light FORD THUNDERBIRD 1996 10.G Repair Manual

261
%*
[SV34800( ALL)03/95]
Power Steering Fluid
*
[SV34900( ALL)01/95]
Check the level of the power steering fluid at
least twice a year (i.e., every Spring and Fall).
%*
[SV35000( ALL)03/95]
Checking and Adding Power Steering
Fluid
[SV35050( BC )10/95]
3.8L SFI engine
*
[SV35100( ALL)02/95]
1. Start the engine and let it run until the
power steering fluid reaches normal
operating temperature. The power steering
fluid will be at the right temperature when
the engine coolant temperature gauge in the
instrument cluster is near the center of the
NORMAL operating temperature range.
*
[SV35200( ALL)01/95]
2. While the engine idles, turn the steering
wheel back and forth several times. Make
sure that the cap assembly is installed at this
time.
*
[SV35300( ALL)05/95]
3. Turn the engine off.
%*
[SV35400(MBC )03/94]
4. Check the fluid level on the dipstick (which
is highlighted in yellow in your vehicle). The
fluid level should be between the arrows in
the FULL HOT range, which is marked on
the side of the dipstick, opposite the side
marked FULL COLD. Do not add fluid if the
level is within the FULL HOT range.
*
[SV35500(MBC )07/94]
5. If the power steering fluid is low, add fluid
in small amounts, continuously checking the
level, until you reach the FULL HOT range.
Do not overfill.
*
[SV35600(MBC )03/95]
6. When you are finished, put the dipstick back
in and make sure that it fits snugly.
File:rcsvb.ex
Update:Mon Feb 19 10:46:54 1996

274
*
[SV43300( ALL)08/95]
If you replace a circuit breaker, use one with the
same amperage rating. To remove a circuit
breaker mounted in the fuse panel, grip it with
your finger and thumb and pull it straight out
of its socket.
%
*
[SV44400( ALL)03/95]
Lights and Bulb Replacement
*
[SV44500( ALL)01/95]
It is a good idea to check the operation of the
following lights frequently:
*
[SV44600( ALL)01/95]
q
headlamps
*
[SV44700( ALL)01/95]
q
tail lamps
*
[SV44800( ALL)01/95]
q
brakelamps
*
[SV44900( ALL)01/95]
q
hazard flasher
*
[SV44950( ALL)02/95]
q
high-mount brakelamp
*
[SV45000( ALL)01/95]
q
turn signals
*
[SV45200( ALL)01/95]
q
license plate lamp
%*
[SV45600( ALL)01/95]
The alignment of your headlamps should be
checked if:
*
[SV45700( ALL)01/95]
q
oncoming motorists frequently signal you to
turn off your vehicle's high beams when you
do not have the high beams on
*
[SV45800( ALL)01/95]
q
the headlamps do not seem to give you
enough light to see clearly at night
*
[SV45900( ALL)01/95]
q
the headlamp beams are pointed substantially
away from a position slightly down and to
the right
File:rcsvb.ex
Update:Mon Feb 19 10:46:54 1996

281
those which your vehicle or engine was
originally equipped.
*
[SV53150( ALL)05/95]
Ford strongly recommends the use of genuine
Ford replacement parts. If other than Ford or
Motorcraft parts or Ford authorized
remanufactured parts are used for maintenance
replacements or for the service of components
affecting emission control, such non-Ford parts
should be equivalent to genuine Ford Motor
Company parts in performance and durability. It
is the owner's responsibility to determine the
equivalency of such parts. Please consult your
warranty booklet for complete warranty
information.
*
[SV53175( ALL)05/95]
RWARNING
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine
compartment and exhaust system, which
can start a fire.
*
[SV53200( ALL)05/95]
Watch for fluid leaks, strange odors, smoke, loss
of oil pressure, the charge warning light, the
check engine light, or the temperature warning
light. These sometimes indicate that the emission
system is not working properly.
*
[SV53300( ALL)01/95]
Do not make any unauthorized changes to your
vehicle or engine. Changes that cause more
unburned fuel to reach the exhaust system can
increase the temperature of the engine or
exhaust system.
*
[SV53400( ALL)01/95]
By law, anyone who manufactures, repairs,
services, sells, leases, trades vehicles, or
supervises a fleet of vehicles is not permitted to
intentionally remove an emission control device
or prevent it from working. In some of the
United States and in Canada, vehicle owners
may be liable if their emission control device is
removed or is prevented from working.
File:rcsvb.ex
Update:Mon Feb 19 10:46:54 1996

