belt GMC SAFARI 2003 Repair Manual

93,000 Miles (155 000 km)
❑Change engine oil andlter (or every 3 months,
whichever occursrst).An Emission Control Service.
❑Lubricate chassis components (or every 3 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.
96,000 Miles (160 000 km)
❑Change engine oil andlter (or every 3 months,
whichever occursrst).An Emission Control Service.
❑Lubricate chassis components (or every 3 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-58for proper rotation pattern and additional
information.(See footnote +.)
99,000 Miles (165 000 km)
❑Change engine oil andlter (or every 3 months,
whichever occursrst).An Emission Control Service.
❑Lubricate chassis components (or every 3 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.
100,000 Miles (166 000 km)
❑Inspect spark plug wires.An Emission Control
Service.
❑Replace spark plugs.An Emission Control Service.
❑If you haven’t used your vehicle under severe service
conditions listed previously and, therefore, haven’t
changed your automatic transmissionuid, change
both theuid andlter.
❑Change transfer caseuid.
❑Inspect Positive Crankcase Ventilation (PCV) valve.
An Emission Control Service.
150,000 Miles (240 000 km)
❑Drain,ush and rell cooling system (or every
60 months since last service, whichever occursrst).
SeeEngine Coolant on page 5-25for what to use.
Inspect hoses. Clean radiator, condenser, pressure
cap and neck. Pressure test cooling system and
pressure cap.An Emission Control Service.
❑Inspect engine accessory drive belt.An Emission
Control Service.
6-18
2003 - Safari OM

100,000 Miles (166 000 km)
❑Inspect spark plug wires.An Emission Control
Service.
❑Replace spark plugs.An Emission Control Service.
❑If you haven’t used your vehicle under severe service
conditions listed previously and, therefore, haven’t
changed your automatic transmissionuid, change
both theuid andlter.
❑Change transfer caseuid.
❑Inspect Positive Crankcase Ventilation (PCV) valve.
An Emission Control Service.
150,000 Miles (240 000 km)
❑Drain,ush and rell cooling system (or every
60 months since last service, whichever occursrst).
SeeEngine Coolant on page 5-25for what to use.
Inspect hoses. Clean radiator, condenser, pressure
cap and neck. Pressure test the cooling system
and pressure cap.An Emission Control Service.
❑Inspect engine accessory drive belt.An Emission
Control Service.
6-26
2003 - Safari OM

At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages
are working properly. Look for any other loose or
damaged safety belt system parts. If you see anything
that might keep a safety belt system from doing its
job, have it repaired. Have any torn or frayed safety belts
replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag
system does not need regular maintenance.)
Wiper Blade Check
Inspect wiper blades for wear or cracking. Replace
blade inserts that appear worn or damaged or that
streak or miss areas of the windshield. Also see
Cleaning the Outside of Your Vehicle on page 5-79.
Spare Tire Check
At least twice a year, after the monthly ination check of
the spare tire determines that the spare is inated to
the correct tire ination pressure, make sure that
the spare tire is stored securely. Push, pull, and then try
to rotate or turn the tire. If it moves, use the wheel
wrench to tighten the cable. SeeChanging a Flat Tire
on page 5-65.
Weatherstrip Lubrication
Silicone grease on weatherstrips will make them last
longer, seal better, and not stick or squeak. Apply
silicone grease with a clean cloth. During very cold,
damp weather more frequent application may be
required. SeePart D: Recommended Fluids and
Lubricants on page 6-34.
Automatic Transmission Check
Check the transmissionuid level; add if needed. See
Automatic Transmission Fluid on page 5-22.Auid loss
may indicate a problem. Check the system and repair
if needed.
6-28
2003 - Safari OM

