fuses FORD F650 2016 13.G User Guide

Protected components
Fuse amp rating
Fuse or relay number
Left front window motor.
30A
1
Upfitter relay #4.
15A
2
Right front window motor.
30A
3
Interior lamps.
10A
4
Not used.
—
5
Not used.
—
6
Power mirror switch.
7.5A
7
Not used.
—
8
Upfitter relay #3.
10A
9
Run/accessory customer access.
10A
10
Ford telematics battery feed.
10A
11
Interior lighting.
15A
12
Right turn and brake lamps.
15A
13
Left turn and brake lamps.
15A
14
Center high-mounted stop lamp.
15A
15
Backup lamps.
Right headlamp low beam.
10A
16
Left headlamp low beam.
10A
17
Powertrain control module wakeup.
10A
18
Brake shift interlock.
Not used.
—
19
Power door locks.
20A
20
Brake on/off switch.
10A
21
Horn.
20A
22
Instrument cluster.
15A
23
Diagnostic connector.
15A
24
Power fold mirror relay.
Steering wheel control module.
168
F650750 (TBC), enUSA, First Printing Fuses

Protected components
Fuse amp rating
Fuse or relay number
Remote keyless entry.
Not used.
—
25
Steering wheel control module.
5A
26
Not used.
—
27
Ignition switch.
15A
28
GPS module.
20A
29
Radio.
SYNC.
Parking lamps.
15A
30
Trailer tow parking lamps relay coil.
Customer access trailer brake on/off
switch.
5A
31
Delayed accessory power.
15A
32
Driver and passenger door lock switch
illumination.
110v power inverter module.
Telescoping mirror switch.
Not used.
—
33
Ancillary translator module run/start.
10A
34
Tow/Haul run/start.
5A
35
Fuel tank select switch.
10A
36
Auxiliary heater.
10A
37
Delayed accessory power.
10A
38
AM/FM base radio.
Left and right headlamp high beam.
15A
39
Rear parking lamps.
10A
40
Clearance lamps.
Not used.
—
41
Ford telematics run/start.
5A
42
Power Distribution Box run/accessory
fuses.
10A
43
Wiper relay coil.
169
F650750 (TBC), enUSA, First Printing Fuses

Protected components
Fuse amp rating
Fuse or relay number
Customer access upfitter switch power.
10A
44
Ancillary translator module run/accessory
sense.
Not used.
—
45
Climate control module.
10A
46
Fender direction indicator lamps.
15A
47
Power windows switch (crew cab).
30A Circuit breaker
48
Delayed accessory power.
Relay
49
CHANGING A FUSE
Fuses WARNING
Always replace a fuse with one that
has the specified amperage rating.
Using a fuse with a higher amperage
rating can cause severe wire damage and
could start a fire. If electrical components in the vehicle are
not working, a fuse may have blown. A
break in the fuse wire will indicate a blown
fuse. Check the appropriate fuses before
replacing any electrical components.
170
F650750 (TBC), enUSA, First Printing FusesE142430

Engine compartment (with engine off)
Inspect for glazing, fraying or cracking. There should be no
more than 5-7 cracks per rib, per 1 in (2.5 cm)
Belts (fan, alternator,
water pump and air
conditioning
compressor)
Inspect for signs of fluid puddles or dripping fluid on the
ground under the engine, or the underside of the engine.
Fluid leaks
Inspect for debris that may have collected on the HVAC air
inlet grille or inside the exterior module as this may reduce
system performance.
HVAC air inlet Engine starting (with parking brake applied)
Before entering the cab, verify that the vehicle is equipped
with spare electrical fuses (if used), three red reflective
triangles, a properly charged and rated fire extinguisher and
wheel chocks.
Safety and emergency
equipment
Walk around the vehicle and verify all steps and grab handles,
inside and out (as well as behind), are tight and clean. Use
extreme caution and a three-point stance at all times.
Inspect door latches for proper closing, latching and locking.
Set the parking brake. Make sure the gearshift lever is in
neutral (N) or park (P) (if equipped with a park position).
Starting the engine
Diesel engine:
Turn the key to the on position. Turn the key
to start when the wait to start indicator light in the instrument
cluster turns off.
Gasoline engine:
Turn the key to start, and then release it
as soon as the engine starts.
Verify pressure builds to normal operating range.
Engine oil pressure
A tone indicating low air pressure should sound immediately
after the engine starts but before the compressor has built-
up pressure. The tone should stop when the air pressure
reaches
70 psi (483 kPa). Let the air pressure build to
governed cutout pressure, which should occur between
115– 130 psi (793–896 kPa)
.
Low air pressure warning
tone (if equipped with an
air compressor)
Press the accelerator and verify that it operates smoothly,
without any binding or irregular feel. Release the pedal and
verify the engine returns to idle speed immediately.
Accelerator
172
F650750 (TBC), enUSA, First Printing Vehicle Inspection Guide

