maintenance schedule FORD SUPER DUTY 2022 Owner's Guide

California Fuel Filter Replacement
If you register your vehicle in California, the
California Air Resources Board has
determined that the failure to perform this
maintenance item does not nullify the
emission warranty or limit recall liability
before the completion of your vehicle's
useful life. Ford Motor Company, however,
urges you to have all recommended
maintenance services performed at the
specified intervals and to record all vehicle
service.
Hot Climate Oil Change Intervals
Vehicles operating in the Middle East,
North Africa, Sub-Saharan Africa or
locations with similar climates using an
American Petroleum Institute (API)
Certified for Gasoline Engines (Certification
mark) oil of SM or SN quality, the normal
oil change interval is 3,000 mi (5,000 km).
If the available API SM or SN oils are not
available, then the oil change interval is
2,000 mi (3,000 km).
Engine Air Filter and Cabin Air Filter
Replacement
The life of the engine air filter and cabin air
filter is dependent on exposure to dusty
and dirty conditions. Vehicles operated in
these conditions require frequent
inspection and replacement of the engine
air filter and cabin air filter. Diesel Particulate Filter
Over time, a slight amount of ash builds
up in the diesel particulate filter, which is
not removed during the regeneration
process. The filter may need to be replaced
with a new or remanufactured part at
approximately 250,000 mi (400,000 km).
Actual mileage varies depending on engine
and vehicle operating conditions.
In this case, the engine control system sets
a service light (wrench icon) to inform you
to bring your vehicle to the dealer for
service. If there are any issues with the
oxidation catalyst or particulate filter
system, a service light (wrench or engine
icon) sets by the engine control system to
inform you to bring your vehicle into a
dealer for service.
SPECIAL OPERATING
CONDITIONS SCHEDULED
MAINTENANCE - GASOLINE
If you operate your vehicle primarily in any
of the following conditions, you need to
perform extra maintenance as indicated.
If you operate your vehicle occasionally
under any of these conditions, it is not
necessary to perform the extra
maintenance. For specific
recommendations, see your dealership
service advisor or technician.
Towing a Trailer or Using a Car-top Carrier
Inspect and lubricate U-joints if equipped with grease
fittings.
Inspect frequently, service
as required
See axle maintenance items under
Exceptions.
Inspect the wheels and related components for abnormal
noise, wear, looseness or drag.
Every
5,000 mi (8,000 km)
Rotate tires, inspect tires for wear and measure tread
depth.1
636
2022 Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 202103, First-Printing Scheduled Maintenance

Towing a Trailer or Using a Car-top Carrier
Change engine oil and filter.
Every 5,000 mi (8,000 km)
or six months. Inspect and lubricate U-joints if equipped with grease
fittings.
Replace front wheel bearing grease and grease seals if
non-sealed bearings are used.
Every
30,000 mi
(48,000 km)
Change transfer case fluid (Four-wheel drive vehicles).
Every
60,000 mi
(96,000 km) Replace spark plugs.
1 Rotate the front wheels on vehicles with dual rear wheels when specified. Rotate the
rear wheels if unusual wear is noted. Extensive Idling or Low-speed Driving for Long Distances, as in Heavy Commercial Use
(Such as Delivery, Taxi, Patrol Car or Livery)
Replace engine air filter.
Inspect frequently, service
as required
Replace cabin air filter.
Inspect brake system.
Every
5,000 mi (8,000 km)
Inspect wheels and related components for abnormal
noise, wear, looseness or drag.
Lubricate control arm and steering ball joints if equipped
with grease fittings.
Rotate tires, inspect tires for wear and measure tread
depth.1
Inspect and lubricate U-joints if equipped with grease
fittings.
Every
5,000 mi (8,000 km)
or six months
Change engine oil and filter.
Every
5,000 mi (8,000 km)
or six months or 200 engine
hours.
Replace front wheel bearing grease and grease seals if
non-sealed bearings are used.
Every
30,000 mi
(48,000 km)
Replace spark plugs.
