fuel filter FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS 1996 10.G Owners Manual

122
*
[SV16625( ALL)06/95]
NOTE: Idling the engine for extended periods
will accumulate more hours of use on
your vehicles than is actually indicated
by the mileage odometer.
Consequently, the odometer reading
can be often misleading when
determining the right time to change
your engine oil and filter.
*
[SV16800( ALL)06/95]
Refer to theMaintenance Schedule and Record
booklet for additional information.
%*
[SV17250( ALL)04/95]
NOTE: Always dispose of used automotive
fluids in a responsible manner. Follow
your community's standards for
disposing of these types of fluids. Call
your local recycling center to find out
about recycling automotive fluids.
*
[SV17275( ALL)06/95]
RWARNING
Continuous contact with USED motor oil
has caused cancer in laboratory mice.
*
[SV17280( ALL)05/95]
Protect your skin by washing with soap and
water.
*
[SV17300( ALL)03/95]
Engine Coolant
*
[SV17400( ALL)02/95]
Checking the engine coolant
*
[SV17700( ALL)10/89]
Your vehicle's engine coolant protects the engine
from overheating in the summer and from
freezing in the winter. Check the level of the
engine coolant at least once a month, but
preferably each time you stop for fuel. Simply
look at the engine coolant recovery reservoir
located in the engine compartment. To locate
this reservoir, see the diagram of your vehicle's
engine underEngine typesin this chapter.
File:ltsvm.ex
Update:Tue Jun 20 16:44:35 1995

Severe Duty Schedule 181
*
[BK53001( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK53030( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK53035( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
*
[BK53050( ALL)04/93]
four pica chart:0060627-A
*
[BK53101( ALL)01/95]
18,000 MILES (30,000 Kilometers)
*
[BK53201( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK53501( ALL)04/93]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK53601( ALL)05/93]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK53610( ALL)05/94]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK53801( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK54050( ALL)04/93]
four pica chart:0060627-A
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

184 Severe Duty Schedule
*
[BK56400( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK56700( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK56800( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK56900( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK57000( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK57100( ALL)04/93]
q
Inspect parking brake system for damage and
operation.
q
Inspect parking brake fluid (F-Super Duty
only).
*
[BK57450( FM)06/94]
q
Change rear axle lube (F-Super Duty only).
(4)
*
[BK57520( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK57550( ALL)04/93]
four pica chart:0060627-A
*
[BK57600( ALL)01/95]
33,000 MILES (55,000 Kilometers)
*
[BK57700( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK57750( ALL)94/93]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK58050( ALL)04/93]
four pica chart:0060627-A
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

Severe Duty Schedule 187
*
[BK60600( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK60630( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
*
[BK60635( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK60650( ALL)04/93]
four pica chart:0060627-A
*
[BK60700( ALL)01/95]
48,000 MILES (80,000 Kilometers)
*
[BK60800( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK60900( ALL)01/95]
q
Change engine coolant initially at 48,000 miles
(80,000 km) or 48 months. Thereafter, change
engine coolant every 30,000 miles (50,000 km) or
36 months.
*
[BK61300( ALL)04/93]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK61400( ALL)05/93]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK61450( ALL)05/94]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

190 Severe Duty Schedule
*
[BK64200( ALL)94/93]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK64400( ALL)04/93]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK64500( ALL)05/93]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK64550( ALL)05/94]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK64600( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK64900( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK65000( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK65100( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK65400( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK65500( ALL)04/93]
q
Inspect parking brake system for damage and
operation.
*
[BK66025( FM)06/94]
q
Change rear axle lube (F-Super Duty only).
(4)
*
[BK66030( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
*
[BK66035( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK66050( ALL)04/93]
four pica chart:0060627-A
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

