radio GMC ENVOY XUV 2004 Repair Manual

Replacing Brake System Parts
The braking system on a vehicle is complex. Its many
parts have to be of top quality and work well together if
the vehicle is to have really good braking. Your
vehicle was designed and tested with top-quality GM
brake parts. When you replace parts of your braking
system Ð for example, when your brake linings
wear down and you need new ones put in Ð be sure
you get new approved GM replacement parts. If you do
not, your brakes may no longer work properly. For
example, if someone puts in brake linings that are wrong
for your vehicle, the balance between your front and
rear brakes can change Ð for the worse. The braking
performance you have come to expect can change
in many other ways if someone puts in the wrong
replacement brake parts.
Battery
Your new vehicle comes with a maintenance free
ACDelcožbattery. When it is time for a new battery, get
one that has the replacement number shown on the
original battery's label. We recommend an ACDelco
ž
battery. SeeEngine Compartment Overview on
page 5-12for battery location.
Warning:Battery posts, terminals and related
accessories contain lead and lead compounds,
chemicals known to the State of California to cause
cancer and reproductive harm. Wash hands after
handling.
Vehicle Storage
If you are not going to drive your vehicle for 25 days
or more, remove the black, negative (-) cable from
the battery. This will help keep your battery from
running down.
{CAUTION:
Batteries have acid that can burn you and gas
that can explode. You can be badly hurt if you
are not careful. See
Jump Starting on
page 5-41
for tips on working around a battery
without getting hurt.
Contact your dealer to learn how to prepare your
vehicle for longer storage periods.
Also, for your audio system, see
Theft-Deterrent
Feature (RDS Radios) on page 3-117.
5-40

Jump Starting
If your battery has run down, you may want to use
another vehicle and some jumper cables to start your
vehicle. But please use the following steps to do it
safely.
{CAUTION:
Batteries can hurt you. They can be dangerous
because:
·They contain acid that can burn you.
·They contain gas that can explode or
ignite.
·They contain enough electricity to
burn you.
If you do not follow these steps exactly, some
or all of these things can hurt you.
Notice:Ignoring these steps could result in costly
damage to your vehicle that would not be covered
by your warranty.
Trying to start your vehicle by pushing or pulling it
will not work, and it could damage your vehicle.
1. Check the other vehicle. It must have a 12-volt
battery with a negative ground system.
Notice:If the other vehicle's system is not a 12-volt
system with a negative ground, both vehicles can
be damaged. Only use vehicles with 12-volt systems
with negative grounds to jump start your vehicle.
2. Get the vehicles close enough so the jumper cables
can reach, but be sure the vehicles aren't touching
each other. If they are, it could cause a ground
connection you don't want. You wouldn't be able to
start your vehicle, and the bad grounding could
damage the electrical systems.
To avoid the possibility of the vehicles rolling, set
the parking brake ®rmly on both vehicles involved in
the jump start procedure. Put an automatic
transmission in PARK (P) or a manual transmission
in NEUTRAL before setting the parking brake. If
you have a four-wheel-drive vehicle, be sure
the transfer case is not in NEUTRAL.
Notice:If you leave your radio or other accessories
on during the jump starting procedure, they could
be damaged. The repairs would not be covered
by your warranty. Always turn off your radio and
other accessories when jump starting your vehicle.
3. Turn off the ignition on both vehicles. Unplug
unnecessary accessories plugged into the cigarette
lighter or accessory power outlets (if equipped).
Turn off the radio and all lamps that aren't needed.
This will avoid sparks and help to save both
batteries. And it could save your radio!
5-41

Cleaning Leather
Use a soft cloth with lukewarm water and a mild soap or
saddle soap and wipe dry with a soft cloth. Then, let
the leather dry naturally. Do not use heat to dry.
·For stubborn stains, use a leather cleaner.
·Neveruse oils, varnishes, solvent-based or abrasive
cleaners, furniture polish or shoe polish on leather.
·Soiled or stained leather should be cleaned
immediately. If dirt is allowed to work into the ®nish,
it can harm the leather.
Cleaning the Top of the
Instrument Panel
Use only mild soap and water to clean the top surfaces
of the instrument panel. Sprays containing silicones
or waxes may cause annoying re¯ections in the
windshield and even make it difficult to see through the
windshield under certain conditions.
Cleaning Interior Plastic Components
Use only a mild soap and water solution on a soft cloth
or sponge. Commercial cleaners may affect the
surface ®nish.
Cleaning Glass Surfaces
Glass should be cleaned often. GM Glass Cleaner or a
liquid household glass cleaner will remove normal
tobacco smoke and dust ®lms on interior glass. See
Vehicle Care/Appearance Materials on page 5-90.
Notice:If you use abrasive cleaners when cleaning
glass surfaces on your vehicle, you could scratch
the glass and/or cause damage to the rear window
defogger and the integrated radio antenna. When
cleaning the glass on your vehicle, use only a soft
cloth and glass cleaner.
5-86

