adding oil FORD WINDSTAR 2002 2.G Owners Manual

²If the oil level is below the MIN
mark, add enough oil to raise the
level within the MIN-MAX range.
²Oil levels above the MAX mark may cause engine damage. Some oil
must be removed from the engine by a service technician.
7. Put the indicator back in and ensure it is fully seated.
Adding engine oil
1. Check the engine oil. For instructions, refer toChecking the engine
oilin this chapter.
2. If the engine oil level is not within the normal range, add only certified
engine oil of the recommended viscosity. Remove the engine oil filler cap
and use a funnel to pour the engine oil into the opening.
3. Recheck the engine oil level. Make sure the oil level is not above the
MAX mark on the engine oil level indicator (dipstick).
4. Install the indicator and ensure it is fully seated.
5. Fully install the engine oil filler cap by turning the filler cap clockwise
1/4 of a turn until three clicks are heard or until the cap is fully seated.
To avoid possible oil loss, DO NOT operate the vehicle with the
engine oil level indicator and/or the engine oil filler cap removed.
Maintenance and Specifications
247

ENGINE COOLANT
Checking engine coolant
The concentration and level of engine coolant should be checked at the
mileage intervals listed in the scheduled maintenance guide. The coolant
concentration should be maintained at 50/50 coolant and water, which
equates to a freeze point of -36É C (-34É F). Coolant concentration
testing is possible with a hydrometer or antifreeze tester (such as the
Rotunda Battery and Antifreeze Tester, 014±R1060). The level of coolant
should be maintained at the ªcold fullº of ªcold fill rangeº level in the
coolant reservoir. If the level falls below, add coolant per the instructions
in theAdding Engine Coolantsection.
Your vehicle was factory-filled with a 50/50 engine coolant and water
concentration. If the concentration of coolant falls below 40% or above
60%, the engine parts could become damaged or not work properly.A
50±50 mixture of coolant and water provides the following:
²Freeze protection down to -36É C (-34É F).
²Boiling protection up to 129É C (265É F).
²Protection against rust and other forms of corrosion.
²Enables calibrated gauges to work properly.
Maintenance and Specifications
252

in rear seat ......................165, 167
tether anchorage
hardware .................................168
Cleaning your vehicle
engine compartment ..............237
exterior ....................................241
instrument cluster lens ..........239
instrument panel ....................239
interior .....................................239
plastic parts ............237±238, 240
safety belts ..............................240
washing ....................................235
waxing .....................................235
wheels ......................................236
windows ..................................240
wiper blades ............................238
woodtone trim ........................238
Clock ..........................22, 31, 37, 48
Compass, electronic ............88, 107
Console ........................................94
overhead ....................................82
Controls
power seat ...............................130
Coolant
checking and adding ..............252
refill capacities ................256, 278
specifications ..................279±280
Cruise control
(see Speed control) ....................90
Cupholder(s) .............................134
Customer Assistance ................200
Ford accessories for your
vehicle .....................................241
Ford Extended Service
Plan ..........................................227
Getting assistance outside
the U.S. and Canada ..............231Getting roadside
assistance ................................200
Getting the service
you need .................................225
Ordering additional
owner's literature ...................232
The Dispute Settlement
Board .......................................228
Utilizing the Mediation/
Arbitration Program ...............231
D
Daytime running lamps
(see Lamps) ................................67
Defrost
rear window ..............................66
Dipstick
automatic transmission
fluid ..........................................269
engine oil .................................246
Doors
door ajar warning .....................14
lubricant specifications ..........279
power sliding ............................83
Driving under special
conditions
through water .........................192
E
Emergencies, roadside
jump-starting ..........................218
Emission control system ..........265
Engine ................................280±281
check engine/service engine
soon light ..................................10
cleaning ...................................237
coolant .....................................252
Index
288

idle speed control ...................249
lubrication
specifications ..................279±280
refill capacities ........................278
service points ..........................244
starting after a collision .........201
Engine block heater .................178
Engine oil ..................................246
change oil soon warning,
message center .......................246
checking and adding ..............246
dipstick ....................................246
filter, specifications ........248, 277
recommendations ...................248
refill capacities ........................278
specifications ..................279±280
Exhaust fumes ..........................178
F
Floor mats ...................................96
Fluid capacities .........................278
Fuel ............................................257
calculating fuel economy .......262
cap .....................................11, 259
capacity ...................................278
choosing the right fuel ...........260
comparisons with EPA fuel
economy estimates .................265
detergent in fuel .....................261
filling your vehicle
with fuel ..................257, 259, 262
filter, specifications ........262, 277
fuel pump shut-off switch .....201
gauge .........................................17
improving fuel economy ........262
low fuel warning light ..............14
octane rating ...........260, 280±281
quality ......................................261
running out of fuel .................261safety information relating
to automotive fuels ................257
Fuses ..................................203±204
G
Garage door opener ..............82, 96
Gas cap (see Fuel cap) ......11, 259
Gas mileage
(see Fuel economy) .................262
Gauges .........................................16
engine coolant temperature
gauge .........................................16
fuel gauge ..................................17
odometer ...................................17
speedometer .............................17
tachometer ................................18
trip odometer ............................18
GAWR (Gross Axle Weight
Rating) .......................................193
calculating ...............................194
definition .................................193
driving with a heavy load ......193
location ....................................193
GVWR (Gross Vehicle Weight
Rating) .......................................193
calculating .......................193±194
definition .................................193
driving with a heavy load ......193
location ....................................193
H
Hazard flashers .........................201
Head restraints .................129, 133
Headlamps ...................................67
aiming ..................................69±70
autolamp system .......................67
bulb specifications ....................73
Index
289

overdrive off ..............................14
safety belt .................................12
traction control active ..............13
traction control off ...................13
turn signal indicator .................15
Load limits .................................193
GAWR ......................................193
GVWR ......................................193
trailer towing ..........................193
Locks
autolock ...................................121
childproof ................................114
Low tire warning .......................272
Lubricant
specifications .....................279±280
Lumbar support, seats .............132
M
Message center .........................100
english/metric button .............101
system check button ..............101
warning messages ...................102
Mirrors .........................................81
automatic dimming rearview
mirror ........................................88
fold away ...................................89
heated ........................................89
side view mirrors (power) .......88
Motorcraft parts ................262, 277
O
Octane rating ............................260
Odometer .....................................17
Oil (see Engine oil) ..................246
Overdrive .............................93, 187P
Panic alarm feature,
remote entry system ................118
Parking brake ............................181
Parts
(see Motorcraft parts) ..............277
Passenger Occupant
Classification Sensor .................142
Pedals (see Power adjustable
foot pedals) .................................90
Power distribution box
(see Fuses) ...............................208
Power door locks ..............113, 121
Power steering ..........................185
fluid, checking and adding ....267
fluid, refill capacity ................278
fluid, specifications .........279±280
R
Rear window defroster ...............66
Relays ........................................203
Remote entry system .......114, 118
illuminated entry ......68, 121±122
locking/unlocking
doors ........................113, 115±117
panic alarm .............................118
replacement/additional
transmitters .............................120
replacing the batteries ...........119
Reverse sensing system ...........190
Roof rack ...................................112
Index
291