engine coolant FORD TAURUS 1996 User Guide

281
*
[SV19400(ALL)08/95]
Engine Coolant Refill Procedure
*
[SV19450(ALL)01/95]
When the entire cooling system is drained and
refilled, the following procedure should be used
to ensure a complete fill:
[SV19500(ALL)04/95]
q
With the engine OFF and cool, remove the
pressure cap, located on the coolant reservoir.
[SV19550(ALL)04/95]
q
Add a 50/50 mixture of specified coolant and
water to the coolant reservoir. Refer toRefill
Capacitieslater in this chapter for the correct
amount.
[SV19600(ALL)02/95]
q
Continue to fill the reservoir until the coolant
is at the top of the cold fill range.
[SV19650(ALL)04/95]
q
Reinstall the pressure cap until it clicks.
*
[SV19700(ALL)05/95]
q
Start and idle the engine until the radiator
upper hose is warm (this indicates the
thermostat is open and coolant is flowing
through the entire system).
[SV19750(ALL)04/95]
q
Immediately shut off the engine and let cool.
Cautiously remove the pressure cap and add
a 50/50 mixture of specified coolant and
water until the coolant is within the cold fill
range in the coolant reservoir.
[SV19800(ALL)02/95]
q
Reinstall the pressure cap until a click is
heard and felt.
*
[SV19850(ALL)03/95]
q
Check for leaks at the draincock.
*
[SV19900(ALL)03/95]
q
Recheck the engine coolant level, using the
recommended procedure, after one or two
occasions of vehicle use.
File:15fcsvt.ex
Update:Tue Jan 23 13:58:51 1996
ProCarManuals.com

284
*
[SV22400(ALL)05/95]
RWARNING
Do not put windshield washer fluid in the
container for the engine coolant.
%*
[SV22500(ALL)01/95]
Use specially formulated windshield washer
fluid rather than plain water, because specially
formulated washer fluids contain additives that
dissolve road grime. For safety reasons, washer
fluids containing an appropriate antifreeze such
as methanol should be used in freezing weather
(temperatures below32ÊF [0ÊC]).State or local
regulations on Volatile Organic Compounds
(VOC's) may restrict use of the most common
antifreeze, methanol. Washer fluids containing
non-methanol antifreeze agents should be used
only if they provide cold weather protection
without damaging the vehicle's paint finish,
wiper blades, and windshield washer system.
[SV22550(ALL)04/95]
RWARNING
Washer solution contains methanol which
is poisonous. Observe all warnings
indicated on label of washer solution.
% [SV22600(ALL)06/94]
Checking the washer fluid for the
liftgate (If equipped)
[SV23100(ALL)04/95]
If your wagon has a rear window wiper, check
the reservoir for its washer fluid regularly. This
is not the same reservoir that your windshield
wipers use. The opening for this reservoir is on
the right side of the liftgate opening, below the
tail lamp. Refill this reservoir with the same
solution you use for your windshield. To find
out how much washer fluid the reservoir holds,
seeRefill Capacitieslater in this chapter.
File:15fcsvt.ex
Update:Tue Jan 23 13:58:51 1996
ProCarManuals.com

300 [SV31140(ALL)11/94]
one third page art:0000672-BThe brake fluid reservoir
%*
[SV31200(ALL)03/95]
Power Steering Fluid
*
[SV31300(ALL)01/95]
Check the level of the power steering fluid at
least twice a year (i.e., every Spring and Fall).
%*
[SV31400(ALL)03/95]
Checking and Adding Power Steering
Fluid
*
[SV31500(ALL)02/95]
1. Start the engine and let it run until the
power steering fluid reaches normal
operating temperature. The power steering
fluid will be at the right temperature when
the engine coolant temperature gauge in the
instrument cluster is near the center of the
NORMAL operating temperature range.
*
[SV31600(ALL)01/95]
2. While the engine idles, turn the steering
wheel back and forth several times. Make
sure that the cap assembly is installed at this
time.
*
[SV31700(ALL)05/95]
3. Turn the engine off.
File:15fcsvt.ex
Update:Tue Jan 23 13:58:51 1996
ProCarManuals.com

Index 357
Index
A
ABS warning light
(see Anti-lock brake system)....... 81
Accessory position on the ignition..... 59
Additives, engine oil.......... 273
Air bag supplemental
restraint system............. 23
and child safety seats........ 26,33
description............... 23
disposal................ 31
driver air bag............. 23
indicator light............. 77
operation............... 27
passenger air bag............ 23
proper seating............. 24
service and information labels...... 27
tone generator............. 30
wearing safety belts........... 24
Air cleaner filter
location............... 260
replacing............... 296
specifications............. 329
Air conditioning
electronic automatic temperature
control system............ 95
manual heating and air
conditioning system......... 93
Alarm, activating remote personal.... 135
Antenna, radio
(see Electronic sound system)..... 176
Antifreeze (see Engine coolant)...... 276
Anti-lock brake system (ABS)
description.............. 203
see also Brake............ 202
warning light.............. 81
File:fcixt.ex
Update:Tue Jan 23 08:18:16 1996
ProCarManuals.com