A
Accessory Power Outlets.................................3-16
Activating the Theft-Deterrent Feature................3-47
Adding Equipment to Your Air Bag-Equipped
Vehicle.......................................................1-68
Adding Washer Fluid.......................................5-38
Additional Program Information........................... 7-9
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment............................5-85
Add-On Equipment..........................................4-31
Adjusting the Speakers (Balance/Fade)......3-39, 3-42
Air Bag
Readiness Light..........................................3-26
Air Bag System..............................................1-62
Adding Equipment to Your Air Bag-Equipped
Vehicle...................................................1-68
How Does an Air Bag Restrain?....................1-66
Servicing Your Air Bag-Equipped Vehicle.........1-67
What Makes an Air Bag Inflate?....................1-65
What Will You See After an Air Bag Inflates? . . 1-66
When Should an Air Bag Inflate?...................1-65
Where Are the Air Bags?..............................1-64
Air Cleaner/Filter, Engine.................................5-21
All Overseas Locations...................................... 7-5
All-Wheel Drive...............................................5-48
All-Wheel Drive (AWD) System.........................2-26
All-Wheel-Drive Service Light............................3-34AM ...............................................................3-49
AM-FM Radio.................................................3-38
Antenna, Fixed Mast.......................................3-49
Anti-lock Brake System..................................... 4-7
Anti-Lock Brake, System Warning Light..............3-29
Appearance Care............................................5-76
Care of Safety Belts....................................5-79
Chemical Paint Spotting...............................5-82
Cleaning the Inside of Your Vehicle................5-77
Cleaning the Outside of Your Vehicle
..............5-79
Finish Damage
............................................5-82
GM Vehicle Care/Appearance Materials
..........5-83
Sheet Metal Damage
...................................5-82
Underbody Maintenance
...............................5-82
Weatherstrips
..............................................5-79
Ashtrays
........................................................3-17
Audio System(s)
.............................................3-37
AM-FM Radio
.............................................3-38
Care of Your CD Player
...............................3-49
Care of Your CDs
........................................3-49
Fixed Mast Antenna
.....................................3-49
Radio with CD
............................................3-40
Rear Seat Audio (RSA)
................................3-45
Setting the Time for Radios with HR and
MN Buttons
.............................................3-37
Setting the Time for Radios with the Set
Button
....................................................3-37
1
2003 - Safari OM

Audio System(s) (cont.)
Theft-Deterrent Feature................................3-46
Understanding Radio Reception.....................3-49
Automatic Headlamp System............................3-13
Automatic Transmission
Fluid..........................................................5-22
Operation...................................................2-23
Automatic Transmission Check..........................6-28
Automatic Transmission Shift Lock Control
System Check.............................................6-30
B
Backing Up....................................................4-38
Battery..........................................................5-42
Battery Replacement......................................... 2-6
Battery Run-Down Protection............................3-16
Before Leaving on a Long Trip.........................4-20
Bench Seat............................................1-11, 1-57
Body Lubrication Service..................................6-29
Brake
Parking......................................................2-26
System Inspection.......................................6-33
System Warning Light..................................3-28
Brake Adjustment............................................5-42
Brake Fluid....................................................5-39
Brake Pedal Travel.........................................5-42
Brake Wear...................................................5-41
Brakes..........................................................5-39Braking........................................................... 4-6
Braking in Emergencies..................................... 4-8
Break-In, New Vehicle.....................................2-18
Bucket Seats, Rear.........................................1-12
Bulb Replacement...........................................5-50
Front Turn Signal Lamps..............................5-54
Halogen Bulbs............................................5-50
Headlamps.................................................5-51
Replacement Bulbs......................................5-56
Taillamps....................................................5-54
Buying New Tires...........................................5-60C
California Fuel.................................................. 5-5
Canada........................................................... 7-4
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-7
Canceling the Sliding Door Security Lock...........2-12
Capacities and Specifications............................5-92
Carbon Monoxide...........................4-24, 4-31, 2-30
Care of
Safety Belts................................................5-79
Your CD Player...........................................3-49
Your CDs ...................................................3-49
Cargo Vans...........................................1-41, 1-48
Center Passenger Position, Safety Belts.............1-27
Chains, Tires..................................................5-64
Charging System Light....................................3-27
2
2003 - Safari OM

