maintenance FORD F550 2011 Owners Manual

D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:Scheduled Maintenance
434
2011 F-250/350/450/550 (f23)
Owners Guide, 4th Printing
USA (fus)

SPECIAL OPERATING CONDITIONS
The following information pertains to 6.2L V8 and 6.8L V10 gasoline
engines only. Scheduled maintenance for the diesel engine can be found
in the diesel supplement.
If you operate your vehicle primarily in one of the more demanding
conditions listed below, you will need to have some items maintained
more frequently. If you only occasionally operate your vehicle under
these conditions, it is not necessary to perform the additional
maintenance. For specific recommendations, see your dealership service
advisor or technician.
Towing a trailer or using a camper or car-top carrier
Inspect frequently,
service as required Inspect and lubricate U-joints
See axle maintenance items under Exceptions
Every 5,000 miles
(8,000 km) Inspect wheels and related components for
abnormal noise, wear, looseness or drag
Rotate tires, inspect tires for wear and measure
tread depth
Every 5,000 miles
(8,000 km) or
6 months Change engine oil and filter
Inspect and lubricate U-joints
Every 30,000 miles
(48,000 km) Change automatic transmission fluid (except
6R80 and TorqShift  transmissions)
Replace front wheel bearing grease/grease seals if
non-sealed bearings are used (2WD vehicles)
Every 60,000 miles
(96,000 km) Change transfer case fluid (4WD vehicles)
Extensive idling and/or low-speed driving for long distances as
in heavy commercial use (i.e. delivery, taxi, patrol car or livery)
Inspect frequently,
service as required Replace cabin air filter (if equipped)
Replace engine air filterScheduled Maintenance
435
2011 F-250/350/450/550 (f23)
Owners Guide, 4th Printing
USA (fus)

Extensive idling and/or low-speed driving for long distances as
in heavy commercial use (i.e. delivery, taxi, patrol car or livery)
Every 5,000 miles
(8,000 km) Inspect brake system
Inspect wheels and related components for
abnormal noise, wear, looseness or drag
Lubricate control arm and steering ball joints if
equipped with grease fittings
Rotate tires, inspect tires for wear and measure
tread depth
Every 5,000 miles
(8,000 km) or
6 months Inspect and lubricate U-joints
Every 5,000 miles
(8,000 km),
6 months or 200
engine hours Change engine oil and filter
Every 30,000 miles
(48,000 km) Change automatic transmission fluid (except
6R80 and TorqShift  transmissions)
Replace front wheel bearing grease/grease seals if
non-sealed bearings are used (2WD vehicles)
Every 60,000 miles
(96,000 km) Change transfer case fluid (4WD vehicles)
Replace spark plugs
Operating in dusty conditions such as unpaved or dusty roads
Inspect frequently,
service as required Replace cabin air filter (if equipped)
Replace engine air filter
Every 5,000 miles
(8,000 km) Inspect the wheels and related components for
abnormal noise, wear, looseness or drag
Rotate tires, inspect tires for wear and measure
tread depth
Every 5,000 miles
(8,000 km) or
6 months Change engine oil and filter
Inspect and lubricate U-jointsScheduled Maintenance
436
2011 F-250/350/450/550 (f23)
Owners Guide, 4th Printing
USA (fus)

Operating in dusty conditions such as unpaved or dusty roads
Every 30,000 miles
(48,000 km) Change automatic transmission fluid (except
6R80 and TorqShift  transmissions)
Replace front wheel bearing grease/grease seals if
non-sealed bearings are used (2WD vehicles)
Every 50,000 miles
(80,000 km) Change rear axle fluid (F-450/550 only)
Every 60,000 miles
(96,000 km) Change transfer case fluid (4WD vehicles)
Off-road operation
Inspect frequently,
service as required Inspect steering linkage, ball joints and U-joints;
lubricate if equipped with grease fittings
Replace cabin air filter (if equipped)
Replace engine air filter
Every 5,000 miles
(8,000 km) or
6 months Change engine oil and filter
Inspect wheels and related components for
abnormal noise, wear, looseness or drag
Rotate tires, inspect tires for wear and measure
tread depth
Every 30,000 miles
(48,000 km) Change automatic transmission fluid (except
6R80 and TorqShift  transmissions)
Replace front wheel bearing grease/grease seals if
non-sealed bearings are used (2WD vehicles)
Every 50,000 miles
(80,000 km) Change rear axle fluid (F-450/550 only)
Every 60,000 miles
(96,000 km) Change transfer case fluid (4WD vehicles)
Exclusive use of E85 (Flex Fuel Vehicles only)
Every oil change
interval If ran exclusively on E85, fill the fuel tank full
with regular unleaded fuelScheduled Maintenance
437
2011 F-250/350/450/550 (f23)
Owners Guide, 4th Printing
USA (fus)

Special operating condition log D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:Scheduled Maintenance
438
2011 F-250/350/450/550 (f23)
Owners Guide, 4th Printing
USA (fus)

D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:Scheduled Maintenance
439
2011 F-250/350/450/550 (f23)
Owners Guide, 4th Printing
USA (fus)

