check transmission fluid FORD FREESTAR 2005 1.G Owners Manual

Liftgate ajar Warning returns after the ignition key
is turned from OFF to ON
Check left park lamp
Check right park lamp
Check left headlamp
Check fuel cap
Check right headlamp
Check left turn lamp
Washer fluid low
Check right turn lamp
Change oil soon
Check tires/low tire pressure
(if equipped)
Tire pressure monitor fault (if
equipped)
Tire pressure sensor fault (if
equipped)
Check brake lamps
Turn signal on reminder
DRIVER’S DOOR AJAR.Displayed when the driver’s door is not
completely closed.
PASSENGER DOOR AJAR.Displayed when the passenger side door is
not completely closed.
LEFT REAR DOOR AJAR.Displayed when the driver’s rear door is not
completely closed.
RIGHT REAR DOOR AJAR.Displayed when the passenger side rear
door is not completely closed.
LIFTGATE AJAR.Displayed when the liftgate is not completely closed.
TRANSMISSION OVERHEATED.Indicates the transmission is
overheating. This warning may appear when towing heavy loads or when
driving in a low gear at a high speed for an extended period of time.
Stop the vehicle as soon as safely possible, turn off the engine and let it
cool. Check the transmission fluid and level. Refer toTransmission
fluidin theMaintenance and Specificationschapter. If the warning
stays on or continues to come on, contact your dealer for transmission
service as soon as possible.
REVIEW COPY
2005 Freestar(win), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Driver Controls
84

CHECKING AND ADDING POWER STEERING FLUID
Check the power steering fluid.
Refer to the scheduled maintenance
guide for the service interval
schedules. If adding fluid is
necessary, use only MERCONAT F.
1. Start the engine and let it run until it reaches normal operating
temperature (the engine coolant temperature gauge indicator will be
near the center of the normal area between H and C).
2. While the engine idles, turn the steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the reservoir. It should be between the MIN
and MAX lines. Do not add fluid if the level is within this range.
5. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the correct operating range. Be sure to put the
cap back on the reservoir.
BRAKE FLUID RESERVOIR
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels between the“MIN”and
“MAX”lines are within the normal
operating range; there is no need to
add fluid. If the fluid levels are
outside of the normal operating
range the performance of your
brake system could be
compromised; seek service from
your dealer immediately.
TRANSMISSION FLUID
Checking automatic transmission fluid
Refer to yourScheduled Maintenance Guidefor scheduled intervals for
fluid checks and changes. Your transaxle does not consume fluid.
REVIEW COPY
2005 Freestar(win), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
286

However, the fluid level should be checked if the transaxle is not working
properly, i.e., if the transaxle slips or shifts slowly or if you notice some
sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 30 km [20 miles]). If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
1. Drive the vehicle 30 km (20 miles) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry lint free rag. If
necessary, refer toIdentifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect the fluid level. The fluid should be in
the designated areas for normal operating temperature.
Low fluid level
Do not drive the vehicle if the fluid
level is at the bottom of the dipstick
and the outside temperatures are
above 10°C (50°F).
Correct fluid level
The transmission fluid should be checked at normal operating
temperatures 66°C-77°C (150°F-170°F) on a level surface. The normal
operating temperature can be reached after approximately 30 km (20
miles) of driving.
REVIEW COPY
2005 Freestar(win), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
287

