check transmission fluid GMC C-SERIES 1999 User Guide

yellowblue
7-17 99,000 Miles (165 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
100,000 Miles (166 000 km)

Change power steering fluid (or every 36 months,
whichever occurs first). (13)

Front axle service (or every 36 months, whichever
occurs first). (38)

Rear axle service
-- Eaton, Rockwell, Spicer Axles
(or every 12 months, whichever occurs first). (1)(37)

Exhaust brake service (if equipped). Check for
excessive spindle free play and smooth operation.
Lubricate ball joint cap.

Accelerator control cable replacement (diesel) (or
every 36 months, whichever occurs first). (19)

Air brake service (or every 12 months, or
3,600 hours, whichever occurs first). (44)
150,000 Miles (240 000 km)

Cooling system service (or every 60 months since
last service, whichever occurs first). (3)(35)
200,000 Miles (320 000 km)

Remove, disassemble, clean and inspect the air brake
trailer supply valve (or every 2 years, or 7,200 hours,
whichever occurs first).
250,000 Miles (400 000 km)

Wheel bearings service -- Eaton Axle (oil-filled) (or
every 36 months, whichever occurs first). (2)(23)

Rear axle service
-- Eaton, Rockwell, Spicer Axles
(or every 36 months, whichever occurs first). (2)(37)

Manual transmission fluid replacement (or every
60 months, whichever occurs first).
300,000 Miles (480 000 km)

Remove, disassemble, clean and inspect the air brake
air dryer (or every 3 years, or 10,800 hours,
whichever occurs first). Replace dessicant on
Bendix
-Westinghouse units.
ProCarManuals.com

yellowblue
7-18 Footnotes

= The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle's useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
(1) = If your vehicle has an Allison automatic
transmission, your GM Owner's Manual is
supplemented by an Allison Transmission Operator's
Manual. Always refer to these manuals for related
maintenance services.
(2) = Check the fluid level in the manual transmission.
(3) = An Emission Control Service.
(4) = A Noise Emission Control Device.
(5) = Applies only to vehicles sold in the United States.
(6) = Check fluid level in brake master cylinder, clutch
master cylinder (if equipped), power steering pump,
axle, transmission and hydraulic spring parking brake
pump (if equipped). A low fluid level in the brake
master cylinder can indicate worn brake linings and
should be checked accordingly.(7) = Inspect brake lines and hoses for proper hook
-up,
binding, leaks, cracks, chafing, etc. Inspect disc brake
pads for wear and rotors for surface condition. Check
brake pedal for excessive free play or travel (or every
6 months, whichever occurs first) and have serviced if
needed. Check brakes more often if driving habits and
conditions result in frequent braking.
(8) = Inspect hydraulic parking brake drum and linings
for wear or cracks and check linkage and adjustment.
Check spring brake actuator and pump for leaks.
Note: The spring brake section of the actuator is
non
-serviceable.
(9) = This vehicle has an Engine Oil Life Monitor. This
monitor will show you when to change the engine oil
and filter
-- usually between 3,000 miles (5 000 km) and
7,500 miles (12 500 km) since your last oil change.
Under severe conditions, the indicator may come on
before 3,000 miles (5 000 km). Never drive your vehicle
more than 7,500 miles (12 500 km) or 12 months
without an oil and filter change.
The system won't detect dust in the oil. So if you drive
in a dusty area, be sure to change your oil and filter
every 3,000 miles (5 000 km) or sooner if the Change
Oil Light comes on. Remember to reset the Oil Life
Monitor whenever the oil is changed. For more
information, see ªChange Oil Lightº in the Index.
ProCarManuals.com

yellowblue
7-19
(10) = Check clutch pedal for free travel. Press pedal
by hand until resistance is felt. Free travel should be
maintained at 1.5 to 2 inches (38 to 51 mm) measured
at the clutch pedal pad. Make checks at 3,000 miles
(5 000 km) and 6,000 miles (10 000 km) and then every
6,000 miles (10 000 km) thereafter.
(11) = Inspect rear axle air shift motor for fluid leaks.
Remove plug to check fluid level. Inspect air lines and
hoses for proper hook
-up, binding, leaks, etc. Inspect at
3,000 miles (5 000 km) and 24,000 miles (40 000 km)
and then every 24,000 miles (40 000 km) thereafter.
(12) = Chassis Lubrication Service: Lubricate all grease
fittings in front suspension, front axle and steering
linkage. DO NOT lubricate kingpin bushings with air
pressure equipment; instead, use a hand grease gun to
ensure complete purge and eliminate sealer cap
distortion. Lubricate transmission and shift linkage,
hood latches and hood hinges, parking brake lever pivot,
clevis pins and linkage, disc brake caliper rails, clutch
linkage and release bearing (if equipped), propeller shaft
slip joint, universal joint, brake camshaft bracket, slack
adjusters, pedal shaft, clutch cross shaft and clutch pedal
springs. Lubricate suspension, axle and steering linkage
more often when operating under dusty or muddy
conditions and in excessive off
-road use.(13) = Check steering system:

Look for damaged, loose or missing parts. Also
look for parts showing signs of wear or lack of
lubrication. Replace parts as needed. Also check
steering gear mounting bolts, pitman arm nut, gear
housing upper cover and side cover attaching bolts,
steering column mounting bolts and cardan
joint clamp bolts; tighten if necessary.
(See service manual.)

Inspect power steering hoses, tubes and fittings for
leaks. Hoses and lines must not be twisted, kinked or
tightly bent. Make sure clips, clamps, supporting
tubes and hoses are in place and properly secured.

Check steering gear for leakage around pitman shaft
and housing. If leakage is evident (lubricant
oozing out, not just oily film), leak should be
corrected immediately.
(14) = Check front and rear suspension. Look for
damaged, loose or missing parts or parts showing signs
of wear or lack of lubrication. Replace parts as needed.
(15) = Adjust tire pressures as indicated on the
Certification/Tire label for optimum tire life. See ªTiresº
in the Index for further details. Check tires for excessive
or abnormal wear or damage. Also check for damaged
wheels. Replace wheels and/or tires as needed.
ProCarManuals.com

9-yellowblue
9-1
Section 9 Index
A
ir
Brake System Warning Light 2-59 . . . . . . . . . . . . . . . . . . . .
Cleaner 6-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaner Filter 6-77 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Compressor Filter 6-77 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Conditioning 3-5, 6-77 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Conditioning Refrigerants 6-77 . . . . . . . . . . . . . . . . . . . . . .
Dryer 6-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Filter Restriction Indicator 6-17 . . . . . . . . . . . . . . . . . . . . . .
Suspension 2-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Brake Systems 6-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Dryer 6-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Alcohol Injector 6-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Moisture Ejector 6-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Alcohol Injector 6-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Alignment and Balance, Tire 6-51 . . . . . . . . . . . . . . . . . . . . . .
AM-FM Stereo 3-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
AM-FM Stereo with Remote Cassette Tape Player 3-10 . . . . .
Antenna 3-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Antifreeze 6-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti-Lock
Brakes 4-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake System Warning Light 2-61, 4-7 . . . . . . . . . . . . . . . .
Appearance Care 6-59 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Appearance Care Materials 6-66 . . . . . . . . . . . . . . . . . . . . . . . Apply Park Brake Warning Light 2
-60 . . . . . . . . . . . . . . . . . .
Ashtray 2-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio Systems 3-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic Transmission Fluid 6-18 . . . . . . . . . . . . . . . . . . . . .
Automatic Transmission Shift Indicator Check 7-25 . . . . . . . .
Auxiliary Power Jacks 2-48 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Axle, Rear 6-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Airshift Control 2-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Differential Lock Control 2-41 . . . . . . . . . . . . . . . . . . . . . . .
Fluid Capacity 6-76 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shift Motor 6-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tw o-Speed Electric Shift Control 2-17 . . . . . . . . . . . . . . . .
Towing 5-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery 6-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery, Jump Starting 5-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake
Adjustment 6
-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Brake Systems 6-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Parking Brake 2-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electric/Hydraulic Parking Brake 2-25 . . . . . . . . . . . . . . . .
Electric/Hydraulic Parking Brake Fluid 6-36 . . . . . . . . . . . .
Exhaust 2-16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid 6-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ProCarManuals.com