Cruise Control................................................3-10
Current and Past Model Order Forms................7-11
Customer Assistance Information
Courtesy Transportation.................................. 7-7
Customer Assistance for Text Telephone (TTY)
Users....................................................... 7-4
Customer Assistance Offices........................... 7-4
Customer Satisfaction Procedure..................... 7-2
GM Mobility Program for Persons with
Disabilities................................................ 7-5
Reporting Safety Defects to General Motors.......7-10
Reporting Safety Defects to the Canadian
Government............................................7-10
Reporting Safety Defects to the United States
Government.............................................. 7-9
Roadside Assistance Program......................... 7-6
Service Publications Ordering Information........7-10
D
Daytime Running Lamps (DRL).........................3-14
Defensive Driving............................................. 4-2
Defogging and Defrosting.................................3-19
Directing the Airflow ........................................3-20
Disabling the Theft-Deterrent Feature.................3-48
Doing Your Own Service Work........................... 5-3Dome Lamps .................................................3-15
Door
Front Doors.................................................. 2-8
Locks.......................................................... 2-7
Power Door Locks......................................... 2-8
Programmable Automatic Door Locks............... 2-9
Rear Doors
.................................................2-13
Sliding Side Door
........................................2-10
Driver
Position, Safety Belt
.....................................1-19
Driver Information System
................................2-42
Driving
At Night
.....................................................4-14
City
...........................................................4-18
Defensive
..................................................... 4-2
Drunken
....................................................... 4-2
Freeway
.....................................................4-19
Hill and Mountain Roads
..............................4-22
In Rain and on Wet Roads
...........................4-15
Winter
........................................................4-24
Driving On Grades
..........................................4-38
Driving on Snow or Ice
....................................4-24
Driving Through Deep Standing Water
...............4-17
Driving Through Flowing Water
.........................4-18
Driving with a Trailer
.......................................4-37
4
2003 - Safari OM

E
Electrical System
Add-On Equipment......................................5-85
Fuses and Circuit Breakers...........................5-86
Headlamp Wiring.........................................5-85
Power Windows and Other Power Options......5-85
Windshield Wiper Fuses...............................5-85
Emissions Inspection and
Maintenance Programs.................................3-32
Engine
Air Cleaner/Filter.........................................5-21
Battery.......................................................5-42
Check and Service Engine Soon Light............3-30
Compartment Overview................................5-12
Coolant......................................................5-25
Coolant Heater............................................2-21
Coolant Temperature Gage...........................3-29
Cooling System Inspection............................6-32
Cover........................................................5-17
Exhaust.....................................................2-30
Fan Noise..................................................5-36
Oil .............................................................5-13
Overheating................................................5-28
Starting......................................................2-20
Engine Coolant Level Check.............................6-27
Engine Oil Additives........................................5-16
Engine Oil Level Check...................................6-27Entry Lighting.................................................3-15
Erasing HomeLink
®Buttons..............................2-37
Except Cargo Vans.................................1-38, 1-47
Exit Lighting...................................................3-15
Express-Down Window....................................2-17
Extender, Safety Belt.......................................1-34
Exterior Lamps...............................................3-12
F
Filter
Engine Air Cleaner......................................5-21
Finding a Station....................................3-38, 3-41
Finish Care....................................................5-80
Finish Damage...............................................5-82
Fixed Mast Antenna........................................3-49
Flash-to-Pass................................................... 3-7
Flat Tire........................................................5-64
Flat Tire, Changing.........................................5-65
Fluid
Automatic Transmission................................5-22
Power Steering...........................................5-36
Windshield Washer
......................................5-37
FM
...............................................................3-49
Following Distance
..........................................4-37
Front Axle
......................................................5-49
Front Doors
..................................................... 2-8
5
2003 - Safari OM

Horn ............................................................... 3-5
How to Add Coolant to the Coolant
Recovery Tank............................................5-31
How to Add Coolant to the Radiator..................5-33
How to Add Fluid............................................5-25
How to Check........................................5-23, 5-58
How to Check Lubricant...................................5-49
How to Check Power Steering Fluid..................5-37
How to Inspect the Engine Air Cleaner/Filter.......5-22
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-18
Hydroplaning..................................................4-17
I
If No Steam Is Coming From Your Engine..........5-29
If Steam Is Coming From Your Engine...............5-28
If the Light Is Flashing.....................................3-31
If the Light Is On Steady.................................3-31
If You Are Stuck in Sand, Mud, Ice or Snow.......4-28
If You Do Decide To Pull A Trailer.....................4-32
If You’re Caught in a Blizzard...........................4-26
Ignition Positions.............................................2-19
Ignition Transmission Lock Check......................6-30Infants and Young Children, Restraints...............1-38
Inflation -- Tire Pressure..................................5-58
Inspection
Brake System.............................................6-33
Engine Cooling System................................6-32
Exhaust System..........................................6-32
Fuel System...............................................6-32
Part C - Periodic Maintenance.......................6-32
Steering, Suspension and Front Drive Axle
Boot and Seal.........................................6-32
Throttle System...........................................6-33
Transfer Case and Front Axle
(All-Wheel Drive)......................................6-33
Installing a Garage Door Opener.......................2-40
Instrument Panel
Cluster.......................................................3-24
Overview..................................................... 3-2
Instrument Panel Brightness Control..................3-15
Instrument Panel Fuse Block............................5-86
Interior Lamps................................................3-15
J
Jump Starting.................................................5-43
7
2003 - Safari OM

