lock GMC SAVANA 1997 Owners Manual

Engine Compartment Fuse Relay Center
The fuse block is on the driver's side of the engine
compartment at the rear.
[-I
[)
[T]
Name
BLOWER
ABS
Circuits Protected
Blower Motor
Electronic Brake Control Module
Name
IGN-B
IGN-A
BATT
LIGHTING
RR BLOWER
ENG-
1
A/C SPARE
AUX A
AUX-B
RH-HDLP
Circuits Protected
Ignition Switch
Starter Relay, Ignition Switch
Instrument Panel Fuse Block
Instrument Panel Fuse Block,
Headlamp Switch
Rear Auxiliary Blower
Motor Relays
Heated
02 Sensors, Mass Air
Flow Sensor, EGR Valve
Solenoid, Evap Canister Purge
Valve, Crankshaft Position Sensor,
Secondary Air Injection Relay
(Diesel), Water in Fuel Sensor
(Diesel), Fuel Heater (Diesel),
Glowplug Relay (Diesel),
Wastegate Solenoid (Diesel)
Air Conditioning Clutch Relay
Spare Fuses
Upfitter Provisions
Upfitter Provisions
Right-hand Headlamp
(Export Only)
6-63
ProCarManuals.com

Short TripKity Maintenance Schedule -- Gasoline Engines
The services shown in this schedule up to 100,000 miles
(166
000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals. The services shown
at
150,000 miles (240 000 km) should be performed at
the same interval after
150,000 miles (240 000 km).
See “Owner Checks and Services” and “Periodic
Maintenance Inspections” following.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
# Lubricate the front suspension, kingpin bushings,
steering linkage and rear driveline center splines.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic
Maintenance Inspection” in Part C of this schedule.
** Drive axle service (see “Recommended Fluids and
Lubricants” in the Index for proper lubricant to use):
0
a
a
Locking Differential -- Drain fluid and refill at first
engine oil change. At subsequent oil changes, check
fluid level and add fluid
as needed. If driving in
dusty areas or towing a trailer, drain fluid and refill
every 15,000 miles (25
000 km).
Standard Differential -- Check fluid level and add
fluid as needed at every oil change. If driving in
dusty areas or towing a trailer, drain fluid and refill
every 15,000 miles
(25 000 km).
More frequent lubrication may be required for
heavy-duty use.
7-8
ProCarManuals.com

I Long Tripmighway Maintenance Schedule -- Gasoline Engines
The services shown in this schedule up to 100,000 miles
( 166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals. The services shown
at
150,000 miles (240 000 km) should be performed at
the same interval after 150,000 miles
(240 000 km).
See “Owner Checks and Services” and “Periodic
Maintenance Inspections” following.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will
not nullify
the emission warranty or limit recall liability prior
to the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
## Lubricate the front suspension, kingpin bushings,
steering linkage and rear driveline center splines.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic
Maintenance Inspections”
in Part C of this schedule.
** Drive axle service (see “Recommended Fluids and
Lubricants” in the Index for proper lubricant to use):
0 Locking Differential -- Drain fluid and refill at first
engine oil change. At subsequent oil changes, check
fluid level and add fluid as needed.
0 Standard Differential -- Check fluid level and add
fluid as needed at every engine oil change.
ProCarManuals.com

At Least Twice a Year At Least Once
a Year
Restraint System Check Key Lock Cylinders
Service
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly.
Look for any other loose or damaged
safety belt system parts. If you see anything that might
keep a safety belt system from doing its
job, have it
repaired. Have
any torn or frayed safety belts replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag system
does not need regular maintenance.) Lubricate the key lock
cylinders with the lubricant
specified in Part
D.
Body Lubrication Service
Lubricate all hood hinges, hood prop rod pivot, fuel
filler door, rear compartment hinges, latches, locks and
any moving seat hardware.
Part D tells you what to use.
More frequent lubrication may be required when
exposed
to a corrosive environment.
Wiper Blade Check Starter Switch Check
Inspect wiper blades
for wear or cracking. Replace blade
inserts that appear worn or damaged or that streak or
miss areas of the windshield. Also see “Wiper Blades,
Cleaning” in the Index.
Automatic Transmission Check
Check the transmission fluid level; add if needed. See
“Automatic Transmission” in the Index.
A fluid loss
may indicate a problem. Check the system and repair
if needed.
I
When you are doing this check, the vehicle could
move suddenly.
If it does, you or others could be
injured. Follow the steps below.
I. Before you start, be sure you have enough room
around the vehicle.
7-46
ProCarManuals.com

