transmission FORD F-450 2022 Warranty Guide

[x] Cancel search | Manufacturer: FORD, Model Year: 2022, Model line: F-450, Model: FORD F-450 2022
Pages: 55, PDF Size: 0.45 MB

Page 18 of 55

than Ford dealer facilities. Tire replacements under warranty will
be made with the same brand and model as originally equipped
with the vehicle unless the same brand and model is no longer
available, in which case a tire of the same brand, size, load, speed
and tread type will be used. In some circumstances, Ford may
authorize another brand and/or model to substitute for the
original brand and model, even if still available.
Normal tire wear or damage is not reimbursable. See page 18 for
details of what is not covered.
Extended warranty coverage periods are available for certain
vehicle parts and conditions. Specifically,
(1) Your vehicle's Powertrain components are covered for five
years or 60,000 miles, whichever occurs first. The extended
coverage applies to theEngine:all internal lubricated parts,
cylinder block, cylinder heads, electrical fuel pump, powertrain
control module, engine mounts, flywheel, injection pump,
manifold (exhaust and intake), manifold bolts, oil pan, oil pump,
seals and gaskets, engine thermostat, engine thermostat
housing, timing chain cover, timing chain (gears or belt),
turbocharger/supercharger unit, valve covers, water pump;
Transmission: all internal parts, clutch cover, seals and gaskets,
torque converter, transfer case (including all internal parts),
transmission case, transmission mounts (front and rear);
Front-Wheel Drive: axle shafts, support bracket, front bearings,
seals and gaskets, universal and constant velocity joints;
Rear-Wheel Drive:axle shafts, rear bearings, center support
bearing, drive axle housing (including all internal parts), drive
shaft, retainers, supports, seals and gaskets, universal and
constant velocity joints. Four-Wheel/All-Wheel Drive: axle
shafts, support bracket, bearings (front and rear), center support
bearing, drive shafts, final drive housing (including all internal
parts), hubs-automatic front locking (four-wheel drive), locking
rings (four-wheel drive), seals and gaskets, universal and
constant velocity joints.
11

Page 20 of 55

FORD F-450 2022 Warranty Guide (5) The electrical drivetrain system of your vehicle is covered by
the Hybrid & Electric Vehicle Unique Component coverage for
eight years or 100,000 miles, whichever comes first. The
components in th

(5) The electrical drivetrain system of your vehicle is covered by
the Hybrid & Electric Vehicle Unique Component coverage for
eight years or 100,000 miles, whichever comes first. The
components in the electrical drivetrain system of your vehicle will
vary, depending on whether your vehicle is a hybrid, plug-in
hybrid, but you can rest assured knowing that your vehicle’s
electrical drivetrain system is covered by this comprehensive
warranty. Depending on your vehicle, electrical drivetrain system
components covered by this warranty may include, and are not
limited to: high-voltage battery, high-voltage battery connector,
battery energy control module (BECM), on-board charger,
inverter system controller (ISC), DC/DC converter, hybrid
continuously variable transmission or electric driveline motor and
transmission range sensor. If an electrical drivetrain system
component requires replacement under warranty, it may be
replaced with a new, factory remanufactured, or factory
refurbished component, at Ford’s discretion. Refurbished battery
components selected for your vehicle will align with your
vehicle’s age and mileage, and meet Ford’s stringent
requirements and standards. (see "Note: High-Voltage Battery
Gradual Capacity Loss" below).
Note: High Voltage Battery Gradual Capacity Loss
The high voltage battery will experience gradual capacity loss
with time and use, similar to all batteries, which is considered
normal wear and tear. Loss of battery capacity due to or resulting
from gradual capacity loss is NOT covered under the New Vehicle
Limited Warranty. See your Owner’s Manual for important tips on
how to maximize the life and capacity of the high voltage battery.
NOTE:Some components may also be covered by the Emissions
Warranties. For more information, see pages 22-41.
If you own or lease a 2022-model Next Generation Police
Interceptor Vehicle (NGPI), refer to the Warranty Addendum Card
that was given to you when you took delivery of your vehicle for
further explanation of Amendments to the New Vehicle Limited
Warranty. The Warranty Addendum applies only the NGPI
vehicles delivered in the State of Florida and New York.
13

Page 34 of 55

FORD F-450 2022 Warranty Guide • Heating Element of BackWindow (3.0L diesel F-150
only)
• High Voltage Battery (Hybrid and Plug-in Hybrid vehicles
only)
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/o

transmission FORD F-450 2022 Warranty Guide

Page 18 of 55

Page 20 of 55

Page 34 of 55

Page 44 of 55

Other 2022 FORD F-450 Manuals

FORD Owners Manuals