remote control FORD SIERRA 1991 2.G XR4 Workshop Manual

Turbocharger
pC
pG/H/I
pF
pD
pA
pB
pE
pA Standard Wastegate Actuator Since the stock XR
wastegate is no longer available new, we supply a high quality
re manufactured unit. Internal components (diaphragm) are re-
placed and exterior is zinc plated.) M521WR
pB
Turbochargers We offer both re manufactured stock
specification and modified high performance turbos for the
XR. High quality re manufactured turbos include; new center
cartridge compressor/turbine wheel assembly with recondi-
tioned outer compressor/turbine housings, new bearings,
seals and O-rings and fasteners. Our high performance turbo
adds a few extra tweeks. A GNX compressor wheel machined
into the stock comp housing for an additional 30% airflow and
a 360 degree thrust bearing is fitted for added durability.
Turbos are fully dressed and include wastegate actuator,
base & drain gaskets and sold on a exchange "core" basis-
outright purchase will add an additional $100.00 to the cost.
Standard Reman. Turbocharger M522TR
High Performance Turbocharger M522TM
pC
Intercooler Kit If you are looking for a large high flow
intercooler kit this is the one to have. Intercooler core mounts
ahead of the steering rack in front of the engine facing the
ground. Air is ducted up and through the core. Plumbing is kept
short and allows for a larger core than what can usually be fitted
in the bumper/grille area. Kit is complete with intercooler core
(8" x 20" x 3.5"), mounting brackets, inlet plumbing pipes &
connectors, clamps, turbo output elbow, bypass valve and
additional hardware and instructions.
M522ICpD
Adjustable Boost Valve Kit Replace the troublesome
stock boost control solenoid with this easy to adjust under hood
boost valve. This kit uses a check valve to accurately control the
boost level which allows for faster turbo spool-up (reduced lag)
over typical adjustable "bleed-off" valves. This is a low cost modifi-
cation and should be a "must have" for all XR's.
M521BV
pE
Dual Port Wastegate Actuator These are new actua-
tors which feature an adjustable length rod (set boost & pre load)
and dual vacuum ports. The dual port feature permits use of a
remote mounted boost valve (see below), but can also be used
as a replacement for stock actuator.
M521WA2
pF
Cockpit Mounted Boost Valve Remote cockpit
mounted adjustable boost valve for use with dual port wastegate
actuators (see above). Vacuum signal is regulated by the in
car mounted valve and recirculated to the dual port actuator for
precise adjustment. M521TB
pG
Turbo Oil Feed Pipe is prone to cracking/leaking and
should always be replaced when a new turbo is fitted to assure
proper oil flow. Just look inside an old one and you will see
what we mean. M522P
pH
Turbo Inlet Hose we have a version of this (discontin-
ued by Ford) hose that links the turbo outlet pipe to the throttle
body. Ours is high specification 4-ply Silicone (blue) rated to
over 600 degrees, 190 psi burst pressure- better & cheaper
than the original ! M22H
pI
Stainless Base Gasket replacement for between the turbo
base and exhaust manifold. L521GT
2 5

Price List
This catalog is viewable and
downloadable from our internet site
(www.batinc.net) you can get
catalog updates there too.
PAGE 2 front suspension & steering
Front Sway Bar- Cosworth 28mm M407 185.00
Front Strut- Spax Adjustable (each) XR M401A 165.00
Front Strut- Spax Sport- fixed rate- (each) XR M401V 99.50
Front Strut- Bilstein-Gas- (each) XR M401B 92.50
Front Strut- R/S Adjustable (each) XR M401RS 219.95
Front Strut- Koni Sport (each) Scorpio G401K 199.95
Front Strut- Boge Turbo-Gas (each) XR M401S 97.50
Front Strut- Boge Turbo-Gas (each) Scorpio G401S 101.50
Front Strut- DeCarbon Gas (each) XR M401G 145.00
Front Strut- DeCarbon Gas (each) Scorpio G401G 145.00
Front Strut- KYB GR2 (each) XR M401Y 99.50
Front Strut- KYB GR2 (each) Scorpio G401Y 99.50
Steering Rack Assembly* (XR) M434SR 349.00
Steering Rack Assembly* Scorpio G434SR 349.00
*this item requires an additional 100.00 charge refundable upon core return
Steering Rack Bushing H.D. (set) M434BH 30.00
Steering Rack Boot (left or right) XR & Scorpio M434RB 15.50
Control Arm* (left) XR M428L 75.00
Control Arm* (left) Scorpio G428L 99.50
Control Arm* (right) XR M428R 75.00
Control Arm* (right) Scorpio G428R 99.50
*NEW control arms (ball joints and bushings are installed)
Adjustable Control Arms (pair) w/bushings DISCONTINUED
Adjustable Control Arms- Race (pair) DISCONTINUED
