spare tire FORD F-250 2020 Owner's Manual

WARNING: To help prevent your
vehicle from moving when changing a
wheel, shift the transmission into park
(P), set the parking brake and use an
appropriate block or wheel chock to
secure the wheel diagonally opposite to
the wheel being changed. For example,
when changing the front left wheel,
place an appropriate block or wheel
chock on the right rear wheel. WARNING:
Always use the jack
provided as original equipment with your
vehicle. If using a jack other than the one
provided, make sure the jack capacity is
adequate for the vehicle weight,
including any vehicle cargo or
modifications. If you are unsure if the jack
capacity is adequate, contact the
authorized dealer. WARNING:
Failure to follow these
guidelines could result in an increased
risk of loss of vehicle control, injury or
death. WARNING:
Never place anything
between the vehicle jack and your
vehicle. WARNING:
Never place anything
between the vehicle jack and the ground. WARNING:
Park your vehicle so
that you do not obstruct the flow of
traffic or place yourself in any danger and
set up a warning triangle. WARNING:
Do not work on your
vehicle when the jack is the only support
as your vehicle could slip off the jack.
Failure to follow this instruction could
result in personal injury or death. WARNING:
Do not get under a
vehicle that is only supported by a
vehicle jack. WARNING:
Do not attempt to
change a tire on the side of the vehicle
close to moving traffic. Pull far enough
off the road to avoid the danger of being
hit when operating the jack or changing
the wheel. WARNING:
Only use the spare
wheel carrier to stow the wheel provided
with your vehicle. Other wheel sizes
could cause the spare wheel carrier to
fail if it does not fit securely or is too
heavy.
Note: Do not use impact tools or power
tools operating at over 200 RPM on the
spare wheel carrier winch, which may cause
it to malfunction and prevent a secure fit.
Override the winch at least three times
(there is an audible click each time) to make
sure the wheel and tire fit securely.
Note: Passengers should not remain in the
vehicle when the vehicle is being jacked.
1. Park the vehicle on a level firm ground and activate the hazard flashers.
2. Apply the parking brake, place the transmission in park (P), switch the
engine off.
3. Block the wheel diagonally opposite the flat tire. For example, if the left
front tire is flat, block the right rear
wheel.
419
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and Tires

4. You can find the jack on the floor
behind the rear-most seat on the
passenger side. Turn the retainers
counterclockwise to remove the jack. 5. You can find the tool kit on the floor
under the driver seat for regular cab or
under the rear seat on the driver side.
Turn the retainers counterclockwise to
remove the tool kit. 6.
Use the ignition key to open the lock at
the rear bumper. 7. One or more handle extensions are
used to operate the spare tire carrier.
To assemble, align the button with the
hole and slide the parts together. To
disconnect, press the button and pull
apart. 8. The lug wrench is used to turn the
handle extensions and the jack handle;
slide the square end of the handle
extension into the square hold of the
lug wrench until it clicks in place. 9. Fully insert the jack handle, with one
extension, through the bumper hole
and into the guide tube. Additional
extensions will be needed if the tailgate
is in the lowered position and cannot
be raised. Turn the handle
counterclockwise and lower the spare
tire until you can slide the tire rearward
420
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and TiresE175447 E309424 E309795 E308882 E162796

and the cable is slack. You will feel
some resistance when you turn the jack
handle assembly. If not replacing the
spare or flat tire to the underbody
storage area, raise the wheel retainer
up into the installed position.
10. Slide the retainer through the center of the spare tire wheel and remove
the spare tire. 11. Remove the wheel trim with the lug
wrench tip, or use the wheel trim tool
described later in this section.
12. Loosen each wheel lug nut one-half turn counterclockwise, but do not
remove them until the wheel is raised
off the ground. For dual rear wheel,
assemble the lug wrench and
extension tool together to access the
lug nuts. 13. Position the jack under the correct
jacking points according to following
pictures.
Removing Wheel Trim With Single
Wheels
1. Insert the flat end of the lug wrench between the wheel rim and the wheel
trim.
2. Carefully remove the wheel trim.
Vehicles With Dual Rear Alloy Wheels 421
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and TiresE310417 E309794 E338541

