belt FORD F-59 2020 Warranty Guide

Maintenance/Wear
The New Truck Limited Warranty does not cover: (1) parts and labor
needed to maintain the vehicle; and (2) the replacement of parts due to
normal wear and tear. You, as the owner, are responsible for these items.
Here are examples:
•replacement of filters, windshield wiper blades, brake linings, clutch
linings, and engine belts and hoses
• wheel alignment and tire balancing (unless required by a warranty
repair)
• adjustments such as wheel balancing, wheel alignment, and headlight
alignment
• adjustments to the mechanical valves, belts, transmission, clutch
systems, and brake systems
• cleaning of fuel, cooling, and brake systems
• addition of fluids such as engine oil and washer fluid
• tightening of nuts, bolts, and fittings
Some maintenance and wear items have limited coverage, as follows:
• wiper blade replacements are not covered beyond 6 months in service,
regardless of miles driven
• brake pad/lining replacements are not covered beyond 12 months or
18,000 miles, whichever occurs first
14

•Diesel glow plugs and control module
• Diesel particulate filter
• Diesel vacuum pump
• Electronic engine control sensors and switches
• Electronic Engine Control Unit (ECU)*
• Evaporative emission control system
• Exhaust Gas Recirculation (EGR) system
• Exhaust manifolds
• Exhaust pipe (manifold to catalyst)
• Fuel filler tube and cap (gasoline only)
• Fuel injection system
• Fuel injector driver module
• Fuel pump
• Fuel tank (gasoline only)
• Intake manifold
• Malfunction Indicator Light (MIL) system
• Oil filler cap
• Positive Crankcase Ventilation (PCV) system
• Supercharger assembly
• Spark ignition system
• Thermostat
• Throttle body
• Transmission Control Module (TCM)
• Transmission solenoids
• Turbocharger assembly
• Emissions-related bulbs, hoses, clamps, belts, tubes, gaskets, seals,
brackets, connectors, and wiring harnesses used in the above systems
* includes hardware and emission related software changes only
Some of the covered parts may require scheduled maintenance. These
parts are warranted until the time they are first scheduled to be
replaced, according to the schedule in the Owner’s Manual.
WHAT IS NOT COVERED?
Ford may deny you warranty coverage if your vehicle or a part has failed
because of abuse, neglect, improper maintenance, unapproved modifications,
or any items included in What Is Not Covered?
, pages 12-15.
18

6. California requirements for emissions warranty
YOUR WARRANTY RIGHTS AND OBLIGATIONS
The California Air Resources Board and Ford are pleased to explain the
emission control system warranty on your 2020-model vehicle. In
California, new motor vehicles must be designed, built, and equipped to
meet the State’s stringent anti-smog standards. Ford must warrant the
emission control system on your vehicle for the periods of time listed
below, provided there has been no abuse, neglect, or improper
maintenance of your vehicle.
Your emission control system may include parts such as the fuel injection
system, the ignition system, catalytic converter, and engine computer.
Also included may be hoses, belts, connectors, and other
emission-related assemblies.
Where a warrantable condition exists, Ford will repair your vehicle at no
cost to you including diagnosis, parts, and labor.
MANUFACTURER’S WARRANTY COVERAGE
F-600/F53/F59 over 19,500 lbs. GVWR trucks are provided California
emissions warranty coverage for 5 years or 60,000 miles (whichever first
occurs) for gasoline engines and 5 years or 100,000 miles (whichever
first occurs) for diesel engines.
If an emissions-related part on your vehicle is defective, the part will be
repaired or replaced by Ford. This is your emission control system
Defects Warranty.
Vehicles Eligible For California Emissions Warranty Coverage
California emission warranty coverage applies if your vehicle meets the
following two criteria:
•Your vehicle is registered in California, Maine, New York (gasoline
only), or Pennsylvania and
• Your vehicle is certified for sale in California, as indicated on the
important engine information label.
19

•Diesel Exhaust Fluid (DEF) system
• Diesel particulate filter
• Diesel vacuum pump
• Electronic engine control sensors and switches
• Electronic Engine Control Unit (ECU)*
• Evaporative emission control system
• Exhaust Gas Recirculation (EGR) system
• Exhaust manifolds
• Exhaust pipe (manifold to catalyst)
• Fuel filler tube and cap (gasoline only)
• Fuel injection system
• Fuel injector driver module
• Fuel pump
• Fuel tank (gasoline only)
• Intake manifold
• Malfunction Indicator Light (MIL) system
• Oil filler cap
• Positive Crankcase Ventilation (PCV) system
• Spark ignition system
• Supercharger assembly
• Thermostat
• Throttle body
• Transmission Control Module (TCM)
• Transmission solenoids
• Turbocharger assembly
• Emissions-related bulbs, hoses, clamps, belts, tubes, gaskets, seals,
brackets, connectors, and wiring harnesses used in the above systems
* includes hardware and emission related software changes only
WHAT IS NOT COVERED?
Any items that are not covered under Ford’s New Truck Limited
Warranty are also not covered under the emissions warranties. (See
What Is Not Covered?, pages 12-15.)
21