head FORD KUGA 2011 1.G Wiring Diagram Service Manual

R21
R22
R20
R15
(F111= 5A: FOR C394 DIESEL ENGINE)
PCB SHOULD BE ABLE TO ACCEPT THE LOAD IF F119 IS CHANGED FROM 25A TO 30A
(F111=15 A: FOR GAS ENGINE)
KEYLESS GO/KEYLESS VEHICLETO PASSENGER DOOR MODULE
TO DRIVER DOOR MODULETO BACKLITE SW STATUS
NOTE2
NOTE4
NOTE2
NOTE1 1/2(R26/R27)
1/2 (R
2
1/2 (R29/R30)
PCB
1/2 (R26/R27) 1/2 R25
15
TO AC SW, EATC, SSCD
FROM LIGHT SW / AUTO LIGHT
FROM LIGHT SWITCH
LUGGAGE COMPARTMENT LIGHTING TO WIPER MOTOR HIGH
TO IGNITION FOR EJB FROM IGNITION SWITCH POS 15 DTRL RESISTOR WIREFROM FRONT JUNCTION BOX
TO LIGHT SWITCH VBAT DTRL / PARK LT CLUSTER
DATA LINK CONN.
TO RIGHT LOW BEAM LAMP
TO LEFT LOW BEAM LAMP
TO RIGHT HIGH BEAM LAMP
TO LEFT HIGH BEAM LAMP KEYLESS VEHICLE
LH RH RL RR DOOR LATCH
DD LATCH / F FLAP
POWER GND
TO DOOR LATCH LOCK
TO DOOR LATCH UNLOCK
30 (1)
*
FROM BUSBAR 1(F3 60A)
FROMBUSBAR1(F360A)
TO WIPER GROUND
1/2 (R23/R24)
FRONT FOOTWELL LAMPS RKE / DVD PLAYER
TRAILER TOW MODULE/LUGGAGE COMP PWR PNTELECTRONIC MODULE(DPF,PAM(FAP))
DTRL RESISTOR WIRE
TO FUEL PUMP MOTOR FUEL CUT OFF SWITCH
POSITION LIGHT SWBACKUP LAMP SWITCH
AUTOLAMP OR DTRL INDICATOR
AUTOLAMP
HEATED BACKLITE RELAY
REAR WIPERBATTERY SAVER
FUEL PUMP STATUS
FRONT WIPER HIGH SPEED
FRONT WIPER LOW SPEEDHEADLIGHT LOW BEAMHEADLIGHT HIGH BEAMDOOR UNLOCK RELAYDOOR LOCK RELAYDEADLOCK RELAYDD & FF UNLOCK RELAY
ELECTRONIC SIGNALELECTRONIC POWERELECTRONIC POWER.
IGNITION
FRONT WIPER FAST SW
HEATED BACKLITE SWITCH
ELECTRO. PART
HW SPEC FOR FUNC.OF THE BOX SEE
CCM ONLY
BP02
+10A
F103+15A
F111
C102C96
+20A
F129
C96
+10A
F113+
F102 10A
+20A
F126
C103
+20A
F135
C1-5
C1-1C1-3
C1-2.LF10
R15
C96
+20A
F134+25A
F133
C100
LF36
.RW03
.RW03
.
C102C96C96C96C96C100C100C100C102C102C102
+
F139 10A
+
F140 10A
. LF38
C100C100C102C102C100C98C100C100C100C100C100
+15A
F142
C102C96C96
. E608 R19
C103C102
+25A
F119
C96
LF37
.
+15A
F143
+
F106 20A
C102
+
F107 10A
Central Junction Box (CJB)
)
.