Front passenger side (4x4): F-350 dual
rear wheel
Front driver side (4x4): F-350 dual rear
wheel
Note:
Make sure the jack fits onto the flat
area on the outboard side of the differential
housing. Rear: F-350 dual rear wheel
Front: F-450 and F-550
Rear: F-450 and F-550
Insert the hooked end of the jack handle
into the jack and turn the jack handle
clockwise. For hydraulic jacks, operate the
handle up-and-down until the wheel is
completely off the ground and high enough
to install the spare tire.
Note:
Hydraulic jacks have a pressure relief
valve that prevents lifting loads which
exceed the jack's rated capacity.
F-250 and F-350 Single Rear Wheel
Vehicles
424
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and TiresE162815 E162814 E162817 E162816 E162818

F-350 Dual Rear Wheel Vehicles
Remove the lug nuts with the lug wrench,
replace the flat tire with the spare, making
sure the valve stem of the spare is facing
outward when replacing a front wheel. For
the rear wheel position on vehicles with
single rear wheel fitments, install the spare
with the valve stem facing outward. For
vehicles with dual rear wheels, the valve
stem of the spare must face outward when
replacing an inner wheel, but must face
inward when replacing an outboard wheel.
Reinstall the lug nuts until the wheel is
snug against the hub. Do not fully tighten
the lug nuts until the wheel has been
lowered.
Lower the vehicle completely by turning
the jack handle counterclockwise until the
vehicle is completely lowered. Note:
For F-350 Dual Rear Wheel, F-450
and F-550 Vehicles, insert the notched end
of the jack handle to the release valve, open
the release valve slightly by turning the
handle counterclockwise. Stop turning the
release valve when vehicle start to lower.
Make sure to close the valve when you
completely lower your vehicle.
F-350 Dual Rear Wheel, F-450 and
F-550 Vehicles. Installing the lug Nuts and Ornaments
8-lug nut torque sequence
425
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and TiresE162811 E162819 E162812 E161441
13
4
27
6
5
8

Stowing the Flat Tire or Spare Tire
1. Place the tire on end with the valve
stem facing toward the front of the
vehicle. Lay the tire on the ground, near
the rear of the vehicle, with the valve
stem side facing up. 2. Slide the wheel partially under the
vehicle and install the retainer through
the wheel center. If equipped, you may
have to remove the wheel center cap
prior to pushing the retainer through
the center of the wheel. To remove the
center cap, press it off with the lug
wrench tip from the inner side of the
wheel. Pull on the cable to align the
components at the end of the cable.
3. Turn the lug wrench clockwise until the
tire is raised to its stowed position
underneath the vehicle. The wrench
will become harder to turn and the
spare tire winch will ratchet or slip
when the tire is raised to maximum
tightness. You will hear a clicking sound
from the winch indicating that the tire
is properly stowed. Check that the tire
lies flat against the frame and is
properly tightened.
4. Carefully place all tools back in the tool
kit bag.
5. Reinstall the tool kit bag and tighten the wing nut.
6. Properly reinstall the jack into the bracket and tighten the wing nut.
427
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and TiresA
C
B
D
E162824 E162800

Check Every Month
Air filter restriction gauge. 1
Engine oil level.
Function of all interior and exterior lights.
Tires including the spare for wear and proper pressure. Windshield washer fluid level.
Fuel and water separator. Drain if necessary or if indicated by the information display. 1
Holes and slots in the tail pipe to make sure they are functional and clear of debris. 1
1 Diesel vehicles only. Check Every Six Months
Battery connections. Clean if necessary.
Body and door drain holes for obstructions. Clean if necessary. Cooling system fluid level and coolant strength.
Door weatherstrips for wear. Lubricate if necessary.
Hinges, latches and outside locks for proper operation. Lubricate if necessary. Parking brake for proper operation.
Safety belts and seat latches for wear and function.
Safety warning lamps, brake, ABS, airbag and safety belt for operation.
Washer spray and wiper operation. Clean or replace blades as necessary.
555
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Scheduled Maintenance

