ignition FORD F-53 2021 Warranty Guide

•Charge air cooler
• Diesel Exhaust Fluid (DEF) System
• Diesel glow plugs and control module
• Diesel particulate filter
• Diesel vacuum pump
• Electronic engine control sensors and switches
• Electronic Engine Control Unit (ECU)*
• Evaporative emission control system
• Exhaust Gas Recirculation (EGR) system
• Exhaust manifolds
• Exhaust pipe (manifold to catalyst)
• Fuel filler tube and cap (gasoline only)
• Fuel injection system
• Fuel injector driver module
• Fuel pump
• Fuel tank (gasoline only)
• Intake manifold
• Malfunction Indicator Light (MIL) system
• Oil filler cap
• Positive Crankcase Ventilation (PCV) system
• Supercharger assembly
• Spark ignition system
• Thermostat
• Throttle body
• Transmission Control Module (TCM)
• Transmission solenoids
• Turbocharger assembly
• Emissions-related bulbs, hoses, clamps, belts, tubes, gaskets, seals,
brackets, connectors, and wiring harnesses used in the above systems
* includes hardware and emission related software changes only
Some of the covered parts may require scheduled maintenance. These
parts are warranted until the time they are first scheduled to be
replaced, according to the schedule in the Owner’s Manual.
WHAT IS NOT COVERED?
Ford may deny you warranty coverage if your vehicle or a part has failed
because of abuse, neglect, improper maintenance, unapproved modifications,
or any items included in What Is Not Covered?
, pages 12-15.
18

6. California requirements for emissions warranty
YOUR WARRANTY RIGHTS AND OBLIGATIONS
The California Air Resources Board and Ford are pleased to explain the
emission control system warranty on your 2021-model vehicle. In California,
new motor vehicles must be designed, built, and equipped to meet the
State’s stringent anti-smog standards. Ford must warrant the emission
control system on your vehicle for the periods of time listed below, provided
there has been no abuse, neglect, or improper maintenance of your vehicle.
Your emission control system may include parts such as the fuel injection
system, the ignition system, catalytic converter, and engine computer.
Also included may be hoses, belts, connectors, and other
emission-related assemblies.
Where a warrantable condition exists, Ford will repair your vehicle at no
cost to you including diagnosis, parts, and labor.
MANUFACTURER’S WARRANTY COVERAGE
F-600/F-650/F-750/F53/F59 Over 19,500 lbs. GVWR trucks are provided
California emissions warranty coverage for 5 years or 50,000 miles
(whichever occurs first) for gasoline engines and 5 years or 100,000
miles (whichever occurs first) for diesel engines. The warranty includes
coverage of components whose failure would increase the vehicle’s
emissions of air conditioning refrigerants. Trucks designated as a
VOCATIONAL TRUCKon the driver’s doorVEHICLE EMISSION
CONTROL INFORMATION label receive tire warranty coverage for
defects that affect compliance with greenhouse gas requirements for 2
years or 24,000 miles (whichever comes first).
If an emissions-related part on your vehicle is defective, the part will be
repaired or replaced by Ford. This is your emission control system
Defects Warranty.
Vehicles Eligible For California Emissions Warranty Coverage
California emission warranty coverage applies if your vehicle meets the
following two criteria:
• Your vehicle is registered in California, Maine, New York (gasoline
only), or Pennsylvania and
19

•Charge air cooler
• Diesel glow plugs and control module
• Diesel Exhaust Fluid (DEF) system
• Diesel particulate filter
• Diesel vacuum pump
• Electronic engine control sensors and switches
• Electronic Engine Control Unit (ECU)*
• Evaporative emission control system
• Exhaust Gas Recirculation (EGR) system
• Exhaust manifolds
• Exhaust pipe (manifold to catalyst)
• Fuel filler tube and cap (gasoline only)
• Fuel injection system
• Fuel injector driver module
• Fuel pump
• Fuel tank (gasoline only)
• Intake manifold
• Malfunction Indicator Light (MIL) system
• Oil filler cap
• Positive Crankcase Ventilation (PCV) system
• Spark ignition system
• Supercharger assembly
• Thermostat
• Throttle body
• Transmission Control Module (TCM)
• Transmission solenoids
• Turbocharger assembly
• Emissions-related bulbs, hoses, clamps, belts, tubes, gaskets, seals,
brackets, connectors, and wiring harnesses used in the above systems
* includes hardware and emission related software changes only
WHAT IS NOT COVERED?
Any items that are not covered under Ford’s New Truck Limited
Warranty are also not covered under the emissions warranties. (See
What Is Not Covered?, pages 12-15.)
21