octane FORD FUSION HYBRID 2012 Owners Manual

fill inlet lamp or CHECK FUEL FILL INLET message may not reset
immediately. It may take several driving cycles for the check fuel fill inlet
lamp or CHECK FUEL FILL INLET message to turn off. A driving cycle
consists of an engine start-up (after four or more hours with the engine
off) followed by city/highway driving. Continuing to drive with the check
fuel fill inlet lamp or CHECK FUEL FILL INLET message on may cause
the service engine soon lamp to turn on as well.
WARNING:The fuel system may be under pressure. If you hear
a hissing sound near the fuel filler door (Easy Fuel“no cap”
fuel system), do not refuel until the sound stops. Otherwise, fuel may
spray out, which could cause serious personal injury.
Choosing the right fuel
Use only UNLEADED fuel or UNLEADED fuel blended with a maximum
of 10% ethanol. Do not use fuel ethanol (E85), diesel, methanol, leaded
fuel or any other fuel. The use of leaded fuel is prohibited by law and
could damage your vehicle.
Your vehicle was not designed to use fuel or fuel additives with metallic
compounds, including manganese-based additives.
Note:Use of any fuel other than those recommended may cause
powertrain damage, a loss of vehicle performance, and repairs may not
be covered under warranty.
Octane recommendations
“Regular” unleaded gasoline with a
pump (R+M)/2 octane rating of 87 is
recommended. Some stations offer
fuels posted as “Regular” with an
octane rating below 87, particularly
in high altitude areas. Fuels with octane levels below 87 are not
recommended.
Do not be concerned if your engine sometimes knocks lightly. However, if
it knocks heavily under most driving conditions while you are using fuel
with the recommended octane rating, see your authorized dealer to
prevent any engine damage.
Fuel quality
If you are experiencing starting, rough idle or hesitation driveability
problems during a cold start, try a different brand of “Regular” unleaded
gasoline.
87(R+M)/2 METHOD
Maintenance and Specifications
302
2012 Fusion Hybrid(hfv)
Owners Guide, 1st Printing
USA(fus)

Do not add aftermarket fuel additive products to your fuel tank. It
should not be necessary to add any aftermarket products to your fuel
tank if you continue to use high quality fuel of the recommended octane
rating. These products have not been approved for your engine and
could cause damage to the fuel system. Repairs to correct the effects of
using an aftermarket product in your fuel may not be covered by your
warranty.
Many of the world’s automakers approved the World-Wide Fuel Charter
that recommends gasoline specifications to provide improved
performance and emission control system protection for your vehicle.
Gasolines that meet the World-Wide Fuel Charter should be used when
available. Ask your fuel supplier about gasolines that meet the
World-Wide Fuel Charter.
Cleaner air
Ford endorses the use of reformulated “cleaner-burning” gasolines to
improve air quality, per the recommendations in theChoosing the right
fuelsection.
Running out of fuel
Avoid running out of fuel because this situation may have an adverse
effect on powertrain components.
If you have run out of fuel:
•You may need to cycle the ignition from off to on several times after
refueling to allow the fuel system to pump the fuel from the tank to
the engine. On restarting, cranking time will take a few seconds longer
than normal.
•Normally, adding 1 gallon (3.8L) of fuel is enough to restart the
engine. If the vehicle is out of fuel and on a steep grade, more than
1 gallon (3.8L) may be required.
•The service engine soon
indicator may come on. For more
information on the service engine soon indicator, refer toWarning
lights and chimesin theInstrument Clusterchapter.
Maintenance and Specifications
303
2012 Fusion Hybrid(hfv)
Owners Guide, 1st Printing
USA(fus)

ESSENTIALS OF GOOD FUEL ECONOMY
Measuring techniques
Your best source of information about actual fuel economy is you, the
driver. You must gather information as accurately and consistently as
possible. Fuel expense, frequency of fill-ups or fuel gauge readings are
NOT accurate as a measure of fuel economy. We do not recommend taking
fuel economy measurements during the first 1,000 miles (1,600 km) of
driving (engine break-in period). You will get a more accurate
measurement after 2,000 miles–3,000 miles (3,000 km–5,000 km).
Filling the tank
When the fuel gauge indicates empty, there is still a small reserve of fuel
in the fuel system. When refueling your vehicle after the fuel gauge
indicates empty, you might not be able to refuel the full amount of the
advertised capacity of the fuel tank due to the empty reserve still
present in the tank. The amount of usable fuel in the empty reserve
varies and should not be relied upon to increase driving range.
For consistent results when filling the fuel tank:
•Turn the engine/ignition switch to the off position prior to refueling;
an error in the reading will result if the engine is left running.
•Allow no more than two automatic click-offs when filling.
•Always use fuel with the recommended octane rating.
•Use a known quality gasoline, preferably a national brand.
Your results will be most accurate if your filling method is consistent.
Calculating fuel economy
1. Fill the fuel tank completely and record the initial odometer reading
(in miles or kilometers).
2. Each time you fill the tank, record the amount of fuel added (in
gallons or liters).
3. After at least three to five tank fill-ups, fill the fuel tank and record
the current odometer reading.
4. Subtract your initial odometer reading from the current odometer reading.
5. Follow one of the simple calculations in order to determine fuel economy:
Calculation 1:Divide total miles traveled by total gallons used.
Calculation 2:Multiply liters used by 100, then divide by total
kilometers traveled.
Maintenance and Specifications
305
2012 Fusion Hybrid(hfv)
Owners Guide, 1st Printing
USA(fus)

