key FORD F150 2012 12.G Manual PDF

Fuse/Relay
LocationFuse Amp
RatingProtected Circuits
12 15A Interior lighting, Puddle lamps,
Backlighting, Cargo lamp
13 15A Right turn signals/stop lamps
14 15A Left turn signals/stop lamps
15 15A Reverse lights, High-mounted stop
lamp
16 10A Right low-beam headlamp
17 10A Left low-beam headlamp
18 10A Brake-shift interlock, Keypad
illumination, PCM wakeup, PATS
19 20A Audio amplifier
20 20A Power door locks
21 10A Ambient lighting
22 20A Horn
23 15A Steering wheel control module
24 15A Datalink connector, Steering
wheel control module
25 15A Not used (spare)
26 5A Radio frequency module
27 20A Not used (spare)
28 15A Ignition switch
29 20A Radio/Navigation
30 15A Front parking lamps
31 5A BOO – IP, BOO – Engine
32 15A Delay/accessory – moon roof,
power windows, locks, Automatic
dimming mirror/Compass
33 10A Heated seats
34 10A Reverse sensing system, 4x4
switch, Rear video, Off road
indicator (SVT Raptor)
35 5A Hill descent switch (SVT Raptor)
Roadside Emergencies
331
2012 F-150(f12)
Owners Guide, 1st Printing
USA(fus)

Location of the spare tire and tools
The spare tire is located under the vehicle, just forward of the rear
bumper. The jack, jack handle and lug wrench are located in the
following locations:
Body Style Location
Regular Cab Attached to a floor bracket
behind/under the driver’s seat (for
easier access move the driver seat
forward)
SuperCab Attached to a floor bracket under
the rear seat on the driver’s side
SuperCrew In a plastic box in the floor under
the rear seat
To remove the jack on Regular Cab and SuperCab models:
Remove the wing nut and turn the jack screw counterclockwise to
release pressure before removing the jack from the bracket.
To remove the jack on SuperCrew models:
1. Lift both rear seat cushions.
2. Remove the insert containing the Easy Fuel ™ funnel from the driver’s
side.
3. Remove the two small wing nuts on the passenger side.
4. Slide the plastic box toward the driver’s side and remove.
Removing the spare tire
1. Use the ignition key to remove
the lock cylinder from the access
hole of the bumper to allow access
to the guide tube. Assemble the jack
handle as shown in the illustration.
Roadside Emergencies
341
2012 F-150(f12)
Owners Guide, 1st Printing
USA(fus)

4. Check that the tire lies flat against the frame and is properly
tightened. Try to push or pull, then turn the tire to be sure it will not
move. Loosen and retighten, if necessary. Failure to properly stow the
spare tire may result in failure of the winch cable and loss of the tire.
5. Repeat this tightness check procedure when servicing the spare tire
pressure (every six months, as per yourscheduled maintenance
information),or at any time that the spare tire is disturbed through
service of other components.
6. If removed, install the spare tire lock (if equipped) into the bumper
drive tube with the spare tire lock key (if equipped) and jack handle.
WHEEL LUG NUT TORQUE SPECIFICATIONS
Retighten the lug nuts to the specified torque within 100 miles (160 km)
after any wheel disturbance (rotation, flat tire, wheel removal, etc.).
Bolt size Wheel lug nut torque*
ft-lb N•m
M14 x 2.0 150 200
* Torque specifications are for nut and bolt threads free of dirt and
rust. Use only Ford recommended replacement fasteners.
WARNING:When a wheel is installed, always remove any
corrosion, dirt or foreign materials present on the mounting
surfaces of the wheel or the surface of the wheel hub, brake drum or
brake disc that contacts the wheel. Ensure that any fasteners that
attach the rotor to the hub are secured so they do not interfere with
the mounting surfaces of the wheel. Installing wheels without correct
metal-to-metal contact at the wheel mounting surfaces can cause the
wheel nuts to loosen and the wheel to come off while the vehicle is in
motion, resulting in loss of control.
Note:Inspect the wheel pilot hole
(1) and mounting surface prior to
installation. Remove any visible
corrosion or loose particles.
Roadside Emergencies
346
2012 F-150(f12)
Owners Guide, 1st Printing
USA(fus)

