transfer case GMC CANYON 2017 Owner's Guide

GMC Canyon Owner Manual (GMNA-Localizing-U.S./Canada-10122677) -
2017 - crc - 1/20/17
358 Vehicle Care
Caution (Continued)
on roads that have been sprayed
with magnesium, calcium,
or sodium chloride. These
chlorides are used on roads for
conditions such as ice and dust.
Always wash the chrome with
soap and water after exposure.
Caution
To avoid surface damage, do not
use strong soaps, chemicals,
abrasive polishes, cleaners,
brushes, or cleaners that contain
acid on aluminum or
chrome-plated wheels. Use only
approved cleaners. Also, never
drive a vehicle with aluminum or
chrome-plated wheels through an
automatic car wash that uses
silicone carbide tire cleaning
brushes. Damage could occur
and the repairs would not be
covered by the vehicle warranty.
Brake System
Visually inspect brake lines and
hoses for proper hook-up, binding,
leaks, cracks, chafing, etc. Inspect
disc brake pads for wear and rotors
for surface condition. Inspect drum
brake linings/shoes for wear or
cracks. Inspect all other brake parts.
Steering, Suspension, and
Chassis Components
Visually inspect steering,
suspension, and chassis
components for damaged, loose,
or missing parts or signs of wear at
least once a year.
Inspect power steering for proper
attachment, connections, binding,
leaks, cracks, chafing, etc.
Visually check constant velocity joint
boots and axle seals for leaks.
Body Component Lubrication
Lubricate all key lock cylinders,
hood hinges, liftgate hinges, steel
fuel door hinge, and power assist
step hinges, unless the components
are plastic. Applying silicone greaseon weatherstrips with a clean cloth
will make them last longer, seal
better, and not stick or squeak
Underbody Maintenance
At least twice a year, spring and fall,
use plain water to flush any
corrosive materials from the
underbody. Take care to thoroughly
clean any areas where mud and
other debris can collect.
Do not directly power wash the
transfer case and/or front/rear axle
output seals. High pressure water
can overcome the seals and
contaminate the fluid. Contaminated
fluid will decrease the life of the
transfer case and/or axles and
should be replaced.
Sheet Metal Damage
If the vehicle is damaged and
requires sheet metal repair or
replacement, make sure the body
repair shop applies anti-corrosion
material to parts repaired or
replaced to restore corrosion
protection.

GMC Canyon Owner Manual (GMNA-Localizing-U.S./Canada-10122677) -
2017 - crc - 1/20/17
Service and Maintenance 367
Maintenance Schedule
Additional Required
Services - Normal12 000 km/7,500 mi
24 000 km/15,000 mi
36 000 km/22,500 mi
48 000 km/30,000 mi
60 000 km/37,500 mi
72 000 km/45,000 mi
84 000 km/52,500 mi
96 000 km/60,000 mi
108 000 km/67,500 mi
120 000 km/75,000 mi
132 000 km/82,500 mi
144 000 km/90,000 mi
156 000 km/97,500 mi
168 000 km/105,000 mi 180 000 km/112,500 mi
192 000 km/120,000 mi
204 000 km/127,500 mi
216 000 km/135,000 mi
228 000 km/142,500 mi
240 000 km/150,000 mi
Rotate tires and perform Required Services.
Check engine oil level and oil life percentage.
Change engine oil and filter, if needed.@ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @
Replace passenger compartment air filter. (1)@ @@@@@
Replace engine air cleaner filter. (2)@ @@
Inspect evaporative control system. (3)@@@
Replace spark plugs. Inspect spark plug wires.@
Change transfer case fluid, if equipped with
4WD. (4)@
Drain and fill engine cooling system. (5)@
Visually inspect accessory drive belts. (6)@
Replace brake/clutch fluid. (7)
Footnotes—Maintenance
Schedule Additional Required
Services - Normal
(1) Or every two years, whichever
comes first. More frequent
passenger compartment air filter
replacement may be needed if
driving in areas with heavy traffic,
poor air quality, high dust levels, or environmental allergens.