Fuses and Circuit Breakers
The wiring circuits in your vehicle are protected from
short circuits by a combination of fuses and circuit
breakers. This greatly reduces the chance of ®res
caused by electrical problems.
Look at the silver-colored band inside the fuse. If the
band is broken or melted, replace the fuse. Be sure you
replace a bad fuse with a new one of the identical
size and rating.
If you ever have a problem on the road and don't have
a spare fuse, you can borrow one that has the same
amperage. Just pick some feature of your vehicle
that you can get along without Ð like the radio or
cigarette lighterÐ and use its fuse, if it is the correct
amperage. Replace it as soon as you can.
Engine Compartment Fuse Block
The fuse block is located under the hood in the engine
compartment on the driver's side of the vehicle. See
Engine Compartment Overview on page 5-12for more
information on location.
Remove the primary cover by pressing the two locking
tabs. Remove the secondary cover by snapping off
while lifting. To reinstall the fuse panel cover, reverse
the sequence.
5-93

Fuses Usage
23Endgate Module/Driver Seat
Module
24 Unlock
25 Roof Module
26 OH Battery/OnStar
27 Midgate
28 Sunroof
29 RainsenseŸ Wipers
30 Parking Lamps
31Truck Body Controller 4 Cruise
Control
32 Truck Body Controller 5
33 Front Wipers
34 Vehicle Stop
35 Blank
36Heat Ventilation Air
Conditioning B
37 Front Parking LampsFuses Usage
38 Left Turn Signal
39Heat Ventilation Air
Conditioning 1
40 Truck Body Controller 4
41 Radio
42 Trailer Park
43 Right Turn Signal
44 Heat Ventilation Air Conditioning
45 Blank
46 Auxiliary Power 1
47 Ignition 0
48 Four-Wheel Drive
49 Blank
50 Truck Body Controller Ignition
51 Brakes
52 Truck Body Controller Run
5-100

A
Accessory In¯ator...........................................5-68
Accessory Power Outlets.................................3-19
Adding a Snow Plow or Similar Equipment.........4-56
Adding Washer Fluid.......................................5-36
Additional Program Information........................... 7-9
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment............................5-92
Adjustable Throttle and Brake Pedal..................2-27
Adjusting the Speakers
(Balance/Fade)............................3-65, 3-77, 3-92
After Off-Road Driving.....................................4-28
Air Bag
Readiness Light..........................................3-34
Air Bag Systems.............................................1-50
How Does an Air Bag Restrain?....................1-56
Servicing Your Air Bag-Equipped Vehicle.........1-59
What Makes an Air Bag In¯ate?....................1-56
What Will You See After an Air Bag In¯ates?......1-57
When Should an Air Bag In¯ate?...................1-55
Where Are the Air Bags?..............................1-53
Air Cleaner/Filter, Engine.................................5-20
Airbag Sensing and Diagnostic Module (SDM)...... 7-9
All Overseas Locations...................................... 7-4
AM .............................................................3-119
Antenna, Fixed Mast......................................3-121
Antenna, XMŸ Satellite Radio Antenna System . . . 3-121
Anti-lock Brake System..................................... 4-6Anti-Lock Brake, System Warning Light..............3-37
Appearance Care............................................5-83
Care of Safety Belts....................................5-87
Chemical Paint Spotting...............................5-90
Cleaning the Inside of Your Vehicle................5-84
Cleaning the Outside of Your Vehicle..............5-87
Finish Damage............................................5-89
Sheet Metal Damage...................................5-89
Underbody Maintenance...............................5-90
Vehicle Care/Appearance Materials................5-90
Weatherstrips..............................................5-87
Approaching a Hill..........................................4-20
Ashtrays........................................................3-19
Audio Output................................................3-113
Audio System(s).............................................3-61
Audio Steering Wheel Controls....................3-118
Care of Your Cassette Tape Player...............3-119
Care of Your CD and DVD Player................3-121
Care of Your CDs and DVDs.......................3-120
Chime Level Adjustment.............................3-121
Fixed Mast Antenna...................................3-121
Navigation/Radio System.............................3-104
Radio Personalization.................................3-117
Radio with Cassette and CD.........................3-74
Radio with CD............................................3-62
Radio with Six-Disc CD................................3-89
Rear Seat Audio (RSA)...............................3-116
Setting the Time..........................................3-61
Theft-Deterrent Feature...............................3-117
1

