steering FORD FREESTYLE 2006 1.G Owner's Manual

Readiness for Inspection/Maintenance (I/M) testing
In some localities, it may be a legal requirement to pass an I/M test of
the on-board diagnostics system. If your
indicator is on, refer to
the description in theWarning lights and chimessection of the
Instrument Clusterchapter. Your vehicle may not pass the I/M test with
the
indicator on.
If the vehicle’s powertrain system or its battery has just been serviced,
the on-board diagnostics system is reset to a “not ready for I/M test”
condition. To ready the on-board diagnostics system for I/M testing, a
minimum of 30 minutes of city and highway driving is necessary as
described below:
•First, at least 10 minutes of driving on an expressway or highway.
•Next, at least 20 minutes driving in stop-and-go, city-type traffic with
at least four idle periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete.
POWER STEERING FLUID
Refer to thescheduled maintenance informationfor the service
interval schedules. If adding fluid is necessary, use only MERCONAT F.
1. Start the engine and let it run
until it reaches normal operating
temperature (the engine coolant
temperature gauge indicator will be
near the center of the normal area
between H and C).
2. While the engine idles, turn the
steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the reservoir. It should be between the MIN
and MAX lines. Do not add fluid if the level is in this range.
5. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the range between the MIN and MAX lines. Be
sure to put the cap back on the reservoir.
2006 Freestyle(219)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
267

REFILL CAPACITIES
Fluid Ford Part
NameApplication Capacity
Brake fluid Motorcraft High
Performance
DOT 3 Motor
Vehicle Brake
FluidAll Between MAX
and MIN on
reservoir
Engine coolant
1Motorcraft
Premium Gold
Engine Coolant
(yellow-colored)3.0L engine 11.6 quarts
(11.0L)
Engine oil
(includes filter
change)
2
Motorcraft SAE
5W-20 Premium
Synthetic Blend
Motor Oil (US)
Motorcraft SAE
5W-20 Super
Premium Motor
Oil (Canada)3.0L engine 6.0 quarts
(5.7L)
Fuel tank
capacityN/A All 19.0 gallons
(71.9L)
Power steering
fluidMotorcraft
MERCONAT F3.0L engine Between MAX
and MIN on
reservoir
Automatic
transaxle fluidMotorcraft
Continuously
Variable Chain
Type
Transmission
Fluid
3
CVT automatic
transaxle10.0 quarts
(9.5L)4
Rear axle
lubricantMotorcraft SAE
80W-90
Premium Rear
Axle LubricantAWD 1.5 pints (0.7L)
2006 Freestyle(219)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
270

ItemsFord Part
Name or
equivalentFord Part
NumberFord
Specification
Power Transfer
UnitMotorcraft SAE
75W-90 Fuel
Efficient High
Performance
Rear Axle
LubricantXY-75W-90–QFEHP
—
Engine oil Motorcraft SAE
5W-20 Premium
Synthetic Blend
Motor Oil (US)
Motorcraft SAE
5W-20 Super
Premium Motor
Oil (Canada)
XO-5W20-QSP
(US)
CXO-5W20–LSP12
(Canada)WSS-M2C930-A
and API
Certification
Mark
Constant
velocity jointsCV Joint Grease
(High Temp.)XG-5 WSS-M2C258–A1
Engine coolant Motorcraft
Premium Gold
Engine Coolant
(yellow-colored)VC-7-A (U.S.,
except CA, OR
and NM),
VC-7-B (CA, OR
and NM)WSS
-M97B51–A1
Power steering
fluidMotorcraft
MERCONAT FXT-2-QDX MERCON
Windshield
washer fluidMotorcraft
Premium
Windshield
Washer
ConcentrateZC-32–A WSB-M8B16–A2
1Using any transaxle fluid other than those that meet the
recommended specification may cause internal transaxle damage.
2006 Freestyle(219)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
273