SERVICE RECOMMENDATIONS
To help you service your vehicle, we providescheduled maintenance
informationwhich makes tracking routine service easy.
If your vehicle requires professional service, your authorized dealer can
provide the necessary parts and service. Check yourWarranty Guideto
find out which parts and services are covered.
Use only recommended fuels, lubricants, fluids and service parts
conforming to specifications. Motorcraftparts are designed and built to
provide the best performance in your vehicle.
PRECAUTIONS WHEN SERVICING YOUR VEHICLE
•Do not work on a hot engine.
•Make sure that nothing gets caught in moving parts.
•Do not work on a vehicle with the engine running in an enclosed
space, unless you are sure you have enough ventilation.
•Keep all open flames and other lit material away from the battery and
all fuel related parts.
WARNING:Turn off the power running boards, if equipped,
before working under the vehicle, jacking or placing any object
under the vehicle. Never place your hand between the extended running
board and the vehicle. A moving running board may cause injury.
Working with the engine off
1. Set the parking brake and ensure the gearshift is securely latched in P
(Park).
2. Turn off the engine and remove the key.
3. Block the wheels to prevent the vehicle from moving unexpectedly.
Working with the engine on
WARNING:To reduce the risk of vehicle damage and/or
personal burn injuries, do not start your engine with the air
cleaner removed and do not remove it while the engine is running.
1. Set the parking brake and shift to P (Park).
2. Block the wheels.
Maintenance and Specifications
371
2012 F-150(f12)
Owners Guide, 1st Printing
USA(fus)

in some cases after charging the battery with the external charger, the
BMS requires eight hours of vehicle sleep time (key off with doors
closed) to relearn the new battery state of charge. Prior to relearning the
state of charge, the BMS may disable electrical features (to protect the
battery) earlier than normal.
ENGINE COOLANT
Checking engine coolant
The concentration and level of engine coolant should be checked at the
intervals listed inscheduled maintenance information.The coolant
concentration should be maintained at 50/50 coolant and distilled water.
For best results, coolant concentration should be tested with a
refractometer such as Rotunda tool 300-ROB75240E available from your
dealer. Ford does not recommend the use of hydrometers or coolant test
strips for measuring coolant concentration. The level of coolant should
be maintained at the FULL COLD level or within the COLD FILL RANGE
in the coolant reservoir. If the level falls below, add coolant per the
instructions in theAdding engine coolantsection.
Your vehicle was factory-filled with a 50/50 engine coolant and water
concentration. If the concentration of coolant falls below 40% or above
60%, the engine parts could become damaged or not work properly.A
50/50 mixture of coolant and water provides the following:
•Improved freeze protection.
•Improved boiling protection.
•Protection against rust and other forms of corrosion.
•Proper function of calibrated gauges.
When the engine is cold, check the
level of the engine coolant in the
reservoir.
•The engine coolant should be at the FULL COLD level, or within the
COLD FILL or MIN / MAX range as listed on the engine coolant
reservoir (depending upon application).
Maintenance and Specifications
385
2012 F-150(f12)
Owners Guide, 1st Printing
USA(fus)