Bushing- H.D. (GPN) Inner Control Arm (each) M428BH-N 16.75
Bushing- H.D. (GPN) Inner Control Arm (each) ScorpioG428BH-N 22.50
Bushings- Urethane Inner Control Arm (set) M428BU 30.00
Bushings- Urethane Inner Control Arm (set) Scoprio G428BU 35.00
Bushing (standard) Inner Control Arm (each) XR C428B 9.50
Bushings*- Urethane Outer Control/Sway (set) M428BK 70.00
Bushings*- H.D. (GPN) Outer Control/Sway (set) M428BK-N 50.00
Bushings*(standard) Outer Control/Sway (1 arm pair) M428B 20.00
*M428B, M428BK & M428BK-N are all suitable for Scorpio
Washer (shallow)- Sway Bar / Outer TCA (each) M407W 2.95
Tie Rod End (left) XR M434L 24.50
Tie Rod End (right) XR M434R 24.50
Tie Rod End (same L or R) Scorpio G434 27.50
Mount/Insulator -H.D. Upper Strut (each) XR M404 24.00
Upper Strut Mount/Insulator- Scorpio (each) G404 24.50
Upper Strut Rotating Bearing- Scorpio (each) G403 7.95
Upper Strut Rotating Bearing- XR4 (each) M403 9.50
PAGE 3 suspension components
Spax Sport Kit -XR M400S 495.00
Spax Sport Kit (adjustable) XR M400A 649.00
Sport Spring Set (4) front/rear (-25mm) XR M414M 189.50
Sport Spring Set (4) front/rear (-40mm) XR M414C 225.00
Sport Spring Set (4) front/rear (standard height) XR M414S 249.00
Sport Spring Set (4) front/rear (-30mm) Scorpio G414M 269.00
Front Spring Scorpio - Standard O.E. Ford (each) G414 63.65
Rear Spring Scorpio - Standard O.E. Ford (each) G415 106.40
Rear Camber Shim Kit -XR M423R 30.00
Front Upper Strut Brace (alloy) XR M403F 149.50
Rear Upper Shock Brace (alloy) XR M403R 142.50
Rear Upper Shock Brace (steel) XR M403RS 78.00
PAGE 4 suspension components
Bar Bushing H.D. 25mm- XR4 w/standard bar M407BU 20.00
Bar Bushing H.D. 28mm- XR4 w/Cosworth barM407BAU 20.00
Bar Bushing H.D. 25mm- XR4 w/ std. bar & G407C clampG407BA 20.00Bar Bushing H.D. 28mm- ScorpioG407BAU 20.00
Front Sway Bar Clamp- Scorpio (each) M407C 7.50
Steering Rack Assembly* XR M434SR 349.00
Steering Rack Assembly* Scorpio G434SR 349.00
*this item requires an additional 100.00 charge refundable upon core return
Steering Rack Bushing (each) M434B 8.70
Steering Rack Bushing H.D. (each) M434BH 20.00
Inner Tie Rod -XR4 M434TK 51.00
Inner Tie Rod -Scorpio G434TK 51.00Steering Rack Boot (left or right) XR & Scorpio M434RB 16.75
Outer Tie Rod End (left) XR M434L 24.50
Outer Tie Rod End (right) XR M434R 24.50
Outer Tie Rod End (same L or R) Scorpio G434 27.50
Power Steering Pump XR4Ti* (integral reservoir) M434P 135.00
Power Steering Pump XR4Ti* (remote reservoir) M434PA 136.00
Power Steering Pump Scorpio* G434P 136.00
*this item requires an additional 25.00 charge refundable upon core return
P/S Pressure Hose XR4Ti M434PH 58.33
Strut Boot/Bump Stop (each) XR & Scorpio M405B 19.00
Strut Insulator/Bearing Kit XR4 (does 1 side) M403K 7.00
Upper Rotating Bearing XR4 (each) M403 8.50
Upper Rotating Bearing Scorpio (each) G403 7.95
PAGE 5
Pricing is listed with part numbers on this pages
PAGE 6
rear suspension
Rear Sway Bar w/bush- Cosworth 16mm (XR4) M408 99.50Rear Sway Bar w/bush- Cosworth 18mm (Scorpio only)G408 89.95
Rear Bar End Shackle (each) -XR M408S 15.00
Rear Bar End Shackle (each) -Scorpio G408S 15.00
Rear Bar Bush(12mm) urethane (each) stock XR4 M408BU 6.00
Rear Bar Bush (16mm) urethane (each) Cosworth M408BAU 6.00
Rear Bar Bush (16mm) urethane (each) Scorpio G408BU 6.00
Rear Control Arm Set -H.D. Competition M424 675.00
Bushing*- Urethane Outer Control Arm (each) M424BO 29.75
Bushing*- GPN Outer Control Arm (each) M424BO-N 30.50
Bushing*- GPN Body Beam Mount (each) M429B 36.75
Bushing*- Urethane H.D. Body Beam Mount (each) M429BU 54.50
Bushing*- Urethane Inner Control Arm (each) M424BI 29.75
*above bushings also Scorpio suitable
Beam/Subframe Assembly -H.D. CompetitionDISCONTINUED
Rear Shock- Spax Adjustable (each) XR M402A 89.00
Rear Shock- Spax Adjustable (each) Scorpio G402A 105.50
Rear Shock- Spax Sport- fixed rate- (each) XR M402V 75.00
Rear Shock- Bilstein- Gas (each) XR M402B 73.00
Rear Shock- Koni R/S Adjustable (each) XR M402RS 99.50
Rear Shock- Koni Sport (each) Scorpio G402K 122.85Rear Shock- Boge Turbo-Gas (each) XR M402S 75.50
Rear Shock- Boge Turbo-Gas (each) Scorpio G402S 62.50
Rear Shock- DeCarbon-Gas (each) XR M402G 63.00Rear Shock- DeCarbon-Gas (each) Scorpio G402G 87.00
Rear Shock- KYB (each) XR M402Y 46.50
Rear Shock -KYB (each) Scorpio G402Y 46.50
IMPORTANT PRICE LIST NOTES:
(1) Scorpio versions of listed XR4 parts will generally
appear below XR4 item in
italics.
