spare wheel FORD F-450 2020 Owner's Manual

4. You can find the jack on the floor
behind the rear-most seat on the
passenger side. Turn the retainers
counterclockwise to remove the jack. 5. You can find the tool kit on the floor
under the driver seat for regular cab or
under the rear seat on the driver side.
Turn the retainers counterclockwise to
remove the tool kit. 6.
Use the ignition key to open the lock at
the rear bumper. 7. One or more handle extensions are
used to operate the spare tire carrier.
To assemble, align the button with the
hole and slide the parts together. To
disconnect, press the button and pull
apart. 8. The lug wrench is used to turn the
handle extensions and the jack handle;
slide the square end of the handle
extension into the square hold of the
lug wrench until it clicks in place. 9. Fully insert the jack handle, with one
extension, through the bumper hole
and into the guide tube. Additional
extensions will be needed if the tailgate
is in the lowered position and cannot
be raised. Turn the handle
counterclockwise and lower the spare
tire until you can slide the tire rearward
420
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and TiresE175447 E309424 E309795 E308882 E162796

and the cable is slack. You will feel
some resistance when you turn the jack
handle assembly. If not replacing the
spare or flat tire to the underbody
storage area, raise the wheel retainer
up into the installed position.
10. Slide the retainer through the center of the spare tire wheel and remove
the spare tire. 11. Remove the wheel trim with the lug
wrench tip, or use the wheel trim tool
described later in this section.
12. Loosen each wheel lug nut one-half turn counterclockwise, but do not
remove them until the wheel is raised
off the ground. For dual rear wheel,
assemble the lug wrench and
extension tool together to access the
lug nuts. 13. Position the jack under the correct
jacking points according to following
pictures.
Removing Wheel Trim With Single
Wheels
1. Insert the flat end of the lug wrench between the wheel rim and the wheel
trim.
2. Carefully remove the wheel trim.
Vehicles With Dual Rear Alloy Wheels 421
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and TiresE310417 E309794 E338541

Front passenger side (4x4): F-350 dual
rear wheel
Front driver side (4x4): F-350 dual rear
wheel
Note:
Make sure the jack fits onto the flat
area on the outboard side of the differential
housing. Rear: F-350 dual rear wheel
Front: F-450 and F-550
Rear: F-450 and F-550
Insert the hooked end of the jack handle
into the jack and turn the jack handle
clockwise. For hydraulic jacks, operate the
handle up-and-down until the wheel is
completely off the ground and high enough
to install the spare tire.
Note:
Hydraulic jacks have a pressure relief
valve that prevents lifting loads which
exceed the jack's rated capacity.
F-250 and F-350 Single Rear Wheel
Vehicles
424
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and TiresE162815 E162814 E162817 E162816 E162818

F-350 Dual Rear Wheel Vehicles
Remove the lug nuts with the lug wrench,
replace the flat tire with the spare, making
sure the valve stem of the spare is facing
outward when replacing a front wheel. For
the rear wheel position on vehicles with
single rear wheel fitments, install the spare
with the valve stem facing outward. For
vehicles with dual rear wheels, the valve
stem of the spare must face outward when
replacing an inner wheel, but must face
inward when replacing an outboard wheel.
Reinstall the lug nuts until the wheel is
snug against the hub. Do not fully tighten
the lug nuts until the wheel has been
lowered.
Lower the vehicle completely by turning
the jack handle counterclockwise until the
vehicle is completely lowered. Note:
For F-350 Dual Rear Wheel, F-450
and F-550 Vehicles, insert the notched end
of the jack handle to the release valve, open
the release valve slightly by turning the
handle counterclockwise. Stop turning the
release valve when vehicle start to lower.
Make sure to close the valve when you
completely lower your vehicle.
F-350 Dual Rear Wheel, F-450 and
F-550 Vehicles. Installing the lug Nuts and Ornaments
8-lug nut torque sequence
425
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and TiresE162811 E162819 E162812 E161441
13
4
27
6
5
8