Readiness for Inspection/Maintenance (I/M) testing
Some state/provincial and local governments may have
Inspection/Maintenance (I/M) programs to inspect the emission control
equipment on your vehicle. Failure to pass this inspection could prevent
you from getting a vehicle registration. Your vehicle may not pass the I/M
test if the service engine soon
indicator is on or not working
properly (bulb is burned out), or if the OBD-II system has determined
that some of the emission control systems have not been properly
checked. In this case, the vehicle is considered not ready for I/M testing.
If the service engine soon
indicator is on or the bulb does not
work, the vehicle may need to be serviced. Refer toOn-board
diagnostics (OBD-II)in this chapter.
If the vehicle’s engine or transmission has just been serviced, or the
battery has recently run down or been replaced, the OBD-II system may
indicate that the vehicle is not ready for I/M testing. To determine if the
vehicle is ready for I/M testing, turn the ignition key to the on position
for 15 seconds without cranking the engine. If the service engine
soon
indicator blinks eight times, it means that the vehicle is not
ready for I/M testing; if the service engine soon
indicator stays on
solid, it means that the vehicle is ready for I/M testing.
The OBD-II system is designed to check the emission control system
during normal driving. A complete check may take several days. If the
vehicle is not ready for I/M testing, the following driving cycle consisting
of mixed city and highway driving may be performed:
15 minutes of steady driving on an expressway/highway followed by
20 minutes of stop-and-go driving with at least four 30-second idle
periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete. If
the vehicle is still not ready for I/M testing, the above driving cycle will
have to be repeated.
Maintenance and Specifications
405
2012 F-150(f12)
Owners Guide, 1st Printing
USA(fus)

Lifestyle
•Ash cup / smoker’s package•Racks and carriers*
•Bedliners and bedmats•Truck bed camping tent*
•Bed side step•Sportliner cargo liner*
•Towing mirrors•Rear seat entertainment*
•Bed extender•Trailer brake controller
•Tonneau covers*•Hitch balls and towbars
•Interior cargo organization and management
•Truck bed cargo organization and management
•Trailer hitches, wiring harnesses and accessories
Peace of mind
•Keyless entry keypad•Remote start
•Vehicle security systems•Wheel locks
•Bed step*•Bed hooks*
•Protective seat covers*•Back up alarm*
•Cable lock*•Tool/cargo boxes*
•Locking gas plug for capless fuel system
•Bumper and hitch mounted parking sensors*
*Ford Licensed Accessories (FLA) are warranted by the accessory
manufacturer’s warranty. Ford Licensed Accessories are fully designed
and developed by the accessory manufacturer and have not been
designed or tested to Ford Motor Company engineering requirements.
Contact your Ford dealer for details regarding the manufacturer’s limited
warranty and/or a copy of the FLA product limited warranty offered by
the accessory manufacturer.
For maximum vehicle performance, keep the following information in
mind when adding accessories or equipment to your vehicle:
•When adding accessories, equipment, passengers and luggage to your
vehicle, do not exceed the total weight capacity of the vehicle or of
the front or rear axle (GVWR or GAWR as indicated on the Safety
Compliance Certification label). Consult your authorized dealer for
specific weight information.
Accessories
425
2012 F-150(f12)
Owners Guide, 1st Printing
USA(fus)

E
Electronic message center ...20, 31
Emergencies, roadside
jump-starting ..........................347
running out of fuel .........347, 398
Emission control system ..........403
Engine ................................419–420
cleaning ...................................362
coolant .....................................385
fail-safe cooling .......................389
idle speed control ...................382
lubrication specifications .......415
refill capacities ........................415
service points ..................373–376
Engine block heater .................282
Engine oil ..................................378
checking and adding ..............378
dipstick ....................................378
filter, specifications ................414
refill capacities ........................415
specifications ..........................415
Event data recording ....................7
Exhaust fumes ..........................282
F
Fail safe cooling ........................389
Fleet MyKey programming ......136
Flexible Fuel Vehicle (FFV) ....392
Floor mats .........................122–123
Fluid capacities .........................415
Fog lamps ....................................82
Four-Wheel Drive vehicles .......312
description ..............................314
driving off road .......................319
electronic shift ........................313
indicator light .........................312preparing to drive your
vehicle .....................................294
Fuel ............................................392
calculating fuel
economy ............................22, 400
cap ...........................................395
capacity ...................................415
choosing the right fuel ...........396
detergent in fuel .....................398
filler funnel .............................398
filling your vehicle
with fuel ..................392, 395, 400
filter, specifications ........392, 414
fuel pump shut-off ..................328
improving fuel economy ........400
octane rating ...........397, 419–420
quality ......................................398
running out of fuel .........347, 398
safety information relating
to automotive fuels ................392
Fuel - flex fuel vehicle
(FFV) .........................392, 396–397
Fuses ..................................328–329
G
Garage door opener ..................116
Gas cap (see Fuel cap) ............395
Gas mileage (see Fuel
economy) ...................................400
Gauges .........................................18
H
Hazard flashers .........................327
Headlamps ...................................82
aiming ........................................84
autolamp system .......................82
bulb specifications ....................88
daytime running lights .............83
Index
458
2012 F-150(f12)
Owners Guide, 1st Printing
USA(fus)