interior trim ............................239
plastic parts ............................238
washing ....................................236
waxing .....................................236
wheels ......................................237
wiper blades ............................238
Climate control
(see Air conditioning
or Heating) ................42, 44, 46, 49
Clock adjust
6-CD in dash .............................21
Compass, electronic
set zone adjustment .................81
Console ..................................63–64
overhead ....................................64
Controls
power seat ...............................108
steering column ........................73
Coolant
checking and adding ..............251
refill capacities ................256, 270
specifications ..................272, 274
Cruise control
(see Speed control) ....................70
Customer Assistance ................205
Ford Extended Service
Plan ..........................................233
Getting assistance outside the
U.S. and Canada .....................234
Getting roadside assistance ...205
Getting the service you
need .........................................229
Ordering additional owner’s
literature .................................234
Utilizing the
Mediation/Arbitration
Program ...................................232D
Daytime running lamps
(see Lamps) ................................53
Dipstick
automatic transmission
fluid ..........................................268
engine oil .................................246
Doors
lubricant specifications ..........272
Driving under special
conditions ..........................199, 202
sand .........................................200
snow and ice ...........................202
through water .................201, 203
E
Electronic message center .........78
Emergencies, roadside
jump-starting ..........................222
Emission control system ..........265
Engine ........................................274
cleaning ...................................237
coolant .....................................251
idle speed control ...................249
lubrication specifications ......272,
274
refill capacities ........................270
service points ..........................244
starting after a collision .........206
Engine block heater .................189
Engine oil ..................................246
change oil soon warning,
message center .......................246
checking and adding ..............246
dipstick ....................................246
filter, specifications ........248, 269
recommendations ...................248
refill capacities ........................270
2006 Freestyle(219)
Owners Guide (post-2002-fmt)
USA(fus)
Index
282

K
Keyless entry system .................97
autolock .....................................99
Keys
positions of the ignition .........186
L
Lamps
autolamp system .......................52
bulb replacement
specifications chart ..................57
daytime running light ...............53
fog lamps ...................................54
headlamps ...........................52, 57
headlamps, flash to pass ..........53
instrument panel, dimming .....54
interior lamps ...........................56
replacing bulbs ...................56–60
Lane change indicator
(see Turn signal) ........................56
Liftgate ........................................88
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........190
Load limits .................................176
Locks
autolock .....................................99
childproof ..................................91
doors ..........................................90
Lubricant specifications ...272, 274
Lug nuts ....................................221
Luggage rack ...............................89
Lumbar support, seats .............107
M
Message center ...........................78
english/metric button ...............83system check button ................84
warning messages .....................84
Mirrors ...................................63, 68
automatic dimming rearview
mirror ........................................68
fold away ...................................68
heated ........................................69
side view mirrors (power) .......68
Moon roof ....................................74
Motorcraft parts ........240, 257, 269
N
Navigation system .......................24
O
Octane rating ............................261
Oil (see Engine oil) ..................246
P
Parking brake ............................191
Parts (see Motorcraft parts) ....269
Passenger Occupant
Classification Sensor .................120
Power adjustable foot pedals .....69
Power distribution box
(see Fuses) ...............................211
Power door locks ........................90
Power mirrors .............................68
Power point .................................65
Power steering ..........................193
fluid, checking and adding ....267
fluid, refill capacity ................270
fluid, specifications .........272, 274
Power Windows ...........................66
R
Radio ......................................17, 20
2006 Freestyle(219)
Owners Guide (post-2002-fmt)
USA(fus)
Index
284

Relays ........................................207
Remote entry system .................92
illuminated entry ................96–97
Reverse sensing system ...........196
Roadside assistance ..................205
Roof rack .....................................89
S
Safety Belt Maintenance ..........131
Safety belts
(see Safety restraints) ............118,
122–125
Safety Canopy ...........................144
Safety defects, reporting ..........235
Safety restraints ........118, 122–125
belt minder .............................126
extension assembly ................131
for adults .........................123–125
for children .............................147
Occupant Classification
Sensor ......................................120
safety belt maintenance .........131
warning light and chime ........126
Safety seats for children ..........151
Safety Compliance
Certification Label ....................276
Seat belts
(see Safety restraints) .............118
Seats ..........................................105
child safety seats ....................151
front seats ...............105–106, 109
heated ............................44, 46, 49
memory seat .....................93, 110
second row seats ............111, 114
third row seats ........114, 116–117
Servicing your vehicle ..............242Setting the clock
AM/FM/In-dash 6 CD ................21
Spare tire
(see Changing the Tire) ...........216
Spark plugs, specifications ......269,
274
Specification chart,
lubricants ...........................272, 274
Speed control ..............................70
Starting your vehicle ........186–188
jump starting ..........................222
Steering wheel
controls ......................................73
tilting .........................................62
T
Tilt steering wheel ......................62
Tires ...........................161–162, 214
alignment ................................168
care ..........................................166
changing ..................214, 216–217
checking the pressure ............166
inspecting and inflating .........163
label .........................................175
replacing ..................................170
rotating ....................................168
safety practices .......................167
sidewall information ...............170
snow tires and chains ............176
spare tire .................................214
terminology .............................162
tire grades ...............................162
treadwear ........................161, 166
Towing .......................................182
recreational towing .................185
trailer towing ..........................182
wrecker ....................................227
Traction control ........................192
2006 Freestyle(219)
Owners Guide (post-2002-fmt)
USA(fus)
Index
285