Wide Fuel Charter.
Cleaner air
Ford endorses the use of reformulated “cleaner-burning” gasolines to
improve air quality, per the recommendations in theChoosing the right
fuelsection.
Running out of fuel
Avoid running out of fuel because this situation may have an adverse
effect on powertrain components.
If you have run out of fuel:
•You may need to cycle the ignition from off to on several times after
refueling to allow the fuel system to pump the fuel from the tank to
the engine. On restarting, cranking time will take a few seconds longer
than normal.
•Normally, adding 1 gallon (3.8L) of fuel is enough to restart the
engine. If the vehicle is out of fuel and on a steep grade, more than
1 gallon (3.8L) may be required.
•The service engine soon
indicator may come on. For more
information on the service engine soon
indicator, refer to
Warning lights and chimesin theInstrument Clusterchapter.
Maintenance and Specifications
315
2010 07+ Explorer Sport Trac(esp)
Owners Guide(own2002), 1st Printing
USA(fus)

EPA fuel economy estimates
Every new vehicle should have a sticker on the window called the
Monroney Label which contains EPA fuel economy estimates. Contact
your authorized dealer if the Monroney Label is not supplied with your
vehicle. The EPA fuel economy estimates should be your guide for the
fuel economy comparisons with other vehicles. Your fuel economy may
vary depending upon the method of operation and conditions.
EMISSION CONTROL SYSTEM
Your vehicle is equipped with various emission control components and a
catalytic converter which will enable your vehicle to comply with
applicable exhaust emission standards. To make sure that the catalytic
converter and other emission control components continue to work
properly:
•Use only the specified fuel listed.
•Avoid running out of fuel.
•Do not turn off the ignition while your vehicle is moving, especially at
high speeds.
•Have the items listed inscheduled maintenance information
performed according to the specified schedule.
The scheduled maintenance items listed inscheduled maintenance
informationare essential to the life and performance of your vehicle
and to its emissions system.
If other than Ford, Motorcraft or Ford-authorized parts are used for
maintenance replacements or for service of components affecting
emission control, such non-Ford parts should be equivalent to genuine
Ford Motor Company parts in performance and durability.
WARNING:Do not park, idle, or drive your vehicle in dry grass
or other dry ground cover. The emission system heats up the
engine compartment and exhaust system, which can start a fire.
Illumination of the service engine soon
indicator, charging system
warning light or the temperature warning light, fluid leaks, strange odors,
smoke or loss of engine power could indicate that the emission control
system is not working properly.
An improperly operating or damaged exhaust system may allow exhaust
to enter the vehicle. Have a damaged or improperly operating exhaust
system inspected and repaired immediately.
Maintenance and Specifications
319
2010 07+ Explorer Sport Trac(esp)
Owners Guide(own2002), 1st Printing
USA(fus)

A
Accessory delay ..........................88
AdvanceTrac ..............................225
Air cleaner filter ...............324–325
Air conditioning ..........................67
Airbag supplemental restraint
system ........................147, 156, 158
and child safety seats ............149
description ..............147, 156, 158
disposal ....................................161
driver airbag ............149, 157, 159
indicator light .................156, 161
operation .................149, 157, 159
passenger airbag .....149, 157, 159
side airbag ...............................156
All Wheel Drive (AWD),
driving off road .........................241
Ambulance packages ....................6
Antifreeze
(see Engine coolant) ................304
Anti-lock brake system
(see Brakes) ......................222–223
Anti-theft system ......................118
Audio system
(see Radio) ......................37, 41, 48
Automatic transmission
driving an automatic
overdrive .........................233, 235
fluid, adding ............................323
fluid, checking ........................323
fluid, refill capacities ..............326
fluid, specification ..................326
Auxiliary input jack (Line in) ....56
Auxiliary power point .................84
Axle
lubricant specifications ..........326refill capacities ........................326
B
Battery .......................................302
acid, treating emergencies .....302
jumping a disabled battery ....270
maintenance-free ....................302
replacement, specifications ...325
servicing ..................................302
Belt-Minder
.............................142
Booster seats .............................176
Brakes ........................................222
anti-lock ...........................222–223
anti-lock brake system (ABS)
warning light ...........................223
fluid, checking and adding ....322
fluid, refill capacities ..............326
fluid, specifications .................326
lubricant specifications ..........326
parking ....................................223
shift interlock ..........................232
C
Calculating load ........................209
Capacities for refilling fluids ....326
Cargo cage .................................100
Cargo management system ......104
Cell phone use ..............................9
Changing a tire .........................261
Child safety seats ......................166
attaching with tether
straps .......................................173
in front seat ............................167
in rear seat ..............................167
LATCH .....................................170
recommendations ...................164
Index
339
2010 07+ Explorer Sport Trac(esp)
Owners Guide(own2002), 1st Printing
USA(fus)

