lights FORD SUPER DUTY 2004 1.G Owner's Manual

The 4WD system:
•provides 4x4 High engagement and disengagement while the vehicle is
moving.
•is operated by a rotary control located on the instrument panel that
allows you select 2WD, 4x4 High or 4x4 Low operation.
•uses auto-manual hub locks that can be engaged and disengaged
automatically based on the 4x4 mode selected.
•auto-manual hub locks can be
manually overridden by rotating
the hub lock control from AUTO
to LOCK if desired.
•automatic operation of the
hub locks is recommended,and
will increase fuel economy
•For proper operation, make
sure that the arrow and the
indicator dot on the hub are
aligned, and that both hub
locks are set the same (both
set to AUTO or both set to
LOCK).
4WD system indicator lights
The 4WD system indicator lights illuminate only under the following
conditions. If these lights illuminate when driving in 2WD, contact your
Ford dealer as soon as possible.
•4x4- momentarily illuminates
after the engine is started.
Illuminates when 4H (4x4 High)
or 4L (4x4 Low) is engaged.
•LOW RANGE–momentarily
illuminates when the ignition is
turned to the ON position.
Illuminates when 4L (4x4 Low) is
engaged.
4x4
LOW
RANGE
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Driving
144

Do not connect a trailer’s hydraulic brake system directly to your
vehicle’s brake system. Your vehicle may not have enough
braking power and your chances of having a collision greatly increase.
The braking system of the tow vehicle is rated for operation at the
GVWR not GCWR.
Trailer lamps
Trailer lamps are required on most towed vehicles. Make sure all running
lights, brake lights, turn signals and hazard lights are working. See your
dealer or trailer rental agency for proper instructions and equipment for
hooking up trailer lamps.
Using a step bumper (if equipped)
The rear bumper is equipped with an integral hitch and only requires a
ball with a 25.4 mm (one inch) shank diameter. The bumper has a 2,270
kg (5,000 lb.) trailer weight and 227 kg (500 lb.) tongue weight capacity.
If it is necessary to relocate the trailer hitch ball position, a
frame-mounted trailer hitch must be installed.
Driving while you tow
When towing a trailer:
•Turn off the speed control. The speed control may shut off
automatically when you are towing on long, steep grades.
•Consult your local motor vehicle speed regulations for towing a trailer.
•If your vehicle is equipped with a 4–speed automatic
transmission:To eliminate excessive transmission shifting, use a
lower gear. This will also assist in transmission cooling. (For additional
information, refer to theUnderstanding the positions of the 4–speed
automatic transmissionsection in this chapter.
•If your vehicle is equipped with a 5–speed automatic
transmission:To eliminate excessive transmission shifting, activate
the Tow/Haul feature. This will also assist in transmission cooling. (For
additional information, refer to theUnderstanding the positions of
the 5–speed automatic transmissionsection in this chapter.
•Anticipate stops and brake gradually.
•Do not exceed the GCWR rating or transmission damage may occur.
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Driving
185

3. The fuel cap may not have been securely tightened.
These temporary malfunctions can be corrected by filling the fuel tank
with good quality fuel and/or properly tightening the fuel cap. After three
driving cycles without these or any other temporary malfunctions
present, theCheck Engine/Service Engine Soonlight should turn off.
(A driving cycle consists of a cold engine startup followed by mixed
city/highway driving.) No additional vehicle service is required.
If theCheck Engine/Service Engine Soonlight remains on, have your
vehicle serviced at the first available opportunity.
Readiness for Inspection/Maintenance (I/M) testing
In some localities, it may be a legal requirement to pass an I/M test of
the on-board diagnostics system. If your“Check Engine/Service Engine
Soon”light is on, refer to the description in theWarning lights and
chimessection of theInstrument clusterchapter. Your vehicle may not
pass the I/M test with the“Check Engine/Service Engine Soon”light on.
If the vehicle’s powertrain system or its battery has just been serviced,
the on-board diagnostics system is reset to a“not ready for I/M test”
condition. To ready the on-board diagnostics system for I/M testing, a
minimum of 30 minutes of city and highway driving is necessary as
described below:
•First, at least 10 minutes of driving on an expressway or highway.
•Next, at least 20 minutes driving in stop-and-go, city-type traffic with
at least four idle periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete.
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
255

FORD ACCESSORIES FOR YOUR VEHICLE
A wide selection of genuine Ford accessories are available for your
vehicle through your local authorized Ford or Ford of Canada dealer.
These quality accessories have been specifically engineered to fulfill your
automotive needs; they are custom designed to complement the style
and aerodynamic appearance of your vehicle. In addition, each accessory
is made from high quality materials and meets or exceeds Ford’s rigorous
engineering and safety specifications. Ford Motor Company will repair or
replace any properly dealer-installed Ford accessory found to be
defective in factory-supplied materials or workmanship during the
warranty period, as well as any component damaged by the defective
accessory. The accessory will be warranted for whichever provides you
the greatest benefit:
•12 months or 20,000 km (12,000 miles) (whichever occurs first), or
•the remainder of your new vehicle limited warranty.
This means that genuine Ford accessories purchased along with your
new vehicle and installed by the dealer are covered for the full length of
your New Vehicle’s Limited Warranty—3 years or 60,000 km (36,000
miles) (whichever occurs first). Contact your dealer for details and a
copy of the warranty.
Not all accessories are available for all models.
Following is a list of several Ford Genuine Accessory products. Not all
accessories are available for all models. To find out what accessories are
available for your vehicle, please contact your dealer or visit our online
store at: www.fordaccessoriesstore.com.
Exterior style
Bug shields
Deflectors
Exterior trim
Fender flares
Front end covers
Grille inserts
Headlamps, taillamps, fog lights and Daytime Running Lamps (DRLS)
Running boards
Sliding rear windows - manual and power
Splash guards
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Accessories
Accessories
296