Audio System(s) (cont.)
Understanding Radio Reception...................3-119
XMŸ Satellite Radio Antenna System...........3-121
Automatic Headlamp System............................3-14
Automatic Transfer Case..................................2-32
Automatic Transmission
Fluid..........................................................5-21
Operation...................................................2-29
B
Backglass Wiper Blade Replacement.................5-52
Backing Up....................................................4-63
Battery..........................................................5-40
BATTERY NOT CHARGING.............................3-56
Battery Replacement......................................... 2-6
Battery Run-Down Protection............................3-18
Before Leaving on a Long Trip.........................4-35
Before You Drive...........................................3-104
Before You Go Off-Roading..............................4-15
Brake
Parking......................................................2-35
System Warning Light..................................3-36
Brake Adjustment............................................5-39
Brake Fluid....................................................5-37
Brake Pedal, Throttle.......................................2-27
Brake Pedal Travel.........................................5-39
Brake Wear...................................................5-39
Brakes..........................................................5-37Braking........................................................... 4-5
Braking in Emergencies..................................... 4-8
Break-In, New Vehicle.....................................2-24
Bulb Replacement...........................................5-48
Headlamps.................................................5-48
Replacement Bulbs......................................5-50
Taillamps and Turn Signal Lamps..................5-49
Buying New Tires...........................................5-64
C
California Fuel.................................................. 5-5
Canada........................................................... 7-4
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-7
Capacities and Speci®cations..........................5-101
Carbon Monoxide...........4-39, 4-56, 2-12, 2-13, 2-39
Care of
Safety Belts................................................5-87
Your Cassette Tape Player..........................3-119
Your CD and DVD Player...........................3-121
Your CDs and DVDs..................................3-120
Cargo Area, All-Weather..................................2-52
Cargo Area Floor Drains..................................2-52
Cargo Tie Downs............................................2-53
Cassette Tape Messages.................................3-85
CD Adapter Kits.............................................3-85
CD Messages...............................3-73, 3-88, 3-103
Chains, Tires..................................................5-68
2

Loss of Control...............................................4-14
Low Fuel Warning Light...................................3-45
Lumbar
Power Controls............................................. 1-3
MMaintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill........................................... 6-9
At Least Once a Month................................6-10
At Least Once a Year..................................6-11
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-8
Maintenance Record....................................6-17
Maintenance Requirements............................. 6-2
Normal Maintenance Replacement Parts.........6-15
Owner Checks and Services........................... 6-9
Recommended Fluids and Lubricants.............6-13
Scheduled Maintenance................................. 6-4
Using Your................................................... 6-3
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-65
Making Turns.................................................4-63
Malfunction Indicator Light................................3-38
Manual Seats................................................... 1-2
Matching Transmitter(s) to Your Vehicle............... 2-5
Memory Seat.................................................2-54Message
DIC Warnings and Messages........................3-56
Mexico, Central America and Caribbean Islands/
Countries (Except Puerto Rico and U.S. Virgin
Islands)....................................................... 7-5
Midgate.........................................................2-12
Mirror Operation.............................................2-41
Mirrors
Automatic Dimming Rearview with OnStarž
and Compass..........................................2-41
Outside Automatic Dimming Mirror with Curb
View Assist.............................................2-44
Outside Convex Mirror.................................2-44
Outside Heated Mirrors................................2-44
Outside Manual Mirrors................................2-43
Outside Power Mirrors..................................2-43
MyGMLink.com................................................ 7-3
N
Navigation/Radio System................................3-104
New Vehicle Break-In......................................2-24
Normal Maintenance Replacement Parts............6-15
O
Odometer......................................................3-32
Off-Road Recovery..........................................4-12
9