UNDER HOOD OVERVIEW - 6.8L
Windshield washer fluid reservoir. See Washer Fluid Check (page 202).
A
Engine coolant reservoir. See
Engine Coolant Check (page 190).
B
Automatic transmission fluid dipstick. See
Automatic Transmission Fluid
Check (page 200).
C
Brake fluid reservoir. See
Brake Fluid Check (page 201).
D
Engine compartment fusebox. See
Fuses (page 162).
E
Power steering fluid reservoir. See
Power Steering Fluid Check (page 202).
F
Engine oil dipstick. See
Engine Oil Dipstick (page 185).
G
Engine oil filler cap. See
Engine Oil Check (page 185).
H
Air cleaner assembly. See
Changing the Engine Air Filter (page 210).
I
183
F650750 (TBC), enUSA, First Printing MaintenanceABC
FGHI
DE
E209130

UNDER HOOD OVERVIEW - 6.7L DIESEL
Windshield washer fluid reservoir. See Washer Fluid Check (page 202).
A
Secondary Cooling System Reservoir. See Engine Coolant Check (page 195).
B
Engine coolant reservoir. See
Engine Coolant Check (page 195).
C
Automatic transmission fluid dipstick. See
Automatic Transmission Fluid
Check (page 200).
D
Secondary fuel filter. See
Draining the Fuel Filter Water Trap (page 203).
E
Engine oil separator. See Changing the Engine Oil and Oil Filter (page 188).
F
Brake fluid reservoir. See
Brake Fluid Check (page 201).
G
Engine compartment fusebox. See
Fuses (page 162).
H
Power steering fluid reservoir. See
Power Steering Fluid Check (page 202).
I
Air brake compressor. See
Brake System Inspection (page 218).
J
Engine oil filler cap. See
Engine Oil Check (page 186).
K
Engine oil dipstick. See
Engine Oil Dipstick (page 185).
L
Air cleaner assembly. See
Changing the Engine Air Filter (page 211).
M
184
F650750 (TBC), enUSA, First Printing MaintenanceABD
IJKLM
FEGH
E209131C

