ignition FORD FREESTYLE 2006 1.G Repair Manual

Octane recommendations
Your vehicle is designed to use
“Regular” unleaded gasoline with
pump (R+M)/2 octane rating of 87.
We do not recommend the use of
gasolines labeled as “Regular” that
are sold with octane ratings of 86 or lower in high altitude areas.
Do not be concerned if your engine sometimes knocks lightly. However, if
it knocks heavily under most driving conditions while you are using fuel
with the recommended octane rating, see your authorized dealer to
prevent any engine damage.
Fuel quality
If you are experiencing starting, rough idle or hesitation driveability
problems, try a different brand of unleaded gasoline. “Premium” unleaded
gasoline is not recommended for vehicles designed to use “Regular”
unleaded gasoline because it may cause these problems to become more
pronounced. If the problems persist, see your authorized dealer.
It should not be necessary to add any aftermarket products to your fuel
tank if you continue to use high quality fuel of the recommended octane
rating. Aftermarket products could cause damage to the fuel system.
Repairs to correct the effects of using an aftermarket product in your
fuel may not be covered by your warranty.
Many of the world’s automakers approved the World-wide Fuel Charter
that recommends gasoline specifications to provide improved
performance and emission control system protection for your vehicle.
Gasolines that meet the World-wide Fuel Charter should be used when
available. Ask your fuel supplier about gasolines that meet the
World-wide Fuel Charter.
Cleaner air
Ford endorses the use of reformulated “cleaner-burning” gasolines to
improve air quality.
Running out of fuel
Avoid running out of fuel because this situation may have an adverse
effect on powertrain components.
If you have run out of fuel:
•You may need to cycle the ignition from off to on several times after
refueling, to allow the fuel system to pump the fuel from the tank to
the engine.
87(R+M)/2 METHOD
2006 Freestyle(219)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
261

•Theindicator may come on. For more information on the “Check
Engine” or the “Service engine soon” indicator, refer toWarning lights
and chimesin theInstrument Clusterchapter.
ESSENTIALS OF GOOD FUEL ECONOMY
Measuring techniques
Your best source of information about actual fuel economy is you, the
driver. You must gather information as accurately and consistently as
possible. Fuel expense, frequency of fill-ups or fuel gauge readings are
NOT accurate as a measure of fuel economy. We do not recommend
taking fuel economy measurements during the first 1,000 miles (1,600
km) of driving (engine break-in period). You will get a more accurate
measurement after 2,000 miles-3,000 miles (3,000 km–5,000 km).
Filling the tank
The advertised fuel capacity of the fuel tank on your vehicle is equal to
the rated refill capacity of the fuel tank as listed in theRefill capacities
section of this chapter.
The advertised capacity is the amount of the indicated capacity and the
empty reserve combined. Indicated capacity is the difference in the
amount of fuel in a full tank and a tank when the fuel gauge indicates
empty. Empty reserve is the small amount of fuel remaining in the fuel
tank after the fuel gauge indicates empty.
The amount of usable fuel in the empty reserve varies and should
not be relied upon to increase driving range. When refueling your
vehicle after the fuel gauge indicates empty, you might not be
able to refuel the full amount of the advertised capacity of the
fuel tank due to the empty reserve still present in the tank.
For consistent results when filling the fuel tank:
•Turn the engine/ignition switch to the off position prior to refueling,
an error in the reading will result if the engine is left running.
•Use the same filling rate setting (low — medium — high) each time
the tank is filled.
•Allow no more than two automatic click-offs when filling.
•Always use fuel with the recommended octane rating.
•Use a known quality gasoline, preferably a national brand.
•Use the same side of the same pump and have the vehicle facing the
same direction each time you fill up.
2006 Freestyle(219)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
262

EPA window sticker
Every new vehicle should have the EPA window sticker. Contact your
authorized dealer if the window sticker is not supplied with your vehicle.
The EPA window sticker should be your guide for the fuel economy
comparisons with other vehicles.
It is important to note the box in the lower left corner of the window
sticker. These numbers represent the Range of MPG (L/100 km)
expected on the vehicle under optimum conditions. Your fuel economy
may vary depending upon the method of operation and conditions.
EMISSION CONTROL SYSTEM
Your vehicle is equipped with various emission control components and a
catalytic converter which will enable your vehicle to comply with
applicable exhaust emission standards. To make sure that the catalytic
converter and other emission control components continue to work
properly:
•Use only the specified fuel listed.
•Avoid running out of fuel.
•Do not turn off the ignition while your vehicle is moving, especially at
high speeds.
•Have the items listed inscheduled maintenance information
performed according to the specified schedule.
The scheduled maintenance items listed inscheduled maintenance
informationare essential to the life and performance of your vehicle
and to its emissions system.
If other than Ford, Motorcraft or Ford-authorized parts are used for
maintenance replacements or for service of components affecting
emission control, such non-Ford parts should be equivalent to genuine
Ford Motor Company parts in performance and durability.
Do not park, idle, or drive your vehicle in dry grass or other dry
ground cover. The emission system heats up the engine
compartment and exhaust system, which can start a fire.
Illumination of the
indicator, charging system warning light or the
temperature warning light, fluid leaks, strange odors, smoke or loss of
engine power could indicate that the emission control system is not
working properly.
2006 Freestyle(219)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
265