(2) Items that apply for both XR4 & Scorpio are noted.
(3) Fitment notes, and core charge information is also
italicized.
(4) Additional items that do not appear in the literature
can be found in with the corresponding category /
page number reference. These listings are also
italicized.
3 503/11/02

Price List
PAGE 23 cooling system (Scorpio)
Hose- heater valve (out) to core G421HA 8.90
Hose- heater valve to engine G421HB 17.50
Hose- heater valve (inlet) to core G421HC 13.95
Hose- heater valve to pipe G421HD 18.75
Heater Control Valve- XR4 & Scorpio M421V 60.00
Hose- coolant pipe to oil cooler from heat valve G421HL 9.90
Oil Cooler- oil to water heat exchanger AD1000 110.00
Hose- oil cooler to coolant pipe G421HM 14.40
Hose- coolant pipe from oil cooler to water pump G421HK 17.90
Hose- bypass/ water pump outlet to inlet mfld. G421HP 14.10
Hose- upper radiator (late 89) w/vent G421TH-9 35.00
Hose- coolant tank to thermo housing G421HF-9 16.45
Tank Lever Sender M421LS 40.25
Lever Sender Install Kit M421SK 9.40
Cap/Plug- Rubber G421P 2.50
Hose- lower radiator (late 89) w/tee off hose G421BH-9 35.75
Coolant Tank (6/88>89) Oval TypeG421T 52.00
Coolant Tank (late style 6-88>2-92) rectangular shapeG421TL 46.00
Radiator Cap (thread-on) Scorpio & late XR4 G421C 7.35
PAGE 24 A/C system
Evaporator- (XR4 & Scorpio) M470E 245.75
Expansion Valve - (XR4 & Scorpio) M470EV 46.50
Blower Motor - (XR4)
O.E. FordM470A 198.00
Blower Motor - (Scorpio)
O.E. FordG470A 230.00
Refrigerant Hoses*- (XR4Ti only) M470H 149.00
Refrigerant Hoses*- (Scorpio) G470H 129.00
*this item requires an additional 100.00 charge refundable upon core return
Compressor- (XR4 & Scorpio) includes clutchM470C 429.00
Clutch Assembly*- (XR4 & Scorpio) M470CL 157.50
*this item requires an additional 25.00 charge refundable upon core return
Condenser- (XR4) M470D 335.00
Condenser- (Scorpio) G470D 335.00
Electric Condenser Fan- 16" Pusher (XR4 & Scorpio)A16F-PU 89.00
Fan Mounting Tie Set (for above fan)ABKT1 7.95
Pressure Switch-
(XR4 & Scorpio) O.E. Ford DISCONTINUED
Receiver/Dryer- (XR4 & Scorpio) M470R 108.00
Receiver/Dryer- (XR4 & Scorpio) O.E. Ford M470R-F 131.50
PAGE 25 turbo components
Wastegate Actuator* -Reman. M521WR 95.00
*this item requires an additional 30.00 charge refundable upon core return
Turbo/Reman* (specify auto or 5-speed) M522TR 425.00
Performance Turbo* M522TM 649.00
*this item requires an additional 100.00 charge refundable upon core return
Intercooler Kit M522IC 1195.00
Adjustable Boost Kit M521BV 48.00
Wastegate Actuator (adjustable rod- dual port) M521WA2 119.00
Cockpit Mount Adjustable Boost Kit (remote valve) M521TB 74.50
Turbo Oil Feed Pipe M522P 19.00
Turbo Inlet Hose (45 degree elbow) M22H 44.50
Turbo Base Gasket L521GT 8.75
02/05/023 9
PAGE 26 engine & related
Main Bearing Set (STD) L16A 32.65
Main Bearing Set (+.010") L16B10 32.65
Main Bearing Set (+.020") L16B20 32.65