Every
60,000 mi
(96,000 km)
1 Rotate the front wheels on vehicles with dual rear wheels when specified. Rotate the
rear wheels if unusual wear is noted.
637
2022 Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 202103, First-Printing Scheduled Maintenance

Operating in Dusty or Sandy Conditions (Such as Unpaved or Dusty Roads)
Replace engine air filter.
Inspect frequently, service
as required
Replace cabin air filter.
Inspect the wheels and related components for abnormal
noise, wear, looseness or drag.
Every 5,000 mi (8,000 km)
Rotate tires, inspect tires for wear and measure tread
depth.1
Change engine oil and filter.
Every
5,000 mi (8,000 km)
or six months Inspect and lubricate U-joints if equipped with grease
fittings.
Replace front wheel bearing grease and grease seals if
non-sealed bearings are used.
Every
30,000 mi
(48,000 km)
1 Rotate the front wheels on vehicles with dual rear wheels when specified. Rotate the
rear wheels if unusual wear is noted. Off-road operation
Inspect steering linkage, ball joints and U-joints, Lubricate
if equipped with grease fittings.
Inspect frequently, service
as required
Replace engine air filter.
Change engine oil and filter.
Every
5,000 mi (8,000 km)
or six months Replace cabin air filter.
Inspect the wheels and related components for abnormal
noise, wear, looseness or drag.
Rotate tires, inspect tires for wear and measure tread
depth.1
Replace front wheel bearing grease and grease seals if
non-sealed bearings are used.
Every
30,000 mi
(48,000 km)
1 Rotate the front wheels on vehicles with dual rear wheels when specified. Rotate the
rear wheels if unusual wear is noted.
638
2022 Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 202103, First-Printing Scheduled Maintenance

Exclusive use of E85 (Flex Fuel Vehicles Only)
If ran exclusively on E85, fill the fuel tank full with regular
unleaded fuel.
Every oil change interval
Exceptions
Axle and Transfer Case Maintenance
Axle(s) and transfer case (4X4 only) fluid
changes or level checks are not required
unless a leak is suspected or the assembly
has been submerged in water. During long
periods of trailer towing with outside
temperatures above 70°F (21°C) or at
wide-open throttle for long periods above
45 mph (72 km/h)
, change the rear axle
fluid every 30,000 mi (48,000 km) if the
rear axle is filled with non-synthetic fluid.
This interval can be waived and the
150,000 mi (240,000 km) service interval
can continue if the rear axle is filled with
75W140 synthetic gear fluid meeting Ford
specification WSL-M2C192-A, part number
XY-75W140-QL, or equivalent. Add friction
modifier XL-3 (EST-M2C118-A) or
equivalent for complete refill of
Traction-Lok rear axles. See
Capacities
and Specifications (page 467).
Additional Axle Maintenance for Dual
Rear Wheels
Change rear axle fluid every
250,000 mi
(400,000 km) under normal driving
conditions on all commercial applications.
When operating your vehicle at or near
maximum gross vehicle weights, change
the rear axle fluid every
60,000 mi
(96,000 km). In addition, follow this
60,000 mi (96,000 km) schedule when
operating your vehicle under the special
operating conditions where noted. California Fuel Filter Replacement
If you register your vehicle in California, the
California Air Resources Board has
determined that the failure to perform this
maintenance item does not nullify the
emission warranty or limit recall liability
before the completion of your vehicle's
useful life. Ford Motor Company, however,
urges you to have all recommended
maintenance services performed at the
specified intervals and to record all vehicle
service.
Hot Climate Oil Change Intervals
Vehicles operating in the Middle East,
North Africa, Sub-Saharan Africa or
locations with similar climates using an
American Petroleum Institute (API)
Certified for Gasoline Engines (Certification
mark) oil of SM or SN quality, the normal
oil change interval is 3,000 mi (5,000 km).
If the available API SM or SN oils are not
available, then the oil change interval is
2,000 mi (3,000 km)
.
