drl FORD KUGA 2011 1.G Wiring Diagram Workshop Manual

Electronic Engine Controls - 2.0LDuratorq-TDCi (100kW/136PS) - DW,
Emission Requirements: Stage
IV 303-14B
Electronic Engine Controls - 2.0L Duratorq-TDCi (100kW/136PS) -
DW/2.0L Duratorq-TDCi
(103kW/140PS) - DW/2.0L
Duratorq-TDCi (120kW/163PS) - DW,
Emission Requirements: Stage
V 303-14C
Automatic Transmission/Transaxle Automatic Transmission/Transaxle - Vehicles With: 5-Speed Automatic
Transaxle - AW55 AWD 307-01A
Automatic Transmission/Transaxle - Vehicles With: 6-Speed Automatic
Transaxle - 6DCT450, LHD
4WD/RHD 4WD 307-01B
Automatic Transmission/Transaxle External Controls 307-05
Manual Transmission/Transaxle, Clutch and
Transfer Case Four-Wheel Drive Systems 308-07
Exhaust System Exhaust System - 2.0L Duratorq-TDCi (DW) Diesel 309-00
Fuel System - General Information Fuel Tank and Lines 310-01
Speed Control 310-03
GROUP 4 Electrical
Climate Control System
Climate Control 412-01
Auxiliary Climate Control 412-02
Instrumentation and Warning Systems Instrument Cluster 413-01
Horn 413-06
Warning Devices 413-09
Parking Aid 413-13
Battery and Charging System Battery, Mounting and Cables 414-01 Generator and Regulator
414-02
Information and Entertainment Systems Information and Entertainment System 415-01
Lighting Exterior Lighting 417-01
Interior Lighting 417-02
Daytime Running Lamps (DRL) 417-04
Electrical Distribution Module Communications Network 418-00
Electronic Feature Group Anti-Theft - Active 419-01
Multifunction Electronic Modules 419-10
GROUP 5 Body and Paint
Body and Paint
Rear View Mirrors 501-09
Seating 501-10
Glass, Frames and Mechanisms 501-11
Instrument Panel and Console 501-12
Handles, Locks, Latches and Entry Systems 501-14
Wipers and Washers 501-16
Safety Belt System 501-20A
Supplemental Restraint System 501-20B
GROUP 7 General Wiring
Information
Wiring Information
General Information 700-00
Fuse and Relay Information 700-01
Power Distribution 700-02
Grounding Strategy 700-03
Electrical Connectors 700-04
Index
2011.0 Kuga
BACK TO CHAPTER INDEX
TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS
PAGE 2 OF 2

GROUP
Electrical
4
SECTION TITLEPAGE
Climate Control System Climate Control.................................................................\
.............................................412 -01
Auxiliary Climate Control.................................................................\
...............................412-02
Instrumentation and Warning Systems Instrument Cluster.................................................................\
.........................................413- 01
Horn........................................................................\
....................................................... 413-06
Warning Devices.................................................................\
...........................................413-0 9
Parking Aid.....................................................................\
................................................ 413-13
Battery and Charging System Battery, Mounting and Cables..................................................................\
......................414-01
Generator and Regulator...............................................................\
................................414-02
Information and Entertainment Systems Information and Entertainment System..................................................................\
........415-01
Lighting Exterior Lighting................................................................\
.............................................41 7-01
Interior Lighting................................................................\
..............................................4 17-02
Daytime Running Lamps (DRL).................................................................\
....................417-04
Electrical Distribution Module Communications Network.................................................................\
................418-00
Electronic Feature Group Anti-Theft - Active..................................................................\
........................................419- 01
Multifunction Electronic Modules.................................................................\
..................419-10
2011.0 Kuga
BACK TO MAIN INDEX
TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

SECTION 417-04 Daytime Running Lamps (DRL)
VEHICLE APPLICATION:2011.0 Kuga
PA G E
CONTENTS
ELECTRICAL SCHEMATICS
417-04-2
Daytime Running Lamps (DRL) ........................................................................\
..................
ELECTRICAL CONNECTORS 417-04-4
Daytime Running Lamps (DRL) Relay ........................................................................\
.......
417-04-1
Daytime Running Lamps (DRL)
417-04- 1
.
BACK TO CHAPTER INDEX TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

