brake fluid FORD WINDSTAR 1996 1.G Owners Manual

68
%*
[LG00475(ALL)06/94]
The Mechanical Cluster
[LG00501(ALL)06/94]
The following warning lights and gauges are on the Mechanical
Cluster. All of these indicators alert you to the status of vehicle
systems or possible problems with your vehicle. Some of the
lights listed are optional. The following section explains each of
the indicators.
[LG00600(ALL)12/93]
Warning and Indicator Lights
%*
[LG00900(ALL)03/95]
Brake System Light
[LG01000(ALL)11/93]
The warning light for the brakes indicates two things Ð that
either the parking brake is on or not fully released, or that the
brake fluid level is low in the master cylinder reservoir. If the
fluid level is low, the brake system should be checked by a
qualified service technician.
[LG01100(ALL)11/93]
6 pica art:0050144-B
The brake system light
[LG01200(ALL)12/93]
The BRAKE light normally comes on when you turn the
ignition key to the ON or START position to verify that the
indicator bulb is working. If the light stays on or comes on
when the engine is running and after you have released the
parking brake fully, have the hydraulic brake system serviced.
*
[LG01300(ALL)05/95]
RWARNING
The BRAKE light indicates that the brakes may not be
working properly. Have the brakes checked immediately.
File:wnlgs.ex
Update:Tue Mar 19 08:25:03 1996

84
[LG10835(ALL)11/93]
6 pica art:0050148-B
The safety belt warning light
%*
[LG10845(ALL)03/95]
Brake System Light
[LG10848(ALL)11/93]
The warning light for the brakes indicates two things Ð that
either the parking brake is on or not fully released, or that the
brake fluid level is low in the master cylinder reservoir. If the
fluid level is low, the brake system should be checked by a
qualified service technician.
[LG10850(ALL)11/93]
6 pica art:0050144-B
The brake system light
[LG10855(ALL)12/93]
The BRAKE light normally comes on when you turn the
ignition key to the ON or START position to verify that the
indicator bulb is working. If the light stays on or comes on
when the engine is running and after you have released the
parking brake fully, have the hydraulic brake system serviced.
*
[LG10858(ALL)05/95]
RWARNING
The BRAKE light indicates that the brakes may not be
working properly. Have the brakes checked immediately.
File:wnlgs.ex
Update:Tue Mar 19 08:25:03 1996

Warning Lights and Gauges
91
% [LG11255(ALL)03/94]
Low Windshield Washer Fluid Level Warning Light
[LG11257(ALL)11/93]
This light indicates that the level of your washer fluid is low,
and you have to add more fluid. This light comes on briefly
after you turn your ignition key from the START to the ON
position. If the washer fluid is low, a one second chime will
sound and the light will remain on for 60 seconds. If the washer
fluid is not low, the light should turn off a few seconds after
the engine has started. The light and chime also come on if the
washer fluid is low when you use your windshield washers.
[LG11258(ALL)03/94]
The washer fluid is only checked when the engine is started or
the windshield washers are in operation. The light will not
come on if the fluid level becomes low while you are driving
unless you turn on the windshield washers.
[LG11260(ALL)12/93]
6 pica art:0050062-B
The low windshield washer indicator light
*
[LG11265(ALL)06/95]
Speed Control Indicator
[LG11270(ALL)05/95]
A SPEED CONTROL light is displayed in the optional electronic
instrument cluster when the speed control system is engaged.
The display will turn off when the brake pedal is pressed or if
speed control is shut off.
*
[LG11275(ALL)05/95]
This display does not indicate any problems with the speed
control, but is simply a convenient way of knowing when it is
active.
File:wnlgs.ex
Update:Tue Mar 19 08:25:03 1996