ENGINE DATA
Engine 3.0L-DOHC V6 engine
Displacement 183 cubic inches
Required fuel 87 octane
Firing order 1–4–2–5–3–6
Spark plug gap (0.052–0.056 inch) 1.32–1.42 mm
Ignition system Coil on plug
Compression ratio 10.0:1
ENGINE DRIVEBELT ROUTING
•3.0L V6 Engine
VEHICLE DIMENSIONS
Vehicle dimensions Inches (mm)
(1) Overall length 199.8 (5075)
(2) Overall width 74.4 (1891)
(3) Overall height 68.9 (1732)
(4) Wheelbase 112.9 (2867)
(5) Tread - Front 64.6 (1640)
(5) Tread - Rear 65.0 (1650)
2006 Freestyle(219)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
274

specifications ..................272, 274
Exhaust fumes ..........................189
F
Fluid capacities .........................270
Foglamps .....................................54
Four-Wheel Drive vehicles
driving off road .......................198
Fuel ............................................257
calculating fuel
economy ............................79, 262
cap ...........................................259
capacity ...................................270
choosing the right fuel ...........260
comparisons with EPA fuel
economy estimates .................265
detergent in fuel .....................261
filling your vehicle
with fuel ..................257, 259, 262
filter, specifications ........257, 269
fuel pump shut-off switch .....206
improving fuel economy ........262
octane rating ...................261, 274
quality ......................................261
running out of fuel .................261
safety information relating to
automotive fuels .....................257
Fuel pump shut-off switch .......206
Fuses ..........................................207
G
Garage Door Opener
(see Homelink wireless control
system) ........................................74
Gas cap (see Fuel cap) ............259
Gas mileage
(see Fuel economy) .................262
Gauges .........................................14H
Hazard flashers .........................206
Head restraints .................105, 110
Headlamps ...................................52
aiming ........................................54
autolamp system .......................52
bulb specifications ....................57
daytime running lights .............53
flash to pass ..............................53
high beam .................................53
replacing bulbs .........................57
turning on and off ....................52
Heating
heating and air conditioning
system ...............40, 42, 44, 46, 49
Homelink wireless control
system ..........................................74
Hood ..........................................243
I
Ignition ...............................186, 274
Infant seats
(see Safety seats) .....................151
Inspection/maintenance (I/M)
testing ........................................267
Instrument panel ........................63
cleaning ...................................239
cluster ........................................10
lighting up panel and
interior .......................................54
J
Jack ............................................214
positioning ...............................214
storage .....................................214
Jump-starting your vehicle ......222
2006 Freestyle(219)
Owners Guide (post-2002-fmt)
USA(fus)
Index
283

K
Keyless entry system .................97
autolock .....................................99
Keys
positions of the ignition .........186
L
Lamps
autolamp system .......................52
bulb replacement
specifications chart ..................57
daytime running light ...............53
fog lamps ...................................54
headlamps ...........................52, 57
headlamps, flash to pass ..........53
instrument panel, dimming .....54
interior lamps ...........................56
replacing bulbs ...................56–60
Lane change indicator
(see Turn signal) ........................56
Liftgate ........................................88
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........190
Load limits .................................176
Locks
autolock .....................................99
childproof ..................................91
doors ..........................................90
Lubricant specifications ...272, 274
Lug nuts ....................................221
Luggage rack ...............................89
Lumbar support, seats .............107
M
Message center ...........................78
english/metric button ...............83system check button ................84
warning messages .....................84
Mirrors ...................................63, 68
automatic dimming rearview
mirror ........................................68
fold away ...................................68
heated ........................................69
side view mirrors (power) .......68
Moon roof ....................................74
Motorcraft parts ........240, 257, 269
N
Navigation system .......................24
O
Octane rating ............................261
Oil (see Engine oil) ..................246
P
Parking brake ............................191
Parts (see Motorcraft parts) ....269
Passenger Occupant
Classification Sensor .................120
Power adjustable foot pedals .....69
Power distribution box
(see Fuses) ...............................211
Power door locks ........................90
Power mirrors .............................68
Power point .................................65
Power steering ..........................193
fluid, checking and adding ....267
fluid, refill capacity ................270
fluid, specifications .........272, 274
Power Windows ...........................66
R
Radio ......................................17, 20
2006 Freestyle(219)
Owners Guide (post-2002-fmt)
USA(fus)
Index
284