belt FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS 1997 10.G Owners Manual

12 % [IS04000( M)01/96]Safety Belt Warning Light
[IS04500( M)01/96]
The warning light reminds you to fasten your
safety belt. Each time the ignition is turned to
ON, the warning light comes on for four to
eight seconds to remind you to fasten your
safety belt.
*
[IS04600( ALL)01/96]
one inch art:0020046-B
Safety belt warning light symbol
%*
[IS04700( ALL)01/96]
Check Engine Warning Light
*
[IS04800( ALL)01/96]
The Powertrain On-Board Diagnostic II (OBD II)
system consists of the hardware and software
necessary to monitor the operation of the
powertrain. The OBD II system is designed to
check the function of the vehicle's powertrain
control system during normal operation. If an
emission problem is detected, the Check Engine
Warning Light (in the cluster) is turned on.
*
[IS04900( ALL)01/96]
one inch art:0020048-A
Check engine warning light symbol
File:03ltism.ex
Update:Fri Dec 13 11:17:22 1996

38
*
[TO01300( ALL)01/96]
Before you start your vehicle, do the following:
[TO01500( M)01/96]
1. Make sure you and all your passengers
buckle your safety belts.
*
[TO01600( ALL)01/96]
2. Make sure the headlamps and other
accessories are turned off when starting.
*
[TO01800( E M)01/96]
3. Make sure that the gearshift is in P (Park)
and the parking brake is set before you turn
the key.
%*
[TO02300( ALL)01/96]
Starting Your Engine
*
[TO02400( ALL)01/96]
To start your engine:
*
[TO02500( ALL)01/96]
1. Follow the steps underPreparing to Start
Your Vehicleat the beginning of this section.
*
[TO02600( ALL)01/96]
2. Turn the ignition key to the ON position.
*
[TO02700( ALL)01/96]
3. DO NOT depress the accelerator pedal when
starting your engine. DO NOT use the
accelerator while the vehicle is parked.
*
[TO02800( ALL)01/96]
4. Turn the key to the START position
(cranking) until the engine starts. Allow the
key to return to the ON position after the
engine has started.
*
[TO02900( ALL)01/96]
If you have difficulty in turning the key,
rotate the steering wheel slightly because it
may be binding.
File:08lttom.ex
Update:Fri Dec 13 11:22:15 1996

58
*
[GF20835( ALL)01/96]
RWARNING
It is extremely dangerous to ride in a
cargo area, inside or outside of a vehicle.
In a collision, people riding in these areas
are more likely to be seriously injured or
killed. Do not allow people to ride in any
area of your vehicle that is not equipped
with seats and safety belts. Be sure
everyone in your vehicle is in a seat and
using a safety belt properly.
*
[GF20840( ALL)01/96]
RWARNING
Cargo should always be secured to
prevent it from shifting and causing
damage to the vehicle or harm to
passengers.
[GF20843( ALL)01/96]
Trucks, unlike passenger cars, are basically
custom vehicles designed to carry a load. Most
owners start with a base vehicle and add
production and dealer installed and/or
aftermarket components to suit their tastes and
purposes. Even trucks that are purchased for
personal transportation only are likely to have
considerable optional equipment, such as step
bumpers and light bars, for example.
*
[GF20845( ALL)01/96]
Each additional item of equipment affects how
much cargo a vehicle can carry. If a vehicle is
overloaded, performance will suffer and service
concerns may arise.
*
[GF20880( ALL)01/96]
Understanding Loading/Towing
Information
*
[GF20885( ALL)01/96]
The following terms are used to describe the
ability to carry or tow a load:
*
[GF20890( ALL)01/96]
q
Base Curb Weight
*
[GF20895( ALL)01/96]
q
Payload
*
[GF20900( ALL)01/96]
q
GVW (Gross Vehicle Weight)
File:09ltgfm.ex
Update:Fri Dec 13 11:22:54 1996

124 %
*
[MC26850( ALL)01/96]
Replacing the Tires
*
[MC26900( ALL)01/96]
Replace any tires that show wear bands. When
your tire shows a wear band, it has only 1/16
inch (2 mm) of tread left.
*
[MC26950( ALL)01/96]
quarter page art:0060006-A
Wear band
*
[MC27000( ALL)01/96]
Because your vehicle's tires may wear unevenly,
you may need to replace them before a wear
band appears across the entire tread. Some spots
wear more heavily than others.
*
[MC27050( ALL)01/96]
Your wheels and tires are match-mounted for
improved ride. Before you begin to repair a tire,
mark the wheel and tire so that they are
properly aligned when remounted. This will
ensure that the tires will continue to give you
the same ride level.
*
[MC27100( ALL)01/96]
RWARNING
When replacing full size tires, never mix
radial, bias-belted, or bias-type tires. Use
only the tire sizes that are listed on the
tire pressure decal. Make sure that all tires
are the same size, speed rating, and
load-carrying capacity. Use only the tire
combinations recommended on the decal.
If you do not follow these precautions,
your vehicle may not drive properly and
safely.
File:11ltmcm.ex
Update:Fri Dec 13 11:24:54 1996

