engine oil FORD TRANSIT 2017 5.G Service Manual

Exclusive use of E85 (Flex fuel vehicles only)
If ran exclusively on E85, fill the fuel tank full with regular
unleaded fuel.
Every oil change interval
Exceptions
There are several exceptions to the Normal
Schedule:
Normal vehicle axle maintenance: Rear
axles and power take-off units with
synthetic fluid and light-duty trucks
equipped with Ford-design axles are
lubricated for life; do not check or change
fluid unless a leak is suspected, service is
required or the assembly has been
submerged in water. During long periods
of trailer towing with outside temperatures
above 70°F (21°C) and at wide-open
throttle for long periods above 45 mph
(72 km/h), change non-synthetic rear axle
fluid every 30,000 mi (48,000 km) or
three months, whichever comes first. This
interval can be waived if the axle is filled
with 75W85 synthetic gear fluid meeting
Ford specification WSS-M2C942-A or
equivalent. Add friction modifier XL-3
EST-M2C118-A or equivalent for complete
refill of Traction-Lok rear axles. See
Capacities and Specifications
(page
281).
Police, Taxi and Livery vehicle axle
maintenance: Change rear axle fluid every
100,000 mi (160,000 km)
. Rear axle fluid
change may be waived if the axle was filled
with 75W85 synthetic gear fluid meeting
Ford specification WSS-M2C942-A or equivalent. Add four ounces (118 milliliters)
of additive friction modifier XL-3
EST-M2C118-A, or equivalent, for complete
refill of Traction-Lok rear axles. Change
the axle fluid anytime the axle submerges
in water.
California fuel filter replacement: If you
register your vehicle in California, the
California Air Resources Board has
determined that the failure to perform this
maintenance item does not nullify the
emission warranty or limit recall liability
before the completion of your vehicle's
useful life. Ford Motor Company, however,
urges you to have all recommended
maintenance services performed at the
specified intervals and to record all vehicle
service.
Hot climate oil change intervals
:
Vehicles operating in the Middle East,
North Africa, Sub-Saharan Africa or
locations with similar climates using an
American Petroleum Institute (API)
Certified for Gasoline Engines (Certification
mark) oil of SM or SN quality, the normal
oil change interval is 5,000 mi (8,000 km)
.
If the available API SM or SN oils are not
available, then the oil change interval is
3,000 mi (4,800 km)
.
Engine air filter replacement: The life of
the engine air filter is dependent on
exposure to dusty and dirty conditions.
Vehicles operated in these conditions
require frequent inspection and
replacement of the engine air filter.
434
Transit (TTH) Canada/United States of America, HK3J 19A321 AA enUSA, Edition date: 04/2016, First Printing Scheduled Maintenance

Brake Fluid Check........................................223
Brakes...............................................................146 General Information.......................................... 146
Breaking-In.....................................................180
Bulb Specification Chart...........................236
C
California Proposition 65.............................10
Capacities and Specifications - 3.2L Power Stroke Diesel................................294
Capacities............................................................ 294
Specifications..................................................... 295
Capacities and Specifications - 3.5L Ecoboost™.................................................288
Capacities............................................................ 288
Specifications..................................................... 289
Capacities and Specifications - 3.7L..................................................................291
Capacities.............................................................. 291
Specifications..................................................... 292
Capacities and Specifications
.................281
Car Wash See: Cleaning the Exterior.............................. 240
Catalytic Converter
......................................123
Driving with a Catalytic Converter................123
Changing a Bulb
............................................231
Central High Mounted Brake Lamp............234
Front Clearance Lamp..................................... 233
Headlamp.............................................................. 231
Interior Lamp....................................................... 234
License Plate Lamp.......................................... 234
Reading Lamps................................................... 235
Rear Lamps.......................................................... 233
Side Direction Indicator................................... 233
Sun Visor Mirror Lamp..................................... 235
Changing a Fuse..........................................209 Fuses...................................................................... 209
Changing a Road Wheel...........................270 Dissimilar Spare Wheel and Tire Assembly
Information
....................................................... 271
Front Jacking Points.......................................... 276
Installing a Road Wheel.................................. 278
Locking Lug Nuts................................................ 272
Rear Jacking Points............................................ 277
Removing a Road Wheel................................. 277
Stowing the Wheel and Vehicle Jack.........279
Vehicle Jack.......................................................... 275Vehicles With a Spare Wheel........................