2.
3.
Firmly apply both the parking brake (see “Parking Brake” in the Index if necessary) and the regular brake.
NOTE:
Do not use the accelerator pedal, and be
ready to turn off the engine immediately if it starts.
Try to start the engine in each gear. The starter
should work only in PARK
(P) or NEUTRAL (N). If
the starter works in any other position, your vehicle
needs service.
Brake-Transmission Shift Interlock (BTSI) Check
When you are doing this check, the vehicle could
move suddenly.
If it does, you or others could be
injured. Follow the steps below.
1. Before you start, be sure you have enough around the vehicle. It should
be parked on a level surface.
2. Firmly apply the parking brake (see “Parking Brake”
in the Index
if necessary).
NOTE: Be ready to apply the regular brake
immediately if the vehicle begins
to move.
3. With the engine off, turn the key to the RUN
position, but don’t start the engine. Without applying
the regular brake, try
to move the shift lever out
of PARK (P) with normal effort. If the shift lever
moves out of PARK (P), your vehicle’s BTSI
needs service.
Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to
LOCK in each shift lever position.
0 The key should turn to LOCK only when the shift
lever is in PARK (P).
The key should come out only in LOCK.
7-47
ProCarManuals.com

Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from your
GM dealer.
USAGE
Engine Oil
(Gasoline
Engine)
Engine Coolant
Hydraulic Brake
System
FLUIDLUBRICANT
Engine oil with the American
Petroleum Institute Certified For
Gasoline Engines “Starburst”
symbol of the proper viscosity. To
determine the preferred viscosity
for your vehicle’s engine, see
“Engine Oil”
in the Index.
50/50 mixture of clean water
(preferably distilled) and use only
GM Goodwrench’ DEX-COOL@
or Havoline@ DEX-COOL@
coolant. See “Engine Coolant” in
the Index.
Delco Supreme 11
@ Brake Fluid
(GM Part No. 12377967 or
equivalent DOT-3 brake fluid).
USAGE
Parking Brake
Cable Guides
Power Steering System
Automatic
Transmission
Key Lock
Cylinders
Chassis
Lubrication
FLUIDlLUBRICANT
Chassis lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI
## 2, Category LB
or GC-LB.
GM Power Steering Fluid
(GM Part
No. 1052884 - 1 pint,
10500 17 - 1 quart, or equivalent).
DEXRON@-IU Automatic
Transmission Fluid.
Multi-Purpose lubricant, Superlube@ (GM
Part No. 12346241
or equivalent).
Chassis lubricant
(GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI ## 2, Category LB
or GC-LB.
c
7-5 1
ProCarManuals.com

Roadside Assistance
In
nnl
GMC’s Roadside Assistance provides stranded owners
with over-the-phone roadside repairs, location of the
nearest GMC dealer or
the following special services:
Flat Tire Change: Installation of spare tire will be
covered at no charge (customer is responsible for repair
or replacement of tire).
Fuel Delivery: Delivery of enough fuel for the customer
to get to the nearest service station (up to
$4.00) will
be covered.
Jump Start: No-start situations which require a battery
jump start will be covered at no charge.
Lock Out: Replacement keys or locksmith service will
be covered
at no charge if you are unable to gain entry
into your vehicle. Delivery
of the replacement key will
be covered at no charge within
10 miles (16 km).
Emergency Towing Service: Towing to the nearest
GMC dealer for warranty related disablements will
be covered.
8-5
ProCarManuals.com

Section 9 Index
Adjustable Mast Antenna ........................ 3-28
AirBag
....................................... 1-25
Adding Equipment
............................ 1-32
How Does it Restrain
.......................... 1-30
How
it Works ................................ 1-28
Location
.................................... 1-28
Readiness Light
......................... 1.27. 2.5 1
Servicing ................................... 1-31
What Makes
it Inflate .......................... 1-29
What Will
You See After it Inflates ............... 1-30
When Should it Inflate
......................... 1-29
Aircleaner
.................................... 6-17
Air Conditioning
................................ 3 -7
Air Conditioning Refrigerants
..................... 6-67
Alignment and Balance. Tire
...................... 6-47
Aluminum Wheels. Cleaning
...................... 6-55
Antenna. Adjustable Mast
........................ 3-28
Antenna. Power
................................ 3-28
Antifreeze
..................................... 6-22
Anti-Lock
Brake System Warning Light
................ 2.53. 4.7
Brakes
...................................... 4-7
Appearance Care
............................... 6-49
Air Control.
Climate Control System
................. 3-3 Appearance
Care Materials
....................... 6-57
Arbitration Program .............................. 8-9
Audio Systems
.................................. 3-8
Automatic Transmission
Transmission Check
........................... 7-46
Transmission Fluid
............................ 6-18
Transmission Operation
........................ 2-20
Transmission Park Mechanism Check
............. 7-48
Axle. Locking Rear
............................. 2-23
Axle. Rear
.................................... 6-22
Ashtrays
...................................... 2-43
Shifting
..................................... 2-20
Battery
...................................... 6-32
Jump Starting
................................. 5-3
Replacement. Remote Keyless Entry
............... 2-8
Warnings
.................................... 5-3
Warnings
.................................... 5-3
Before Leaving on a Long Trip
.................... 4-21
Blizzard. Driving In
............................. 4-25
BBB Auto
Line
................................. 8-9
Better Business Bureau Mediation
................... 8-9
9-1
ProCarManuals.com