Engine Air Filter and Cabin Air Filter
Replacement
The life of the engine air filter and cabin air
filter is dependent on exposure to dusty
and dirty conditions. Vehicles operated in
these conditions require frequent
inspection and replacement of the engine
air filter and cabin air filter.
639
2022 Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 202103, First-Printing Scheduled Maintenance

Zambia
PERCHLORATE
Certain components in your vehicle such
as airbag modules, seatbelt pretensioners
and remote control batteries may contain
perchlorate material. Special handling
may apply for service or vehicle end of life
disposal.
For more information visit:
www.dtsc.ca.gov/hazardouswaste/perchlorate.
REPLACEMENT PARTS
RECOMMENDATION
We have built your vehicle to the highest
standards using quality parts. We
recommend that you demand the use of
genuine Ford and Motorcraft parts
whenever your vehicle requires scheduled
maintenance or repair. You can clearly
identify genuine Ford and Motorcraft parts
by looking for the Ford, FoMoCo or
Motorcraft branding on the parts or their
packaging. Scheduled Maintenance and
Mechanical Repairs
One of the best ways for you to make sure
that your vehicle provides years of service
is to have it maintained in line with our
recommendations using parts that
conform to the specifications detailed in
this Owner
’s Manual.
Genuine Ford and Motorcraft parts meet
or exceed these specifications.
Collision Repairs
We hope that you never experience a
collision, but accidents happen sometimes.
Genuine Ford replacement collision parts
meet our stringent requirements for fit,
finish, structural integrity, corrosion
protection and dent resistance. During
vehicle development we validate that
these parts deliver the intended level of
protection as a whole system. A great way
to know for sure you are getting this level
of protection is to use genuine Ford
replacement collision parts.
Warranty on Replacement Parts
Genuine Ford and Motorcraft replacement
parts are the only replacement parts that
benefit from a Ford Warranty.
The Ford Warranty may not cover damage
caused to your vehicle as a result of failed
non-Ford parts.
For additional information, refer to the
terms and conditions of the Ford Warranty.
684
2022 Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 202103, First-Printing Customer InformationE340659

Manually Shifting Gears............................225
Shifting Using the Buttons on the Selector
Lever................................................................... 225
Manual Seats
.................................................159
Adjusting the Head Restraint......................... 159
Adjusting the Lumbar Support....................... 161
Adjusting the Seat Backrest............................ 161
Folding the Seats............................................... 168
Head Restraint Components......................... 159
Installing the Head Restraint......................... 160
Moving the Seat Backward and Forward............................................................. 160
Removing the Head Restraint....................... 160
Unfolding the Seats.......................................... 168
Massage Seats
..............................................164
Adjusting the Massage Seat Settings.........164
Massage Seat Limitations.............................. 164
Memory Function
..........................................174
Memory Function Precautions.................174
Mislock...............................................................84 Mislock Limitations............................................. 84
Switching Mislock On and Off........................ 84
What Is Mislock.................................................... 84
Mobile Communications Equipment..................................................685
Mobile Device Data - Vehicles With: SYNC 3
.............................................................27
Mobile Device Data - Vehicles With: SYNC 4.............................................................27
Moonroof Bounce-Back
.............................132
Overriding Moonroof Bounce-Back.............132
What Is Moonroof Bounce-Back.................. 132
Moonroof
..........................................................131
Moonroof Bounce-Back................................... 132
Motorcraft Parts - 6.2L.............................469
Motorcraft Parts - 6.7L Diesel..................471
Motorcraft Parts - 7.3L
...............................472
Muting the Audio.........................................526
MyKey Settings................................................77 Configurable MyKey Settings........................... 77
Non-Configurable MyKey Settings.................77
MyKey – Troubleshooting..........................80 MyKey – Frequently Asked Questions.........82
MyKey – Information Messages..................... 80
MyKey ™
..............................................................77
MyKey Settings...................................................... 77