Inspection/maintenance (I/M)
testing ........................................321
Instrument panel
cleaning ...................................288
cluster ........................................12
J
Jack ....................................261, 264
positioning .......................261, 265
storage .....................261, 263–264
Jump-starting your vehicle ......270
K
Keyless entry system
autolock ...........................107, 109
keypad .....................................117
locking and unlocking doors ..118
programming entry code .......117
Keys ...........................................120
positions of the ignition .........217
L
Lamps
bulb replacement
specifications chart ............75–76
daytime running light ...............72
fog lamps ...................................72
headlamps .................................71
interior lamps ...........................75
replacing bulbs .........................80
LATCH anchors .........................170
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........223
Load limits .................................202
Loading instructions .................209
Locks
autolock ...........................107, 109childproof ................................112
doors ........................................107
Lubricant specifications ...........326
Lug nuts ....................................269
Luggage rack .............................105
Lumbar support, seats .....126, 128
M
Message center ...............20, 28–29
english/metric button .........25, 34
system check button ..........25, 34
warning messages ...............26, 34
Mirrors .........................................90
automatic dimming rearview
mirror ........................................90
fold away ...................................91
heated ........................................91
side view mirrors (power) .......90
Moon roof ....................................97
Motorcraft parts ........290, 310, 325
N
Navigation system .......................64
O
Octane rating ............................314
Oil (see Engine oil) ..................297
P
Parking brake ............................223
Parts (see Motorcraft parts) ....325
Passenger Occupant
Classification Sensor .................133
Index
342
2010 07+ Explorer Sport Trac(esp)
Owners Guide(own2002), 1st Printing
USA(fus)

Pedals (see Power adjustable
foot pedals) .................................92
Power adjustable foot pedals .....92
Power distribution box
(see Fuses) ...............................257
Power door locks ......................107
Power mirrors .............................90
Power point ...........................84–85
Power steering ..........................230
fluid, checking and adding ....322
fluid, refill capacity ................326
fluid, specifications .................326
Power Windows ...........................86
Preparing to drive your
vehicle ........................................231
R
Radio ................................37, 41, 48
Recommendations for
attaching safety restraints for
children ......................................164
Relays ........................................254
Remote entry system ...............112
illuminated entry ....................116
locking/unlocking
doors ................................113–114
panic alarm .............................114
replacing the batteries ...........114
Reverse sensing system ...........238
Roadside assistance ..................251
Roof rack ...................................105
S
Safety belts (see Safety
restraints) ..........132, 135–138, 140Safety Canopy ...........156, 158–159
Safety defects, reporting ..........283
Safety restraints ........132, 135–140
Belt-Minder
...........................142
extension assembly ................141
for adults .........................136–138
for children .............................162
Occupant Classification
Sensor ......................................133
warning light and
chime ...............................141–142
Safety restraints - LATCH
anchors ......................................170
Safety seats for children ..........166
Safety Compliance
Certification Label ....................332
Satellite Radio Information ........61
Seats ..........................................122
child safety seats ....................166
front seats ...............................125
heated ..............................128–129
SecuriCode keyless entry
system ........................................117
SecuriLock passive anti-theft
system ........................................118
Setting the clock
AM/FM single CD .....................43
AM/FM/In-dash 6 CD ................50
Snowplowing .................................6
SOS Post Crash Alert ...............161
Spark plugs,
specifications .....................325, 331
Special notice
ambulance conversions ..............6
utility-type vehicles ....................6
Specification chart,
lubricants ...................................326
Index
343
2010 07+ Explorer Sport Trac(esp)
Owners Guide(own2002), 1st Printing
USA(fus)

Speed control ..............................92
Starting your
vehicle ........................217–218, 220
jump starting ..........................270
Steering wheel
controls ......................................95
tilting .........................................82
SYNC
..........................................64
T
Tailgate ........................................99
Tilt steering wheel ......................82
Tire Pressure Monitoring
System (TPMS)
Driving .....................................246
Roadside Emergencies ...........261
Tires, Wheels and Loading ....197
Warning Displays ..........12, 26, 34
Tires ...........................182–184, 261
alignment ................................190
care ..........................................187
changing ..........................261, 265
checking the pressure ............187
inflating ...................................185
label .........................................196
replacing ..........................188, 265
rotating ....................................191
safety practices .......................190
sidewall information ...............192
snow tires and cables .............202
spare tire .........................261, 263
terminology .............................184
tire grades ...............................183
treadwear ........................183, 187
Tonneau cover ...........................101
Towing .......................................210
recreational towing .................216trailer towing ..........................210
wrecker ....................................275
Transfer case
fluid checking .........................323
Transmission .............................233
brake-shift interlock (BSI) ....232
fluid, checking and adding
(automatic) .............................323
fluid, refill capacities ..............326
lubricant specifications ..........326
Trunk .........................................103
Turn signal ..................................75
U
USB port ......................................58
V
Vehicle Identification Number
(VIN) ..........................................332
Vehicle loading ..........................202
camper bodies ........................216
Ventilating your vehicle ...........220
W
Warning lights (see Lights) .......12
Washer fluid ..............................296
Water, Driving through .............250
Windows
power .........................................86
Windshield washer fluid and
wipers ..........................................81
checking and adding fluid .....296
replacing wiper blades ...........297
Wrecker towing .........................275
Index
344
2010 07+ Explorer Sport Trac(esp)
Owners Guide(own2002), 1st Printing
USA(fus)