272
Changing the 12V Battery.........................226 Installing the Battery........................................ 228
Removing the Battery...................................... 226
Changing the Engine Air Filter.................237 Secondary Foam Air Filter.............................. 238
Changing the Engine Oil and Oil Filter.................................................................217
Engine Lubrication for Severe Service Operation.......................................................... 217
Changing the Wiper Blades.....................228 Changing the Windshield Wiper
Blades............................................................... 228
Checking MyKey System Status...............54
Checking the Wiper Blades......................228
Child Restraint and Seatbelt Maintenance.................................................35
Child Restraint Positioning
..........................27
Child Safety.......................................................15
General Information............................................. 15
Child Safety Locks.........................................28 Left-Hand Side..................................................... 28
Right-Hand Side................................................... 29
Cigar Lighter
...................................................109
Cleaning Products.......................................239
Cleaning the Engine.....................................241
Cleaning the Exterior..................................240
Body Paintwork Preservation....................... 240
Cleaning the Chrome Trim............................. 240
Cleaning the Headlamps................................ 240
Cleaning the Rear Window............................ 240
Sliding Door Tracks........................................... 240
Cleaning the Instrument Panel and Instrument Cluster Lens.........................243
Cleaning the Interior
...................................242
Fabric, Carpets, Cloth Seats, Headliners
and Floor Mats............................................... 242
Instrument Cluster Screens, LCD Screens and Radio Screens....................................... 243
Leather Interior.................................................... 242
Rear Windows..................................................... 243
Seatbelts............................................................... 242
Storage Compartments, Cup Holders and Ashtrays............................................................ 243
Suede Micro Fiber Fabric................................ 242
Cleaning the Wheels
..................................244
Cleaning the Windows and Wiper Blades............................................................241
472
Transit (TTH) Canada/United States of America, HK3J 19A321 AA enUSA, Edition date: 04/2016, First Printing Index

Clearing All MyKeys.......................................53
Climate Control..............................................95
Cold Weather Precautions.........................181
Coolant Check See: Engine Coolant Check............................. 218
Crash Sensors and Airbag Indicator.......46
Creating a MyKey............................................52 Programming/Changing Configurable
Settings............................................................... 52
Cruise Control.................................................68 Principle of Operation....................................... 157
Cruise control See: Using Cruise Control................................. 157
Cup Holders
......................................................111
Customer Assistance.................................189
D
Data Recording
..................................................9
Daytime Running Lamps.............................74
Diesel Particulate Filter
...............................115
Regeneration......................................................... 115
Digital Radio..................................................308
HD Radio Reception and Station
Troubleshooting........................................... 309
Direction Indicators........................................74
Doors and Locks..............................................57
DPF See: Diesel Particulate Filter............................ 115
Draining the Fuel Filter Water Trap - 3.2L Power Stroke Diesel.................................224
Changing the Fuel Filter.................................. 224
Purging Air From the Fuel System...............225
Driver Alert
......................................................159
Principle of Operation....................................... 159
Using Driver Alert................................................ 159
Driver and Passenger Airbags...................38 Children and Airbags........................................... 43
Passenger Airbag On and Off Switch ..........38
Proper Driver and Front Passenger Seating Adjustment........................................................ 43
Driving Aids
.....................................................159
Driving Hints...................................................180
Driving Through Water.................................181
DRL See: Daytime Running Lamps......................... 74E
Economical Driving.....................................180
Emission Control System..........................130
Diesel Exhaust System: Oxidation Catalyst
And Diesel Particulate Filter System
........................................................................\
....... 132
Noise Emissions Warranty, Prohibited Tampering Acts and Maintenance.........140
On-Board Diagnostics (OBD-II)..................... 131
Readiness for Inspection/Maintenance (I/M) Testing..................................................... 131
Tampering With a Noise Control System............................................................... 139
End User License Agreement
.................445
VEHICLE SOFTWARE END USER LICENSE
AGREEMENT (EULA) ................................. 445