362 Index
Coolant (see Engine coolant)
checking and adding......... 276
drain and flush............ 280
preparing for storage......... 333
refill capacities............ 328
specifications............. 330
temperature gauge........... 82
Cooling fan............... 256
Cruise control............. 120
Cupholder(s).............. 156
Customer Assistance Center, Ford (U.S.) . . 239
Customer Assistance Centre,
Ford of Canada..........239, 245
D
Dashboard (see Instrument panel)...... 91
Daytime running light system...... 107
Defects, reporting............ 244
Defrost
rear window and side view mirrors. . . 104
windshield............ 95,103
Dipstick
automatic transaxle fluid........ 296
engine oil.............. 273
power steering fluid.......... 300
Disabled vehicle (see Towing)...... 233
Dispute Settlement Board........ 240
Doors................. 125
childproof locks............ 125
door ajar warning light......... 77
lubricant specifications......... 330
Driving under special conditions
bad weather............. 206
heavy load.............. 208
high speed.............. 290
high water.............. 208
slippery roads............ 206
tips for safe driving.......... 206
towing a trailer............ 211
File:fcixt.ex
Update:Tue Jan 23 08:18:16 1996
ProCarManuals.com

Index 363
E
Electrical system
fuses................ 303
operating when the engine is off..... 59
relays................ 303
Electronic sound system
radio reception............ 177
tuning the radio........... 173
warranty and service information . . . 190
Electronic stereo cassette radio
(see Electronic sound system)..... 172
Electronic stereo radio (see Electronic sound
system)............... 172
Emergencies, roadside
assistance.............. 237
battery acid spills........... 217
fuel................. 268
jump-starting............. 217
towing................ 233
Emergency brake (parking brake)..... 205
Emission control system
catalytic converter.......... 323
emissions warranty......... 4,323
Engine
does not start........... 63,65
fuel pump shut-off switch........ 65
preparing to start............ 61
refill capacities............ 328
service points............ 260
starting................ 62
starting after a collision......... 65
storing your vehicle.......... 332
Engine block heater............ 64
Engine coolant
checking and adding......... 276
checking hoses............ 277
disposal............... 280
drain and flush............ 280
preparing for storage......... 333
File:fcixt.ex
Update:Tue Jan 23 08:18:16 1996
ProCarManuals.com

364 Index
Engine coolant (continued)
proper solution............ 278
recovery reservoir........... 277
refill capacities............ 328
specifications............. 330
temperature gauge........... 82
Engine coolant temperature gauge..... 82
Engine fan............... 256
Engine oil
changing oil and oil filter....... 275
checking and adding......... 273
dipstick............... 274
disposal............... 275
engine oil pressure warning light..... 75
filter, specifications.......... 329
refill capacities............ 328
specifications............. 330
synthetic oil............. 273
ªbreak-inº oils............. 5
viscosity............... 273
Entry system, keyless.......... 128
Exhaust fumes.............. 68
Extended Service Plan, Ford........ 4
F
Fan, engine fan, avoiding injury..... 256
Flashers, hazard............. 118
Flashing the lights............ 116
Flat tire................. 222
Floor mats............... 152
Fluid refill capacities........... 328
File:fcixt.ex
Update:Tue Jan 23 08:18:16 1996
ProCarManuals.com

366 Index
Fuses
checking and replacing........ 311
G
Gas cap (see Fuel cap).......... 264
Gas mileage (see Fuel economy)..... 270
Gasoline (see Fuel)............ 264
Gauges, Mechanical
engine coolant temperature gauge.... 82
fuel gauge............... 82
odometer................ 84
speedometer.............. 84
tachometer............... 84
trip odometer.............. 84
GAWR (Gross Axle Weight Rating)
calculating.............. 209
definition............... 208
driving with a heavy load....... 208
location............... 208
Gearshift
automatic operation........192, 195
column-mounted........... 197
console-mounted........... 198
locking the gearshift........... 59
positions.............192, 195
shifting the gears.........192, 195
shift-lock.............192, 196
GVWR (Gross Vehicle Weight Rating)
calculating.............. 209
definition............... 208
driving with a heavy load....... 208
location............... 208
File:fcixt.ex
Update:Tue Jan 23 08:18:16 1996
ProCarManuals.com