K
Key Lock Cylinders Service..............................6-29
Keyless Entry System....................................... 2-4
Keys............................................................... 2-2
L
Lamps
Exterior......................................................3-12
Interior.......................................................3-15
Lamps On Reminder.......................................3-13
Lap Belt........................................................1-27
Lap-Shoulder Belt...................................1-19, 1-29
LATCH System
Child Restraints...........................................1-52
Securing a Child Restraint Designed for the
LATCH System........................................1-54
Latches, Seatback............................................ 1-6
Leaving Your Vehicle.......................................2-10
Leaving Your Vehicle With the Engine
Running.....................................................2-28
Light
Air Bag Readiness.......................................3-26
Anti-Lock Brake System Warning...................3-29
Brake System Warning.................................3-28Light (cont.)
Charging System.........................................3-27
Check Gages Warning.................................3-35
Low Fuel Warning.......................................3-36
Malfunction Indicator....................................3-30
Safety Belt Reminder
...................................3-25
Security
.....................................................3-34
Service All-Wheel-Drive
................................3-34
Tow/Haul Mode
...........................................3-35
Loading Your Vehicle
.......................................4-29
Locking Rear Axle
............................................ 4-8
Locks
Door
........................................................... 2-7
Front Doors
.................................................. 2-8
Leaving Your Vehicle
....................................2-10
Power Door
.................................................. 2-8
Programmable Automatic Door Locks
............... 2-9
Long Trip/Highway Definition
.............................. 6-6
Long Trip/Highway Intervals
............................... 6-6
Long Trip/Highway Scheduled Maintenance
........6-19
Loss of Control
...............................................4-13
Low Fuel Warning Light
...................................3-36
Luggage Carrier
..............................................2-45
Lumbar
Manual Controls
............................................ 1-3
8
2003 - Safari OM

O
Odometer......................................................3-25
Off-Road Recovery..........................................4-11
Oil
Engine.......................................................5-13
Pressure Gage............................................3-33
Older Children, Restraints................................1-35
Online Owner Center........................................ 7-3
Operation Tips................................................3-22
Other Warning Devices...................................... 3-5
Outlet Adjustment............................................3-22
Outside
Convex Mirror.............................................2-33
Manual Mirrors............................................2-32
Power Mirrors.............................................2-32
Overhead Console..........................................2-39
Owners, Canadian............................................... ii
Owner’s Information........................................7-11
P
Park (P)
Shifting Out of............................................2-29
Parking
Brake........................................................2-26
Over Things That Burn.................................2-30
Parking Brake and Automatic Transmission Park
(P) Mechanism Check..................................6-31Parking on Hills..............................................4-39
Park(P)
Shifting Into................................................2-27
Part A - Scheduled Maintenance Services............ 6-4
Part B - Owner Checks and Services................6-27
Part C - Periodic Maintenance Inspections..........6-32
PartD-Recommended Fluids and Lubricants.......6-34
PartE-Maintenance Record...........................6-36
Passing.................................................4-11, 4-38
Passlock
®......................................................2-18
Payload.........................................................4-31
Plan Ahead When Possible................................ 7-7
Playing a Compact Disc...................................3-42
Playing the Radio
...................................3-38, 3-40
Power
Accessory Outlets
........................................3-16
Door Locks
.................................................. 2-8
Electrical System
.........................................5-85
Seat
............................................................ 1-3
Steering Fluid
.............................................5-36
Windows
....................................................2-17
Power Steering
................................................ 4-9
Programmable Automatic Door Locks
.................. 2-9
Programming the HomeLink Transmitter
.............2-34
Q
Questions and Answers About Safety Belts
.........1-17
10
2003 - Safari OM