MyKey – Troubleshooting................................. 80N
Navigation Map Updates
..........................610
Navigation.......................................................574
Adjusting the Map.............................................. 610
Live Traffic............................................................. 610
Route Guidance................................................... 611
Setting a Destination........................................ 610
Waypoints.............................................................. 611
Normal Scheduled Maintenance - Diesel
.............................................................625
Normal Scheduled Maintenance - Gasoline.......................................................628
O
Off-Road Driving...........................................371 After Driving Your Vehicle Off-Road............372
Basic Off-Road Driving Techniques.............371
Driving Through Water Limitations..............372
What Is Off-Road Driving................................. 371
Opening and Closing the Flip Key............69
Opening and Closing the Hood.............396
Opening and Closing the Moonroof.......131
Opening and Closing the Sliding Windows........................................................127
Opening and Closing the Sun Shade
..............................................................131
Opening and Closing the Windows.......126
Opening the Tailgate....................................94 Opening the Tailgate From Inside Your
Vehicle................................................................. 99
Opening the Tailgate From Outside Your Vehicle................................................................. 94
Opening the Tailgate Using the Remote Control................................................................ 99
Operating the Doors From Inside Your Vehicle.............................................................83
Individually Unlocking and Locking the Doors Using the Locking Button................83
Opening the Doors From Inside Your Vehicle................................................................. 84
Operating the Doors From Outside Your Vehicle.............................................................83
Unlocking and Locking the Doors Using the Key Blade............................................................ 83
Unlocking and Locking the Doors Using the Remote Control............................................... 83
728
2022 Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 202103, First-Printing Index

Remote Start Limitations.........................146
Remote Start Precautions........................146
Remote Start Remote Control Indicators.......................................................147
Remote Start
.................................................146
Remote Start Settings...................................... 147
Remote Start Settings................................147 Setting the Remote Start Duration.............148
Switching Climate Control Auto Mode On
and Off............................................................... 147
Switching Climate Control Last Settings On and Off........................................................ 147
Switching the Heated Seat Settings On and Off........................................................................\
147
Switching the Heated Steering Wheel Settings On and Off..................................... 148
Removing and Installing the Tailgate...........................................................94
Removing the Key Blade.............................70
Removing Your Vehicle From Storage.........................................................428
Repairing Minor Paint Damage..............426
Replacement Parts Recommendation....................................684
Replacing a Lost Key or Remote Control
.............................................................73
Replacing the Cabin Air Filter...................157
Replacing the Front Wiper Blades..........116
Reporting Safety Defects in Canada.........................................................642
Reporting Safety Defects in the United States............................................................642
Reprogramming the Garage Door Opener...........................................................179
Resetting the Individual Trip Values............................................................145
Resetting the Stopping Position - Vehicles With: Power Adjustable
Steering Column
.........................................112
Resetting the Trip Computer....................145
Resetting Tire Pressure Monitoring System.........................................................450
Resuming the Set Speed...........................271
Roadside Assistance
..................................378
Rollover Warning.........................................640
Route Guidance.............................................611
Adjusting the Guidance Prompt
Volume............................................................... 611Canceling Route Guidance..............................