Multi-Point Inspection
In order to keep your vehicle running right,
it is important to have the systems on your
vehicle checked regularly. This can help
identify potential issues and prevent major
problems. We recommend having the
following multi-point inspection performed
at every scheduled maintenance interval
to help make sure your vehicle keeps
running great.Multi-Point Inspection
Hazard warning system operation
Accessory drive belt or belts
Horn operation
Battery performance
Radiator, cooler, heater and air conditioninghoses
Engine air filter
Suspension components for leaks ordamage
Exhaust system
Steering and linkage
Exterior lamps operation
Tires including the spare for wear andproper pressure 2
Fluid levels 1
; fill if necessary
Windshield for cracks, chips or pits
For oil and fluid leaks
Washer spray and wiper operation
Half-shaft dust boots
1 Brake, coolant recovery reservoir and window washer.
2 If your vehicle is equipped with a temporary mobility kit, check the tire sealant expiration
Use By date on the canister. Replace as needed.
Be sure to ask your dealership service
advisor or technician about the multi-point
vehicle inspection. It is a comprehensive
way to perform a thorough inspection of
your vehicle. Your checklist gives you
immediate feedback on the overall
condition of your vehicle. NORMAL SCHEDULED
MAINTENANCE
Intelligent Oil-Life Monitor
Your vehicle has an Intelligent Oil-Life
Monitor that determines when you should
change the engine oil based on how you
use your vehicle. By using several
important factors in its calculations, the
monitor helps reduce the cost of owning
your vehicle and reduces environmental
waste at the same time.
556
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Scheduled Maintenance

Alternative Engine Oil for Extremely Cold
Climates.......................................................... 440
Automatic Transmission-Six Speed..........438
Automatic Transmission-Ten Speed.........438
Engine Coolant................................................... 439
Engine Oil............................................................. 439
Front Axle............................................................. 444
Fuel Tank............................................................... 441
Grease..................................................................... 441
Hydraulic Brake System.................................. 442
Locks...................................................................... 443
Power Steering System................................... 442
Rear Axle - 10.5.................................................. 444
Rear Axle - 11.8 ................................................... 445
Transfer Case...................................................... 443
Washer Reservoir............................................... 445
Capacities and Specifications - 6.7L Diesel............................................................446
Air Conditioning System................................. 446
Alternative Engine Oil for Biodiesel Fuel Blends (B20 Max)........................................ 450
Alternative Engine Oil for Extremely Cold Climates ........................................................... 450
Alternative Engine Oil for Severe Duty Service............................................................... 451
Automatic Transmission................................. 447
Diesel Exhaust Fluid (DEF) Tank.................452
Engine Coolant................................................... 448
Engine Oil............................................................. 448
Front Axle............................................................. 455
Fuel Tank................................................................ 451
Grease.................................................................... 452
Hydraulic Brake System.................................. 453
Locks...................................................................... 454
Power Steering System................................... 453
Rear Axle - 10.5................................................... 455
Rear Axle - 10.8.................................................. 456
Rear Axle - 11.8 ................................................... 456
Transfer Case...................................................... 454
Washer Reservoir............................................... 457
Capacities and Specifications - 7.3L..................................................................457
Air Conditioning System................................. 458
Alternative Engine Oil for Extremely Cold Climates.......................................................... 460
Automatic Transmission................................ 458
Engine Coolant................................................... 459
Engine Oil............................................................. 459Front Axle.............................................................
464
Fuel Tank............................................................... 461
Grease..................................................................... 461
Hydraulic Brake System.................................. 462
Locks...................................................................... 463
Power Steering System................................... 462
Rear Axle - 10.5.................................................. 464
Rear Axle - 10.8.................................................. 465
Rear Axle - 11.8 (With HD Tow Option)............................................................. 465
Rear Axle - 11.8 (Without HD Tow Option)............................................................ 466
Transfer Case...................................................... 463
Washer Reservoir............................................... 467
Capacities and Specifications................429
Cargo Lamps...................................................90
Car Wash See: Cleaning the Exterior............................... 381
Catalytic Converter......................................189 On-Board Diagnostics (OBD-II)................... 190
Readiness for Inspection and Maintenance (I/M) Testing.................................................... 191
Center Console..............................................165
Changing a Bulb...........................................372 Cargo Lamp and Central High Mounted
Brake Lamp Bulbs......................................... 374
Fog Lamp Bulbs.................................................. 373
Front Park and Direction Indicator Lamp Bulbs.................................................................. 372
Headlamp Bulbs................................................. 372
LED Lamps........................................................... 375
License Plate Lamp Bulb................................ 375
Rear Lamps, Brake Lamps, Rear Direction Indicator and Reversing Lamp
Bulbs.................................................................. 373
Changing a Fuse...........................................335 Fuses...................................................................... 335
Changing a Road Wheel.............................417 Dissimilar Spare Wheel and Tire Assembly
Information....................................................... 417
Jacking the Vehicle............................................ 422
Location of the Spare Tire and Tools..........418
Stowing the Flat Tire or Spare Tire..............427
Tire Change Procedure..................................... 418
Changing the 12V Battery.........................368 Battery Management System...................... 369
Changing the Engine Air Filter - 6.2L................................................................346
615
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Index