EXCEPTIONS
There are several exceptions to the Normal Schedule. They are listed
below:
Normal vehicle axle maintenance: Rear axles and power take-off
(PTO) units with synthetic fluid and light-duty trucks equipped with
Ford-design axles are lubricated for life; do not check or change fluid
unless a leak is suspected, service is required or the assembly has been
submerged in water. During long periods of trailer towing with outside
temperatures above 70°F (21°C) and at wide-open throttle for long
periods above 45 mph (72 km/h), non-synthetic rear axle fluids should
be changed every 3,000 miles (4,800 km) or three months, whichever
comes first. This interval can be waived if the axle is filled with 75W140
synthetic gear fluid meeting Ford specification WSL-M2C192-A, part
number F1TZ-19580-B or equivalent. Add friction modifier XL-3
(EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear
axles (refer to Maintenance product specifications and capacities in
the Maintenance and Specifications chapter for details).
Police/Taxi/Livery vehicle axle maintenance: Change rear axle fluid
every 100,000 miles (160,000 km). Rear axle fluid change may be waived
if the axle was filled with 75W140 synthetic gear fluid meeting Ford
specification WSL-M2C192-A, part number FITZ-19580-B or equivalent.
Add four ounces (118 mL) of additive friction modifier XL-3
(EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear
axles. The axle fluid should be changed anytime the axle has been
submerged in water.
E–450 and F–450/550 axle maintenance: Change rear axle fluid every
100,000 miles (160,000 km) under normal driving conditions. For
vehicles operated at or near maximum Gross Vehicle Weights, the rear
axle fluid should be changed every 50,000 miles (80,000 km). In
addition, this 50,000 mile (80,000 km) schedule should be observed
when the vehicles are operated under the Special Operating Conditions.
California fuel filter replacement: If the vehicle is registered in
California, the California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify the emission
warranty or limit recall liability prior to the completion of the vehicle’s
useful life. Ford Motor Company, however, urges you to have all
recommended maintenance services performed at the specified intervals
and to record all vehicle service.Scheduled Maintenance
440
2011 F-250/350/450/550 (f23)
Owners Guide, 4th Printing
USA (fus)

Class A Motorhome: Change brake fluid every two years.
Hot climate oil change intervals: If operating conditions are normal
and you drive your vehicle under typical, everyday conditions and you
are using an API performance category oil of SL or later (for example
SM, etc.) then you can follow the 7,500 mile (12,000 km) normal service
oil change intervals schedule. Vehicles operating in the Middle East,
North Africa, Sub-Saharan Africa or locations with similar climates must
follow the oil change interval of 3,000 mile (4,800 km) if the owner is
using oils defined by the American Petroleum Institute (API)
performance category of API SK or earlier (for example SJ, etc).
Edge/MKX AWD only – vehicles operating off-road in sand during high
ambient temperatures must replace the AWD PTU (All-wheel drive
Power Transfer Unit) lube every 20,000 miles (32,000 km).
Engine air filter & cabin air filter replacement: Engine air filter and
cabin air filter life is dependent on exposure to dusty and dirty
conditions. Vehicles operated in these conditions will require frequent
inspection and replacement of the engine air filter and cabin air filter.
ENGINE COOLANT CHANGE RECORD
Initial change 6 years or 105,000 miles (168,000 km)
(whichever comes first)
After initial change Every 3 years or 45,000 miles (72,000 km) Scheduled Maintenance
441
2011 F-250/350/450/550 (f23)
Owners Guide, 4th Printing
USA (fus)

Engine coolant change log D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
: D EALER
V ALIDATION
:
P&A C ODE
:
RO#: H OURS
:
D AT E
:M ILEAGE
:
Scheduled Maintenance
442
2011 F-250/350/450/550 (f23)
Owners Guide, 4th Printing
USA (fus)

A
Accessory delay ........................103
AdvanceTrac ..............................271
Airbag supplemental restraint
system ........................178, 182, 184
and child safety seats ............179
description ..............178, 182, 184
disposal ....................................192
driver airbag ............180, 183, 185
indicator light .........................187
operation .................180, 183, 185
passenger airbag .....180, 183, 185
passenger deactivation
switch ......................................188
side airbag ...............................182
Air cleaner filter .......400–401, 406
Air conditioning ....................77, 80
manual heating and air
conditioning system .................77
Ambulance packages ....................8
Antifreeze (see Engine
coolant) .....................................375
Anti-lock brake system (see
Brakes) ......................................268
Anti-theft system ..............147, 149
arming the system ..........148, 150
disarming a triggered
system .....................................150
triggering .................................150
Audio system (see Radio) ...59, 61
Automatic transmission ............286
driving an automatic
overdrive .................................284
fluid, adding ............................396
fluid, checking ........................396
fluid, refill capacities ..............407
Selectshift (SST) ....................289
Auxiliary Input Jack ...................68 Auxiliary power point ...............100
Axle
refill capacities ........................407
B
Battery .......................................373
acid, treating emergencies .....373
jumping a disabled battery ....343
maintenance-free ....................373
replacement, specifications ...406
servicing ..................................373
Bed extender ............................124
Belt-Minder  .............................174
Booster seats .............................209
Brakes ........................................268
anti-lock ...................................268
anti-lock brake system (ABS)
warning light ...........................269
fluid, checking and adding ....396
fluid, refill capacities ..............407
parking ....................................269
shift interlock ..........................282
trailer .......................................254
Bulbs ............................................91
C
Capacities for refilling fluids ....407
Car2U  Home Automation
System .......................................115
Cassette tape player ...................59
Cell phone use ............................11
Changing a tire .........................326
Child safety seats ......................197
attaching with tether straps ..204
in front seat ....................198, 204
in rear seat ......................198, 204 Index
443
2011 F-250/350/450/550 (f23)
Owners Guide, 4th Printing
USA (fus)