door lock FORD FIESTA 2007 Workshop Manual

I 00-04-1 2 Noise, Vibration and Harshness I 00=04m12
DIAGNOSIS AND TESTING
Power Steering Hiss Noise
Test Condition
Listen for steering hiss noise with the vehicle
parked, transmission in neutral and all windows
-
closed in the following test conditions.
Power Steering Lock Stop Impact Knock 1. Turn the steering wheel to the left-hand and
Noise right-hand steering locks and listen for the
impact noise.
Test Condition
Listen for steering knock noise with the engine
speed at idle in the following test conditions (noise
also apparent with engine off).
Action
CHECK the installation and
potential damage of the floor seal.
Certain amount of noise level
acceptable, not a safety critical
item.
Certain amount of noise level
acceptable, not a safety critical
item.
Certain amount of noise level
acceptable, not a safety critical
item.
Symptom
N0TE:Engine speed at idle
turning the steering wheel slowly
lock to lock.
Power steering system hiss noise
- a high frequency, continuous
rush or swish noise like escaping
air from a balloon. Hiss occurs
while turning between the steering
lock stops, all steering angles.
Noise does not change with
engine rpm and is worse at high
operating temperatures.
N0TE:Engine speed at idle
holding the steering wheel against
a steering lock for three seconds.
Do not hold for more than five
seconds.
Power steering system hiss noise
- a continuous noise like escaping
air occurs while holding the
steering against a steering lock
stop.
Possible Sources
Floor seal.
Power steering gear valve design.
Power steering system hydraulic
design.
Power pump pressure
relief valve.
Power Steering Mechanical Knock Noise 1. Turn the steering wheel 90 degrees to the right,
(PAS off) hold and then quickly release.
2. Turn the steering wheel 90 degrees to the left, Test Condition hold and then quickly release.
Listen for steering knock noise with the engine off
in the following test conditions (no power assist).
2006.0 Fiesta 1212006 G37349en
Action
Certain amount of noise level
acceptable, not a safety critical
item.
Symptom
Power steering system knock
noise
- a heavy loud sound like a
knock on a door that occurs in
parking condition when hitting the
lock stop.
Possible Sources
Power steering gear mechanical
noise, metal to metal at end of
steering travel.
procarmanuals.com

100-04-13 Noise, Vibration and Harshness 100-04-13
DIAGNOSIS AND TESTING
Power Steering Mechanical Knock Noise 1. Turn the steering wheel to a steering lock and
(PAS on) return to center quickly.
2. Turn the steering wheel 90 degrees to the left
Test Condition and then 90 degrees to the right quickly.
Listen for steering knock noise with the engine
speed at idle in the following test conditions (power
assist).
Action
Certain amount of noise level
acceptable, not a safety critical
item.
Certain amount of noise level
acceptable, not a safety critical
item.
Symptom
Power steering system knock
noise - a heavy loud repeating
sound like a knock on a door that
occurs in several driving and
steering conditions.
Power Steering Hammer Knock (Hydraulic) 1. Turn the steering wheel to a steering lock
Noise position and return quickly.
Possible Sources
Power steering system knock
noise
- a damped, metallic knock
noise which only occurs at
steering condition with engine off
(very high efforts),
Tolerances in the steering gear
components.
Test Condition
Action
REFER to Steering System.
REFER to: Steering System (21
1 -
00, Diagnosis and Testing).
Symptom
Power steering system knock
noise - clear knock noise from
steering gear linkage area.
Listen for steering knock noise with the engine
speed at idle in the following test conditions (for
vehicles with hydraulic power assisted steering only, not electro-hydraulic power steering).
Possible Sources
Worn tie-rod ball joints (inner and
outer ball joints).
Symptom Possible Sources Action
hitting the suspension cross- Certain
amount of noise level
by pressure impulse in gear and
return line).
Power Steering Hydraulic KnocWClonk 1. Drive over cobbled roads at low speed 10-30
Noise kmlh (6-20 mph) with and without turning.
2. Drive over straight tar strips road rails or 25 mm
Test Condition tall harshness strips at low speed 10-30 kmlh
Listen for steering knocklclonk noise in the (6-20
mph) both driving straight and with
following test conditions with the windows closed. moderate turning.
2006.0 Fiesta 1212006 G37349en
procarmanuals.com

Automatic Transmission/Transaxle -
Vehicles With: 4-Speed Automatic
307-01 -40 Transmission (AW81-40)
307-01 -40
DESCRIPTION AND
OPEMION
Driver's side door ajar switch
The door ajar switch is located in the door lock on
the driver's side.
When the door is closed a ground connection is
signalled to the transmission control unit.
When the door is opened this ground connection
is interrupted.
The transmission control unit uses the signal from
the driver's side door ajar switch to warn the driver
if the selector lever is not in position
"P" and the
driver's door is open.
In this case the transmission control unit transmits
the warning tone request via the CAN
databus to
the instrument cluster.
The instrument cluster passes this request on to
the GEM, which then generates a warning tone.
Consequences of signal failure:
no warning tone request.
Actuators
Main regulating valve
Item Description
I 1 I Main regulating valve I
The main regulating valve is a proportional valve
which converts the applied electric current into a
proportional hydraulic pressure.
The currentless state corresponds to maximum
pressure.
/
The main regulating valve is used to determine the
main line pressure and therefore the actuating
pressure for the clutches and brakes.
Consequences of signal failure:
hydraulic emergency running mode.
SSA and SSB shift solenoid valves
Item Description
2006.0 Fiesta 1212006 G380530en
1
2
SSA
SSB
(- t..
procarmanuals.com