power steering FORD THUNDERBIRD 2004 11.G User Guide

If the vehicle’s powertrain system or its battery has just been serviced,
the on-board diagnostics system is reset to a “not ready for I/M test ”
condition. To ready the on-board diagnostics system for I/M testing, a
minimum of 30 minutes of city and highway driving is necessary as
described below:
• First, at least 10 minutes of driving on an expressway or highway.
• Next, at least 20 minutes driving in stop-and-go, city-type traffic with
at least four idle periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete.
POWER STEERING FLUID
Refer to the scheduled maintenance guide for the service interval
schedules. If adding fluid is necessary, use only MERCON AT F.
1. Start the engine and let it run
until it reaches normal operating
temperature (the engine coolant
temperature gauge indicator will be
near the center of the normal area
between H and C).
2. While the engine idles, turn the
steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the
reservoir. It should be between the
MIN and MAX lines. Do not add
fluid if the level is in this range.
5. If the fluid is low, add fluid in
small amounts, continuously
checking the level until it reaches
the range between the MIN and
MAX lines. Be sure to put the cap
back on the reservoir.
M AX
M I
N
M AX
M IN
2004 Thunderbird
(tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Maintenance and Specifications
185

Fluid Ford PartNameApplication Capacity
Engine coolant
2Motorcraft
Premium Gold
Engine Coolant
(yellow-colored) 3.9L-4V V8
engine
11.3L (11.9
quarts)
Power steering
fluid Motorcraft
MERCON
AT F All Fill to MAX line
on reservoir
Rear axle
3Motorcraft SAE
75W-90 Fuel
Efficient High
Performance
Synthetic Rear
Axle Lubricant All 1.2
–1.3L
(2.5 –2.7 pints)
Fuel tank N/A All 68.2L (18.0 gallons)
Transmission
fluid
4Motorcraft
MERCON V
AT F Automatic
(5R55S)
11.2L (11.9
quarts)5
Windshield
washer fluidMotorcraft
Premium
Windshield
Washer
ConcentrateAll Fill to line on
reservoir
1Use only brake fluids certified to meet Ford specifications. Refer to
Lubricant Specifications in this chapter. DOT 3 fluid is recommended.
However, if DOT 3 is not available, DOT 4 fluid can be used.
2Add the coolant type originally equipped in your vehicle.3Your vehicle ’s rear axle is filled with a synthetic rear axle lubricant and
is considered lubricated for life. These lubricants do not need to be
checked or changed unless a leak is suspected, service is required or the
axle assembly has been submerged in water. The axle lubricant should
be changed any time the rear axle has been submerged in water. Fill 6
mm to 14 mm (1/4 inch to 9/16 inch) below bottom of fill hole.
4Ensure the correct automatic transmission fluid is used. MERCON and
MERCON V are not interchangeable. DO NOT MIX MERCON and
MERCON V. Refer to the scheduled maintenance guide to determine
the correct service interval.
2004 Thunderbird (tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Maintenance and Specifications
202

Item Ford partnameFord part
number Ford
specification
Lock cylinders Motorcraft Penetrating and
Lock LubricantXL-1 none
Power steering
fluid Motorcraft
MERCON
AT F XT-2-QDX MERCON

Rear Axle
Lubricant Motorcraft SAE
75W-90 Fuel
Efficient High
Performance
Synthetic Rear
Axle Lubricant
2
XY-75W90-QFEHP
Automatic
transmission
fluid Motorcraft
MERCON
V
AT F
3
XT-5-QM MERCON V
Windshield
washer fluid Motorcraft
Premium
Windshield
Washer
ConcentrateZC-32-A WSB-M8B16
–A2
1Use only brake fluids certified to meet Ford specifications. DOT 3 fluid
is recommended. However, if DOT 3 is not available, DOT 4 fluid can be
used.
2Ford design rear axles contain a synthetic lubricant that does not
require changing unless the axle has been submerged in water.
3Ensure the correct automatic transmission fluid is used. MERCON and
MERCON V are not interchangeable. DO NOT MIX MERCON and
MERCON V. Refer to the scheduled maintenance guide to determine
the correct service interval.
2004 Thunderbird (tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Maintenance and Specifications
204