190 Severe Duty Schedule
*
[BK71800( ALL)01/95]
90,000 MILES (150,000 Kilometers)
*
[BK71900( ALL)11/95]
q
Change engine oil and replace oil filter.
*
[BK72000( ALL)08/95]
q
Replace air cleaner filter every 30,000 miles
(50,000 km) or 30 months. If operating in dusty
conditions consult your dealer and/or follow severe
duty maintenance schedule. (1)
*
[BK72150( ALL)06/95]
q
Inspect engine cooling system, hoses, and clamps;
and check coolant strength every 15,000 miles
(25,000 km) or 12 months.
*
[BK72175( ALL)08/95]
q
Inspect accessory drive belt(s).
*
[BK72195( ALL)04/93]
q
Replace crankcase emission air filter. If operating
in dusty conditions consult your dealer and/or
follow severe duty maintenance schedule.
*
[BK72400( ALL)09/95]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK72500( ALL)06/95]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK72550( ALL)09/95]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK72600( ALL)08/95]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK72800( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996

192 Severe Duty Schedule
*
[BK75050( ALL)09/95]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK75100( ALL)08/95]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK75300( ALL)09/95]
q
Lubricate throttle kickdown or TV lever ball
studs.
*
[BK75450( ALL)04/93]
four pica chart:0060627-A
*
[BK75500( ALL)01/95]
99,000 MILES (165,000 Kilometers)
*
[BK75600( ALL)11/95]
q
Change engine oil and replace oil filter.
*
[BK75650( M)06/94]
q
Inspect accessory drive belt(s).
*
[BK75700( ALL)06/94]
q
Replace rear axle lube.
*
[BK75750( ALL)04/93]
four pica chart:0060627-A
*
[BK75800( ALL)01/95]
102,000 MILES (170,000 Kilometers)
*
[BK75900( ALL)11/95]
q
Change engine oil and replace oil filter.
*
[BK76100( ALL)09/95]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK76200( ALL)06/95]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996

196 Severe Duty Schedule
*
[BK79600( ALL)01/95]
120,000 MILES (200,000 Kilometers)
*
[BK79700( ALL)11/95]
q
Change engine oil and replace oil filter.
*
[BK79800( ALL)06/95]
q
Inspect engine cooling system, hoses, and clamps;
and check coolant strength every 15,000 miles
(25,000 km) or 12 months.
*
[BK79900( ALL)08/95]
q
Replace air cleaner filter every 30,000 miles
(50,000 km) or 30 months. If operating in dusty
conditions consult your dealer and/or follow severe
duty maintenance schedule. (1)
*
[BK80100( ALL)04/95]
q
Replace spark plugs (Gasoline engines only).
*
[BK80300( ALL)04/93]
q
Replace crankcase emission air filter. If operating
in dusty conditions consult your dealer and/or
follow severe duty maintenance schedule.
*
[BK80400( ALL)07/95]
q
Replace PCV valve.
*
[BK80500( ALL)06/94]
q
Check thermactor hoses and clamps.
(Recommended, not required.)
*
[BK80600( ALL)08/95]
q
Inspect accessory drive belt(s).
*
[BK81000( ALL)09/95]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK81100( ALL)06/95]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK81150( ALL)09/95]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK81200( ALL)08/95]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996

Index 211
Lamps (continued)
headlamps............... 21
high beams.............. 26
Lane change indicator (see Turn signal) . . . 25
Lights, warning and indicator
brake................. 11
charging system............ 14
check engine.............. 12
engine oil pressure........... 16
hazard warning light.......... 28
high beam............... 17
oil pressure.............. 16
overdrive off.............. 51
safety belt............... 12
service engine soon........... 12
turn signal indicator.......... 25
Load limits, trailer towing.......56±57
Lubricant specifications......... 149
Lug nuts................. 88
tightening sequence......... 88,90
M
Maintenance schedule and record
(see separate Maintenance Schedule
and Record booklet).......... 4
Maintenance (see Servicing)........ 99
Master cylinder, brakes......... 105
Methanol in fuel............ 130
Mileage, calculating fuel economy.... 133
Motorcraft parts............. 147
N
National Highway Traffic
Safety Administration......... 163
New vehicle break-in........... 8
File:ltixm.ex
Update:Fri Dec 13 11:25:54 1996