)))
Daytime Running Lamps (DRL) Relay
Headlamp High Beam RelayRW03Windshield Wiper Intermittent Wipe RelayeeRlRelayaaeRelayaeRelayaRelayyaWindsh
..AutolampR
Fuel Pump Relay
Headlamp Low Beam Relay
700-01-4 Power Distribution - Central Junction Box (CJB)
2011.0 Kuga (G1226099)
BACK TO CHAPTER INDEX
TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

TO AWD MODULESPARE LSRD COIL 1SPAREPP
LSRDCOIL1
TO MINI LIFTGATE RELEASE MOTORTOMINILIFTGA
TEAA
RELEA
SEMOTOR
SPARE LSRD COIL 1POWER MIRROR
TO LEFT SIDE TURN LAMP
TO RIGHT SIDE TURN LAMP
TO RIGHT REAR TURN LAMP TO LEFT REAR TURN LAMP STOP LT SW
TO INTERIOR LIGHTS
= FET HALF BRIDGE= FET
TO RIGHT FRONT TURN LAMP
TO RESTRAINTS MODULE IGN SUPPLY
TO ACCELERATION PEDAL SENSOR TO HEATER CONTROL HEAD CLUSTER & PATS
PARK AID / DPF MODULE
WIPER WASH SW IGN SUPPLY TO FOG LIGHTS
BACKUP LTS
POWER WINDOWS
TO HEATED SEATS FRONT COOLING UNIT
HEATED WASHER JETS
TO ALARM HORN
TO LEFT FRONT TURN LAMP
TO DOME LAMPS GND
IGNITION OVERLOAD RELAY 15I(COIL) BLOWER MOTOR RELAY
HEADLAMP WASHER RELAY
TO HEATED WINDSCREEN RELAYS
TO HEATED WINDSCREEN SW STATUS
TO SUNROOFPTC HEATER
ADJUSTABLE PEDALS
SUNROOF / RAIN SENSOR /DVD PLAYER
= RELAY DRIVER or SMALL CURR
VEHICLE HORN (USA PROTECT)VEHICLEHORN(USAPROTECT)
TO INTRUSION SENSOR
TO TAILGATE / TRUNKLID RELEASE MOTOR
C394
SPARE
SPARE SPARE
FROM BACKLITE SW
FROM AC REQUEST SW
15I
FROM DOOR LATCH FROM DOOR LATCH
FROM DOOR LATCH
15
FROM WIPER / WASHER SWITCH
FROM WIPER / WASHER SWITCH
FROM WIPER / WASHER SWITCH FROM WIPER / WASHER SWITCH FROM WIPER / WASHER SWITCH FROM WIPER FROM WIPER / WASHER SWITCH FROM WIPER / WASHER SWITCH FROM HAZARD SW FROM STALK SWITCH
FROM STALK SWITCH FROM DOOR LATCHS
FROM DOOR LATCHS
FROM DOOR LATCH FROM HOOD AJAR SW
FROM DOOR LATCHS FROM DOOR LATCHS
FROM TAILGATE LATCHSPARE LSI2SPARE
DTRL
TO PCM
LIGHT SW FROM IGNITION OVERLOAD RELAY 15ITO IGNITION FOR EJB FROM IGNITION SWITCH POS 15
FROM HEATED WINDSHILD SWSPAREPPSPAREPP
LSI2
SPAREPPSPAREPPFROM TAILGATE REL. SWITCH EXTERNAL FROM TAILGATE AJAR SW
+10A
F122+10A
F141+
F127 25A
+10A
F100+
F116 20A
+15A
F132+
F115 7.5A
+10A
F114
C102C96C99C99C99C99C103C103C99C99C103C103C99C103C99C103C96C103C103C103C103C103
C102C102C102C102C96C100C102C102
C96
C96C100
+
F121 20A
C100
+10A
F110
C102C98C100
+10A
F130
C100
+10A
F138
C96
C103C103C95C99C99C99
C100C100C100
C103C95
VEHICLE HORNPTC HEATERGLOBAL CLOSING
HEATED WINDSCREEN RELAYHEADLAMP WASHER RELAYBLOWER MOTOR RELAYIGNITION OL RELAYSPAREADJ PEDALSINTERIOR LIGHTSSPARE HS RELAY DRIVER