waxing .....................................157
wheels ......................................158
wiper blades ............................159
Climate control (see Air
conditioning or Heating) ............22
Console ........................................60
Controls power seat .................................74
steering column ........................45
Convertible ..................................50 cleaning .............................54, 160
installation of the boot .............51
lowering the convertible top ...50
raising the convertible top ......52
Coolant checking and adding ..............170
refill capacities ................174, 201
specifications ..................203, 205
Cruise control
(see Speed control) ....................42
Customer Assistance ................125 Ford accessories for your
vehicle .....................................162
Ford Extended Service
Plan ..........................................150
Getting assistance outside the
U.S. and Canada .....................154
Getting roadside assistance ...125
Getting the service you
need .........................................148
Ordering additional owner ’s
literature .................................155
The Dispute Settlement
Board .......................................150
Utilizing the
Mediation/Arbitration
Program ...................................153 D
Daytime running lamps
(see Lamps) ................................27
Defrost
rear window ..............................25
Dipstick automatic transmission
fluid ..........................................186
engine oil .................................165
Doors lubricant specifications ..........203
Driving under special
conditions ..................................120 through water .........................121
E
Emergencies, roadside jump-starting ..........................141
Emergency Flashers .................126
Emission control system ..........183
Engine ........................................205 cleaning ...................................158
coolant .....................................170
fail-safe coolant ......................174
idle speed control ...................168
lubrication
specifications ..................203, 205
refill capacities ........................201
service points ..........................164
Engine block heater .................112
Engine oil ..................................165 checking and adding ..............165
dipstick ....................................165
filter, specifications ........167, 201
recommendations ...................167
refill capacities ........................201
specifications ..................203, 205
2004 Thunderbird (tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Index
213

K
Keyless entry systemautolock .....................................68
Keys positions of the ignition .........109
L
Lamps autolamp system .......................27
bulb replacement
specifications chart ..................31
daytime running light ...............27
headlamps .................................27
headlamps, flash to pass ..........28
instrument panel, dimming .....28
interior lamps .....................30 –31
replacing bulbs .......30, 32, 34 –37
Lane change indicator
(see Turn signal) ........................30
Lights, warning and indicator ....10 anti-lock brakes (ABS) ..........112
Load limits .................................121
Locks autolock .....................................68
doors ..........................................61
Lubricant specifications ...203, 205
Lumbar support, seats ...............74
M
Manual transmission fluid capacities ........................201
lubricant specifications ..........205
Master lighting switch ................27
Mirrors .........................................41 side view mirrors (power) .......41
Motorcraft parts ................179, 201 O
Octane rating ............................178
Oil (see Engine oil) ..................165
P
Parking brake ............................113
Parts (see Motorcraft parts) ....201
Power distribution box
(see Fuses) .......................131, 134
Power door locks ........................61
Power point .................................39
Power steering ..................114
–115
fluid, checking and adding ....185
fluid, refill capacity ................201
fluid, specifications .........203, 205
Power Windows ...........................40
R
Radio ............................................16
Rear window defroster ...............25
Relays ........................................127
Remote entry system .................64 illuminated entry ......................67
locking/unlocking doors ...........61
opening the trunk .....................65
Roadside assistance ..................125
S
Safety Belt Maintenance ............85
Safety belts
(see Safety restraints) .........76 –80
Safety defects, reporting ..........156
Safety restraints ....................76 –80
2004 Thunderbird (tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Index
215

belt minder ...............................81
extension assembly ..................85
for adults .............................77–80
for children ...............................97
safety belt maintenance ...........85
warning light and chime ..........81
Safety seats for children ..........100
Seat belts
(see Safety restraints) ...............76
Seats ............................................73 child safety seats ....................100
Select Shift Transmission
(SST) shifter .............................118
Servicing your vehicle ..............163
Spare tire
(see Changing the Tire) ...........136
Spark plugs,
specifications .....................201, 205
Specification chart,
lubricants ...........................203, 205
Speed control ..............................42
Starting your vehicle ........109 –111
jump starting ..........................141
Steering speed sensitive .......................115
Steering wheel controls ......................................45
tilting .........................................39
T
Tilt steering wheel ......................39
Tires ...........................136, 188 –189
changing ..................136 –137, 141
snow tires and chains ............200
tire grades ...............................189 treadwear ................................189
Towing .......................................124 recreational towing .................124
trailer towing ..........................124
wrecker ....................................147
Traction control ........................113
Transmission .............................115 brake-shift interlock (BSI) ....115
fluid, checking and adding
(automatic) .............................186
fluid, refill capacities ..............201
lubricant specifications ..203, 205
Trunk ...........................................62 remote release ....................41, 65
Turn signal ..................................30
V
Vehicle dimensions ...................205
Vehicle Identification Number
(VIN) ..........................................207
Vehicle loading ..........................121
Ventilating your vehicle ...........112
W
Warning lights (see Lights) .......10
Washer fluid ..............................165
Water, Driving through .............121
Windows power .........................................40
Windshield washer fluid and
wipers ..........................................38 checking and adding fluid .....165
replacing wiper blades .............38
Wrecker towing .........................147
2004 Thunderbird (tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Index
216