DTRL ONLYPART OF CLUSTERCAN
CANLIGHT ON WARNING
DTRL RESISTOR WIRE
FJB PARTIAL
30-DA1 RD WA 6.0
13
11
C320101631-LE29 BK WA 0.50
0.50
WA
OG-BK
29-LE29
C102
33
30-DA25 RD FWK 25.0
15-LE29 GN-BK WA 0.35
1.0
WA
RD
30-LE6
8C32012C320
13 C102
+
F115 7.5A
+
F113 10A
C102
8
415
15-LE6 GN-YE WA 0.50
+10A
F110
C102
15
S731-DA24 BK WA 0.756
+
F11 20A
+15A
F103
0.75
WA
GN-RD
15S-LE8
+20A
F135
4.0
WA
BK
31-DA2
1.5
WA
BK
31-DA1
19
C102
S6
C102
C96
22
C96
261
C96
1
B+PM
(+)
(-)
BATTERY
+
F3 60A
B-1
25.0
FLR9
BK
31-BA11A25.0
FLR9
BK
31-BA11
G8
ENGINE
GROUNDGROUND BATTERY
G1
G20
PASSENGER SIDE
GROUND
GROUND PASSENGER SIDE G20
BP02
C1-12 P
C1-16 58
C1-1130C1-815C1-7XR
C1-13
58L/RC1-15
DC1-4
5256
C1-6C1-10 3183B
C1-3C1-2 83A
58D
C1-9
G
C1-1
4
3
FOGLAMP SWITCH ONLY
1 2
4) 2 3) 1
2) O
SEARCH
ILLUM
FF RF
0
FOG ELECTR
DIMMER
RF
0
1) P
FOGLAMP SWITCH: COMBINED LIGHT AND
CAN BE ACTIVATED IN
FF
REAR FRONT
FOG
HEADLAMP
LEVELING POSITION 3 & 4
LF23.
BATTERAYRBBATTERAYRBBATTERAAYRRBattery
GROUNDGGROUNDGGGROUNDSUPPORT
GROUNDGGROUNDGGGROUNDSUPPORT
GROUNDGGROUNDGGGROUNDA-PILLAR
GROUNDGGROUNDGGGROUNDA-PILLAR
Central Junction Box (CJB)
.Headlamp Switch
417-04-2 Daytime Running Lamps (DRL)
2011.0 Kuga (G1223815)
BACK TO CHAPTER INDEX TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

S109
GROUND LEFT FRONTG37
6C836
C8364C8374
6C837
S121
2.5
WA
BK
31-DA3
0.75
WA
BK
31-LE310.75
WA
BK
31-LE30
29S-LF1 OG-YE WA 1.029S-LF5 OG-BU WA 0.50
4.0
WA
BK
31-DA4
OG-BU WA 0.50
29S-LF7
29S-LF16 OG-GN WA 0.50
15S-LE23 GN-WH WA 0.7515S-LE16 GN-OG WA 0.75
22
0.35
WA
GN-RD
15S-LE42
44
C102
0.35
WA
GN-BK
15S-LE21
3412
67
9
LOW HIGH PARK TURNLeveling M
LF08
.3412
67
9
LOW HIGH PARK TURNLevelingM
LF09
+15A F143+15A F142
34
C102C102
1
+7.5A
F124+F125 7.5A
+7.5A
F117
35
C96
28
C96
8
C96
7
C1035
3934
C100
10
C100
HEADLAMP LOW BEAM SW
HEADLIGHT LOW BEAM
ELECTRONIC POWERIGNITIONPOSITION LIGHT SW
AUTOLAMP OR DTRL INDICATOR
CAN
(LIGHT ON WARNING)
G56B
RIGHT FRONT
SIDE MEMBER GND
GROUND LEFT
G77B
C4754
C4752
29S-LF11A OG-WH WA 0.50
S216
31-DA16 BK WA 1.5
1.0
WA
BK
31-LF23A
TAIL
STOP.
LS18
S199C4742
C4744
1.0
WA
BK
31-LF24B
2.5
WA
BK
31-DA15
GROUND RIGHT
G70A
TAIL
STOP.
4LS19
29S-LF20A OG WA 0.50
1C492C4922C4912
S202
6C59
1
C491
29S-LF22 OG-BK WA 0.50
0.50
WA
BK
31-LF220.50
WA
OG-BK
29S-LF210.50
WA
BK
31-LF21
0.50
WA
OG-BK
29S-LF21B
C58
5
31-DA13B BK WA 1.0
1C59
31-DA13B BK WA 1.0
2.5
WA
BK
31-DA13AS196
GROUND LEFT
G77A
S240
29S-LF12 OG-BK WA 0.50
.
LS04LS05
.
0.50
WA
OG-BK
29S-LF21
GROUNDGGROUNDGGGROUNDFENDER
Headlamp Assembly RH
SIDEMEMBSSIDEMEMBSSSIDEMEMBFRAME
GROUNDGGROUNDGGGROUNDWHEELARCH
.Rear Lamp Assembly LH
GROUNDGGROUNDGGGROUNDWHEELARCH
.Rear Lamp Assembly RH
GROUNDGGROUNDGGGROUNDWHEELARCH
.License Plate Lamp LH.License Plate Lamp RH
417-04-3 Daytime Running Lamps (DRL)
2011.0 Kuga (G1223815)
BACK TO CHAPTER INDEX
TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