TAILGATE RELEASE
TURN SIGNAL LAMPS RIGHTTURN SIGNAL LAMPS LEFTALARM ACTIVATION HORNIS POWERSPAREHCSV RELAY
FRONT WIPER INTERMITANT DATA3FRONT WIPER INTERMITANT DATA2FRONT WIPER INTERMITANT DATA1
FRONT WIPER FAST SWFRONT WIPER SLOW SW
FRONT WIPER PARK POSITIONREAR WIPER INTERVAL SWFRONT WIPER INTERVAL SW
AC REQUEST SWDOOR AJAR SW RRDOOR AJAR SW RLDOOR AJAR SW PASSDOOR AJAR SW DRIVERHAZARD WARNING SWTURN LAMP SW RHTURN LAMP SW LHHEATED BACKLITE SW
SPARE
HEATED WINDSHIELD SWANTITHEFT INHIBIT SWTAILGATESW EXTERNALTAILGATE AJAR SWUNLOCK SW FL FRLOCK SW FL FRRESET SW FL FRSET SW FL FRHOOD AJAR SWSPARE LSI2SPARE
HSI SPARE SW
IGNITION
TAILGATE IN TAILGATE RELEASE
ELECTRONIC PART OF THE BOX
SEE HARDWARE SPEC FOR FUNCTIONALITYBP0
+
F136 15A
C99C99
C100C103C95C102C100C98C103C95C103C95C95C95C98C103C98C100C96C96C100C100C96C96
+20A
F128
C100C100
Cen
700-01-6 Power Distribution - Central Junction Box (CJB)
2011.0 Kuga (G1226099)
BACK TO CHAPTER INDEX
TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

C394
TO ELECTRONIC GROUND (no longer used)BATTERY BACKED SOUNDER: STATUS
RAIN SENSORTO SUNROOF
AMBIENT TEMP SENSOR INTRUSION SENSOR
CRUISE CONTROL SW
ELECTRONIC GROUND SUPPLY ROOF
TO ELECTRONIC GROUND
RENT DEVICE
MINI LIFTGATE FEATURE WILL BE ADDED FOR C394 BOXES ONLY
FROM MINI LIFTGATE REL. SW. EXT. FROM MINI LIFTGATE AJAR SW
NOTES
1 WHERE PINS, FUSES AND RELAYS ARE SHOWN AS SPARE OR PROTECTED THESE NEED
2 SPARE CAPACITY SHOULD NOT BE TAKEN INTO ACCOUNT FOR COSTING
3 THE PJB NEEDS TO BE TESTED WITH MAXIMUM FUNCTIONALITYTO BE POPULATED DURING PROTOTYPE PHASE AND REMOVED FOR PRODUCTION -
THE TRACKS IN THE PCB WILL REMAIN FOR FUTURE USE
3M5T-14489-AR*
3M5T-14A073-B*
32 WAY
C95 GREEN
WHITE
LOW BLUE BROWN BROWN BLACK GREEN
FLOOR - 1 ROOF - 1 32 WAY
C96
46 WAY
C100
C102 C99 41 WAY
46 WAY
FLOOR - 2
COCKPIT - 1 C98 14 WAY
C103
CONNECTOR DETAILS
COCKPIT - 2
BOX NUMBER32 WAY
BLUE
3M5T-14489-AP* 3M5T-14489-ZX* 3M5T-14489-ZV* 3M5T-14489-BP* 98AG-14489-TM* 3M5T-14489-ZR*
FRONT - 2
FRONT - 1
3M5T-14489-AR*TT
3M5T-14A073-B*TT
32WAWWYAAC95GREEN
WHITELOW
BLUE
BROWNBROWN
BLACK
GREEN
FLOOR-1
ROOF-1
32WAWWYAA
C96
46WAWWYAA
C100
C102
C99
41WAWWYAA
46WAWWYAAFLOOR-2
COCKPIT-1
C9814WAWWYAA
C103COCKPIT-2
BOXOONUMBER
32WAWWYAABLUE3M5T-14489-AP*TT3M5T-14489-ZX*TT
3M5T-14489-ZV*TT3M5T-14489-BP*TT
98AG-14489-TM*
3M5T-14489-ZR*TTFRONT-2FRONT-1