A
Accessory delay ..........................68
AdvanceTrac ..............................222
Air bag supplemental restraint
system ................149–150, 156, 158and child safety seats ............151
description ..............150, 156, 158
disposal ....................................162
driver air bag ..........152, 157, 160
indicator light .................156, 161
operation .................152, 157, 160
passenger air bag ...152, 157, 160
side air bag ..............................156
Air cleaner filter .......288–289, 293
Air filter, cabin ............................44
Antifreeze
(see Engine coolant) ................271
Anti-lock brake system
(see Brakes) ......................221–222
Anti-theft system ......................110 arming the system ..................111
disarming a triggered
system .....................................111
Audio system
(see Radio) ................18, 20, 23, 26
Automatic transaxle .................225 fluid, adding ............................286
fluid, checking ........................286
fluid, refill capacities ..............294
fluid, specification ..................297
Automatic transmission driving an automatic
overdrive .................................227
Auxiliary power point .................66
Axle lubricant specifications ..........295 B
Battery .......................................269
acid, treating emergencies .....269
jumping a disabled battery ....241
maintenance-free ....................269
replacement, specifications ...293
servicing ..................................269
BeltMinder .................................144
Brakes ........................................221 anti-lock ...........................221–222
anti-lock brake system (ABS)
warning light ...........................221
fluid, checking and adding ....286
fluid, refill capacities ..............294
fluid, specifications .........295, 297
lubricant specifications ..295, 297
parking ....................................222
shift interlock ..........................225
Bulbs ............................................51
C
Capacities for refilling fluids ....294
Cargo net .....................................92
Cassette tape player .......18, 20, 26
Cell phone use ............................74
Certification Label ....................299
Child safety restraints ..............162 child safety belts ....................162
Child safety seats ......................165 in front seat ............................167
in rear seat ..............................167
tether anchorage hardware ...169
Cleaning your vehicle engine compartment ..............258
instrument panel ....................260
interior .....................................260
interior trim ............................260
plastic parts ............................259
REVIEW COPY
2005 Freestar (win), Owners Guide (post-2002-fmt) (own2002),
Market: USA_English (fus)
Index
Index
303

washing ....................................257
waxing .....................................257
wheels ......................................258
wiper blades ............................259
Clock ............................................66
Compass, electronic ....................59 calibration .................................60
set zone adjustment .................60
Console ........................................74 overhead ....................................58
Controls power seat ...............................113
steering column ........................74
Coolant checking and adding ..............271
refill capacities ................275, 294
specifications ..................295, 297
Cruise control
(see Speed control) ....................71
Cupholder(s) .............................117
Customer Assistance ................231 Ford accessories for your
vehicle .....................................262
Ford Extended Service
Plan ..........................................254
Getting assistance outside
the U.S. and Canada ..............255
Getting roadside assistance ...231
Getting the service you
need .........................................248
Ordering additional owner ’s
literature .................................255
The Dispute Settlement
Board .......................................251
Utilizing the
Mediation/Arbitration
Program ...................................253 D
Daytime running lamps
(see Lamps) ................................46
Dipstick
automatic transmission
fluid ..........................................286
engine oil .................................266
Doors ...........................................61 lubricant specifications ..........295
power sliding ............................62
Driving under special
conditions ..................................228 through water .........................230
E
Emergencies, roadside jump-starting ..........................241
Emission control system ..........283
Engine ........................................297 cleaning ...................................258
coolant .....................................271
idle speed control ...................269
lubrication
specifications ..................295, 297
refill capacities ........................294
service points ..................265 –266
starting after a collision .........232
Engine block heater .................220
Engine oil ..................................266 change oil soon warning,
message center .......................266
checking and adding ..............266
dipstick ....................................266
filter, specifications ........268, 293
recommendations ...................268
refill capacities ........................294
specifications ..................295, 297
Exhaust fumes ..........................220
REVIEW COPY
2005 Freestar (win), Owners Guide (post-2002-fmt) (own2002),
Market: USA_English (fus)
Index
304

Transaxleautomatic operation ...............225
fluid, refill capacities ..............294
lubricant specifications ..........297
Transmission brake-shift interlock (BSI) ....225
fluid, checking and adding
(automatic) .............................286
lubricant specifications ..........295
Turn signal ..................................49
V
Vehicle dimensions ...................297
Vehicle Identification Number
(VIN) ..........................................299
Vehicle loading ..........................208
Ventilating your vehicle ...........220 W
Warning lights (see Lights)
.......10
Washer fluid ..............................266
Water, Driving through .............230
Windows power .........................................68
rear wiper/washer .....................56
Windshield washer fluid and
wipers ..........................................56
checking and adding fluid .....266
liftgate reservoir .....................266
replacing wiper blades .............57
Wrecker towing .........................247
REVIEW COPY
2005 Freestar(win), Owners Guide (post-2002-fmt) (own2002),
Market: USA_English (fus)
Index
308