ENGINE DATA
Engine 2.5L I4 engine
Cubic inches 152
Required fuel Minimum 87 octane
Firing order 1-3-4-2
Ignition system Coil on plug
Spark plug gap 0.049–0.053 inch (1.25–1.35mm)
Compression ratio 12.3:1
Engine drivebelt routing
High voltage battery data
High voltage battery
Battery chemistry Nickel metal hydride
Nominal voltage 275 volts
Battery system capacity 5.5 amp-hours
Maintenance and Specifications
316
2012 Fusion Hybrid(hfv)
Owners Guide, 1st Printing
USA(fus)

service points ..................287–288
Engine block heater .................223
Engine oil ..................................289
checking and adding ..............289
dipstick ....................................289
filter, specifications ........290, 313
recommendations ...................290
refill capacities ........................314
specifications ..........................314
Event data recording ..................13
Exhaust fumes ..........................223
F
Fleet MyKey programming ......113
Floor mats .........................110–111
Fluid capacities .........................314
Fog lamps ....................................78
Fuel ............................................299
calculating fuel
economy ............................38, 305
cap ...........................................301
capacity ...................................314
choosing the right fuel ...........302
detergent in fuel .....................303
filler funnel .............................303
filling your vehicle with
fuel ...........................299, 301, 305
filter, specifications ........298, 313
fuel pump shut-off ..................250
improving fuel economy ........305
octane rating ...................302, 316
quality ......................................302
running out of fuel .........264, 303
safety information relating to
automotive fuels .....................299
Fuses ..................................250–251
G
Garage door opener ..................103Gas cap (see Fuel cap) ............301
Gas mileage
(see Fuel economy) .................305
Gauges .........................................25
H
Hazard flashers .........................249
Headlamps ...................................77
aiming ........................................80
autolamp system .......................77
bulb specifications ....................83
daytime running lights .............79
flash to pass ..............................79
high beam .................................78
replacing bulbs .........................84
turning on and off ....................77
Heating
heating and air conditioning
system .................................68, 71
Hood ..........................................286
I
Ignition ...............................220, 316
Illuminated visor mirror .............89
Infant seats
(see Safety seats) .....................179
Inspection/maintenance (I/M)
testing ........................................309
Instrument panel ........................93
cleaning ...................................281
cluster ........................................18
lighting up panel and
interior .......................................79
J
Jack ............................................258
Index
344
2012 Fusion Hybrid(hfv)
Owners Guide, 1st Printing
USA(fus)

positioning ...............................258
storage .....................................258
Jump-starting your vehicle ......265
K
Keyless entry system
autolock ...................................118
keypad .....................................127
locking and unlocking doors ..128
programming entry code .......127
Keys ...................................112, 130
positions of the ignition .........220
L
Lamps
autolamp system .......................77
bulb replacement
specifications chart ..................83
daytime running light ...............79
fog lamps ...................................78
headlamps .................................77
headlamps, flash to pass ..........79
instrument panel, dimming .....79
interior lamps .....................81, 84
replacing bulbs .........................84
LATCH anchors .........................183
Lights, warning and indicator ....18
anti-lock brakes (ABS) ..........225
Load limits .................................212
Locks
autolock ...................................118
childproof ................................121
doors ........................................117
Lubricant specifications ...........314
Lug nuts ....................................264
Lumbar support, seats .............139
M
Message center ...........................36system check button ................45
warning messages .....................46
Mirrors ...................................97–98
automatic dimming rearview
mirror ........................................97
heated ........................................98
side view mirrors (power) .......98
Moon roof ..................................101
Motorcraftparts ..............284, 313
MyKey ........................................113
N
Navigation system .......................67
O
Octane rating ............................302
Oil (see Engine oil) ..................289
P
Parental MyKey
programming .............................113
Parking brake ............................227
Parts
(see Motorcraftparts) ...........313
Passenger Occupant
Classification Sensor .................145
Power distribution box
(see Fuses) ...............................254
Power door locks ......................117
Power mirrors .............................98
Power point .................................93
Power steering ..................231–232
Power Windows ...........................95
Index
345
2012 Fusion Hybrid(hfv)
Owners Guide, 1st Printing
USA(fus)