fuel filter FORD TRANSIT 2017 5.G Owner's Guide

Other maintenance items
1
Change rear axle fluid.
Replace accessory drive belt(s).
1 Perform these maintenance items within 3000 miles (4800 kilometers) of the last
engine oil and filter change. Do not exceed the designated distance for the interval.
2 Replace early if indicated by per Water In Fuel warning lamp. See Warning Lamps and
Indicators (page 81).
3 Initial replacement at six years or 100000 miles (160000 kilometers), then every three
years or 50000 miles (80000 kilometers).
4 After initial inspection, inspect every other oil change until replaced.
SPECIAL OPERATING
CONDITIONS SCHEDULED
MAINTENANCE
If you operate your vehicle primarily
in any
of the following conditions, you need to
perform extra maintenance as indicated.
If you operate your vehicle
occasionally
under any of these conditions, it is not
necessary to perform the extra
maintenance. For specific
recommendations, see your dealership
service advisor or technician. Perform the services shown in the
following tables when specified or within
3000 miles (4800 kilometers) of the oil
change required message appearing in the
information display.
•
Example 1
: The message appears at
28,750 mi (46,270 km). Perform the
30,000 mi (48,000 km) automatic
transmission fluid replacement.
• Example 2
: The message does not
appear, but the odometer reads
30,000 mi (48,000 km) (for example,
the Intelligent Oil-Life Monitor was
reset at
25,000 mi (40,000 km)).
Perform the engine air filter
replacement. Towing a trailer or using a car-top carrier
Change engine oil and filter as indicated by the information
display and perform services listed in the Normal Scheduled
Maintenance chart.
As required
Inspect and lubricate U-joints.
Inspect frequently,
service as required
See axle maintenance items under
Exceptions.
Replace spark plugs.
Every 60000 miles
(96000 km)
432
Transit (TTH) Canada/United States of America, HK3J 19A321 AA enUSA, Edition date: 04/2016, First Printing Scheduled Maintenance

Exclusive use of E85 (Flex fuel vehicles only)
If ran exclusively on E85, fill the fuel tank full with regular
unleaded fuel.
Every oil change interval
Exceptions
There are several exceptions to the Normal
Schedule:
Normal vehicle axle maintenance: Rear
axles and power take-off units with
synthetic fluid and light-duty trucks
equipped with Ford-design axles are
lubricated for life; do not check or change
fluid unless a leak is suspected, service is
required or the assembly has been
submerged in water. During long periods
of trailer towing with outside temperatures
above 70°F (21°C) and at wide-open
throttle for long periods above 45 mph
(72 km/h), change non-synthetic rear axle
fluid every 30,000 mi (48,000 km) or
three months, whichever comes first. This
interval can be waived if the axle is filled
with 75W85 synthetic gear fluid meeting
Ford specification WSS-M2C942-A or
equivalent. Add friction modifier XL-3
EST-M2C118-A or equivalent for complete
refill of Traction-Lok rear axles. See
Capacities and Specifications
(page
281).
Police, Taxi and Livery vehicle axle
maintenance: Change rear axle fluid every
100,000 mi (160,000 km)
. Rear axle fluid
change may be waived if the axle was filled
with 75W85 synthetic gear fluid meeting
Ford specification WSS-M2C942-A or equivalent. Add four ounces (118 milliliters)
of additive friction modifier XL-3
EST-M2C118-A, or equivalent, for complete
refill of Traction-Lok rear axles. Change
the axle fluid anytime the axle submerges
in water.
California fuel filter replacement: If you
register your vehicle in California, the
California Air Resources Board has
determined that the failure to perform this
maintenance item does not nullify the
emission warranty or limit recall liability
before the completion of your vehicle's
useful life. Ford Motor Company, however,
urges you to have all recommended
maintenance services performed at the
specified intervals and to record all vehicle
service.
Hot climate oil change intervals
:
Vehicles operating in the Middle East,
North Africa, Sub-Saharan Africa or
locations with similar climates using an
American Petroleum Institute (API)
Certified for Gasoline Engines (Certification
mark) oil of SM or SN quality, the normal
oil change interval is 5,000 mi (8,000 km)
.
If the available API SM or SN oils are not
available, then the oil change interval is
3,000 mi (4,800 km)
.
Engine air filter replacement: The life of
the engine air filter is dependent on
exposure to dusty and dirty conditions.
Vehicles operated in these conditions
require frequent inspection and
replacement of the engine air filter.
434
Transit (TTH) Canada/United States of America, HK3J 19A321 AA enUSA, Edition date: 04/2016, First Printing Scheduled Maintenance