THE DOTTED INPUTS / OUTPUTS ARE POPULATED DURING DEVOLOPMENT PHASE
AND MUST BE DEPOPULATED FOR J#1
TO WASHER PUMP FRONT
TO WASHER PUMP REAR
FROM STALK SWITCH FROM WIPER / WASHER SWITCH FROM WIPER / WASHER SWITCH
FROM STALK SWITCH
FROM HANDBRAKE SW
FROM BRAKE FLUID LEVEL SWITCH
RADIO FROM INTRUSION SENSOR
TO IP
TO IP
TO CABIN
TO CABIN
FROM LIGHT SWITCH
FROM AMBIENT TEMP SENSOR
FROM CRUISE SW
TO RKE MODULE FROM AC SWITCH
TO KVM MODULE
NOTE:
C102C102C96C103C103C103C96C96C103C98
GND MICROC CONTROL RTNIS GNDAMB TEMP SENS GNDMS CAN -MS CAN +VEHICLE SPEEDRAIN SENSORBATTERY BACKUP SOUNDER
RADIO ANTITHEFT
BRAKE FLUID LEVEL SW
PARK BRAKEHIGH BEAM SWFLASH SW
FRONT WASHER SWITCH
REAR WASHER SW
IS SENSE
AMBIENT TEMP SENSORC CONTROL+-RESRKE SERIAL DATA
HEADLAMP LOW BEAM SW
AUX HEATER REQUEST/HSCOV_FAP
TAILGATE IN TAILGATE AJAR SWTAILGATE INTAILGATE SW EXTERNAL
02
C98C95C98C99C99C98C95C103C98C102C103C103
C102C103C98C95C103C99
C96
C99C99
ntral Junction Box (CJB)
700-01-7 Power Distribution - Central Junction Box (CJB)
2011.0 Kuga (G1226099)
BACK TO CHAPTER INDEXTO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

.C459 TO MULFIFUNCTION SW.
.C838 TO HID CTRL MODULE
.C896 TO COLUMN STEERING CLOCKSPRING
.TO FRONT AND REAR WIPER SW.
C441
.C200 TO DIAGNOSTIC CONNECTOR.
.C809 TO INSTRUMENT CLUSTER.C391 TO PATS RF MODULE
.TO HEATED BACKLITE SW.
C381
.C382 TO HEATED WINDSHIELD SW..
.TO DATC CTRL HEAD
C539.TO HEATING CTRL HEAD
C378
.C457 TO START/STOP & HAZARD WARN. SW..TO ESCL
C231
1024WA 0.50WA 0.35
7
WA 0.353
0.50
WA5
62WA 0.350.50
WA
220.35
WAWA 0.35
0.50
WA24
0.35
WA
40.35
WA
0.75
WA4
C231 4
0.50
WA
700-03-3 A-Pillar LH Ground Point
2011.0 Kuga (G1246658)
BACK TO CHAPTER INDEX
TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

TO
TO RIGHT HEADLAMP(LEV. MOTOR) C837
TO LEFT HEADLAMP(LEV. MOTOR) C836
.0.0
TO CIGAR LIGHTER.TO REAR CONSOLE POWER POINT 0.0
GROAIR G39
C155
52.5
WA
BK
31-HA231-HA6 BK WA 2.5
C158 12.5
WA
BK
31-HA30S16WA
BK
31-HA21C9122.5
WA
BK
31-HA61
C609
GROGGROGGGROBAG
700-03-4 A-Pillar RH Ground Point
2011.0 Kuga (G1246659)
BACK TO CHAPTER INDEX
TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

.TO BRUSHLESS MOTOR.C912
TO CIGAR LIGHTER
.C102
TO PJB(GROUND)
.C379
TO HEATING CTRL HEAD
.C441OFRONT AND REAR WIPER SWITCH.
.C846
TO GLOVE BOX ASSY.C383
TO GEAR SHIFT MODULE.C200
TO FDS DIAGNOSTIC CONNECTOR.C320
TO LIGHT SWITCH
.7.6
.PASS. HEATED SEATS SW. C695
.DRIVER HEATED SEATS SW. C694
.C102
TO PJB (GND).
.C102
TO PJB (GND).