336
%*
[SV31700(ALL)02/93]
Checking the Automatic Transaxle Fluid
*
[SV31800(ALL)01/93]
With the vehicle on a level surface, start the engine and move
the gearshift lever through all of the gear ranges allowing
sufficient time for each position to engage. Securely latch the
gearshift lever in the P (Park) position, fully set the parking
brake and leave the engine running.
*
[SV32000(ALL)01/93]
Wipe off the dipstick cap, pull the dipstick out and wipe the
indicator end clean. Put the dipstick back into the filler tube and
make sure it is fully seated. Pull the dipstick out and read the
fluid level.
[SV32100(ALL)10/93]
When checking fluid at normal operating temperature, the fluid
level should be within the crosshatched area on the dipstick.
[SV32200(ALL)08/94]
7-1/2 pica art:0050021-A
The automatic transmission dipstick
[SV32250(ALL)11/93]
NOTE: Your vehicle should not be driven until some fluid
has been added if the fluid level is below the bottom
hole on the dipstick and the outside temperature is
above50ÊF (10ÊC). Addonly enough fluid to bring the
level above the bottom hole. The fluid level should be
rechecked at normal operating temperature.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

Servicing Your Windstar
337
%*
[SV32300(ALL)01/95]
Adding Automatic Transaxle Fluid
*
[SV32400(ALL)04/95]
The fluid type is stamped on the dipstick. Before adding any
fluid, be sure that the correct type will be used.
*
[SV32500(ALL)05/95]
Add fluid in 1/2 pint (0.25 liter) increments through the filler
tube to bring the level to the correct area on the dipstick. If an
overfill occurs, excess fluid should be removed by a qualified
technician.
%*
[SV32600(ALL)01/93]
NOTE: Always dispose of used automotive fluids in a
responsible manner. Follow your community's
standards for disposing of these types of fluids. Call
your local recycling center to find out about recycling
automotive fluids.
*
[SV32700(ALL)06/94]
NOTE: Always use Motorcraft MERCONHor equivalent
MERCONHautomatic transaxle fluid when you refill
your automatic transaxle fluid.
%*
[SV32800(ALL)02/95]
Brake Fluid
*
[SV32900(ALL)05/90]
Your vehicle is equipped with a brake fluid level indicator in
the master cylinder which lights the BRAKE warning light on
the instrument panel when the brake fluid level is low.
*
[SV33000(ALL)01/93]
Under normal circumstances, your vehicle should not use up
brake fluid rapidly. However, expect the level of the brake fluid
to slowly fall as you put more mileage on your vehicle and the
brake pads wear.
*
[SV33100(ALL)10/89]
Check the brake fluid at least once a year. You can do this by
looking at the fluid level in the plastic reservoir on the master
cylinder. The fluid level should be at or near the MAX mark.
*
[SV33200(ALL)05/95]
RWARNING
Brake fluid is toxic.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

338
*
[SV33220(ALL)05/95]
If brake fluid contacts eyes, flush eyes with running water for
15 minutes. Get medical attention if irritation persists. If taken
internally, drink water and induce vomiting. Get medical
attention immediately.
%*
[SV33300(ALL)02/95]
If the fluid is low, carefully clean and remove the filler cap
from the reservoir. Fill the reservoir to the MAX line with Ford
High Performance DOT 3 Brake Fluid C6AZ-19542-AA or DOT
3 equivalent fluid meeting Ford specification ESA-M6C25-A.
[SV33550(ALL)05/95]
13-1/2 pica
art:0050216-B
The brake fluid reservoir
*
[SV33600(ALL)01/95]
RWARNING
If you use a brake fluid that is not DOT 3, you will
cause permanent damage to your brakes.
*
[SV33700(ALL)01/95]
Do not fill the reservoir above the MAX line.
*
[SV33800(ALL)01/95]
If you find that the fluid level is excessively low Ð below the
seam or ridge on the outside of the plastic reservoir Ð have the
brake system inspected.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

