tires FORD WINDSTAR 2002 2.G User Guide

²Vehicle speeds less than 30 km/h (20 mph), greater than 120 km/h
(70 mph) or driving duration less than 10 miles.
²Transporting a heavy load or towing a trailer.
²A different tire was replace and was not the same brand, type, size,
speed rating, load carrying capacity and DOT code as the other tire on
the same axle.
The low tire warning feature can be turned off by your dealer.
Checking the tire pressure
²Use an accurate tire pressure gauge.
²Check the tire pressure when tires are cold, after the vehicle has been
parked for at least one hour or has been driven less than 5 km (3
miles).
²Adjust tire pressure to recommended specifications found on the
Certification Label.
Improperly inflated tires can affect vehicle handling and can fail
suddenly, possibly resulting in loss of vehicle control.
Tire rotation
Because your vehicle's tires perform different jobs, they often wear
differently. To make sure your tires wear evenly and last longer, rotate
them as indicated in the scheduled maintenance guide. If you notice that
the tires wear unevenly, have them checked.
Maintenance and Specifications
274

²Four tire rotation
Replacing the tires
Replace the tires when the wear
band is visible through the tire
treads.
When replacing full size tires, never mix radial bias-belted, or
bias-type tires. Use only the tire sizes that are listed on the
Certification Label. Make sure that all tires are the same size, speed
rating, and load-carrying capacity. If one tire needs to be replaced
sooner than the other on the same axle replace it with the same brand,
type, size, speed rating, load carrying capacity and DOT code as the
other tire. Note: tires on the same axle (front or rear) must match for
the low tire warning system to function properly. Use only the tire
combinations recommended on the label. If you do not follow these
precautions, your vehicle may not drive properly and safely.
Maintenance and Specifications
275

Make sure that all replacement tires are of the same size, type,
load-carrying capacity and tread design (e.g., ªAll Terrainº, etc.),
as originally offered by Ford.
Do not replace your tires with ªhigh performanceº tires or larger
size tires.
Failure to follow these precautions may adversely affect the
handling of the vehicle and make it easier for the driver to lose
control and roll over.
Tires that are larger or smaller than your vehicle's original tires may also
affect the accuracy of your speedometer.
SNOW TIRES AND CHAINS
Driving too fast for conditions creates the possibility of loss of
vehicle control. Driving at very high speeds for extended periods
of time may result in damage to vehicle components.
Snow tires must be the same size and grade as the tires you
currently have on your vehicle.
The tires on your vehicle have all weather treads to provide traction in
rain and snow. However, in some climates, you may need to use snow
tires and chains. If you need to use chains, it is recommended that steel
wheels (of the same size and specifications) be used as chains may chip
aluminum wheels.
Follow these guidelines when using snow tires and chains:
²Do not use tire chains with 215/65R16 and P225/60R16 size tires.
²Use only SAE Class S chains.
²Install chains securely, verifying that the chains do not touch any
wiring, brake lines or fuel lines.
²Drive cautiously. If you hear the chains rub or bang against your
vehicle, stop and re-tighten the chains. If this does not work, remove
the chains to prevent damage to your vehicle.
Maintenance and Specifications
276

²If possible, avoid fully loading your vehicle.
²Remove the tire chains when they are no longer needed. Do not use
tire chains on dry roads.
²The suspension insulation and bumpers will help prevent vehicle
damage. Do not remove these components from your vehicle when
using snow tires and chains.
MOTORCRAFT PART NUMBERS
Component 3.8L OHV V6 engine
Air filter element FA-1616
Fuel filter FG-986B
Battery (standard) BXT-65-650
Battery (optional) BXT-65-750
Oil filter FL-400S
PCV valve EV-152
Spark plugs* AWSF-42EE***
* Refer to Vehicle Emissions Control Information (VECI) decal for spark
plug gap information.
*** If a spark plug is removed for inspection, it must be reinstalled in the
same cylinder. Cylinders No. 1, 2, and 3 have a ªEGº suffix. Cylinders No.
4, 5, and 6 have a ªEº suffix. If a spark plug needs to be replaced, use
only spark plugs with the service part number suffix letter ªEEº as
shown on the engine decal.
Maintenance and Specifications
277

S
Safety belts (see Safety
restraints) ....15, 141, 144, 146, 148
Safety defects, reporting ..........234
Safety
restraints ...........141, 144, 146, 148
belt minder .............................150
cleaning the safety
belts .................................154, 240
extension assembly ................154
for adults .........................146, 148
for children .....................162±163
lap belt ....................................149
Occupant Classification
Sensor ......................................142
warning light and
chime ...................12, 15, 149±150
Safety seats for children ..........164
Seat belts
(see Safety restraints) .............141
Seats ..........................................129
child safety seats ....................164
cleaning ...................................239
memory seat ...........................132
SecuriLock passive
anti-theft system ...............124±126
Servicing your vehicle ..............242
Spark plugs,
specifications .............277, 280±281
Specification chart,
lubricants ...........................279±280
Speed control ..............................90
Speedometer ...............................17
Starting your vehicle ........175±177
jump starting ..........................218Steering wheel
controls ................................81, 90
tilting .........................................81
T
Tachometer .................................18
Temperature control
(see Climate control) .................58
Tire warning ..............................272
Tires ...........................212, 271±272
changing ..................212±213, 215
checking the pressure ............274
replacing ..................................275
rotating ....................................274
snow tires and chains ............276
tire grades ...............................272
treadwear ................................271
Towing .......................................195
recreational towing .................198
trailer towing ..........................195
wrecker ....................................223
Traction control ........................182
active light ................................13
off light ......................................13
Transaxle
automatic operation ...............186
fluid, refill capacities ..............278
lubricant specifications ..........280
Transmission
fluid, checking and adding
(automatic) .............................269
lubricant specifications ..........279
Trip odometer .............................18
Turn signal ............................15, 71
Index
292