Passenger compartment air filter
replacement may also be needed if
there is reduced airflow, window
fogging, or odors. Your GM dealer
can help determine when to replace
the filter.
(2)
Or every four years, whichever
comes first. If driving in dusty
conditions, inspect the filter at each
oil change or more often as needed.
(3) Visually check all fuel and vapor
lines and hoses for proper
attachment, connection, routing, and
condition.

GMC Canyon Owner Manual (GMNA-Localizing-U.S./Canada-10122677) -
2017 - crc - 1/20/17
368 Service and Maintenance
(4)Do not directly power wash the
transfer case and/or front/rear axle
output seals. High pressure water
can overcome the seals and
contaminate the transfer case fluid.
Contaminated fluid will decrease the
life of the transfer case and/or axles
and should be replaced. (5)
Or every five years, whichever
comes first. See Cooling System
0 290.
(6) Or every 10 years, whichever
comes first. Inspect for fraying,
excessive cracking, or damage;
replace, if needed. (7)
Replace brake/clutch fluid every
five years. See Brake Fluid0297.

GMC Canyon Owner Manual (GMNA-Localizing-U.S./Canada-10122677) -
2017 - crc - 1/20/17
Service and Maintenance 369
Maintenance Schedule
Additional Required
Services - Severe12 000 km/7,500 mi
24 000 km/15,000 mi
36 000 km/22,500 mi
48 000 km/30,000 mi
60 000 km/37,500 mi
72 000 km/45,000 mi
84 000 km/52,500 mi
96 000 km/60,000 mi
108 000 km/67,500 mi
120 000 km/75,000 mi
132 000 km/82,500 mi
144 000 km/90,000 mi
156 000 km/97,500 mi
168 000 km/105,000 mi 180 000 km/112,500 mi
192 000 km/120,000 mi
204 000 km/127,500 mi
216 000 km/135,000 mi
228 000 km/142,500 mi
240 000 km/150,000 mi
Rotate tires and perform Required Services.
Check engine oil level and oil life percentage.
Change engine oil and filter, if needed.@ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @
Replace passenger compartment air filter. (1)@ @@@@@
Replace engine air cleaner filter. (2)@ @@
Inspect evaporative control system. (3)@@@
Replace spark plugs. Inspect spark plug wires.@
Change automatic transmission fluid and filter.@@@
Change manual transmission fluid.@@@
Change transfer case fluid, if equipped with
4WD. (4)@@@
Drain and fill engine cooling system. (5)@
Visually inspect accessory drive belts. (6)@
Replace brake/clutch fluid. (7)
Footnotes—Maintenance
Schedule Additional Required
Services - Severe
(1) Or every two years, whichever
comes first. More frequent
passenger compartment air filter
replacement may be needed if driving in areas with heavy traffic,
poor air quality, high dust levels,
or environmental allergens.
Passenger compartment air filter
replacement may also be needed if
there is reduced airflow, window
fogging, or odors. Your GM dealer
can help determine when to replace
the filter.
(2)
Or every four years, whichever
comes first. If driving in dusty
conditions, inspect the filter at each
oil change or more often as needed.

GMC Canyon Owner Manual (GMNA-Localizing-U.S./Canada-10122677) -
2017 - crc - 1/20/17
370 Service and Maintenance
(3)Visually check all fuel and vapor
lines and hoses for proper
attachment, connection, routing, and
condition.
(4) Do not directly power wash the
transfer case and/or front/rear axle
output seals. High pressure water
can overcome the seals and
contaminate the transfer case fluid.
Contaminated fluid will decrease the
life of the transfer case and/or axles
and should be replaced.
(5) Or every five years, whichever
comes first. See Cooling System
0 290.
(6) Or every 10 years, whichever
comes first. Inspect for fraying,
excessive cracking, or damage;
replace, if needed.