flash to pass ..............................83
high beam .................................83
replacing bulbs .........................89
turning on and off ....................82
Heating
heating and air conditioning
system .....................68, 71, 73, 76
Hood ..........................................372
I
Ignition .......................278, 419–420
Illuminated visor mirror .............97
Infant seats
(see Safety seats) .....................213
Inspection/maintenance (I/M)
testing ........................................405
Instrument panel
cleaning ...........................365–366
cluster ........................................12
J
Jack ............................................338
positioning ...............................338
storage .....................................338
Jump-starting your vehicle ......347
K
Keyless entry system
autolock ...................................144
keypad .....................................154
locking and unlocking doors ..156
programming entry code .......154
Keys ...................................136, 157
positions of the ignition .........278L
Lamps
autolamp system .......................82
bulb replacement
specifications chart ..................88
daytime running light ...............83
fog lamps ...................................82
headlamps .................................82
headlamps, flash to pass ..........83
interior lamps ...........................86
replacing bulbs ...................89, 93
LATCH anchors .........................220
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........285
Limited-slip axle .......................294
Loading instructions .................262
Load limits .................................255
Locks
autolock ...................................144
childproof ................................148
doors ........................................144
Lubricant specifications ...........415
Lug nuts ....................................346
Lumbar support, seats .....166–167
M
Message center .....................20, 31
english/metric button ...............24
system check button ................24
warning messages ...............24, 39
Mirrors ...............................105–106
automatic dimming rearview
mirror ......................................105
fold away .................................107
heated ....................71, 73, 76, 107
programmable memory ..........150
side view mirrors (power) .....106
Index
459
2012 F-150(f12)
Owners Guide, 1st Printing
USA(fus)

signal .......................................108
Moon roof ..................................114
Motorcraftparts ..............369, 414
MyKey ........................................136
N
Navigation system .......................67
O
Octane rating ............................397
Oil (see Engine oil) ..................378
P
Parental MyKey
programming .............................136
Parking brake ............................285
Parts
(see Motorcraftparts) ...........414
Passenger Occupant
Classification Sensor .................178
Pedals (see Power adjustable
foot pedals) ...............................109
Power adjustable foot pedals ...109
Power deployable running
boards ........................................109
Power distribution box
(see Fuses) .......................329, 332
Power door locks ......................144
Power mirrors ...........................106
Powerpoint ................................100
Power steering ..........................292
fluid, checking and adding ....406
fluid, refill capacity ................415
fluid, specifications .................415Power Windows .........................103
Preparing to drive your
vehicle ........................................294
R
Radio ......................................47, 49
6-CD in dash .............................49
Rear heated seats .....................176
Rear-view camera system .........306
Recommendations for
attaching safety restraints for
children ......................................211
Relays ........................................328
Remote entry system .......148–149
illuminated entry ....................152
locking/unlocking
doors ................................149–150
Remote start ...........................153
replacement/additional
transmitters .............................152
replacing the batteries ...........151
Remote start .............................153
Remote start climate
operation .....................................80
Reverse sensing system ...........304
Roadside assistance ..................326
S
Safety belts
(see Safety restraints) ....180, 182,
184–185, 188
Safety Canopy ...................203, 205
Safety defects, reporting ..........359
Safety restraints ...............180, 182,
184–185, 187–188
Belt-Minder...........................189
Index
460
2012 F-150(f12)
Owners Guide, 1st Printing
USA(fus)