Severe Duty Schedule 193
*
[BK68700( ALL)01/95]
75,000 MILES (125,000 Kilometers)
*
[BK68800( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK68850( ALL)05/95]
q
Inspect engine cooling system, hoses, and clamps;
and check coolant strength every 15,000 miles
(25,000 km) or 12 months.
*
[BK69100( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK69200( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK69300( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK69330( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
*
[BK69335( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK69350( ALL)04/93]
four pica chart:0060627-A
*
[BK69400( ALL)01/95]
78,000 MILES (130,000 Kilometers)
*
[BK69500( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK69525( ALL)05/95]
q
Change engine coolant every 30,000 miles
(50,000 km) or 36 months.
*
[BK69550( ALL)94/93]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK69700( ALL)04/93]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK69800( ALL)05/93]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

196 Severe Duty Schedule
*
[BK72195( ALL)04/93]
q
Replace crankcase emission air filter. If operating
in dusty conditions consult your dealer and/or
follow severe duty maintenance schedule. (4.9L,
5.0L man. trans., and 7.5L only.) (1)
*
[BK72400( ALL)04/93]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK72500( ALL)05/93]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK72550( ALL)05/94]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK72600( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK72800( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK72900( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK73000( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK73100( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK73200( ALL)04/93]
q
Inspect parking brake system for damage and
operation.
*
[BK73650( FM)06/94]
q
Change rear axle lube (F-Super Duty only).
(4)
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

Severe Duty Schedule 199
*
[BK76300( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK76450( ALL)04/93]
four pica chart:0060627-A
*
[BK76500( ALL)01/95]
105,000 MILES (175,000 Kilometers)
*
[BK76600( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK76650( ALL)05/95]
q
Inspect engine cooling system, hoses, and clamps;
and check coolant strength every 15,000 miles
(25,000 km) or 12 months.
*
[BK76700( ALL)94/93]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK76750( ALL)01/95]
q
Change automatic transmission fluid.
*
[BK76900( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK77000( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK77100( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK77130( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
*
[BK77135( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK77150( ALL)04/93]
four pica chart:0060627-A
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

Severe Duty Schedule 203
*
[BK81200( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK81400( ALL)05/93]
q
Lubricate throttle kickdown or TV lever ball
studs.
*
[BK81600( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK81700( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK81800( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK81900( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK82000( ALL)04/93]
q
Inspect parking brake system for damage and
operation.
*
[BK82450( FM)06/94]
q
Change rear axle lube (F-Super Duty only).
(4)
[BK82502( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
[BK82504( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK82505( ALL)04/93]
four pica chart:0060627-A
*
[BK82510( ALL)05/93]
(1) Extremely dusty conditions will require more frequent
replacement of your air filter. check your air filter at
3,000 miles. If it is dirty replace it and then keep
replacing it at the same interval (every 3,000 miles). If
it's not dirty, check it again at 6,000 miles and again at
9,000 miles until you determine your unique
maintenance interval. Do not go beyond 30,000 miles as
described in the chart. If in doubt, see your dealer.
*
[BK82520( ALL)05/93]
(2) If you operate your vehicle ªoff roadº in water that is
deeper than the hubs (1/2 wheel height) then these
items must be serviced daily.
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

Index 209
Index
A
Accessory position on the ignition..... 10
Additives, engine oil.......... 119
Air cleaner filter, specifications...... 164
Alcohol, in fuel............. 114
Antifreeze (see Engine coolant)...... 122
Appeals (see Dispute settlement board) . . . 95
Assistance (see Customer assistance) . . 91±92
Automatic transmission, fluid, refill capacities 164
Automatic transmission
driving an automatic overdrive..... 47
fluid, adding............. 140
fluid, checking............ 139
fluid, refill capacities......... 164
fluid, specification.......... 165
Axle
lubricant specifications........ 165
refill capacities............ 164
B
Backing up................ 50
Basic vehicle warranty........... 4
Battery
acid, treating emergencies...... 79,137
charging system warning light...... 26
disconnecting.............. 82
how to service............ 136
jumping a disabled battery....... 79
maintenance-free........... 136
proper disposal, recycling....... 137
replacement, specifications....... 164
voltage gauge............. 27
when storing your vehicle....... 169
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995