that any such export laws, rules or
regulations prohibit HERE from complying
with any of its obligations hereunder to
deliver or distribute Data, such failure shall
be excused and shall not constitute a
breach of this Agreement.
Entire Agreement.
These terms and conditions constitute the
entire agreement between Telenav (and
its licensors, including their licensors and
suppliers) and you pertaining to the subject
matter hereof, and supersedes in their
entirety any and all written or oral
agreements previously existing between
us with respect to such subject matter.
Governing Law.
The above terms and conditions shall be
governed by the laws of the State of Illinois
[insert
“Netherlands” where European
HERE Data is used], without giving effect
to (i) its conflict of laws provisions, or (ii)
the United Nations Convention for
Contracts for the International Sale of
Goods, which is explicitly excluded. You
agree to submit to the jurisdiction of the
State of Illinois [insert “The Netherlands”
where European HERE Data is used] for
any and all disputes, claims and actions
arising from or in connection with the Data
provided to you hereunder.
Government End Users.
If the Data is being acquired by or on behalf
of the United States government or any
other entity seeking or applying rights
similar to those customarily claimed by the
United States government, this Data is a
“ commercial item ” as that term is defined
at 48 C.F.R. (“FAR”) 2.101, is licensed in
accordance with these End-User Terms,
and each copy of Data delivered or
otherwise furnished shall be marked and
embedded as appropriate with the
following “Notice of Use, ” and shall be
treated in accordance with such Notice: NOTICE OF USE
CONTRACTOR (MANUFACTURER/ SUPPLIER) NAME: HERE
CONTRACTOR (MANUFACTURER/
SUPPLIER) ADDRESS: c/o Nokia, 425
West Randolph Street, Chicago, Illinois 60606
This Data is a commercial item as
defined in FAR 2.101 and is subject to
these End-User Terms under which this Data was provided.
© 1987 – 2014 HERE – All rights reserved.
If the Contracting Officer, federal
government agency, or any federal official
refuses to use the legend provided herein,
the Contracting Officer, federal
government agency, or any federal official
must notify HERE prior to seeking
additional or alternative rights in the Data. I. US/Canada Territory A. United States Data. The End-User
Terms for any Application containing
Data for the United States shall contain
the following notices: “HERE holds a non-exclusive license
from the United States Postal
Service® to publish and sell ZIP+4®
information. ”
“©United States Postal Service®
20XX. Prices are not established,
controlled or approved by the United
States Postal Service®. The following
trademarks and registrations are
owned by the USPS: United States
Postal Service, USPS, and ZIP+4. ”
357
F650750 (TBC), enUSA, First Printing Appendices

Bulb Specification Chart..........................209
C
California Proposition 65.............................13
Capacities and Specifications - 6.7L Diesel..............................................................261
Engine Oil Specifications............................... 268
Specifications..................................................... 263
Capacities and Specifications - 6.8L
................................................................256
Specifications...................................................... 257
Capacities and Specifications.................251
Car Wash See: Cleaning the Exterior.............................. 225
Changing a Bulb..........................................208 Brake Lamp, Rear Lamp, Rear Direction
Indicator, License Plate Lamp and
Reverse Lamp................................................ 209
Front Clearance and Identification Lamp................................................................. 208
Headlamp Bulbs................................................ 208
Changing a Fuse............................................170 Fuses....................................................................... 170
Changing a Road Wheel............................247 Tire Change Procedure..................................... 247
Changing the 12V Battery.........................204 Battery Management System (If
Equipped)....................................................... 205
Changing the Coalescer Filter Element.........................................................189
Changing the Engine Air Filter - 6.7L Diesel...............................................................211
Air Filter Replacement...................................... 212
Air Filter Restriction Gauge............................... 211
Changing the Engine Air Filter - 6.8L.................................................................210
Changing the Engine-Mounted and Diesel Fuel Conditioner Module Fuel
Filters - 6.7L Diesel....................................215
Diesel Fuel Conditioner Module Filter.........215
Engine-mounted Fuel Filter............................ 216
Purging Air from the Fuel System.................217
Changing the Engine Oil and Oil Filter...............................................................188
Engine lubrication for severe service operation.......................................................... 188
Changing the Wiper Blades....................206 Checking the Wiper Blades.....................206
Child Restraint and Seatbelt
Maintenance..................................................37
Child Restraint Positioning
..........................27
Child Safety........................................................17
General Information............................................. 17
Child Safety Locks.........................................28
Cleaning Products.......................................225
Cleaning the Alloy Wheels.......................229
Cleaning the Engine....................................226
Cleaning the Exterior..................................225 Exterior Chrome Parts...................................... 225
Exterior Plastic Parts........................................ 226
Stripes or Graphics............................................ 226
Underbody........................................................... 226
Cleaning the Instrument Panel and Instrument Cluster Lens.........................228
Cleaning the Interior....................................227
Cleaning the Windows and Wiper Blades............................................................227
Climate Control...............................................70
Cold Weather Precautions........................148 Winter Operating Tips for Arctic Operation
-20°F (-29°C) and Below.......................... 149
Coolant Check See: Engine Coolant Check - 6.7L Diesel....195
See: Engine Coolant Check - 6.8L...............190
Cruise Control
..................................................45
Principle of Operation....................................... 134
Cruise control See: Using Cruise Control................................ 134
Customer Assistance
..................................156
D
Data Recording.................................................12 Service Data Recording....................................... 12
Daytime Running Lamps............................48
Diesel Particulate Filter................................87
Direction Indicators.......................................48
DPF See: Diesel Particulate Filter............................ 87
Draining the Fuel Filter Water Trap - 6.7L Diesel
.............................................................203
Draining the Diesel Fuel Conditioner Module
(DFCM)............................................................. 203
Driving Aids
.....................................................136
Driving Hints...................................................146
368
F650750 (TBC), enUSA, First Printing Index