611
Repeating an Instruction.................................. 611
Running-In See: Breaking-In................................................. 373
Running Out of Fuel...................................208 Adding Fuel From a Portable Fuel
Container......................................................... 208
Filling a Portable Fuel Container.................208
S
Satellite Radio
...............................................513
Locating the Satellite Radio Identification
Number............................................................ 529
Satellite Radio Limitations............................ 529
Satellite Radio Settings.................................. 530
Selecting a Channel......................................... 530
What Is Satellite Radio.................................... 529
Saving a Preset Position.............................174
Scheduled Maintenance...........................622
Seatbelt Extensions......................................56
Seatbelt Precautions
....................................49
Seatbelt Reminder.........................................53
How Does the Seatbelt Reminder
Work..................................................................... 53
Seatbelt Reminder Audible Warnings..........55
Seatbelt Reminder Indicators......................... 55
Switching the Seatbelt Reminder On and Off........................................................................\
. 55
Seatbelts...........................................................49 Automatic Locking Mode................................... 51
Seatbelt Reminder............................................... 53
Sensitive Locking Mode...................................... 51
Security............................................................106 Anti-Theft Alarm System................................ 106
Anti-Theft Alarm System Settings..............107
Passive Anti-Theft System............................. 106
Security – Troubleshooting............................ 108
Security – Troubleshooting......................108 Security – Frequently Asked
Questions......................................................... 109
Security – Information Messages................108
Selecting a Drive Mode...............................281
Selecting a Four-Wheel Drive Mode.............................................................230
Selecting the Audio Source.....................525
Selective Catalytic Reduction System Guidelines.....................................................218
731
2022 Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 202103, First-Printing Index

Selective Catalytic Reduction System
Precautions...................................................217
Selective Catalytic Reduction System Requirements..............................................218
Selective Catalytic Reduction System............................................................217
Filling the Selective Catalytic Reduction
System Tank.................................................... 219
Selective Catalytic Reduction System – Troubleshooting............................................. 221
Selective Catalytic Reduction System – Troubleshooting.........................................221
Selective Catalytic Reduction System – Information Messages.................................. 221
Selective Catalytic Reduction System – Warning Lamps............................................... 221
Sending and Receiving a Text Message......................................................605
Sensitive Locking Mode
................................51
How Does Sensitive Locking Mode
Work...................................................................... 51
What is Sensitive Locking Mode...................... 51
Service Data
.....................................................25
Setting a Destination..................................610 Setting a Destination Using a Point of
Interest................................................................ 611
Setting a Destination Using a Predictive Destination........................................................ 611
Setting a Destination Using a Recent Destination........................................................ 611
Setting a Destination Using a Saved Destination........................................................ 611
Setting a Destination Using the Map Screen............................................................... 610
Setting a Destination Using the Text Entry Screen............................................................... 610
Setting a Memory Preset
..........................526
Settings Data...................................................26
Settings...........................................................582
Setting the Adaptive Cruise Control Gap.................................................................276
Setting the Adaptive Cruise Control Speed.............................................................275
Setting the Blower Motor Speed............150
Setting the Clock and Date......................526
Setting the Cruise Control Speed..........270
Setting the Hill Descent Speed..............254
Setting the Temperature...........................150 Setting the Trail Control Speed..............252
Setting the Wake Word............................600
Setting Up the Trailer Backup Assistance
for a Conventional Trailer......................339
Applying the Trailer Reversing Aid Sticker................................................................ 341
Calibrating the System.................................... 342
Configuring the Trailer..................................... 339
Setting Up the Trailer Backup Assistance for a Fifth-Wheel or Gooseneck
Trailer.............................................................343
Calibrating the System.................................... 345
Configuring the Trailer...................................... 343
Trailer Sensor Installation.............................. 344
Setting Up Trailer Reverse Guidance for a Conventional Trailer.............................357
Applying the Trailer Reverse Aid Sticker............................................................... 359
Calibrating the System................................... 360
Configuring the Trailer...................................... 357
Setting Up Trailer Reverse Guidance for a Fifth-Wheel or Gooseneck
Trailer............................................................360
Calibrating the System.................................... 362
Configuring the Trailer..................................... 360
Trailer Sensor Installation............................... 361
Shifting Your Vehicle Into Gear...............224
Sitting in the Correct Position..................158
Snow Plowing Precautions......................376
Snow Plowing...............................................376
Sounding the Panic Alarm
..........................70
Special Operating Conditions Scheduled Maintenance - Diesel
...............................631
Special Operating Conditions Scheduled Maintenance - Gasoline
........................636
Speed Control See: Cruise Control............................................ 270
Stability Control Indicator
.........................251
Stability Control...........................................249
Starter Switch See: Ignition Switch............................................ 191
Starting and Stopping the Engine – Precautions...................................................191
Starting and Stopping the Engine...........191 Automatic Engine Stop.................................... 196
Engine Block Heater.......................................... 194
Starting and Stopping the Engine – Troubleshooting............................................. 198
732
2022 Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 202103, First-Printing Index