recommendations ...................237
refill capacities ........................278
specifications ..................281, 284
Exhaust fumes ..........................128
F
Fail safe cooling ........................244
Fluid capacities .........................278
Foglamps .....................................41
Four-Wheel Drive vehicles .......143
description ..............................147
driving off road .......................149
electronic shift ................143, 147
indicator light .........................144
lever operated shift ................145
manual locking hubs ..............143
preparing to drive your
vehicle .....................................131
Fuel ............................................246
calculating fuel economy .......250
cap ...........................................248
capacity ...................................278
choosing the right fuel ...........248
comparisons with EPA fuel
economy estimates .................253
detergent in fuel .....................249
filling your vehicle with
fuel ...........................246, 248, 250
filter, specifications ........250, 277
fuel pump shut-off switch .....192
improving fuel economy ........250
octane rating ...................249, 284
quality ......................................249
running out of fuel .................249
safety information relating to
automotive fuels .....................246
Fuel pump shut-off switch .......192
Fuses ..................................193–194
G
Garage door opener ....................53Garage Door Opener
(see Homelink wireless
control system) ...........................62
Gas cap (see Fuel cap) ............248
Gas mileage
(see Fuel economy) .................250
Gauges .........................................15
transmission fluid
temperature gauge ...................19
GAWR
(Gross Axle Weight Rating)
calculating ...............................162
GVWR
(Gross Vehicle Weight Rating)
calculating ...............................162
H
Hazard flashers .........................192
Head restraints ...........................89
Headlamps ...................................40
aiming ........................................43
autolamp system .......................40
daytime running lights .............41
flash to pass ..............................42
high beam .................................42
replacing bulbs ...................45–46
turning on and off ....................40
Heating
heating and air conditioning
system .................................37–38
HomeLink universal
transceiver
(see Garage door opener) .........65
Homelink wireless control
system ..........................................62
Hood ..........................................233
I
Ignition ...............................124, 284
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
301

Infant seats
(see Safety seats) .....................116
Inspection/maintenance (I/M)
testing ........................................255
Instrument panel
cleaning ...................................228
cluster ........................................12
lighting up panel and
interior .......................................42
J
Jump-starting your vehicle ......209
K
Keyless entry system .................80
autolock .....................................79
Keys
positions of the ignition .........124
L
Lamps
autolamp system .......................40
bulb replacement
specifications chart ..................44
daytime running light ...............41
fog lamps ...................................41
headlamps .................................40
headlamps, flash to pass ..........42
instrument panel, dimming .....42
interior lamps .....................43–44
replacing bulbs ...................44–49
Lane change indicator
(see Turn signal) ........................43
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........129
speed control ............................61
Load limits .................................159Loading instructions .................162
Locks
autolock .....................................79
childproof ..................................74
Lubricant specifications ...281, 284
Lumbar support, seats ...............88
M
Manual transmission .................138
fluid capacities ........................278
lubricant specifications ..........284
reverse .....................................140
Message center ...........................67
english/metric button ...............68
menu button .............................68
Mirrors .........................................52
fold away ...................................58
heated ........................................57
side view mirrors (power) .......56
Moon roof ....................................53
Motorcraft parts ................250, 277
O
Octane rating ............................249
Oil (see Engine oil) ..................235
Overdrive .....................................51
P
Parking brake ............................129
Parts (see Motorcraft parts) ....277
Pedals (see Power adjustable
foot pedals) .................................59
Power adjustable foot pedals .....59
Power distribution box
(see Fuses) ...............................194
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
302

Traction-lok rear axle ...............131
Transfer case
fluid checking .........................262
Transmission
automatic operation .........51, 132
brake-shift interlock (BSI) ....132
fluid, checking and adding
(automatic) .............................258
fluid, checking and adding
(manual) .................................261
fluid, refill capacities ..............278
lubricant specifications ..281, 284
manual operation ....................138
Turn signal ..................................43
V
Vehicle dimensions ...................284Vehicle Identification Number
(VIN) ..........................................293
Vehicle loading ..........................159
Ventilating your vehicle ...........128
W
Warning lights (see Lights) .......12
Washer fluid ..............................235
Water, Driving through .............158
Windows
power .........................................55
Windshield washer fluid and
wipers ..........................................50
checking and adding fluid .....235
replacing wiper blades .............50
Wrecker towing .........................214
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
304