(7) Replace brake/clutch fluid every
five years. See Brake Fluid0297.Special Application
Services
.
Severe Commercial Use
Vehicles Only: Lubricate chassis
components every oil change.
. Have underbody flushing service
performed. See "Underbody
Maintenance" in Exterior Care
0 354.
Additional
Maintenance and Care
Your vehicle is an important
investment and caring for it properly
may help to avoid future costly
repairs. To maintain vehicle
performance, additional
maintenance services may be
required.
It is recommended that your dealer
perform these services —their
trained dealer technicians know
your vehicle best. Your dealer can
also perform a thorough
assessment with a multi-point
inspection to recommend when your
vehicle may need attention.
The following list is intended to
explain the services and conditions
to look for that may indicate
services are required.
Battery
The 12-volt battery supplies power
to start the engine and operate any
additional electrical accessories.

GMC Canyon Owner Manual (GMNA-Localizing-U.S./Canada-10122677) -
2017 - crc - 1/20/17
374 Service and Maintenance
UsageFluid/Lubricant
Key Lock Cylinders, Hood Hinges, Body Door Hinge Pins, Tailgate
Hinge and Linkage, Tailgate Handle Pivot Points, Hinges, Latch BoltLinkage, and Fuel Door Hinge Multi-Purpose Lubricant, Superlube (GM Part No. 12346241, in
Canada 10953474).
Manual Transmission DEXRON
®-VI Automatic Transmission Fluid.
Transfer Case (If Equipped With Four-Wheel Drive) DEXRON
®-VI Automatic Transmission Fluid.
Weatherstrip Conditioning Weatherstrip Lubricant (GM Part No. 3634770, in Canada 10953518) or Dielectric Silicone Grease (GM Part No. 12345579, in Canada 10953481).
Weatherstrip Squeaks Synthetic Grease with Teflon, Superlube (GM Part No. 12371287, in Canada 10953437).
Windshield Washer Automotive windshield washer fluid that meets regional freeze protection requirements.

GMC Canyon Owner Manual (GMNA-Localizing-U.S./Canada-10122677) -
2017 - crc - 1/20/17
378 Technical Data
Vehicle Data
Capacities and Specifications
The following approximate capacities are given in metric and English conversions. SeeRecommended Fluids and
Lubricants 0373.
Application Capacities
Metric English
Air Conditioning Refrigerant For the air conditioning system refrigerant type and charge amount, see the refrigerant label under thehood. See your dealer for more information.
Cooling System 2.5L L4 9.1 L 9.6 qt
3.6L V6 12.4 L 13.1 qt
Engine Oil with Filter 2.5L L4 4.7 L 5.0 qt
3.6L V6 5.7 L 6.0 qt
Fuel Tank 80 L 21 gal
Transfer Case Fluid 1.9 L 2.0 qt
Wheel Nut Torque 190 Y140 lb ft
All capacities are approximate. When adding, be sure to fill to the approximate level, as recommended in this
manual. Recheck fluid level after filling.

