climate control FORD WINDSTAR 2002 2.G User Guide

If an overfill occurs, excess fluid
should be removed by a qualified
technician.
An overfill condition of
transmission fluid may cause shift and/or engagement concerns
and/or possible damage.
INFORMATION ABOUT UNIFORM TIRE QUALITY GRADING
New vehicles are fitted with tires
that have a rating on them called
Tire Quality Grades. The Quality
grades can be found where
applicable on the tire sidewall
between tread shoulder and
maximum section width. For
example:
²Treadwear 200 Traction AA Temperature A
These Tire Quality Grades are determined by standards that the United
States Department of Transportation has set.
Tire Quality Grades apply to new pneumatic tires for use on passenger
cars. They do not apply to deep tread, winter-type snow tires,
space-saver or temporary use spare tires, tires with nominal rim
diameters of 10 to 12 inches or limited production tires as defined in
Title 49 Code of Federal Regulations Part 575.104(c)(2).
U.S. Department of Transportation-Tire quality grades:The U.S.
Department of Transportation requires Ford to give you the following
information about tire grades exactly as the government has written it.
Treadwear
The treadwear grade is a comparative rating based on the wear rate of
the tire when tested under controlled conditions on a specified
government test course. For example, a tire graded 150 would wear one
and one-half (1 1/2) times as well on the government course as a tire
graded 100. The relative performance of tires depends upon the actual
conditions of their use, however, and may depart significantly from the
norm due to variations in driving habits, service practices, and
differences in road characteristics and climate.
DON’T ADD IF IN CROSSHATCH AREA--CHECH WHEN HOT-IDLING
Maintenance and Specifications
271

Make sure that all replacement tires are of the same size, type,
load-carrying capacity and tread design (e.g., ªAll Terrainº, etc.),
as originally offered by Ford.
Do not replace your tires with ªhigh performanceº tires or larger
size tires.
Failure to follow these precautions may adversely affect the
handling of the vehicle and make it easier for the driver to lose
control and roll over.
Tires that are larger or smaller than your vehicle's original tires may also
affect the accuracy of your speedometer.
SNOW TIRES AND CHAINS
Driving too fast for conditions creates the possibility of loss of
vehicle control. Driving at very high speeds for extended periods
of time may result in damage to vehicle components.
Snow tires must be the same size and grade as the tires you
currently have on your vehicle.
The tires on your vehicle have all weather treads to provide traction in
rain and snow. However, in some climates, you may need to use snow
tires and chains. If you need to use chains, it is recommended that steel
wheels (of the same size and specifications) be used as chains may chip
aluminum wheels.
Follow these guidelines when using snow tires and chains:
²Do not use tire chains with 215/65R16 and P225/60R16 size tires.
²Use only SAE Class S chains.
²Install chains securely, verifying that the chains do not touch any
wiring, brake lines or fuel lines.
²Drive cautiously. If you hear the chains rub or bang against your
vehicle, stop and re-tighten the chains. If this does not work, remove
the chains to prevent damage to your vehicle.
Maintenance and Specifications
276

S
Safety belts (see Safety
restraints) ....15, 141, 144, 146, 148
Safety defects, reporting ..........234
Safety
restraints ...........141, 144, 146, 148
belt minder .............................150
cleaning the safety
belts .................................154, 240
extension assembly ................154
for adults .........................146, 148
for children .....................162±163
lap belt ....................................149
Occupant Classification
Sensor ......................................142
warning light and
chime ...................12, 15, 149±150
Safety seats for children ..........164
Seat belts
(see Safety restraints) .............141
Seats ..........................................129
child safety seats ....................164
cleaning ...................................239
memory seat ...........................132
SecuriLock passive
anti-theft system ...............124±126
Servicing your vehicle ..............242
Spark plugs,
specifications .............277, 280±281
Specification chart,
lubricants ...........................279±280
Speed control ..............................90
Speedometer ...............................17
Starting your vehicle ........175±177
jump starting ..........................218Steering wheel
controls ................................81, 90
tilting .........................................81
T
Tachometer .................................18
Temperature control
(see Climate control) .................58
Tire warning ..............................272
Tires ...........................212, 271±272
changing ..................212±213, 215
checking the pressure ............274
replacing ..................................275
rotating ....................................274
snow tires and chains ............276
tire grades ...............................272
treadwear ................................271
Towing .......................................195
recreational towing .................198
trailer towing ..........................195
wrecker ....................................223
Traction control ........................182
active light ................................13
off light ......................................13
Transaxle
automatic operation ...............186
fluid, refill capacities ..............278
lubricant specifications ..........280
Transmission
fluid, checking and adding
(automatic) .............................269
lubricant specifications ..........279
Trip odometer .............................18
Turn signal ............................15, 71
Index
292