1
5
31-HA6 BK WA 2.531-DA1 1.5
BK WA19
4.0
WA
BK
31-FA4531-FA25 BK WA 4.0
831-KA36 BK WA 0.75
31-DA2 BK WA 4.0S6
0.35
WA
BK
31-LB82431-PF35 BK WA 0.50
431-LE29 BK WA 0.5010
S70.75
WA
BK
31-DA240.35
WA
BK
31-RA1
GROUND PASSENGER SIDE G20
31-LH43 BK WA 0.35
0.35
WA
BK
31-LH29
31-JA4 BK WA 0.75
0.35
WA
BK
31-LE460.50
WA
BN-RD
9-LE46
0.50
WA
BN
9-LE457
7
2
2
0.35
WA
BK
31-LE45
FEAAE:JBTAA
1.5
WA
BK-RD
91-DK2039
OUNDELECTRONIC GROUND
PASSENGER SIDE G19
6
C834
91-DK20A BK-RD WA 1.039
2.5
30
C111
C111
33
GROUNDGGROUNDGGGROUNDA-PILLAR
OUNDOUNDOUNDELECTRONICGEELECTRONICGEEELECTRONICGA-PILLAR
700-03-5 A-Pillar RH Ground Point
2011.0 Kuga (G1246659)
BACK TO CHAPTER INDEX
TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

TO COOLING FAN MODULE
.TO HOOD SWITCH
C897
TO LEFT HEADLAMP
TO LEFT FRONT FOG LAMP
TO LEFT SIDE TURN SIGNAL LAMP (C214 ONLY)
.BRAKE FLUID LEVEL SW.
C810.TO DUAL PRESSURE SW.
C882.TO DUAL PRESSURE SW.
C882
.TO BRAKE PRESSURE SWITCH
C446
TO RIGHT FRONT FOG LAMP
TO HORN
TO DIESEL FUEL HEATER RELAY
.R9 TO HEADLAMP CLEANING REL.
.WATER IN FUEL
C778
.C945 TO FUEL FILTER HEATER
.TO AC CLUTCH
C957
.TO PCM
C419
.TO PCM
C419
.TO PCM
C419
.TO PCM
C417
.TO PCM
C418
.TO PCM
C418
TO LEFT HID LAMP
.TO IGNITION 2 & PARK LIGHT RELAY
EJB.TO A/C COMPRESSOR CYCLING SWITCH
C692
.C79 TO LOW WASHER WATER LEVEL SWITCH.BRAKE FLUID LEVEL SW.
C810
91-GL7 BK WA 0.501
131
0.50
WA
BK-BU
91-GC70.50
WA
BK-BU
91-PA1391-FA38 BK-OG WA 0.50
S1180.50
WA
BK-OG
91-GC891-DA3 BK-OG WA 1.0
10.50
WA
BK-GN
91-TA36
31-KA21B BK WA 4.0R9_4
91-RE8K BK-YE WK 0.7591-RE8L BK-YE WK 1.01.0WK
BK-YE
91-RE8MG4H4K2H4J4K4
0.75WK
BK-YE
91-RE8H0.75WK
BK-YE
91-RE8G
91-RE8J BK-YE WK 0.75
0.50WK
BK-OG
91-RJ322
2.5WK
BK-BU
91-RN2G57B
LEFT FRONT
GROUNDS53
31-FA6 BK WK 1.0
31-PE8B BK WK 0.75
GROUND LEFT FRONT
G57A
2C945
1
3
GROUND ELECTRONIC LEFT FRONT
G31A
91-DA3A BK-OG WA 1.5
91-FA17A BK-RD WA 0.501
R4_20.50
WA
BK-GN
91-BB18
1.0
WA
BK-BU
91-GC7B1
GROUNDGGROUNDGGGROUNDFENDER 2
GROUNDGGROUNDGGGROUNDFENDER 2
ELECTRONICEELECTRONICEEELECTRONICFENDER
700-03-17 Engine Compartment Ground Point LH
2011.0 Kuga (G1246665)
BACK TO CHAPTER INDEX
TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

.TO RIGHT HEADLAMP C837
.
00.0TO EHPAS MODULE
.
TO RIGHT FRONT WINDOW WASHER JET C720
.