yellowblue
9-6
Lamps 2-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dome 2-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
On Reminder 2-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Latches, Seatback 1-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Leaving Your Vehicle 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lighter 2-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lights
Air Brake System Warning 2
-59 . . . . . . . . . . . . . . . . . . . . .
Anti-Lock Brake System Warning 2-61, 4-7 . . . . . . . . . . . .
Apply Park Brake Warning 2-60 . . . . . . . . . . . . . . . . . . . . .
Brake System Warning 2-57 . . . . . . . . . . . . . . . . . . . . . . . . .
Charging System Indicator 2-56 . . . . . . . . . . . . . . . . . . . . . .
Check Gages Indicator 2-67 . . . . . . . . . . . . . . . . . . . . . . . . .
Daytime Running Lamps Indicator 2-67 . . . . . . . . . . . . . . .
Diff Lock Indicator 2-63 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Do Not Shift Warning 2-57 . . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Brake System Warning 2-58 . . . . . . . . . . . . . . . .
Intake Heater Indicator 2-63 . . . . . . . . . . . . . . . . . . . . . . . . .
Lamp and Bulb Data 6-74 . . . . . . . . . . . . . . . . . . . . . . . . . .
Low Coolant Warning 2-62 . . . . . . . . . . . . . . . . . . . . . . . . .
Parking Brake Warning 2-60 . . . . . . . . . . . . . . . . . . . . . . . .
Parking Brake Indicator 2-60 . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Reminder 1-7, 2-55 . . . . . . . . . . . . . . . . . . . . . .
Service Park Brake Warning 2-60 . . . . . . . . . . . . . . . . . . . .
Service Trans Filter Indicator 2-64 . . . . . . . . . . . . . . . . . . . .
Manual Fast Idle Indicator Light 2-62 . . . . . . . . . . . . . . . . .
Loading Your Vehicle 4-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . Locks
Door 2
-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Door 2-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lubricants and Fluids 7-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lubrication Service, Body 7-24 . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance Record 7-31 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Owner Checks and Services 7-23 . . . . . . . . . . . . . . . . . . . . .
Recommended Fluids and Lubricants 7-28 . . . . . . . . . . . . .
Scheduled Maintenance Services 7-4 . . . . . . . . . . . . . . . . . .
Maintenance, Underbody 6-65 . . . . . . . . . . . . . . . . . . . . . . . . .
Malfunction Indicator Lamp 2-64 . . . . . . . . . . . . . . . . . . . . . .
Manual Fast Idle Indicator Light 2-62 . . . . . . . . . . . . . . . . . . .
Manual Transmission Fluid 6-19 . . . . . . . . . . . . . . . . . . . . . . .
Marker and Clearance Lamps 2-45 . . . . . . . . . . . . . . . . . . . . .
Maxi-Fuse Block 6-72 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mirrors
Convex Outside 2
-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Heated Outside 2-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inside Rearview 2-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside 2-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Model Reference vi. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Moisture Ejector 6
-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mountain Roads 4-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Muffler/Catalytic Converter Assembly 6-48 . . . . . . . . . . . . . .
Multifunction Lever 2-32 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ProCarManuals.com

yellowblue
9-9
Storage, Vehicle 6-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Stuck: In Sand, Mud, Ice or Snow 5-37 . . . . . . . . . . . . . . . . . .
Sun Visors 2-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Surge Tank, Coolant 5-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Surge Tank Pressure Cap 6-22 . . . . . . . . . . . . . . . . . . . . . . . . .
Symbols, Vehicle v. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tape Player Care 3-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Theft 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Thermostat 6-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tilt Steering Wheel 2-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tire Loading 6-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tires 6-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Changing a Flat 5-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaning 6-64 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dual Tire Operation 6-50 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inflation 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inflation Check 7-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Loading 6-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pressure 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rims and Wheels 6-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel Replacement 6-57 . . . . . . . . . . . . . . . . . . . . . . . . . . .
When It's Time for New 6-51 . . . . . . . . . . . . . . . . . . . . . . .
Top Strap 1-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Torque, Wheel Nut 6-52 , 6-74 . . . . . . . . . . . . . . . . . . . . . . . .
Towing Your Vehicle 5-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Trailer Brake Hand Control Valve 2
-39 . . . . . . . . . . . . . . . . . .
Trailer Connections 2-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transmission
Automatic 2
-20, 6-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic Transmission External Filter 6-19 . . . . . . . . . . .
Double-Clutching 2-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Filters 6-77 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid, Automatic 6-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid Capacity 6-75 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual 2-22, 6-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual, Fluid 6-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Third Gear Hold 2-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Using the Clutch 2-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic 6-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual 6-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TTY Users 8-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Turn and Lane Change Indicator 2-33 . . . . . . . . . . . . . . . . . . .
Underbody Maintenance 6-65 . . . . . . . . . . . . . . . . . . . . . . . .
Vehicle
Control 4-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Damage Warnings iv. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Identification Number 6
-67 . . . . . . . . . . . . . . . . . . . . . . . . .
Loading 4-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Storage 6-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ventilation System 3-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Visors, Sun 2-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Voltmeter 2-56 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ProCarManuals.com