Main Bearing Set (+.030") L16B30 32.65
Rod Bearing Set (STD) L16H 16.35
Rod Bearing Set (+.010") L16110 16.35
Rod Bearing Set (+.020") L16120 16.35
Rod Bearing Set (+.030") L16130 16.35
Cam Bearing Set L16M 18.50
Cam Bearing Set- grooved L16MA 18.50
Aux. Shaft Bearing L5DC 10.50
Connecting Rod Bolt Set H.D. (standard 2.3 rod) L4FS 44.30
Connecting Rod Bolt Set H.D. (5.7" Chevy rod) L4FSC 35.00
Head Stud Set H.D. L2DS 98.40
Main Stud Set H.D. L2KS 89.20
Full Gasket Set (complete engine) Felpro L15AA 95.00
Top End Gasket Set Felpro L15BA 55.50
Bottom End Gasket Set (block, crank & sump) Felpro L15CA 40.10
Pan Set- sump rails & seals (cork) L15CP 22.05
Head Gasket H.D. (Ford Motorsport turbo style) L15D 16.00
Head Gasket H.D.- Felpro L15DA 19.50
Head Gasket Competition (extreme duty racing gasket)L15DR 29.50
Head Space Shim .020" L15DS 17.85
Valve Cover Gasket (standard cork) L15E 6.75
Valve Cover Gasket H.D. 2300 (hi-temp rubber)L15EA 24.00
Valve Cover Gaskets H.D. 2.9L V6 (hi-temp rubber)G15EA 15.50
Intake Manifold Gasket Set L15FA 11.40
Water Outlet Gasket (thermostat housing) L15N CALL
Water Pump Gasket (pump to block) L15P CALL
Crankshaft Rear Seal L15Q CALL
Camshaft Seal L15R 8.25
Auxiliary Shaft Seal L15S 9.25
Crankshaft Front Seal L15T 16.08
Inlet Hose- Turbo to T.Body (silicone blue) M22H 45.00
Performance Exhaust System 3" (full system) M522 705.00
Performance Exhaust System 2.5" (down pipe w/cat back)M522B 425.00
Exhaust Down Pipe 3" M522DP 159.00
Exhaust Manifold (standard cast Fomoco) M521 185.00
Exhaust Header 2.3 Turbo (tubular stainless steel) L521T 595.00
Gasket- turbocharger to manifold (stainless) L521GT 8.75
Exhaust Hanger (rubber donut) each C522H 5.25
PAGE 27
engine & related
Air Filter- XR4Ti (2.3L Turbo) M22P 35.10
Air Filter- Scorpio (2.9L V-6) G22P 50.00
Mylar Fyre Foil Sleeve -10 (7/8" I.D.) per foot 320510 4.55
Mylar Fyre Foil Sleeve -12 (1" I.D.) per foot 320512 4.90
Mylar Fyre Foil Sleeve -16 (1 1/4" I.D.) per foot 320516 5.64
Mylar Fyre Foil Sleeve -20 (1 1/2" I.D.) per foot 320520 6.32
Motor Mount Insulator (left or right same) XR- each M433 99.50
Motor Mount Insulator (L or R same) Scorpio- each G433 69.45
Transmission Mount/Insulator- Scorpio G433T 39.50
Transmission Mount/Insulator H.D. M433TA 53.00
Trans Crossmember XR (wide) 87-89 manual & auto
DISCONTINUED
Trans Crossmember XR (narrow) 85-86 manual & autoDISCONTINUED
Belt- XR4Ti (1985-89) W. Pump, Alt, P. SteeringM6G 11.90
Belt- XR4Ti (1986-89)
A/C Comp.M6H 9.50
Belt- XR4Ti (1985)
A/C Comp.M6HA 9.50
Belt- Scorpio (1988-89)
Fan & Power SteeringG6G 14.20
Belt- Scorpio (1988-89)
AlternatorG6GA 12.65
Belt- Scorpio (1988-89)
A/C Comp.G6H 10.25
Ignition Wire Set- XR4Ti (8mm ) L9HT 39.95
Ignition Wire Set- XR4Ti (8.5mm KV85 wire) M9HT 69.50
Ignition Wire Set- XR4Ti (10mm R-100 wire) M9HTR 79.00
Ignition Wire Set- Scorpio (8mm) G9HT 50.75
Ignition Wire Set- Scorpio (8.5mm KV85 wire) G9HT9 88.75