engine FORD TAURUS 1996 Manual Online

300 [SV31140(ALL)11/94]
one third page art:0000672-BThe brake fluid reservoir
%*
[SV31200(ALL)03/95]
Power Steering Fluid
*
[SV31300(ALL)01/95]
Check the level of the power steering fluid at
least twice a year (i.e., every Spring and Fall).
%*
[SV31400(ALL)03/95]
Checking and Adding Power Steering
Fluid
*
[SV31500(ALL)02/95]
1. Start the engine and let it run until the
power steering fluid reaches normal
operating temperature. The power steering
fluid will be at the right temperature when
the engine coolant temperature gauge in the
instrument cluster is near the center of the
NORMAL operating temperature range.
*
[SV31600(ALL)01/95]
2. While the engine idles, turn the steering
wheel back and forth several times. Make
sure that the cap assembly is installed at this
time.
*
[SV31700(ALL)05/95]
3. Turn the engine off.
File:15fcsvt.ex
Update:Tue Jan 23 13:58:51 1996
ProCarManuals.com

301 [SV31800(ALL)04/95]
3.0L Vulcan engine:
%*
[SV31900(ALL)03/94]
4. Check the fluid level on the dipstick (which
is highlighted in yellow in your vehicle). The
fluid level should be between the arrows in
the FULL HOT range, which is marked on
the side of the dipstick, opposite the side
marked FULL COLD. Do not add fluid if the
level is within the FULL HOT range.
*
[SV32100(ALL)07/94]
5. If the power steering fluid is low, add fluid
in small amounts, continuously checking the
level, until you reach the FULL HOT range.
Do not overfill.
[SV32150(ALL)02/95]
half page art:0000311-C
Dipstick for power steering fluid (3.0L Vulcan)
*
[SV32175(ALL)03/95]
6. When you are finished, put the dipstick back
in and make sure that it fits snugly.
File:15fcsvt.ex
Update:Tue Jan 23 13:58:51 1996
ProCarManuals.com

324should be equivalent to genuine Ford Motor
Company parts in performance and durability. It
is the owner's responsibility to determine the
equivalency of such parts. Please consult your
warranty booklet for complete warranty
information.
*
[SV41800(ALL)05/95]
RWARNING
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine
compartment and exhaust system, which
can start a fire.
[SV41900(ALL)04/95]
Watch for fluid leaks, strange odors, smoke, loss
of oil pressure, the charging system warning
light, the service engine soon light, or the
temperature warning light. These sometimes
indicate that the emissions system is not
working properly.
*
[SV42000(ALL)01/95]
Do not make any unauthorized changes to your
vehicle or engine. Changes that cause more
unburned fuel to reach the exhaust system can
increase the temperature of the engine or
exhaust system.
*
[SV42100(ALL)01/95]
By law, anyone who manufactures, repairs,
services, sells, leases, trades vehicles, or
supervises a fleet of vehicles is not permitted to
intentionally remove an emission control device
or prevent it from working. In some of the
United States and in Canada, vehicle owners
may be liable if their emission control device is
removed or is prevented from working.
*
[SV42200(ALL)02/92]
Never use a metal exhaust collector when you
service your vehicle. If the metal collector
contacts any of your vehicle's plastic trim or
bumper parts they could melt or deform.
File:15fcsvt.ex
Update:Tue Jan 23 13:58:51 1996
ProCarManuals.com

325
*
[SV42300(ALL)01/95]
Do not drive your vehicle if it does not operate
properly. See your dealer if the engine runs on
for more than five seconds after you shut it off
or if it misfires, surges, stalls, or backfires.
%*
[SV42400(ALL)05/95]
Information about your vehicle's emission
control system is on the Vehicle Emission
Control Information decal located on or near the
engine. This decal identifies engine displacement
and gives some tune-up specifications.
%*
[SV42405(ALL)07/95]
Readiness for Inspection/Maintenance
Testing
*
[SV42410(ALL)07/95]
In some localities it may become a legal
requirement to pass an
Inspection/Maintenance (I/M) test of the
On-Board Diagnostic (OBD) II system. If the
vehicle's powertrain system or its battery has
just been serviced, the OBD II system is reset to
a not ready for I/M testing condition. To
prepare for I/M testing, the law specifies a
ªneed for additional mixed city and highway
driving to complete the checkº of the OBD II
system. As soon as all of the OBD II system
checks are successfully completed, the OBD II
system is set to the ready condition. The amount
of driving required to reach the ready condition
varies with individual driving patterns. To
complete this requirement in the minimum
amount of time, refer to the OBD II Drive Cycle
defined below. If the vehicle owner cannot or
does not want to do the additional driving
required by law, a service center can perform
this drive cycle as it would any other type of
repair work.
File:15fcsvt.ex
Update:Tue Jan 23 13:58:51 1996
ProCarManuals.com