Exterior Mirrors.................................................51
Auxiliary Convex Mirrors...................................... 51
Clearance Lamps................................................. 52
Foldaway Exterior Mirrors...................................51
Heated Exterior Mirrors...................................... 52
Power Exterior Mirrors......................................... 51
Signal Indicator Mirrors...................................... 52
Telescoping Mirrors.............................................. 52
F
Fastening the Seatbelts..............................30 Energy Management Feature.......................... 34
Fastening the Cinch Tongue............................. 32
Lap Belts.................................................................. 32
Safety Belt Extension Assembly.................... 34
Safety Belt Locking Modes............................... 33
Using Safety Belts During Pregnancy...........33
Using the Safety Belt with Cinch Tongue (Front Center and Rear Center Seats
Only)...................................................................... 31
Federal Highway Administration Regulation
.......................................................14
Fifth Wheel Operation................................144 Hook-up................................................................. 145
Un-hook................................................................. 145
Ford Credit
.........................................................13
(U.S. Only)................................................................ 13
Frame and Tow Hook Inspection
...........223
Front Seat Armrest........................................79
Fuel and Refueling
........................................90
Fuel Consumption.......................................102 Calculating Fuel Economy.............................. 103
Filling the Tank.................................................... 102
Fuel Filter - 6.8L...........................................204
Fuel Quality - Diesel
......................................92
Biodiesel.................................................................. 93
Diesel Fuel Additives.......................................... 94
Fuel Requirements - Choosing The Right Fuel: Vehicles Operated Where Ultra Low
Sulfur Diesel Fuel Is Not Required ...........93
Fuel Requirements - Choosing The Right Fuel: Vehicles Operated Where Ultra Low
Sulfur Diesel Fuel Is Required (United
States/Canada/Puerto Rico/U.S. Virgin
Islands And Other Locales) ........................ 92
Fuel Quality - Gasoline.................................91 Choosing the Right Fuel..................................... 91Fuel Shutoff....................................................152
Running Out Of DEF (Diesel Exhaust
Fluid).................................................................. 153
Fuel Tank Selector Switch..........................112
Full Power Brake
...........................................124
Fuses.................................................................162
Fuse Specification Chart...........................162 Passenger Compartment Fuse Panel.........167
Power Distribution Box..................................... 162
G
Gauges...............................................................54 Diesel Engines....................................................... 56
Diesel Exhaust Fluid (DEF) Gauge.................57
Engine Coolant Temperature Gauge............55
Engine Oil Pressure Gauge............................... 55
Fuel Gauge.............................................................. 55
Gasoline Engines.................................................. 54
Gauge Package..................................................... 55
Information Display............................................. 56
Transmission Fluid Temperature Gauge................................................................... 55
General Driving Points
................................146
Backing Up............................................................ 146
General Information.......................................... 146
Parking.................................................................... 147
General Information on Radio Frequencies...................................................38
General Maintenance Information
.........314
Multi-point Inspection..................................... 320
Owner Checks and Services........................... 318
Protecting Your Investment............................ 314
Why Maintain Your Vehicle?........................... 314
Why Maintain Your Vehicle at Your Dealership?...................................................... 314
Getting Assistance Outside the U.S. and Canada..........................................................159
Getting the Services You Need
...............156
Away From Home............................................... 156
H
Handbrake See: Parking Brake............................................... 121
Hazard Warning Flashers...........................152
Headlamp Adjusting See: Adjusting the Headlamps.................... 206
370
F650750 (TBC), enUSA, First Printing Index