GMC Canyon Owner Manual (GMNA-Localizing-U.S./Canada-10122677) -
2017 - crc - 1/20/17
408 Index
DrivingCharacteristics and
Towing Tips . . . . . . . . . . . . . . . . . 267
Defensive . . . . . . . . . . . . . . . . . . . . . 214
Drunk . . . . . . . . . . . . . . . . . . . . . . . . . 214
For Better Fuel Economy . . . . . . . 25
Hill and Mountain Roads . . . . . . 222
If the Vehicle is Stuck . . . . . . . . . 224
Loss of Control . . . . . . . . . . . . . . . 216
Off-Road . . . . . . . . . . . . . . . . . . . . . 217
Off-Road Recovery . . . . . . . . . . . 216
Vehicle Load Limits . . . . . . . . . . . 225
Wet Roads . . . . . . . . . . . . . . . . . . . 221
Winter . . . . . . . . . . . . . . . . . . . . . . . . 223
E
Electrical Equipment, Add-On . . . . . . . . . . . . . . . . . . . . . . . 275
Electrical System Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 308
Fuses . . . . . . . . . . . . . . . . . . . . . . . . 307
Instrument Panel Fuse Block . . . . . . . . . . . . . . . . . . . . . . . . 312
Overload . . . . . . . . . . . . . . . . . . . . . 307
Emergency
OnStar
®. . . . . . . . . . . . . . . . . . . . . . 396
Engine Air Cleaner/Filter . . . . . . . . . . . . . 289 Engine (cont'd)
Check Light (Malfunction
Indicator) . . . . . . . . . . . . . . . . . . . . .117
Compartment Overview . . . . . . . 281
Coolant . . . . . . . . . . . . . . . . . . . . . . . 292
Coolant Temperature
Gauge . . . . . . . . . . . . . . . . . . . . . . .114
Cooling System . . . . . . . . . . . . . . . 290
Cooling System Messages . . . 132
Drive Belt Routing . . . . . . . . . . . . 380
Exhaust . . . . . . . . . . . . . . . . . . . . . . 239
Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . 295
Heater . . . . . . . . . . . . . . . . . . . . . . . . 234
Oil Life System . . . . . . . . . . . . . . . 286
Oil Messages . . . . . . . . . . . . . . . . . 133
Oil Pressure Light . . . . . . . . . . . . 123
Overheating . . . . . . . . . . . . . . . . . . 294
Power Messages . . . . . . . . . . . . . 133
Running While Parked . . . . . . . . 239
Starting . . . . . . . . . . . . . . . . . . . . . . . 233
Entry Lighting . . . . . . . . . . . . . . . . . . . 150
Equipment, Towing . . . . . . . . . . . . . 272
Event Data Recorders . . . . . . . . . . 393
Exit Lighting . . . . . . . . . . . . . . . . . . . . 150
Extender, Safety Belt . . . . . . . . . . . . 55
Exterior Lamp Controls . . . . . . . . . 145
Exterior Lamps Off Reminder . . . 146
F
Fan Engine . . . . . . . . . . . . . . . . . . . . . . . . 295
Filter, Engine Air Cleaner . . . . . . . . . . . 289
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 146
Flashers, Hazard Warning . . . . . . 148
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 334 Changing . . . . . . . . . . . . . . . . . . . . . 336
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 362
Fluid
Automatic Transmission . . . . . . 288
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 297
Four-Wheel DriveTransfer Case . . . . . . . . . . . . . . . 247
Washer . . . . . . . . . . . . . . . . . . . . . . . 296
Fog Lamps . . . . . . . . . . . . . . . . . . . . . 148
Folding Mirrors . . . . . . . . . . . . . . . . . . 38
Forward Collision Alert (FCA) System . . . . . . . . . . . . . . . . . 260
Four-Wheel Drive . . . . . . . . . . 247, 299
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 391
Front Axle . . . . . . . . . . . . . . . . . . . . . . 300
Front Fog Lamp
Light . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Front Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 45