DRL
See: Daytime Running Lamps - Vehicles With:
Configurable Daytime Running Lamps....87
See: Daytime Running Lamps - Vehicles With: Daytime Running Lamps (DRL)................88
E
Economical Driving.....................................307
Electromagnetic Compatibility...............581
Electronic Locking Differential.................215 Activating the Electronic Locking
Differential........................................................ 215
Operating ELD With a Spare or Mismatched Tires.................................................................... 216
Electronic Tailgate.........................................70
With the Outside Control Button................... 70
With the Remote Control.................................. 70
Emission Law.................................................188 Noise Emissions Warranty, Prohibited
Tampering Acts and Maintenance.........189
Tampering With a Noise Control System.............................................................. 188
End User License Agreement.................584 VEHICLE SOFTWARE END USER LICENSE
AGREEMENT (EULA) ................................ 584
Engine Block Heater.....................................176 Using the Engine Block Heater....................... 177
Engine Coolant Check - 6.2L
...................353
Adding Coolant................................................... 353
Engine Coolant Temperature Management.................................................. 356
Fail-Safe Cooling............................................... 355
Recycled Coolant.............................................. 354
Severe Climates................................................. 354
Engine Coolant Check - 6.7L Diesel.............................................................357
Adding Coolant................................................... 357
Coolant Change................................................. 360
Engine and Secondary Cooling System Refill Procedure............................................. 359
Engine-driven Cooling Fan............................ 360
Recycled Coolant.............................................. 359
Severe Climates................................................. 360
Engine Coolant Check - 7.3L...................360 Adding Coolant................................................... 361
Coolant Change................................................. 363Engine Coolant Temperature
Management.................................................. 364
Engine-driven Cooling Fan (Fan Clutch).............................................................. 363
Fail-Safe Cooling............................................... 363
Recycled Coolant............................................... 362
Severe Climates................................................. 363
Engine Emission Control
...........................188
Engine Idle Shutdown.................................176
Engine Immobilizer See: Passive Anti-Theft System..................... 75
Engine Oil Check - 6.2L..............................341 Adding Engine Oil.............................................. 342
Engine Oil Check - 6.7L Diesel................343 Adding Engine Oil.............................................. 343
Engine lubrication for severe service operation ........................................................ 344
Engine Oil Check - 7.3L..............................344 Adding Engine Oil.............................................. 344
Engine Oil Dipstick - 6.2L...........................341
Engine Oil Dipstick - 6.7L Diesel..............341
Engine Oil Dipstick - 7.3L............................341
Engine Specifications - 6.2L....................429 Drivebelt Routing............................................... 429
Engine Specifications - 6.7L Diesel.......429 Drivebelt Routing............................................... 430
Engine Specifications - 7.3L....................430 Drivebelt Routing................................................ 431
Entertainment..............................................509 AM/FM Radio....................................................... 510
Apps........................................................................\
518
Bluetooth Stereo or USB.................................. 517
CD........................................................................\
..... 516
HD Radio ™ Information (If
Available).......................................................... 513
SiriusXM® Satellite Radio (If Activated).......................................................... 511
Sources.................................................................. 510
Supported Media Players, Formats and Metadata Information................................. 518
USB Ports.............................................................. 518
Environment......................................................17
Essential Towing Checks..........................295 Before Towing a Trailer.................................... 303
Dynamic Hitching Using the Rear View Camera System............................................ 296
Hitches................................................................... 297
Integrated Trailer Brake Controller.............300
618
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Index