Engine Block Heater.....................................116 Using the Engine Block Heater....................... 116
Engine Coolant Check
................................218
Adding Coolant.................................................... 219
Coolant Change................................................. 220
Engine Coolant Temperature Management.................................................. 222
Fail-Safe Cooling................................................. 221
Recycled Coolant............................................... 220
Severe Climates................................................. 220
Engine Cooling Fan - Diesel......................218
Engine Cooling Fan - E85/ Gasoline........................................................218
Engine Immobilizer See: Passive Anti-Theft System..................... 62
Engine Oil Check...........................................216 Adding Engine Oil................................................ 217
Engine Oil Dipstick - 3.2L Power Stroke Diesel..............................................................216
Engine Oil Dipstick - 3.5L Ecoboost™..................................................216
Engine Oil Dipstick - 3.7L...........................216
Engine Specifications - 3.2L Power Stroke Diesel
..............................................282
Drivebelt Routing............................................... 282
Engine Specifications - 3.5L Ecoboost™..................................................281
Drivebelt Routing................................................ 281
Engine Specifications - 3.7L.....................281 Drivebelt Routing............................................... 282
473
Transit (TTH) Canada/United States of America, HK3J 19A321 AA enUSA, Edition date: 04/2016, First Printing Index

Headlamp High Beam........................................
73
Lighting Control Positions................................. 72
Parking Lamps....................................................... 72
Lighting...............................................................72 General Information............................................ 72
Load Carrying.................................................164
Load Limit.......................................................164 Special Loading Instructions for Owners of
Pick-up Trucks and Utility-type
Vehicles............................................................. 168
Vehicle Loading - with and without a Trailer................................................................. 164
Load Retaining Fixtures.............................164 Securing Cargo.................................................... 164
Locking and Unlocking
.................................57
Automatic Locking............................................... 61
Automatic Unlocking........................................... 61
Configurable Unlocking...................................... 61
Locking...................................................................... 57
Locking and Unlocking Confirmation............57
Locking and Unlocking the Doors From Inside.................................................................... 57
One-Stage Unlocking.......................................... 61
Opening and Closing the Double Rear Doors.................................................................... 59
Opening and Closing the Sliding Door.........58
Rear Emergency Exit.......................................... 60
Two-Stage Unlocking.......................................... 61
Unlocking................................................................. 57
Zone Re-Locking................................................... 61
Lug Nuts See: Changing a Road Wheel........................ 270
M
Maintenance....................................................211 General Information............................................ 211
Manual Climate Control..............................95
Manual Seats
................................................100
Adjusting the Armrest....................................... 102
Adjusting the Lumbar Support...................... 101
Moving the Seat Backward or Forward............................................................. 100
Recline Adjustment............................................ 101
Media Hub
.......................................................314
Message Center See: Information Displays................................. 85Mirrors
See: Heated Windows and Mirrors................98
See: Windows and Mirrors................................ 76
Mobile Communications Equipment
.......12
Motorcraft Parts - 3.2L Power Stroke Diesel.............................................................285
Motorcraft Parts - 3.5L Ecoboost™.................................................283
Motorcraft Parts - 3.7L..............................284
MyKey Troubleshooting...............................55
MyKey ™..............................................................51
Principle of Operation.......................................... 51
N
Navigation
......................................................386
cityseeker.............................................................. 393
Destination Mode.............................................. 388
Map Mode............................................................ 386
Navigation Map Updates................................ 394
Navigation Menu................................................. 391
SiriusXM Traffic and Travel Link................... 394
Waypoints............................................................ 392
Normal Scheduled Maintenance
..........430
Intelligent Oil-Life Monitor™........................ 430
Normal Maintenance Intervals.................... 430
O
Oil Change Indicator Reset.......................218 Resetting the Oil Life Monitoring
System............................................................... 218
Oil Check See: Engine Oil Check....................................... 216