GMC Canyon Owner Manual (GMNA-Localizing-U.S./Canada-10122677) -
2017 - crc - 1/20/17
Index 411
Locks (cont'd)Power Door . . . . . . . . . . . . . . . . . . . . . 33
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . 34
Loss of Control . . . . . . . . . . . . . . . . . 216
Low Fuel Warning Light . . . . . . . . . 123
Lower Anchors and Tethers
for Children (LATCH
System) . . . . . . . . . . . . . . . . . . . . . . . . 76
Lumbar Adjustment . . . . . . . . . . . . . . 46
Front Seats . . . . . . . . . . . . . . . . . . . . . 46
M
MaintenanceRecords . . . . . . . . . . . . . . . . . . . . . . 376
Maintenance and Care Additional . . . . . . . . . . . . . . . . . . . . . 370
Maintenance Schedule . . . . . . . . . 364 Recommended Fluids andLubricants . . . . . . . . . . . . . . . . . . . 373
Transfer Case . . . . . . . . . . . . . . . . 247
Malfunction Indicator Lamp . . . . . 117
Manual Mirrors . . . . . . . . . . . . . . . . . . 37
Manual Mode . . . . . . . . . . . . . . . . . . . 242
Manual Transmission . . . . . . . . . . . 245 Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 288
Media Avoiding Untrusted Devices . . 169
Messages
Airbag System . . . . . . . . . . . . . . . . 135 Messages (cont'd)
Battery Voltage and
Charging . . . . . . . . . . . . . . . . . . . . 131
Brake System . . . . . . . . . . . . . . . . 132
Compass . . . . . . . . . . . . . . . . . . . . . 132
Door Ajar . . . . . . . . . . . . . . . . . . . . . 132
Engine Cooling System . . . . . . . 132
Engine Oil . . . . . . . . . . . . . . . . . . . . 133
Engine Power . . . . . . . . . . . . . . . . 133
Fuel System . . . . . . . . . . . . . . . . . . 134
Key and Lock . . . . . . . . . . . . . . . . . 134
Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 134
Object Detection System . . . . . 134
Ride Control System . . . . . . . . . . 135
Security . . . . . . . . . . . . . . . . . . . . . . 135
Starting the Vehicle . . . . . . . . . . . 136
Steering System . . . . . . . . . . . . . . 135
Tire . . . . . . . . . . . . . . . . . . . . . . . . . . . 136
Transmission . . . . . . . . . . . . . . . . . 136
Vehicle . . . . . . . . . . . . . . . . . . . . . . . 131
Vehicle Reminder . . . . . . . . . . . . . 137
Vehicle Speed . . . . . . . . . . . . . . . . 138
Messaging
Text . . . . . . . . . . . . . . . . . . . . . . . . . . . 200
Mirrors Automatic DimmingRearview . . . . . . . . . . . . . . . . . . . . . . 40
Blind Spot . . . . . . . . . . . . . . . . . . . . . . 38 Mirrors (cont'd)
Convex . . . . . . . . . . . . . . . . . . . . . . . . . 37
Folding . . . . . . . . . . . . . . . . . . . . . . . . . 38
Heated . . . . . . . . . . . . . . . . . . . . . . . . . 38
Manual . . . . . . . . . . . . . . . . . . . . . . . . . 37
Manual Rearview . . . . . . . . . . . . . . . 39
Power . . . . . . . . . . . . . . . . . . . . . . . . . . 38
Mirrors, Interior Rearview . . . . . . . . 39
Monitor System, Tire Pressure . . . . . . . . . . . . . . . . . . . . . . 323
Multi-band Antenna . . . . . . . . . . . . . 166N
Navigation OnStar®. . . . . . . . . . . . . . . . . . . . . . 396
New Vehicle Break-In . . . . . . . . . . . 231
O
Object Detection System Messages . . . . . . . . . . . . . . . . . . . . . 134
Odometer . . . . . . . . . . . . . . . . . . . . . . . 113 Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . .113
Off-Road . . . . . . . . . . . . . . . . . . . . . . . 217 Driving . . . . . . . . . . . . . . . . . . . . . . . . 217
Recovery . . . . . . . . . . . . . . . . . . . . . 216
Oil Engine . . . . . . . . . . . . . . . . . . . . . . . . 284