TO LEFT FRONT WINDOW WASHER JET C721
.C791
TO BAT. BACKUP SOUNDER.TO HEDLAMP WASHER PUMP C745.C307
TO FUEL FIRED HEATER MODULE
.TO FRONT WIPER MOTOR C848
.C837
TO RIGHT HID LAMP
suffix B* suffix A* EMC GROUN
LHD
EMC GROUN 18C942
EMC GROUN18C942
RHD
suffix F*18C942
1
C340.75
WA
BK
31-HB1S1220.75
WA
BK
31-HB13
0.75
WA
BK
31-HB26
2
2
C79
91-DA7 BK
G74
BODY
GROUND
C79
31-FC9 BK WA
G
R
BRG5C8781
31-KA9A
31-KA9S111
4
91-DA7A BK
G74
BODY
GROUND
31-KA9B BK WA 2.5
GROUND BODY G74
BK
91-DA7B
1
C878
GR
BRG58
WABK
31-FC9A
31-KA9C
GROUNDGGROUNDGGGROUNDEMC
GRGGRGGGRSU
GROUNDGGROUNDGGGROUNDEMC
GROUNDGGROUNDGGGROUNDEMC
GRGGRGGGRSU
700-03-18 Engine Compartment Ground Point RH
2011.0 Kuga (G1246666)
BACK TO CHAPTER INDEX
TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

- DW, Vehicles With: 6-Speed
Manual Transaxle - MMT6,
Emission Requirements: Stage
V...................................................700-00
Engine Upper View—2.0L Duratorq-TDCi (100kW/136PS)
- DW/2.0L Duratorq-TDCi
(103kW/140PS) - DW/2.0L
Duratorq-TDCi (120kW/163PS)
- DW, Vehicles With: 6-Speed
Automatic Transaxle -
6DCT450, Emission
Requirements: Stage V
AWD............................................. 700-00
Evaporative Emission Canister Purge Valve..................................303-13
Exhaust Camshaft Position (CMP) Sensor............................303-14A
Exhaust Gas Recirculation (EGR) Cooler Bypass
Valve—A.................................... 303-08B
Exhaust Gas Recirculation (EGR) Cooler Bypass Valve Position
Sensor—C................................. 303-08B
Exhaust Gas Recirculation (EGR) Vacuum Regulator
Valve.......................................... 303-08B
Exhaust Gas Recirculation (EGR) Valve—B.................................... 303-08B
Exhaust Gas Recirculation (EGR) Valve Position
Sensor....................................... 303-08B
Exhaust Gas Temperature Sensor....................................... 303-14B
Exhaust Gas Temperature Sensor....................................... 303-14B
Exhaust Variable Valve Timing (VVT) Oil Control
Solenoid ..................................... 303-14A
Exterior Lighting—Vehicles Without: Adaptive Front
Lighting/High Intensity
Discharge
Headlamps ................................... 417-01
Exterior Lighting—Vehicles With: Adaptive Front Lighting,
Vehicles Without: High
Intensity Discharge
Headlamps ................................... 417-01Exterior Lighting—Vehicles With:
Adaptive Front Lighting/High
Intensity Discharge
Headlamps ................................... 417-01
Exterior Mirror Control Switch ...........................................501-09
Exterior Mirror Control Switch ...........................................501-09
Exterior Mirror LH............................501-09
Exterior Mirror RH............................501-09
Fog Lamps.......................................417-01
Footwell Air Discharge Temperature Sensor.....................412-01
Footwell Air Discharge Temperature Sensor.....................412-01
Footwell Lamp LH............................417-02
Footwell Lamp RH...........................417-02
Footwell Vent/Duct Blend Door Actuator ........................................ 412-01
Four-Wheel Drive (4WD) Control Module ......................................... 308-07
Front Bumper—2.5L Duratec (147kW/200PS) - VI5, LHD
4WD............................................. 700-00
Front Bumper—2.5L Duratec (147kW/200PS) - VI5, RHD
4WD............................................. 700-00
Front Bumper—2.0L Duratorq-TDCi (100kW/136PS)
- DW, LHD 4WD/LHD
FWD............................................. 700-00
Front Bumper—2.0L Duratorq-TDCi (100kW/136PS)
- DW/2.0L Duratorq-TDCi
(103kW/140PS) - DW/2.0L
Duratorq-TDCi (120kW/163PS)
- DW, LHD 4WD/LHD FWD,
Emission Requirements: Stage
V................................................... 700-00
Front Bumper—2.0L Duratorq-TDCi (100kW/136PS)
- DW, RHD 4WD/RHD
FWD............................................. 700-00
Front Bumper—2.0L Duratorq-TDCi (100kW/136PS)
- DW/2.0L Duratorq-TDCi
(103kW/140PS) - DW/2.0L