Stowing the Flat Tire or Spare Tire
1. Place the tire on end with the valve
stem facing toward the front of the
vehicle. Lay the tire on the ground, near
the rear of the vehicle, with the valve
stem side facing up. 2. Slide the wheel partially under the
vehicle and install the retainer through
the wheel center. If equipped, you may
have to remove the wheel center cap
prior to pushing the retainer through
the center of the wheel. To remove the
center cap, press it off with the lug
wrench tip from the inner side of the
wheel. Pull on the cable to align the
components at the end of the cable.
3. Turn the lug wrench clockwise until the
tire is raised to its stowed position
underneath the vehicle. The wrench
will become harder to turn and the
spare tire winch will ratchet or slip
when the tire is raised to maximum
tightness. You will hear a clicking sound
from the winch indicating that the tire
is properly stowed. Check that the tire
lies flat against the frame and is
properly tightened.
4. Carefully place all tools back in the tool
kit bag.
5. Reinstall the tool kit bag and tighten the wing nut.
6. Properly reinstall the jack into the bracket and tighten the wing nut.
427
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and TiresA
C
B
D
E162824 E162800

Alternative Engine Oil for Extremely Cold
Climates.......................................................... 440
Automatic Transmission-Six Speed..........438
Automatic Transmission-Ten Speed.........438
Engine Coolant................................................... 439
Engine Oil............................................................. 439
Front Axle............................................................. 444
Fuel Tank............................................................... 441
Grease..................................................................... 441
Hydraulic Brake System.................................. 442
Locks...................................................................... 443
Power Steering System................................... 442
Rear Axle - 10.5.................................................. 444
Rear Axle - 11.8 ................................................... 445
Transfer Case...................................................... 443
Washer Reservoir............................................... 445
Capacities and Specifications - 6.7L Diesel............................................................446
Air Conditioning System................................. 446
Alternative Engine Oil for Biodiesel Fuel Blends (B20 Max)........................................ 450
Alternative Engine Oil for Extremely Cold Climates ........................................................... 450
Alternative Engine Oil for Severe Duty Service............................................................... 451
Automatic Transmission................................. 447
Diesel Exhaust Fluid (DEF) Tank.................452
Engine Coolant................................................... 448
Engine Oil............................................................. 448
Front Axle............................................................. 455
Fuel Tank................................................................ 451
Grease.................................................................... 452
Hydraulic Brake System.................................. 453
Locks...................................................................... 454
Power Steering System................................... 453
Rear Axle - 10.5................................................... 455
Rear Axle - 10.8.................................................. 456
Rear Axle - 11.8 ................................................... 456
Transfer Case...................................................... 454
Washer Reservoir............................................... 457
Capacities and Specifications - 7.3L..................................................................457
Air Conditioning System................................. 458
Alternative Engine Oil for Extremely Cold Climates.......................................................... 460
Automatic Transmission................................ 458
Engine Coolant................................................... 459
Engine Oil............................................................. 459Front Axle.............................................................
464
Fuel Tank............................................................... 461
Grease..................................................................... 461
Hydraulic Brake System.................................. 462
Locks...................................................................... 463
Power Steering System................................... 462
Rear Axle - 10.5.................................................. 464
Rear Axle - 10.8.................................................. 465
Rear Axle - 11.8 (With HD Tow Option)............................................................. 465
Rear Axle - 11.8 (Without HD Tow Option)............................................................ 466
Transfer Case...................................................... 463
Washer Reservoir............................................... 467
Capacities and Specifications................429
Cargo Lamps...................................................90
Car Wash See: Cleaning the Exterior............................... 381
Catalytic Converter......................................189 On-Board Diagnostics (OBD-II)................... 190
Readiness for Inspection and Maintenance (I/M) Testing.................................................... 191
Center Console..............................................165
Changing a Bulb...........................................372 Cargo Lamp and Central High Mounted
Brake Lamp Bulbs......................................... 374
Fog Lamp Bulbs.................................................. 373
Front Park and Direction Indicator Lamp Bulbs.................................................................. 372
Headlamp Bulbs................................................. 372
LED Lamps........................................................... 375
License Plate Lamp Bulb................................ 375
Rear Lamps, Brake Lamps, Rear Direction Indicator and Reversing Lamp
Bulbs.................................................................. 373
Changing a Fuse...........................................335 Fuses...................................................................... 335
Changing a Road Wheel.............................417 Dissimilar Spare Wheel and Tire Assembly
Information....................................................... 417
Jacking the Vehicle............................................ 422
Location of the Spare Tire and Tools..........418
Stowing the Flat Tire or Spare Tire..............427
Tire Change Procedure..................................... 418
Changing the 12V Battery.........................368 Battery Management System...................... 369
Changing the Engine Air Filter - 6.2L................................................................346
615
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Index