Servicing Your Windstar
339
*
[SV33900(ALL)01/95]
RWARNING
Do not let the reservoir for the master cylinder run dry.
This may cause the brakes to fail.
%*
[SV34100(ALL)02/95]
Power Steering Fluid
*
[SV34200(ALL)01/95]
Check the level of the power steering fluid at least twice a
year (i.e., every Spring and Fall).
*
[SV34300(ALL)03/95]
To check the level of your power steering fluid:
[SV34400(ALL)02/95]1.
Start the engine and let it run until the power steering fluid
reaches normal operating temperature. The power steering
fluid will reach the right temperature after at least five
minutes of idling or at least one mile (1 km) of driving.
*
[SV34500(ALL)01/95]2.
While the engine idles, turn the steering wheel back and
forth several times. Make sure that the cap assembly is
installed at this time.
*
[SV34600(ALL)03/93]3.
Then turn the engine off.
*
[SV34700(ALL)01/93]4.
Check the fluid level in the power steering fluid reservoir.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

382
Audio system (see Electronic sound system)....... 195
Autolamp system (see Headlamps)........... 123
Autolock (see Keyless entry).............. 154
Automatic transaxle
driving with.................... 235
fluid, adding.................... 337
fluid, checking................... 336
fluid, refill capacities................ 363
fluid, specification.................. 365
B
Backing up...................... 236
Basic vehicle warranty.................. 3
Battery
acid, treating emergencies............261, 325
battery saver.................... 151
charging system warning light........... 72,85
how to service................... 323
jumping a disabled battery.............. 261
maintenance-free.................. 323
proper disposal, recycling.............. 324
when storing your vehicle.............. 368
Brake fluid
brake warning light................ 68,84
checking and adding................ 337
specifications..................338, 365
Brakelamp, bulb replacement.............. 354
Brakes
adjustment..................... 240
anti-lock...................... 240
anti-lock brake system (ABS) warning light..... 69,88
applying the brakes................. 243
brake warning light................ 68,84
fluid, checking and adding.............. 337
fluid, specifications...............338, 365
front disc...................... 240
if brakes do not grip well.............. 242
new brake linings................... 4
File:wnixs.ex
Update:Tue Mar 19 08:12:49 1996

383
Index
Brakes (continued)
noise........................ 242
parking...................... 244
stopping distances.................. 243
trailer....................... 256
when storing your vehicle.............. 368
Brake-shift interlock.................. 236
Break-in period..................... 4
Built-in child seat
cleaning....................... 37
operation....................... 27
Bulbs, replacing
headlamps..................... 352
specifications.................... 358
C
Canada, customer assistance.............. 292
Canadian Motor Vehicle Arbitration Plan (CAMVAP) . . . 292
Capacities for refilling fluids.............. 363
Carbon monoxide in exhaust............... 62
Cargo net....................... 192
Car seats for children (see Child safety seats)....... 39
Cassette tape player
(see Electronic sound system)......213, 225, 228
Catalytic converter................... 359
CD player (see Electronic sound system)......... 201
Chains, tires...................... 333
Changing a tire.................... 267
Charging system warning light............ 72,85
Childproof locks.................... 144
Child safety restraints.................. 25
built-in child seat................... 27
child safety belts................... 38
child safety seats................... 39
Child safety seats
and air bags................... 20,39
attaching with tether straps.............. 50
File:wnixs.ex
Update:Tue Mar 19 08:12:49 1996

391
Index
Lamps (continued)
illuminated mirrors................. 191
interior lamps.................... 125
map lamps..................... 127
trailer....................... 256
Lane change indicator (see Turn signal)......... 129
Lap belts........................ 17
Liftgate........................ 158
Lights, warning and indicator
airbag...................... 74,85
anti-lock brakes (ABS)............... 69,88
anti-theft...................... 104
brake...................... 68,84
charging system.................. 72,85
check engine................... 70,86
door ajar..................... 74,90
hazard warning light................. 93
high beam.................... 75,90
low fuel....................... 76
low washer fluid................. 76,91
oil pressure.................... 73,89
safety belt.................... 69,83
speed control...................91,142
theft system.................... 104
traction control system................ 102
turn signal indicator................ 75,92
Load limits, trailer towing............... 254
Lubricant specifications................. 365
Luggage rack..................... 193
Lug nuts
anti-theft...................... 273
tightening sequence................. 278
Lumbar support pad.................. 170
M
Maintenance (see servicing)............... 301
Map pockets..................... 185
File:wnixs.ex
Update:Tue Mar 19 08:12:49 1996