Oil
Change Engine Oil Light...............................3-42
Engine.......................................................5-15
Pressure Gage............................................3-41
OIL PRESSURE LOW/STOP ENGINE...............3-56
Older Children, Restraints................................1-29
Online Owner Center........................................ 7-3
OnStar
žPersonal Calling.................................2-46
OnStaržServices............................................2-45
OnStaržSystem.............................................2-45
OnStaržVirtual Advisor....................................2-46
OPEN THE ROOF..........................................3-59
Operating Your All-Wheel-Drive Vehicle Off
Paved Roads..............................................4-15
Other Warning Devices...................................... 3-5
Outlet Adjustment...................................3-22, 3-27
Outside
Automatic Dimming Mirror with Curb View
Assist.....................................................2-44
Convex Mirror.............................................2-44
Heated Mirrors............................................2-44
Manual Mirrors............................................2-43
Power Mirrors.............................................2-43
Overhead Console..........................................2-51
Owner Checks and Services.............................. 6-9
Owners, Canadian............................................... ii
Owner's Information........................................7-12
P
Park (P)
Shifting Into................................................2-36
Shifting Out of............................................2-38
PARK TO OPERATE ROOF.............................3-59
Parking
Brake........................................................2-35
Over Things That Burn.................................2-38
Parking on Hills..............................................4-64
PASSENGER DOOR AJAR..............................3-58
Passing.................................................4-12, 4-63
Passlock
ž......................................................2-23
Personalization...............................................3-49
Personalization, Climate Controls......................3-29
Plan Ahead When Possible................................ 7-7
Playing a Cassette Tape..................................3-83
Playing a CD.................................3-71, 3-86, 3-98
Playing a Speci®c Loaded CD..........................3-99
Playing the Radio...........................3-63, 3-75, 3-90
Power
Accessory Outlets........................................3-19
Door Locks.................................................. 2-8
Electrical System.........................................5-92
Lumbar Controls........................................... 1-3
Reduced Engine Light..................................3-43
10

Power (cont.)
Roof..........................................................2-17
Seat............................................................ 1-3
Steering Fluid.............................................5-35
Windows....................................................2-20
Power Steering...............................................4-10
Programmable Automatic Door Locks.................. 2-9
Programmable Locking Feature.......................... 2-9
Programmable Unlocking Feature......................2-10
Programming the HomeLink
žTransmitter...........2-47
Q
Questions and Answers About Safety Belts.........1-12
R
Radiator Pressure Cap....................................5-26
Radio Data System (RDS)...............3-62, 3-74, 3-89
Radio Messages.....................................3-68, 3-80
Radios..........................................................3-61
Care of Your Cassette Tape Player...............3-119
Care of Your CD and DVD Player................3-121
Care of Your CDs and DVDs.......................3-120
Navigation/Radio System.............................3-104
Radio Personalization.................................3-117
Radio with Cassette and CD.........................3-74
Radio with CD............................................3-62
Radio with Six-Disc CD................................3-89Radios (cont.)
Rear Seat Audio........................................3-116
Setting the Time..........................................3-61
Theft-Deterrent..........................................3-117
Understanding Reception............................3-119
RainsenseŸ Wipers.......................................... 3-9
RDS Messages..............................3-67, 3-79, 3-95
Reading Lamps..............................................3-18
Rear Axle......................................................5-46
Locking......................................................4-10
Rear Cargo Mat.............................................2-53
Rear Climate Control System............................3-28
Rear Door Security Locks................................2-11
Rear Safety Belt Comfort Guides......................1-24
Rear Seat Audio (RSA)..................................3-116
Rear Seat Entertainment System.....................3-104
Rear Seat Operation......................................... 1-7
Rear Seat Passenger Positions.........................1-21
Rear Seat Passengers, Safety Belts..................1-21
Rear Underseat Fuse Block..............................5-98
Rear Window Defogger............................3-22, 3-26
REAR WIPER OBSTRUCTION.........................3-60
Rearview Mirror, Automatic Dimming with
OnStar
žand Compass.................................2-41
Reclining Seatbacks.......................................... 1-5
Recommended Fluids and Lubricants.................6-13
Recreational Vehicle Towing.............................4-45
Reduced Engine Power Light............................3-43
Remote Control.............................................3-108
Remote Keyless Entry System............................ 2-4
11