Engine Oil Life System . . . . . . . 286
Messages . . . . . . . . . . . . . . . . . . . . 133

GMC Canyon Owner Manual (GMNA-Localizing-U.S./Canada-10122677) -
2017 - crc - 1/20/17
Index 415
Tow/Haul Mode Light . . . . . . . . . . . 120
TowingDriving Characteristics . . . . . . . . 267
Equipment . . . . . . . . . . . . . . . . . . . . 272
General Information . . . . . . . . . . 267
Recreational Vehicle . . . . . . . . . . 349
Trailer . . . . . . . . . . . . . . . . . . . . . . . . 269
Trailer Sway Control (TSC) . . . 275
Vehicle . . . . . . . . . . . . . . . . . . . . . . . 349
Traction Control System (TCS)/
StabiliTrak
®Light . . . . . . . . . . . . 122
Off Light . . . . . . . . . . . . . . . . . . . . . . 121
Traction Control/Electronic Stability Control . . . . . . . . . . . . . . . 253
Trademarks and License
Agreements . . . . . . . . . . . . . . . . . . . 201
Trailer Sway Control (TSC) . . . . . . . . . . 275
Towing . . . . . . . . . . . . . . . . . . . . . . . . 269
Transfer Case . . . . . . . . . . . . . . . . . . 247
Transmission
Automatic . . . . . . . . . . . . . . . . . . . . . 240
Fluid, Automatic . . . . . . . . . . . . . . 288
Fluid, Manual . . . . . . . . . . . . . . . . . 288
Messages . . . . . . . . . . . . . . . . . . . . 136
Transportation Program, Courtesy . . . . . . . . . . . . . . . . . . . . . . 387 Trip Odometer . . . . . . . . . . . . . . . . . . 113
Truck-Camper Loading
Information . . . . . . . . . . . . . . . . . . . . 231
Turn and Lane-Change Signals . . . . . . . . . . . . . . . . . . . . . . . . 148
Turn Signal Bulb Replacement . . . . . . . . . . . . 305
U
Underseat Storage . . . . . . . . . . . . . 100
Uniform Tire Quality Grading . . . 331
Up-Shift Light . . . . . . . . . . . . . . . . . . . 120
Updates
Software . . . . . . . . . . . . . . . . . . . . . . 160
USB Port . . . . . . . . . . . . . . . . . . 169, 172
Using This Manual . . . . . . . . . . . . . . . . 2
V
Vehicle Alarm System . . . . . . . . . . . . . . . . . . 35
Canadian Owners . . . . . . . . . . . . . . . 2
Control . . . . . . . . . . . . . . . . . . . . . . . 215
Identification Number (VIN) . . . 377
Load Limits . . . . . . . . . . . . . . . . . . . 225
Messages . . . . . . . . . . . . . . . . . . . . 131
Personalization . . . . . . . . . . . . . . . 138
Reminder Messages . . . . . . . . . . 137
Remote Start . . . . . . . . . . . . . . . . . . . 31
Security . . . . . . . . . . . . . . . . . . . . . . . . 35 Vehicle (cont'd)
Speed Messages . . . . . . . . . . . . . 138
Towing . . . . . . . . . . . . . . . . . . . . . . . . 349
Vehicle Ahead Indicator . . . . . . . . 121
Vehicle Care
Tire Pressure . . . . . . . . . . . . . . . . . 321
Vehicle Data Recording and Privacy . . . . . . . . . . . . . . . . . . . . . . . . 392
Ventilation, Air . . . . . . . . . . . . . . . . . . 211
Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Voice Recognition . . . . . . . . . . . . . . 180
W
Warning
Brake System Light . . . . . . . . . . . .119
Caution and Danger . . . . . . . . . . . . . 3
Lane Departure (LDW) . . . . . . . 261
Warning Lights, Gauges, and Indicators . . . . . . . . . . . . . . . . . . . . . 108
Warnings Hazard Flashers . . . . . . . . . . . . . . 148
Washer Fluid . . . . . . . . . . . . . . . . . . . 296
Wheels Alignment and Tire Balance . . 332
Different Size . . . . . . . . . . . . . . . . . 330
Replacement . . . . . . . . . . . . . . . . . 332
When It Is Time for New Tires . . . . . . . . . . . . . . . . . . . . . . . . . . 328
Where to Put the Restraint . . . . . . 74