Duratorq-TDCi (120kW/163PS)
- DW, RHD 4WD/RHD FWD,
Emission Requirements: Stage
V................................................... 700-00
2011.0 Kuga
Index
BACK TO CHAPTER INDEX TO MODEL INDEX
PAGE 8 OF 16
FORD KUGA 2011.0MY WIRING DIAGRAMS

Fuel Rail TemperatureSensor....................................... 303-14B
Fuel Rail Temperature Sensor—A................................. 303-14C
Fuel Vaporizer System Fuel Pump—A ...................................... 309-00
Fuel Vaporizer System Glow Plug—A........................................ 309-00
Generator .........................................414-02
Generator .........................................414-02
Generator .........................................414-02
Glove Compartment Lamp............................................ 417-02
Glow Plug 1...................................303-07B
Glow Plug 2...................................303-07B
Glow Plug 3...................................303-07B
Glow Plug 4...................................303-07B
Glow Plug Module.........................303-07B
Glow Plug Relay............................303-07B
Headlamp Assembly LH..................417-01
Headlamp Assembly RH................................................ 417-01
Headlamp Control Module ......................................... 417-01
Headlamp High Beam Relay ............................................ 417-01
Headlamp Leveling Front Sensor .......................................... 417-01
Headlamp Leveling Rear Sensor .......................................... 417-01
Headlamp Low Beam Relay ............................................ 417-01
Headlamp Switch.............................417-01
Headlamp Washer...........................501-16
Headlamp Washer...........................501-16
Headlamp Washer Pump ............................................ 501-16
Headlamp Washer Pump Relay ............................................ 501-16
Headliner—LHD 4WD/LHD FWD............................................. 700-00
Headliner—RHD 4WD/RHD FWD............................................. 700-00
Heated Oxygen Sensor (HO2S) .......................................303-14A
Heated Oxygen Sensor (HO2S)...................................... 303-14C
Heated Rear Window Element........................................ 501-11
Heated Rear Window Element........................................ 501-11Heated Rear Window
Switch ........................................... 501-11
Heated Seats—LHD 4WD/LHD FWD............................................. 501-10
Heated Seats—RHD 4WD/RHD FWD............................................. 501-10
Heated Windshield Element........................................ 501-11
Heated Windshield Relay ............................................ 501-11
Heated Windshield Switch and Heated Rear Window Switch
Assembly ...................................... 501-11
Heated Windshield, Rear Window, Exterior Mirrors and
Washer Jets—Vehicles
Without: Door Module...................501-11
Heated Windshield, Rear Window, Exterior Mirrors and
Washer Jets—Vehicles
Without: Door Module...................501-11
Heated Windshield, Rear Window, Exterior Mirrors and
Washer Jets—Vehicles With:
Door Module.................................501-11
Heated Windshield, Rear Window, Exterior Mirrors and
Washer Jets—Vehicles With:
Door Module.................................501-11
Heater Core Housing Left-Hand View—LHD 4WD/LHD FWD,
V

ehicles With: Air
Conditioning/Automatic
Temperature Control....................700-00
Heater Core Housing Left-Hand View—LHD 4WD/LHD FWD,
Vehicles With: Air
Conditioning/Manual
Temperature Control....................700-00
Heater Core Housing Left-Hand View—RHD 4WD/RHD FWD,
Vehicles With: Air
Conditioning/Automatic
Temperature Control....................700-00
Heater Core Housing Left-Hand View—RHD 4WD/RHD FWD,
Vehicles With: Air
Conditioning/Manual
Temperature Control....................700-00
2011.0 Kuga
Index
BACK TO CHAPTER INDEX TO MODEL INDEX
PAGE 10 OF 16
FORD KUGA 2011.0MY WIRING DIAGRAMS