Reporting Safety Defects (U.S.
Only)..............................................................327
Resuming the Set Speed...........................237
Roadside Assistance...................................315
Vehicles Sold in Canada: Getting Roadside
Assistance........................................................ 316
Vehicles Sold in the United States: Getting Roadside Assistance.................................... 315
Vehicles Sold in the United States: Using Roadside Assistance.................................... 315
Roadside Emergencies
...............................315
Running-In See: Breaking-In.................................................. 310
Running Out of Fuel....................................183
S
Safety Canopy ™
............................................50
Safety Precautions.......................................178
Satellite Radio.............................................480
Satellite Radio Electronic Serial Number
(ESN)................................................................. 481
Satellite Radio Reception Factors...............481
SiriusXM Satellite Radio Service.................. 481
Troubleshooting................................................. 482
Scheduled Maintenance Record.............571
Scheduled Maintenance
...........................553
Seatbelt Extensions......................................42
Seatbelt Height Adjustment.....................40
Seatbelt Reminder.........................................41 Belt-Minder™......................................................... 41
Seatbelts...........................................................36 Principle of Operation........................................ 36
Seatbelt Warning Lamp and Indicator Chime..............................................................40
Conditions of operation.................................... 40
Seats..................................................................147
Security...............................................................75
Selective Catalytic Reductant System - Diesel...............................................................191
Contaminated Diesel Exhaust Fluid or Inoperative Selective Catalytic Reduction
System............................................................... 195
Diesel Exhaust Fluid Guidelines and Information...................................................... 194
Diesel Exhaust Fluid Level................................ 191
Diesel Exhaust Fluid Warning Messages and Vehicle Operations............................... 193Filling the Diesel Exhaust Fluid Tank...........192
Settings............................................................531 911 Assist................................................................ 531
Ambient Lighting............................................... 532
Audio....................................................................... 531
Automatic Updates........................................... 531
Bluetooth............................................................... 531
Charge Settings.................................................. 532
Clock........................................................................\
531
Display.................................................................... 532
Driver Assist.......................................................... 531
FordPass................................................................ 531
General................................................................... 531
Message Center.................................................. 532
Mobile Apps.......................................................... 531
Multi Contour Seats.......................................... 532
Navigation............................................................. 532
Personal Profiles................................................ 532
Phone...................................................................... 531
Seats....................................................................... 532
Sound...................................................................... 531
Valet Mode........................................................... 532
Vehicle..................................................................... 531
Voice Control....................................................... 532
Setting the Cruise Control Speed..........236 Changing the Set Speed................................. 236
Setting the Trail Control Speed..............225
Side Airbags.....................................................49
Sitting in the Correct Position..................147
Sliding Windows
............................................98
Power Sliding Back Window........................... 98
Snow Chains See: Using Snow Chains................................ 408
Snow Plowing.................................................311 Engine temperature while plowing..............313
Installing the Snowplow................................... 311
Operating the Vehicle with the Snowplow Attached............................................................ 312
Snowplowing with your Airbag Equipped Vehicle................................................................ 312
Transmission operation while plowing.............................................................. 313
Spare Wheel See: Changing a Road Wheel......................... 417
Special Notices
................................................15
New Vehicle Limited Warranty......................... 15
On Board Diagnostics Data Link Connector............................................................ 15
624
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Index