Clearing All MyKeys.......................................53
Climate Control..............................................95
Cold Weather Precautions.........................181
Coolant Check See: Engine Coolant Check............................. 218
Crash Sensors and Airbag Indicator.......46
Creating a MyKey............................................52 Programming/Changing Configurable
Settings............................................................... 52
Cruise Control.................................................68 Principle of Operation....................................... 157
Cruise control See: Using Cruise Control................................. 157
Cup Holders
......................................................111
Customer Assistance.................................189
D
Data Recording
..................................................9
Daytime Running Lamps.............................74
Diesel Particulate Filter
...............................115
Regeneration......................................................... 115
Digital Radio..................................................308
HD Radio Reception and Station
Troubleshooting........................................... 309
Direction Indicators........................................74
Doors and Locks..............................................57
DPF See: Diesel Particulate Filter............................ 115
Draining the Fuel Filter Water Trap - 3.2L Power Stroke Diesel.................................224
Changing the Fuel Filter.................................. 224
Purging Air From the Fuel System...............225
Driver Alert
......................................................159
Principle of Operation....................................... 159
Using Driver Alert................................................ 159
Driver and Passenger Airbags...................38 Children and Airbags........................................... 43
Passenger Airbag On and Off Switch ..........38
Proper Driver and Front Passenger Seating Adjustment........................................................ 43
Driving Aids
.....................................................159
Driving Hints...................................................180
Driving Through Water.................................181
DRL See: Daytime Running Lamps......................... 74E
Economical Driving.....................................180
Emission Control System..........................130
Diesel Exhaust System: Oxidation Catalyst
And Diesel Particulate Filter System
........................................................................\
....... 132
Noise Emissions Warranty, Prohibited Tampering Acts and Maintenance.........140
On-Board Diagnostics (OBD-II)..................... 131
Readiness for Inspection/Maintenance (I/M) Testing..................................................... 131
Tampering With a Noise Control System............................................................... 139
End User License Agreement
.................445
VEHICLE SOFTWARE END USER LICENSE
AGREEMENT (EULA) ................................. 445
Engine Block Heater.....................................116 Using the Engine Block Heater....................... 116
Engine Coolant Check
................................218
Adding Coolant.................................................... 219
Coolant Change................................................. 220
Engine Coolant Temperature Management.................................................. 222
Fail-Safe Cooling................................................. 221
Recycled Coolant............................................... 220
Severe Climates................................................. 220
Engine Cooling Fan - Diesel......................218
Engine Cooling Fan - E85/ Gasoline........................................................218
Engine Immobilizer See: Passive Anti-Theft System..................... 62
Engine Oil Check...........................................216 Adding Engine Oil................................................ 217
Engine Oil Dipstick - 3.2L Power Stroke Diesel..............................................................216
Engine Oil Dipstick - 3.5L Ecoboost™..................................................216
Engine Oil Dipstick - 3.7L...........................216
Engine Specifications - 3.2L Power Stroke Diesel
..............................................282
Drivebelt Routing............................................... 282
Engine Specifications - 3.5L Ecoboost™..................................................281
Drivebelt Routing................................................ 281
Engine Specifications - 3.7L.....................281 Drivebelt Routing............................................... 282
473
Transit (TTH) Canada/United States of America, HK3J 19A321 AA enUSA, Edition date: 04/2016, First Printing Index

Entertainment................................................371
AM/FM Radio....................................................... 372
Apps....................................................................... 380
Bluetooth Stereo or USB................................. 379
CD........................................................................\
.... 378
HD Radio ™ Information (If
Available)......................................................... 375
SIRIUS® Satellite Radio (If Activated)......................................................... 372
Sources................................................................... 371
Supported Media Players, Formats and Metadata Information................................ 380
USB Ports............................................................. 380
Environment......................................................14
Essential Towing Checks............................172 Before Towing a Trailer...................................... 177
Launching or Retrieving a Boat or Personal Water Craft (PWC)........................................ 178
Safety Chains........................................................ 173
Tow Hitch............................................................... 173
Trailer Brakes........................................................ 173
Trailer Lamps......................................................... 177
Trailer Towing Connector................................. 172
When Towing a Trailer....................................... 177
Event Data Recording See: Data Recording.............................................. 9
Export Unique Options..................................13
Exterior Mirrors.................................................77
Fold-Away Exterior Mirrors................................ 77
Power Exterior Mirrors......................................... 77
F
Fan See: Engine Cooling Fan - Diesel.................. 218
See: Engine Cooling Fan - E85/ Gasoline............................................................ 218
Fastening the Seatbelts
................................31
Seatbelt Locking Modes.................................... 32
Using Seatbelts During Pregnancy.................31
Floor Mats
........................................................181
Ford Credit.........................................................10
US Only..................................................................... 10
Ford Protect
...................................................425
Ford Protect (CANADA ONLY)..................... 426
Ford Protect Extended Service Plans (U.S. Only).................................................................. 425
Fuel and Refueling
.........................................117 Fuel Consumption
........................................129
Calculating Fuel Economy.............................. 129
Filling the Fuel Tank........................................... 129
Fuel Filler Funnel Location........................122
Fuel Filter - Gasoline
...................................226
Fuel Quality - Diesel....................................120
Biodiesel.................................................................. 121
Diesel Fuel Additives ......................................... 122
Fuel Requirements - Choosing The Right Fuel: Vehicles Operated Where
Ultra-Low Sulfur Diesel Fuel Is Not
Required ........................................................... 120
Fuel Requirements - Choosing the Right Fuel: Vehicles Operated Where
Ultra-Low Sulfur Diesel Fuel is Required
(United States/Canada/Puerto Rico/U.S.
Virgin Islands and Other Locales)...........120
Fuel Quality - E85.........................................118 Choosing the Right Fuel - Flex Fuel
Vehicles.............................................................. 118
Switching Between E85 and Gasoline........119
Fuel Quality - Gasoline................................118 Choosing the Right Fuel.................................... 118
Fuel Shutoff
...................................................184
Fuse Box Locations.....................................196 Body Control Module Fuse Box.................... 196
Engine Compartment Fuse Box................... 196
Passenger Compartment Fuse Box............196
Pre-fuse Box......................................................... 196
Fuses.................................................................196
Fuse Specification Chart............................197 Body Control Module....................................... 207
Engine Compartment Fuse Box.................... 197
Passenger Compartment Fuse Panel........201
Pre-fuse Box........................................................ 205
G
Gauges................................................................79 Engine Coolant Temperature Gauge.............79
Fuel Gauge............................................................. 80
Information Display............................................. 79
Tripmeter Reset and Distance to Empty.................................................................. 80
General Information on Radio Frequencies...................................................48
General Maintenance Information
........427
Multi-point Inspection..................................... 429
474
Transit (TTH) Canada/United States of America, HK3J 19A321 AA enUSA, Edition date: 04/2016, First Printing Index