Daytime Running Lamps (DRL) Relay (G1313058)
201
1.0 Kuga
417-04- 4
Daytime Running Lamps (DRL)
417-04-4
.
BACK TO CHAPTER INDEX TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

R21
R22
R20
R15
(F111= 5A: FOR C394 DIESEL ENGINE)
PCB SHOULD BE ABLE TO ACCEPT THE LOAD IF F119 IS CHANGED FROM 25A TO 30A
(F111=15 A: FOR GAS ENGINE)
KEYLESS GO/KEYLESS VEHICLETO PASSENGER DOOR MODULE
TO DRIVER DOOR MODULETO BACKLITE SW STATUS
NOTE2
NOTE4
NOTE2
NOTE1 1/2(R26/R27)
1/2 (R
2
1/2 (R29/R30)
PCB
1/2 (R26/R27) 1/2 R25
15
TO AC SW, EATC, SSCD
FROM LIGHT SW / AUTO LIGHT
FROM LIGHT SWITCH
LUGGAGE COMPARTMENT LIGHTING TO WIPER MOTOR HIGH
TO IGNITION FOR EJB FROM IGNITION SWITCH POS 15 DTRL RESISTOR WIREFROM FRONT JUNCTION BOX
TO LIGHT SWITCH VBAT DTRL / PARK LT CLUSTER
DATA LINK CONN.
TO RIGHT LOW BEAM LAMP
TO LEFT LOW BEAM LAMP
TO RIGHT HIGH BEAM LAMP
TO LEFT HIGH BEAM LAMP KEYLESS VEHICLE
LH RH RL RR DOOR LATCH
DD LATCH / F FLAP
POWER GND
TO DOOR LATCH LOCK
TO DOOR LATCH UNLOCK
30 (1)
*
FROM BUSBAR 1(F3 60A)
FROMBUSBAR1(F360A)
TO WIPER GROUND
1/2 (R23/R24)
FRONT FOOTWELL LAMPS RKE / DVD PLAYER
TRAILER TOW MODULE/LUGGAGE COMP PWR PNTELECTRONIC MODULE(DPF,PAM(FAP))
DTRL RESISTOR WIRE
TO FUEL PUMP MOTOR FUEL CUT OFF SWITCH
POSITION LIGHT SWBACKUP LAMP SWITCH
AUTOLAMP OR DTRL INDICATOR
AUTOLAMP
HEATED BACKLITE RELAY
REAR WIPERBATTERY SAVER
FUEL PUMP STATUS
FRONT WIPER HIGH SPEED
FRONT WIPER LOW SPEEDHEADLIGHT LOW BEAMHEADLIGHT HIGH BEAMDOOR UNLOCK RELAYDOOR LOCK RELAYDEADLOCK RELAYDD & FF UNLOCK RELAY
ELECTRONIC SIGNALELECTRONIC POWERELECTRONIC POWER.
IGNITION
FRONT WIPER FAST SW
HEATED BACKLITE SWITCH
ELECTRO. PART
HW SPEC FOR FUNC.OF THE BOX SEE
CCM ONLY
BP02
+10A
F103+15A
F111
C102C96
+20A
F129
C96
+10A
F113+
F102 10A
+20A
F126
C103
+20A
F135
C1-5
C1-1C1-3
C1-2.LF10
R15
C96
+20A
F134+25A
F133
C100
LF36
.RW03
.RW03
.
C102C96C96C96C96C100C100C100C102C102C102
+
F139 10A
+
F140 10A
. LF38
C100C100C102C102C100C98C100C100C100C100C100
+15A
F142
C102C96C96
. E608 R19
C103C102
+25A
F119
C96
LF37
.
+15A
F143
+
F106 20A
C102
+
F107 10A
Central Junction Box (CJB)
)
.
)))
Daytime Running Lamps (DRL) Relay
Headlamp High Beam RelayRW03Windshield Wiper Intermittent Wipe RelayeeRlRelayaaeRelayaeRelayaRelayyaWindsh
..AutolampR
Fuel Pump Relay
Headlamp Low Beam Relay
700-01-4 Power Distribution - Central Junction Box (CJB)
2011.0 Kuga (G1226099)
BACK TO CHAPTER INDEX
TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