Climate Control. Standard ......................... 3-2
Climate Control System
........................... 3-2
Clock. Setting the
................................ 3-8
Comfort Controls ................................ 3-2
Compact Disc Care
............................. 3-27
Compact Disc Player
....................... 3.18. 3.22
Console Storage
................................ 2-44
Control of a Vehicle
.............................. 4-6
Convex Outside Mirror
.......................... 2-44
Coolant
....................................... 6-22
RecoveryTank
............................... 5-16
Cooling System
................................ 5-14
Courtesy Transportation
........................... 8-8
Cruise Control ................................. 2-36
Cupholders
.................................... 2-44
Customer Assistance for Text Telephone Users
......... 8-4
Customer Assistance Information ................... 8- 1
Customer Satisfaction Procedure
.................... 8-2
Damage. Finish
............................... 6-56
Damage. Sheet Metal
............................ 6-55
Daytime Running Lamps
......................... 2-40
Daytime Running Lamps Indicator Light
............ 2-54
Dead Battery
................................... 5-3
Defects. Reporting Safety
........................ 8-10
Defensive Driving
............................... 4-2
Defogging
................................. 3-2. 3-4
Defrosting
................................. 3.2. 3.4
Dome Lamps
.................................. 2-40 Door
Locks
....................................... 2-4
Sliding
...................................... 2-11
Storagepocket
............................... 2-45
Swing-Out Side
............................... 2-9
Drive Position, Automatic Transmission
............. 2-22
Driver Position
................................. 1-15
Driving
City
........................................ 4-19
. Defensive .................................... 4-2
Drunken
..................................... 4-3
Freeway
.................................... 4-20
InaBlizzard
................................. 4-25
In Foreign Countries
........................... 6-5
IntheRain
.................................. 4-16
Night
...................................... 4-14
OnCurves
................................... 4-9
On Grades While Towing a Trailer
............... 4-36
On Hill
and Mountain Roads .................... 4-22
On Snow and Ice
............................. 4-24
Throughwater
............................... 4-18
WetRoads
.................................. 4-16
Winter
...................................... 4-24
With a Trailer
................................ 4-34
DrunkenDriving
................................ 4-3
Dual Tire Operation
............................. 6-45
Storage
..................................... 2-45
9-3
ProCarManuals.com

Electrical Equipment. Adding .................... 6-59
Electrical System ............................... 6-5.9
Electronic Road Speed Governor (Gasoline Engines) ... 2-60
Engine ........................................ 6-9
Coolant ..................................... 6-22
Coolant Level Check
.......................... 7-45
Coolant Temperature Gage
..................... 2-59
Cooling System
.............................. 6-65
Exhaust ..................................... 2-28
FuseBlock
.................................. 6-63
Identification ........................... 6.58. 6.65
OilLevelCheck .............................. 7-45
Overheating
................................. 5- 12
Running While Parked ......................... 2-28
Starting Your
................................ 2- 17
Engine Oil
.................................... 6-12
Adding ..................................... 6-12
Additives ................................... 6-16
Checking ................................... 6-13
Pressure Gage ................................ 2-57
Used
....................................... 6-16
Whentochange .............................. 6-16
Exhaust. Engine ................................ 2-28
Fabric Cleaning
............................... 6-50
Fan Control. Climate Control System ................ 3-2
FillingYourTank ................................ 6-5
Filter. Air ..................................... 6-17
Finish Care .................................... 6-54
Finish Damage ................................. 6-56
First Gear. Automatic Transmission ................ 2-22
Flashers. Hazard Warning
......................... 5-2
Flat Tire. Changing ............................. 5-23
Fluids and Lubricants
............................ 7-51
Foreign Countries. Fuel
........................... 6-5
French Language Manual 11
Front Parkingnurn Signal Lamp Bulb Replacement .... 6-35
Front Storage Area .............................. 2-44
FrontTowing
.................................. 5-10
Fuel .......................................... 6-3
Canada ...................................... 6-5
Filling Your Tank .............................. 6-5
Gage ....................................... 2-58
In Foreign Countries
........................... 6-5
Tankcapacity ............................... 6-66
Fuses and Circuit Breakers ....................... 6-60
.. ...........................
Gages Engine Coolant Temperature
.................... 2-59
Engine Oil Pressure ........................... 2-57
Fuel
....................................... 2-58
Speedometer ................................. 2-49
Voltmeter
................................... 2-60
Gear Positions. Automatic Transmission ............. 2-20
Gross Axle Weight Rating
........................ 4-28
Gross Vehicle Weight Rating
...................... 4-27
Guide en Franqais
11
GAWR ....................................... 4-28
.. .................................
GVWR ....................................... 4-27
9-4
ProCarManuals.com