Opening and Closing the Hood................211 Closing the Hood................................................. 212
Opening the Hood............................................... 211
Ordering Additional Owner's Literature......................................................193
Obtaining a French Owner ’s Manual..........194
Overhead Console
..........................................111
Overhead Storage Compartments................111
P
Parking Aid......................................................152 Switching the Parking Aid System
Off........................................................................\
153
476
Transit (TTH) Canada/United States of America, HK3J 19A321 AA enUSA, Edition date: 04/2016, First Printing Index

Voice Commands for Audio Sources.........343
Using SYNC™ With Your Phone.............319 Accessing Features through the Phone
Menu.................................................................. 324
Accessing Your Phone Settings.................... 327
Bluetooth Devices............................................. 328
Making Calls......................................................... 323
Pairing a Phone for the First Time...............320
Pairing Subsequent Phones........................... 321
Phone Options during an Active Call.........323
Phone Voice Commands................................. 321
Receiving Calls.................................................... 323
System Settings................................................. 329
Text Messaging................................................... 325
Using Traction Control................................149 Switching the System Off............................... 149
System Indicator Lights and Messages.......................................................... 149
Using a Switch..................................................... 149
Using the Information Display Controls............................................................. 149
Using Voice Recognition.............................317 Audio Voice Commands................................. 365
Initiating a Voice Session.................................. 317
Mobile App Voice Commands...................... 368
Navigation Voice Commands........................ 367
Phone Voice Commands............................... 366
SiriusXM Traffic and Travel Link Voice Commands..................................................... 369
System Interaction and Feedback...............318
Voice Settings Commands............................ 369
Using Winter Tires.......................................265
Utilizing the Mediation/Arbitration Program (Canada Only).........................192
V
Vehicle Care
...................................................239
Vehicle Certification Label.......................287
Vehicle Identification Number...............286
Vehicle Storage............................................244
Battery................................................................... 245
Body........................................................................\
245
Brakes.................................................................... 246
Cooling system................................................... 245
Engine.................................................................... 245
Fuel system.......................................................... 245
General.................................................................. 245Miscellaneous.....................................................
246
Removing Vehicle From Storage.................246
Tires........................................................................\
246
Ventilation See: Climate Control........................................... 95
VIN See: Vehicle Identification Number............286
Voice Control
...................................................68
W
Warning Lamps and Indicators..................81 Airbag Warning Lamp.......................................... 81
Anti-Lock Brake System Warning Lamp..................................................................... 81
Brake System Warning Lamp........................... 81
Diesel Warning Lamps........................................ 81
Direction Indicator................................................ 82
Door Ajar.................................................................. 82
Engine Coolant Temperature Warning Lamp.................................................................... 82
Engine Warning Lamps...................................... 82
Fasten Seatbelt Warning Lamp...................... 82
Headlamp High Beam Indicator..................... 82
Ignition Warning Lamp....................................... 82
Lamps on Indicator.............................................. 82
Lane Departure Warning Indicator................82
Low Fuel Level Warning Lamp........................ 83
Low Tire Pressure Warning Lamp.................. 83
Low Washer Fluid Level Warning Lamp.................................................................... 83
Message Center Indicator................................. 83
Oil Pressure Warning Lamp............................. 83
Stability Control and Traction Control Indicator.............................................................. 83
Stability Control and Traction Control Off Warning Lamp.................................................. 83
Transmission Tow/Haul Warning Lamp.................................................................... 83
Washer Fluid Check....................................223
Washers See: Cleaning the Exterior.............................. 240
See: Wipers and Washers................................. 70
Waxing.............................................................240
Wheel Nuts See: Changing a Road Wheel........................ 270
Wheels and Tires..........................................247 General Information.......................................... 247
480
Transit (TTH) Canada/United States of America, HK3J 19A321 AA enUSA, Edition date: 04/2016, First Printing Index