288 [SV55900( BC )03/95]
fourteen pica chart:0010585-K
*
[SV56400( ALL)11/95]
NOTE: Rear axle lube quantities must be
replaced every 100,000 miles
(160,000 km) or if the axle has been
submerged in water. Otherwise, the
lube should not be checked or changed
unless a leak is suspected or repair
required.
%
*
[SV57000( ALL)01/95]
Vehicle Storage
*
[SV57100( ALL)01/95]
Maintenance Tips
*
[SV57150( ALL)01/95]
If you plan on storing your vehicle for an
extended period of time (60 days or more), refer
to the following maintenance recommendations
to ensure your vehicle stays in good operating
condition.
*
[SV57200( ALL)01/95]
General
*
[SV57300( ALL)01/95]
q
Store all vehicles in a dry, ventilated place.
*
[SV57400( ALL)01/95]
q
Protect from sunlight, if possible.
*
[SV57500( ALL)01/95]
q
If vehicles are stored outside, they require
regular maintenance to protect against rust
and damage.
File:rcsvb.ex
Update:Mon Feb 19 10:46:54 1996

289
*
[SV57600( ALL)01/95]
Body
*
[SV57700( ALL)01/95]
q
Wash vehicle thoroughly to remove dirt,
grease, oil, tar or mud from exterior surfaces,
rear wheel housing and underside of front
fenders.
*
[SV57800( ALL)01/95]
q
Periodically wash vehicles stored in exposed
locations.
*
[SV57900( ALL)01/95]
q
Touch-up raw or primed metal to prevent
rust.
*
[SV58000( ALL)01/95]
q
Cover chrome and stainless steel parts with a
thick coat of auto wax to prevent
discoloration. Re-wax as necessary when the
vehicle is washed.
*
[SV58100( ALL)04/95]
q
Lubricate all hood, door and trunk lid hinges
and latches with a light grade oil.
*
[SV58200( ALL)01/95]
q
Cover interior soft trim to prevent fading.
*
[SV58300( ALL)01/95]
q
Keep all rubber parts free from oil and
solvents.
%*
[SV58350( ALL)01/95]
Engine
*
[SV58400( ALL)01/95]
q
Start engine every 15 days. Run at fast idle
until it reaches normal operating temperature.
*
[SV58500( ALL)01/95]
q
With your foot on the brake, shift through all
the gears while the engine is running.
%*
[SV58600( ALL)01/95]
Fuel system
%*
[SV58700( ALL)07/94]
q
Fill fuel tank with high-quality unleaded fuel
until the first automatic shutoff of the fuel
pump nozzle.
*
[SV58900( ALL)03/95]
NOTE: During extended periods of vehicle
storage (60 days or more), fuel may
deteriorate due to oxidation. This can
damage rubber and other polymers in
the fuel system and may also clog
small orifices.
File:rcsvb.ex
Update:Mon Feb 19 10:46:54 1996

290
*
[SV59000( ALL)01/95]
Ford Gas Stabilizer should be added whenever
actual or expected storage periods exceed 60
days. Follow the instructions on the label. The
vehicle should then be operated at idle speed to
circulate the additive throughout the fuel system.
%*
[SV59200( ALL)01/95]
Cooling system
*
[SV59300( ALL)01/95]
q
Protect against freezing temperatures.
%*
[SV59400( ALL)01/95]
Battery
*
[SV59500( ALL)01/95]
q
Check and recharge as necessary.
*
[SV59600( ALL)01/95]
q
Keep connections clean and covered with a
light coat of grease.
*
[SV59650( ALL)03/95]
q
If storing your vehicle for more than 30 days
without recharging the battery, it may be
advisable to disconnect the battery cables to
ensure battery charge is maintained for quick
starting.
[SV59675( ALL)05/94]
NOTE: If battery cables are disconnected, it
will be necessary to reset memory
features.
%*
[SV59700( ALL)01/95]
Brakes
*
[SV59800( ALL)01/95]
q
Make sure brakes and parking brake are fully
released.
%*
[SV59900( ALL)01/95]
Tires
*
[SV60000( ALL)05/95]
q
Maintain recommended air pressure.
*
[SV60100( ALL)01/95]
Miscellaneous
*
[SV60200( ALL)01/95]
q
Make sure all linkages, cables, levers and
clevis pins under vehicle are covered with
grease to prevent rust.
*
[SV60300( ALL)03/95]
q
Move vehicles at least 25 feet (8 m) every 15
days to lubricate working parts and prevent
corrosion.
File:rcsvb.ex
Update:Mon Feb 19 10:46:54 1996