326
*
[SV42420(ALL)09/95]
OBD II Drive Cycle
*
[SV42430(ALL)06/95]
The following steps must be run in the order
shown. If any steps are interrupted, repeat the
preceding step. Any safe driving mode is
acceptable between steps.
*
[SV42440(ALL)06/95]
Always drive vehicle in safe manner according
to traffic conditions and obey all traffic laws.
*
[SV42445(ALL)07/95]
The engine must be warmed up and at
operating temperature before proceeding with
the drive modes of the following OBD II Drive
Cycle.
*
[SV42450(ALL)06/95]
1. Start the engine. Drive or idle (in neutral)
the vehicle for 4 minutes.
*
[SV42460(ALL)06/95]
2. Idle the vehicle in drive for 40 seconds.
*
[SV42465(ALL)07/95]
3. Accelerate the vehicle to 45 mph (70 km/h)
at 1/4 to 1/2 throttle for 10 seconds.
*
[SV42471(ALL)07/95]
4. Drive the vehicle with a steady throttle at
45 mph (70 km/h) for 30 seconds.
*
[SV42475(ALL)06/95]
5. Idle the vehicle in drive for 40 seconds.
*
[SV42481(ALL)07/95]
6. Continue to drive the vehicle in city traffic at
speeds between 25 and 40 mph
(40-60 km/h) for 15 minutes. During the 15
minute drive cycle the following modes must
be achieved:
*
[SV42485(ALL)07/95]
a. at least 5 stop and idle modes at 10
seconds each
*
[SV42491(ALL)07/95]
b. acceleration from idles at 1/4 to 1/2
throttle position, and
*
[SV42495(ALL)07/95]
c. choose 3 different speeds to do 1.5
minute steady state throttle drives.
File:15fcsvt.ex
Update:Tue Jan 23 13:58:51 1996
ProCarManuals.com

332 [SV45150(ALL)04/95]q
Lubricate trunk lid or wagon liftgate hinges
with a light grade oil. (Do not lubricate hood
and door hinges.)
*
[SV45200(ALL)01/95]
q
Cover interior soft trim to prevent fading.
*
[SV45300(ALL)01/95]
q
Keep all rubber parts free from oil and
solvents.
%*
[SV45350(ALL)01/95]
Engine
*
[SV45400(ALL)01/95]
q
Start engine every 15 days. Run at fast idle
until it reaches normal operating temperature.
*
[SV45500(ALL)01/95]
q
With your foot on the brake, shift through all
the gears while the engine is running.
%*
[SV45600(ALL)01/95]
Fuel system
%*
[SV45700(ALL)07/94]
q
Fill fuel tank with high-quality unleaded fuel
until the first automatic shutoff of the fuel
pump nozzle.
*
[SV45900(ALL)03/95]
NOTE: During extended periods of vehicle
storage (60 days or more), fuel may
deteriorate due to oxidation. This can
damage rubber and other polymers in
the fuel system and may also clog
small orifices.
*
[SV46000(ALL)01/95]
Ford Gas Stabilizer should be added whenever
actual or expected storage periods exceed 60
days. Follow the instructions on the label. The
vehicle should then be operated at idle speed to
circulate the additive throughout the fuel system.
*
[SV46100(ALL)01/95]
A volatile corrosion inhibitor added to the fuel
system will protect the fuel system's inner
surfaces from corrosion. Follow the instructions
packaged with the product.
File:15fcsvt.ex
Update:Tue Jan 23 13:58:51 1996
ProCarManuals.com

353 % [QI03300( T)03/95]
full page art:0001069-D
3.0L Vulcan Engine Compartment
File:16fcqit.ex
Update:Tue Jan 23 08:16:56 1996
ProCarManuals.com

354 % [QI03500( T)03/95]
full page art:0001439-A3.0L Duratec Engine Compartment
File:16fcqit.ex
Update:Tue Jan 23 08:16:56 1996
ProCarManuals.com

355 [QI03700( T)10/95]
full page art:0001068-C
3.4L SHO Engine Compartment
File:16fcqit.ex
Update:Tue Jan 23 08:16:56 1996
ProCarManuals.com

Index 357
Index
A
ABS warning light
(see Anti-lock brake system)....... 81
Accessory position on the ignition..... 59
Additives, engine oil.......... 273
Air bag supplemental
restraint system............. 23
and child safety seats........ 26,33
description............... 23
disposal................ 31
driver air bag............. 23
indicator light............. 77
operation............... 27
passenger air bag............ 23
proper seating............. 24
service and information labels...... 27
tone generator............. 30
wearing safety belts........... 24
Air cleaner filter
location............... 260
replacing............... 296
specifications............. 329
Air conditioning
electronic automatic temperature
control system............ 95
manual heating and air
conditioning system......... 93
Alarm, activating remote personal.... 135
Antenna, radio
(see Electronic sound system)..... 176
Antifreeze (see Engine coolant)...... 276
Anti-lock brake system (ABS)
description.............. 203
see also Brake............ 202
warning light.............. 81
File:fcixt.ex
Update:Tue Jan 23 08:18:16 1996
ProCarManuals.com