Communications Network - LocalInterconnect Network (LIN)
Bus—RHD 4WD/RHD
FWD............................................. 418-00
Communications Network - Mid-Speed (MS) Controller
Area Network (CAN)
Bus—LHD 4WD/LHD
FWD............................................. 418-00
Communications Network - Mid-Speed (MS) Controller
Area Network (CAN)
Bus—RHD 4WD/RHD
FWD............................................. 418-00
Compact Disc (CD) Changer ....................................... 415-01
Cooling Fan—2.5L Duratec (147kW/200PS) - VI5...................700-00
Cooling Fan—2.0L Duratorq-TDCi (100kW/136PS)
- DW.............................................700-00
Cooling Fan—2.0L Duratorq-TDCi (100kW/136PS)
- DW/2.0L Duratorq-TDCi
(103kW/140PS) - DW/2.0L
Duratorq-TDCi (120kW/163PS)
- DW, Emission Requirements:
Stage V........................................700-00
Cooling Fan Motor...........................303-03
Cooling Fan Relay...........................303-03
Courtesy and Demand Lighting—LHD 4WD/LHD
FWD, Vehicles Without: Door
Module ......................................... 417-02
Courtesy and Demand Lighting—LHD 4WD/LHD
FWD, Vehicles With: Door
Module ......................................... 417-02
Courtesy and Demand Lighting—RHD 4WD/RHD
FWD, Vehicles Without: Door
Module ......................................... 417-02
Courtesy and Demand Lighting—RHD 4WD/RHD
FWD, Vehicles With: Door
Module ......................................... 417-02
Crankshaft Position (CKP) Sensor....................................... 303-14A
Crankshaft Position (CKP) Sensor—D ................................. 303-14CData Link Connector
(DLC)............................................ 418-00
Daytime Running Lamps (DRL)............................................ 417-04
Daytime Running Lamps (DRL) Relay ............................................ 417-04
Defrost Vent/Register Blend Door Actuator ........................................ 412-01
Diagnostics ...................................... 418-00
Diesel Particulate Filter (DPF) Differential Pressure
Sensor....................................... 303-14C
Direct Current/Alternating Current (DC/AC) Inverter..........................310-01
D-Pillar LH Ground Point—LHD 4WD/LHD FWD............................700-03
D-Pillar LH Ground Point—RHD 4WD/RHD FWD...........................700-03
D-Pillar RH Ground Point—LHD 4WD/LHD FWD............................700-03
D-Pillar RH Ground Point—RHD 4WD/RHD FWD...........................700-03
Driver Air Bag Module...................501-20B
Driver Door Latch.............................501-14
Driver Door Lock Control Switch ........................................... 501-11
Driver Door Module (DDM)...........................................419-10
Driver Door Module (DDM)...........................................419-10
Driver Heated Seat Module ......................................... 501-10
Driver Heated Seat Module ......................................... 501-10
Driver Heated Seat Switch ...........................................501-10
Driver Safety Belt Buckle Switch........................................ 501-20A
Driver Safety Belt Pretensioner .............................. 501-20A
Driver Seat.......................................501-10
Driver Seat.......................................501-10
Driver

Seat.......................................501-10
Driver Seat.......................................501-10
Driver Seat.......................................501-10
Driver Seat.......................................501-10
Driver Seat.......................................501-10
Driver Seat.......................................501-10
Driver Seat.......................................501-10
Driver Side Air Bag Module ....................................... 501-20B
2011.0 Kuga
Index
BACK TO CHAPTER INDEX TO MODEL INDEX
PAGE 5 OF 16
FORD KUGA 2011.0MY WIRING DIAGRAMS