Index 307
Index
A
ABS warning light
(see Anti-lock brake system)....... 58
Accessory position on the ignition..... 45
Additives, engine oil.......... 237
Air bag supplemental restraint system
description............... 18
disposal................ 25
driver air bag............. 18
indicator light............. 60
operation............... 21
proper seating............. 19
tone generator............. 25
wearing safety belts........... 18
Air cleaner filter, location........ 227
Air conditioning
manual heating and air conditioning
system............... 74
semi-automatic temperature control
system............... 77
Alarm, activating remote personal.... 112
Antifreeze (see Engine coolant)...... 240
Anti-lock brake system (ABS)
description.............. 173
see also Brake............ 173
warning light.............. 58
Anti-theft lug nuts and key....... 200
Anti-theft system
arming the system.......... 106
description.............. 104
disarming an untriggered system.... 108
disarming a triggered system..... 109
triggering.............. 108
Assistance (see Customer assistance) . . . 203
Audio system
(see Electronic sound system)..... 131
File:rcixb.ex
Update:Thu Feb 15 12:06:08 1996

308 Index
Autolamp system (see Headlamps)..... 84
Automatic transmission
driving an automatic overdrive..... 165
fluid, checking............ 256
fluid, refill capacities......... 285
fluid, specification........... 287
Axle, traction lok............ 170
B
Backing up............... 167
Basic vehicle warranty........... 3
Battery
acid, treating emergencies....... 185
charging system warning light...... 60
disconnecting............. 248
how to service............ 247
jumping a disabled battery....... 185
maintenance-free........... 247
proper disposal, recycling....... 247
replacement, specifications....... 286
voltage gauge.............. 69
when storing your vehicle....... 290
Brake fluid
brake warning light........... 57
specifications............. 287
Brakelamp
bulb replacement........... 279
high-mount brakelamp........ 277
Brakes
adjustment.............. 173
anti-lock............... 173
anti-lock brake system (ABS)
warning light............. 58
applying the brakes.......... 173
brake warning light........... 57
fluid, checking and adding....... 258
fluid, refill capacities......... 259
fluid, specifications.......... 287
File:rcixb.ex
Update:Thu Feb 15 12:06:08 1996

Index 309
Brakes (continued)
front disc.............. 173
new brake linings............ 4
noise................ 174
parking............... 174
trailer................ 183
when storing your vehicle....... 290
Brake-shift interlock........... 166
Break-in period.............. 4
Bulbs, replacing
headlamps.............. 275
specifications............. 279
C
Canada, customer assistance....... 212
Canadian Motor Vehicle Arbitration Plan
(CAMVAP).............. 212
Capacities for refilling fluids....... 285
Carbon monoxide in exhaust........ 51
Car seats for children
(see Child safety seats)......... 27
Cassette tape player
(see Electronic sound system) . . . 141, 150
Catalytic converter........... 280
CD player
(see Electronic sound system)..... 131
Chains, tires.............. 255
Changing a tire............. 191
Charging system gauge.......... 69
Charging system warning light....... 60
Child safety restraints........... 25
child safety belts............ 43
child safety seats............ 27
Child safety seats
and air bags............ 20,27
automatic locking mode (retractor).... 29
in front seat.............. 29
in rear outboard seat.......... 35
in rear seat............... 42
Chime
key in ignition............. 46
File:rcixb.ex
Update:Thu Feb 15 12:06:08 1996

Index 311
Cooling fan............... 224
Cruise control (see Speed control)..... 97
Customer Assistance Center,
Ford (U.S.).............. 206
Customer Assistance Centre,
Ford of Canada............ 206
D
Dashboard (see Instrument panel)..... 73
Daytime running light system....... 82
Defrost
rear window.............. 81
windshield............. 75,79
Dispute Settlement Board........ 207
Doors
door ajar warning light......... 71
lubricant specifications........ 287
Driving under special conditions
bad weather............. 176
heavy load.............. 178
high water.............. 177
slippery roads............ 176
towing a trailer............ 180
E
Electrical system
circuit breakers............ 273
fuses................ 264
operating when the engine is off..... 45
Electronic sound system
radio reception............ 161
tuning the radio.........133, 152
warranty and service information . . . 164
Electronic stereo cassette radio
(see Electronic sound system)..... 142
Emergencies, roadside
assistance.............. 203
battery acid spills........... 185
jump-starting............. 185
towing................ 201
File:rcixb.ex
Update:Thu Feb 15 12:06:08 1996